9938 ZUZU Evolution Stroller

Instruction Manual & User Guide Evolution Tandem Stroller

An IGC Dorel brand

Please read this manual in its entirety before assembling the product and follow all instructions contained herein.

Please retain instruction manual for future reference.

Illustrations are representative only. Design and style may vary.

Instruction Manual & User Guide

2 9938 – Evolution Tandem Stroller – 11-09

Warnings These instructions detail the safe use, assembly and maintenance of the stroller. Please read these instructions carefully

and ensure that they are followed at all times:

• Check that the stroller is fully erected and that all safety locks are engaged before placing a child in the

stroller.

• Do not allow children to stand on the seat or footrest.

• Do not attempt to lift the stroller by the bumper bar or child tray.

• Do not carry extra children or bags on this stroller, unless in an approved accessory.

• Do not leave children unattended.

• Do not run or jog with this stroller.

• Do not use on stairs or escalators.

• Do not use the stroller near an open fire, barbecue or exposed flame.

• Engage front wheel swivel lock, to lock front wheel(s) when travelling on rough or uneven surfaces.

• Follow the manufacturer’s instructions at all times.

• Make sure children are clear of any moving parts if you adjust the stroller, otherwise they may be injured.

• Not recommended for a child under six months old.

• Please ensure that the safety harness is adjusted firm to the child’s body but comfortably and used at all

times.

• Put on all the brakes whenever you park the stroller.

• Shoulder straps must be unclipped whenever waist strap buckle is unfastened.

• This product is not intended for commercial use.

• To avoid danger of suffocation, keep any plastic bags away from babies and children. Do not use plastic bags

in cribs, beds, carriages or playpens. Plastic bags can block nose and mouth and prevent breathing. Bags are

not toys. Please dispose of waste packaging thoughtfully.

• Use only those accessories which are supplied by IGC Dorel, and approved for use with the stroller.

The weight of each child using this stroller should not be more than 15kg.


9938 – Evolution Tandem Stroller – 11-09 3

Unpacking and assembling your stroller TO OPEN THE STROLLER

• Release the storage latch, as per Figure 1.

• Unfold the stroller as per Figure 2.

• Simultaneously push the handle and the front legs as far as possible, as per Figure 3.

• Press down on the chassis lock foot pedal, as per Figure 4, until it locks, as per Figure 5.

Figure 1 Figure 2 Figure 3

Figure 4 Figure 5

TO ATTACH THE FRONT WHEEL ASSEMBLY • Place each swivel wheel assembly onto the front leg.

Ensure swivel wheel locks are at the top and

point forward and the arrow is pointing in the

right direction, as per Figure 6 and Figure 7.

Check that the assembly has locked in place by

pulling on the wheels.

Note: To remove the front wheel, push both

locking tabs at the base of the wheel post

inwards and pull the wheel.

Figure 6 Figure 7



Unpacking and assembling your stroller (cont.) TO ASSEMBLE THE REAR WHEELS

• Position each side of the axle assembly over the corresponding ends of the rear wheel legs of the frame,

as per Figure 8.

• Push each side down until the spring pins ‘click’ into place.

• Align the brake bar lever located on the centre of the wheel axle with the frame lock, as per Figure 9.

• Push the brake bar lever into the frame lock, as per Figure 10.

• Insert the locking pin into the hole on the side of the frame lock, as per Figure 11.

• Make sure the locking pin slides through the slot in the red brake bar lever, as per Figure 12.

• Insert, twist and secure circular locking clip to the locking pin, as per Figure 13 and Figure 14.

Figure 8



Frame lock

Spring pins

Brake lever at rear

Brake bar



Unpacking and assembling your stroller (cont.) TO FIT THE CANOPY

• Position and slide the mounts on both sides of the hinge molding to enable the grooves to locate onto the

guides and push down to lock tab in position, as per Figure 15.

• Position the back flap of the canopy over the support bar between the handle frame.

• Pass the sides of the back flap around the handle frame on both sides, as per Figure 16.

• Attach the Velcro® tabs on the back flap to the Velcro® tabs on the underside of the canopy on both sides, as per Figure 17.

To remove the canopy, pull on tabs and slide canopy out.

Figure 15

Figure 16

Figure 17



Using your stroller TO LOCK THE FRONT SWIVEL WHEEL

The swivel wheels can be locked in the forward

direction or unlocked to rotate freely.

• Push the lever located in the middle of the unit up in each wheel to

lock the wheel, as per Figure 18.

• To unlock the wheel push the lever located in the middle of the

unit down in each wheel as per Figure 19.

Figure 18 Figure 19

TO APPLY THE BRAKES • Press down firmly on the brake lever until both

wheels are locked, as per Figure 20.

• To release the brakes, push in the brake lever

until brakes fully disengage from wheels, as per

Figure 21.

Figure 20 Figure 21

TO OPEN THE CANOPY • Spread canopy until fully extended.

• Push down on the folding brackets.

To retract the canopy, lift the centre of both folding brackets and close.

Always ensure hood is retracted before folding stroller.



Using your stroller (cont.)

TO SECURE YOUR CHILD A five point harness is provided to secure the child.

• The harness straps can be adjusted by moving each strap’s slider.

• The buckle is released by squeezing the buckle tongues together.

WARNING: Ensure shoulder straps are unclipped

whenever waist strap buckles are unfastened.

TO ADJUST THE BACKREST (BACK SEAT) • With one hand, as per Figure 22, press the adjuster button situated on the center of the holder with your thumb

and slide to the desired position – up, as per Figure 23, or down, as per Figure 24.

• Release adjuster button to fix position.




Using your stroller (cont.) TO ADJUST THE BACKREST (FRONT SEAT)

• Lift the lever at the back of the seat and move backrest to the desired

position, as per Figure 25.

Figure 25

TO ATTACH AND USE THE WRIST TETHER STRAP Correct use of the wrist tether strap will prevent stroller runaway and

consequent injury to the stroller occupant.

• Attach the tether strap to the stroller by wrapping the small loop end of the

tether around the handle, feeding the large loop end through the small loop and

pulling tight, as per the illustration.

Whenever a child is in the stroller and brakes are not engaged, the

large loop should be around your wrist.

TO ATTATCH THE SHOPPING BASKET • The shopping basket attaches to the frame with press stud clips looped around the tubes under the seats.

TO FIT THE STORM COVER • Drape the storm cover over the stroller and pull down for a snug fit.

Lever here



Using your stroller (cont.) TO FOLD THE STROLLER

• Retract the canopy.

• Position the backrest in the upright position.

• Unlock both front swivel wheels to allow them to rotate freely.

• Lift up the frame lock with one foot, as per Figure 27.

• While lifting the two frame lock levers located on each side of the upper handle as per Figure 28, push the

handle forward to allow the stroller to fold. Continue this action until the stroller is folded, as per Figure 29.

• Engage the storage latch as per Figure 30.


Figure 29



Notes



Product care and maintenance • Always store the stroller in a clean and dry place.

• Clean the frame by wiping with a damp cloth.

• Do not use abrasives, bleach or strong detergents.

• Spot clean fabrics with warm water and mild soap.

• Ensure fabric is dry before storing.

• Occasionally clean and lubricate wheels and axles with light lubricating oil.

• Regularly check for loose parts and tighten when required.

• Damaged or broken parts should be replaced.

Customer service Please contact our Customer Service Department if you experience a problem with this product or require assistance:

AUSTRALIAN CUSTOMERS

NEW ZEALAND CUSTOMERS

Email [email protected] [email protected]

Web www.igcdorel.com.au www.igcdorel.com.au

Phone 1 (03) 8311 5300 (09) 276 1040

Phone 2 1300 809 526 (local call cost) 0800 628 000 (Toll Free)

Hours 8:30 am – 4:30 pm, Monday to Friday 9:00 am – 4:00 pm, Monday to Friday

Postal IGC Dorel Pty Ltd P.O. Box 1260 Sunshine West, Victoria, 3020 Australia

IGC Dorel (New Zealand) P.O. Box 82377 Highland Park Mt Wellington New Zealand

Guarantee This product carries a twelve month guarantee to rectify manufacturing defects. It does not cover problems arising from

accidental damage or product misuse. Specifications are subject to change without notice.

Copy or reproduction without permission is prohibited.

© 2009 IGC Dorel Pty Ltd. All Rights Reserved. www.igcdorel.com.au

9938 ZUZU Evolution Stroller

Documents

Transcript of 9938 ZUZU Evolution Stroller