3PL Report - Frost & Sullivan
-
Upload
sugandharohira -
Category
Documents
-
view
1.084 -
download
15
Transcript of 3PL Report - Frost & Sullivan
#4C77-18 © 2006 Frost & Sullivan www.frost.com
Frost & Sullivan takes no responsibility for any incorrect
information supplied to us by manufacturers or users.
Quantitative market information is based primarily on
interviews and therefore is subject to fluctuation.
Frost & Sullivan reports are limited publications con-
taining valuable market information provided to a select
group of customers in response to orders. Our customers
acknowledge when ordering that Frost & Sullivan reports
are for our customers’ internal use and not for general
publication or disclosure to third parties.
No part of this report may be given, lent, resold, or
disclosed to non-customers without written permission.
Furthermore, no part may be reproduced, stored in a
retrieval system, or transmitted in any form or by any
means, electronic, mechanical, photocopying, recording,
or otherwise, without the permission of the publisher.
For information regarding permission, write:
Frost & Sullivan
2400 Geng Road, Suite 201
Palo Alto, CA 94303-3331
United States
Table of Contents
C h a p t e r 1
Executive Summary
Introduction and Overview 1-1
Introduction to Logistics Market in India 1-1
Introduction and Overview of the 3PL Market in the India 1-3
Market Overview and Research Findings 1-3
Total 3PL Market in India Size and Forecasts 1-3
Opportunities for the 3PL Service Providers in India 1-4
Competitive Analysis 1-4
Industry Challenges for the 3PL Market in India 1-4
Drivers for the 3PL Market in the India 1-5
Restraints for the 3PL Market in India 1-5
Implications of VAT on 3PL in India 1-5
Strategic Conclusions 1-6
C h a p t e r 2
Strategic Analysis of Total 3PL Market in India
Introduction 2-1
Introduction and Overview of the Indian Logistics Market 2-1
#4C77-18 © 2006 Frost & Sullivan www.frost.com iii
Introduction to 3PL in India 2-4
Evolution of 3PL Market in India 2-5
Awareness and Perception of 3PL in India 2-6
Scenario of the Indian 3PL Market 2-7
Overall 3PL Usage in the Logistics Functions 2-7
3PL Usage in Transportation 2-9
3PL Usage in Warehousing 2-10
3PL Usage in Freight Forwarding 2-12
3PL Usage in MIS and Other Value-added Services 2-12
Market Size and Revenue Forecasts 2-13
The Total Logistics Market in India 2-13
Size of the 3PL Market in the India 2-14
Growth History of 3PL Market in India 2-15
Estimated Share of the 3PL Market 2-15
Revenue Forecasts 2-16
Revenue Forecasts Breakdown by Different Logistics Functions 2-18
Revenue Forecasts for 3PL in Transportation Function 2-18
Revenue Forecasts for 3PL in Warehousing Function 2-19
Revenue Forecasts for 3PL in Freight Forwarding Function 2-21
Revenue Forecasts for 3PL in MIS and Other Value-Added Services 2-22
Industry Challenges and Market Drivers and Restraints 2-24
Industry Challenges 2-24
Geographical Size and Diversity 2-24
Stiff Competition and Pricing Strategies 2-25
Multinational 3PL Companies are at a Disadvantage Compared to the Indian Companies 2-25
Integrating Supply Chains and Providing Visibility Along the Entire Chain 2-25
Security Concern is a Critical Issue 2-25
#4C77-18 © 2006 Frost & Sullivan www.frost.com iv
Market Drivers 2-26
Growth of Multinational Operations Demand Professional Logistics Management 2-26
Growing Inclination to Outsource Logistics to Specialists 2-27
Economic Growth Across Different Sectors Necessitates Smooth Flow of Supply Chain 2-28
Infrastructure Development Facilitates Logistics 2-28
Implementation of an All India VAT System 2-29
Declining 3PL Rates is Likely to Cause More Outsourcing 2-29
Market Restraints 2-29
High Cost of Logistics in India 2-30
Existence of Infrastructure Bottlenecks 2-30
Non-Uniform Implementation of VAT,Complex Laws and Sales Tax Regulations are not Favored by Compines 2-30
Outsourcing to a 3PL Service Provider Attracts a Service Tax 2-31
Competition from the Unorganized Segment 2-31
Major End-Users of 3PL in India 2-31
Implications of VAT on 3PL 2-32
Introduction to VAT 2-32
Challenges for 3PL Service Providers due to VAT's impact 2-33
Reorganization of IT Infrastructure may be Complicated 2-34
Maintaining Large Volumes of Transactional Records Could be a Difficult Task 2-34
Nonuniformity of VAT Implementation Across the Nation and the Co-existence of VAT with the Central Sales Tax
system is Complicating 2-34
Competition from the Unorganized Segment Poses a Significant Challenge to the Growth of these Companies 2-35
Opportunities for 3PL Service Providers due to VAT's impact 2-36
C h a p t e r 3
End-User Analysis—Overview of 3PL Needs and Practices in India
Overview of 3PL Needs and Practices in India 3-1
3PL Usage in the Indian Automotive and Auto Components Sector 3-1
3PL Usage in the Indian IT Hardware and Electronics Sector 3-4
3PL Usage in the Indian FMCG Sector 3-6
3PL Usage in the Indian Pharmaceuticals Sector 3-8
3PL Usage in the Indian Retail Sector 3-10
#4C77-18 © 2006 Frost & Sullivan www.frost.com v
C h a p t e r 4
Competitive Analysis of the 3PL Providers in Indian Market
Industry Size 4-1
Industry Size in Terms of Number of Companies 4-1
Industry Life Cycle 4-2
Current Status of the Industry Life Cycle 4-2
Current Status of Market Life Cycle 4-4
Market Share Comparison and Breakup 4-4
Competitive Scenario 4-4
Services Comparison 4-7
National 3PL Service Providers 4-7
Regional 3PL Service Providers 4-9
Local 3PL Service Providers 4-9
Profiles of the Major 3PL Service Providers in India 4-9
AFL Logistics 4-9
DHL 4-11
Dynamic Logistics 4-12
GATI 4-14
Geo Logistics 4-15
Om Logistics 4-16
Patel Logistics 4-18
Reliance Logistics 4-19
#4C77-18 © 2006 Frost & Sullivan www.frost.com vi
Safexpress 4-20
SembCorp Logistics 4-21
Take Solutions 4-23
TCI Supply Chain Solutions 4-24
Total Logistics 4-25
Transystem Logistics International 4-26
TVS Logistics 4-27
Clientele: 4-27
C h a p t e r 5
Recommendations and Growth Strategies for 3PL Providers in India
Opportunities for 3PL Service Providers in India 5-1
Types of Services with Potential 5-1
Potential of Services during the Forecast Period 5-2
Business Model 5-4
Suggested Business Model 5-4
Pricing and Positioning 5-4
Suggested Pricing Strategy 5-4
Suggested Positioning Strategy 5-4
Strategic Alliances Joint Ventures and Partnerships 5-5
Suggested Strategy for Forming Alliances Joint Ventures and Partnerships 5-5
#4C77-18 © 2006 Frost & Sullivan www.frost.com vii
C h a p t e r 6
Database of Key Industry Participants
Market Participants—3PL Service Providers 6-1
C h a p t e r 7
Decision Support Database
Comparitive Tabulation of Infrastructure and Industry Figures 7-1
Tabulation of Infrastructural Figures 7-1
Tabulation of Major Industry Sectors Size 7-4
#4C77-18 © 2006 Frost & Sullivan www.frost.com viii
List of Figures
C h a p t e r 2
Strategic Analysis of Total 3PL Market in India
2-1 Total Third Party Logistics Market:
Breakup by Mode of Freight (India), 2005 2-1
2-2 Total Third Party Logistics Market : Penetration by Logistics Function (India), 2005 2-7
2-3 Total Third Party Logistics Market:
Revenue Breakup by Type of Logistics Function (India), 2005 2-14
2-4 Total Third Party Logistics Market:
Estimated Shares (India), 2005 2-15
2-5 Total Third Party Logistics Market:
Revenue Forecasts (India), 2002-2012 2-17
2-6 Total Third Party Logistics Market:
Revenue Forecasts for Transportation Logistics Function (India), 2002-2012 2-18
2-7 Total Third Party Logistics Market:
Revenue Forecasts for Warehousing Logistics Function (India), 2002-2012 2-20
2-8 Total Third Party Logistics Market:
Revenue Forecasts for Freight Forwarding Logistics Function (India), 2002-2012 2-21
2-9 Total Third Party Logistics Market:
Revenue Forecasts for Value-added Services and Other Services Logistics Functions
(India), 2002-2012 2-23
#4C77-18 © 2006 Frost & Sullivan www.frost.com ix
2-10 Total Third Party Logistics Market:
Impact of Top Industry Challenges (India), 2006-2012 2-24
2-11 Total Third Party Logistics Market:
Market Drivers Ranked in Order of Impact (India), 2006-2012 2-26
2-12 Total Third Party Logistics Market:
Market Restraints Ranked in Order of Impact (India), 2006-2012 2-29
2-13 Total Third Party Logistics Market:
Top End-user Sectors (India), 2005 2-31
C h a p t e r 3
End-User Analysis—Overview of 3PL Needs and Practices in India
C h a p t e r 4
Competitive Analysis of the 3PL Providers in Indian Market
4-1 Third Party Logistics Market:
3PL Industry Structure by Type of Service Provider (India), 2005 4-1
4-2 Third Party Logistics Market:
Revenue Breakup by Type of 3PL Service Provider (India), 2005 4-5
4-3 Third Party Logistics Market:
Revenue Share Breakup Between National 3PL Service Providers (India), 2005 4-6
4-4 Third Party Logistics Market:
Services Comparison between National 3PL Service Providers (India), 2005 4-7
#4C77-18 © 2006 Frost & Sullivan www.frost.com x
C h a p t e r 5
Recommendations and Growth Strategies for 3PL Providers in India
5-1 Third Party Logistics Market:
Top Ten 3PL Services with High Growth Potential (India), 2005 5-1
5-2 Third Party Logistics Market:
Top Ten 3PL Services Ranked in Order of Potential (India), 2006-2012 5-2
C h a p t e r 7
Decision Support Database
7-1 Decision Support Database:
Tabulation of Economic and Infrastructural Figures 7-2
7-2 Decision Support Database:
Value of Major Industrial Sectors in India, as of 2005 7-4
#4C77-18 © 2006 Frost & Sullivan www.frost.com xi
List of Charts
C h a p t e r 1
Executive Summary
1.1 Third Party Logistics Market:
Market Attractiveness Index by Function (India), 2005 1-2
C h a p t e r 2
Strategic Analysis of Total 3PL Market in India
2.1 Total Third Party Logistics Market:
Breakup by Mode of Freight (India), 2005 2-2
2.2 Total Third Party Logistics Market : Penetration by Logistics Function (India), 2005 2-7
2.3 Total Third Party Logistics Market:
Revenue Breakup by Type of Logistics Function (India), 2005 2-14
2.4 Total Third Party Logistics Market:
Estimated Share (India), 2005 2-16
2.5 Total Third Party Logistics Market:
Revenue Forecasts (India), 2002-2012 2-17
2.6 Total Third Party Logistics Market:
Revenue Forecasts for Transportation Logistics Function (India), 2002-2012 2-19
2.7 Total Third Party Logistics Market:
Revenue Forecasts for Warehousing Logistics Function (India), 2002-2012 2-20
#4C77-18 © 2006 Frost & Sullivan www.frost.com xiii
2.8 Total Third Party Logistics Market:
Revenue Forecasts for Freight Forwarding Logistics Function (India), 2002-2012 2-22
2.9 Total Third Party Logistics Market:
Revenue Forecasts for Value-Added Logistics Services and Other Services Logistics Functions
(India), 2002-2012 2-23
C h a p t e r 3
End-User Analysis—Overview of 3PL Needs and Practices in India
3.1 Third Party Logistics Market:
Logistics Model followed by Leading MNC Automakers (India), 2005 3-1
3.2 Third Party Logistics Market:
Standard Model of Goods Flow in the IT Hardware and Electronics Sector (India), 2005 3-4
3.3 Third Party Logistics Market:
Standard Model of Goods Flow in the FMCG Sector (India), 2005 3-6
3.4 Third Party Logistics Market:
Standard Model of Goods Flow in the Pharmaceuticals Sector (India), 2005 3-8
3.5 Third Party Logistics Market:
Logistics Model followed Leading Retailers (India), 2005 3-10
C h a p t e r 4
Competitive Analysis of the 3PL Providers in Indian Market
4.1 Third Party Logistics Market:
3PL Industry Structure by Type of Service Provider (India), 2005 4-2
4.2 Third Party Logistics Market:
3PL Industry Life Cycle (India), 2000-2015 4-3
#4C77-18 © 2006 Frost & Sullivan www.frost.com xiv
4.3 Third Party Logistics Market:
Market Life Cycle (India), 2000-2015 4-4
4.4 Third Party Logistics Market:
Revenue Breakup by Type of Service Provider (India), 2005 4-5
4.5 Third Party Logistics Market:
Revenue Share Breakup Between National 3PL Service Providers (India), 2005 4-6
#4C77-18 © 2006 Frost & Sullivan www.frost.com xv
1Executive Summary
I n t r o d u c t i o n a n d O v e r v i e w
Introduction to Logistics Market in India
The logistics market in India is fragmented predominantly due to the large presence of unor-
ganized service providers. Logistics, which is one of the lifelines of a country the size of
India, has been so far considered as a secondary activity. The industry broadly consists of
freight consolidators, transporters, warehousing specialists, and organized third party logis-
tics (3PL) service providers, in the increasing order of value addition to the service.
Roads carry the bulk of the freight in India. The roads in India have a history of being unsafe
and in very bad condition. This is likely to change with the construction of the Golden Quad-
rilateral and North-South-East-West (NSEW) highway networks, traversing the entire
country. The highway infrastructure is highly strained, comprising around 1.4 percent of the
total road network in India, carrying in excess of 50 percent of the country's total freight.
Roads are flexible with easy to own assets and door-delivered consignments. Rail freight
comprises around 670 million tones, which is around 33 percent of all domestic traffic in
India. Even though rail freight is more cost effective in terms of cost per unit distance and per
unit weight, the efficiency of the rail freight system in India has for long been low and it has
been looked down upon as a secondary freight mode. With the Indian Government
announcing plans to open up the containerized rail freight sector to private operators,
companies such as APL Logistics, Maersk Logistics, Gateway Distriparks, Central Ware-
housing Corporation, JM Baxi group, Adani Logistics, and Reliance Logistics are expected to
foray into this segment. The barriers to entry for providing this service are rather low and
intense competition is likely to be witnessed.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-1
The largely unorganized segment of the logistics industry in India poses a formidable chal-
lenge to companies in the organized segment. The unorganized segment service providers
have lesser overhead costs and are hence in a position to provide extremely competitive rates.
This is expected to have a considerably large impact in the future, posing a challenge espe-
cially to the 3PL service providers. Entry barriers too are low, leading to the possibility of
intensified competition even in the organized sector. Complex tax laws and infrastructure
bottlenecks too are challenging issues to be dealt with.
The growth of in the Indian economy, especially in the manufacturing sector is one of the key
growth drivers for the logistics industry in India. Apart from this, sincere initiatives by the
Government to iron out wrinkles in the logistics infrastructure may also drive the growth in
this sector expected to grow at a compound annual growth rate (CAGR) of 6.4 percent from
2005 to 2012.
Chart 1.1 shows the Market Attractiveness Index by Function for the Third Party Logistics
Market (India), 2005.
C h a r t 1 . 1
Third Party Logistics Market: Market Attractiveness Index by Function (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
-200.0
-100.0
0.0
100.0
200.0
300.0
400.0
500.0
600.0
700.0
800.0
Market Attractiveness (Based on CAGR)
Mar
ket S
tren
gth
(Bas
ed o
n M
arke
t Si
ze in
200
5) U
S $M
illio
n
Transportation
Warehousing
Freight Forwarding
MIS and Other Value-added Services
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-2
Introduction and Overview of the 3PL Market in the India
Companies in India generally outsource only a part of their supply chain requirements to a
3PL service provider. Only a small fraction of companies outsource entirely to a 3PL service
provider. Most of these companies are multinationals that entered the country and didn't
have an established network and have to outsource their logistics due to the lack of assets.
The degree and nature of outsourcing of logistics to a 3PL service provider varies signifi-
cantly between verticals and depends greatly on the nature of the company. In the automotive
sector, the trend of end-to-end outsourcing is beginning to significantly catch up as compa-
nies have realized the benefits of concentrating on core competencies and delegating the
logistics to 3PL service providers.
The penetration of 3PL is very high in the automotive sector. Likewise, the IT hardware and
electronics sectors have also begun outsourcing to 3PL service providers to a great extent. In
sectors such as Fast Moving Consumer Goods (FMCG) and pharmaceuticals, the penetration
of the 3PL concept has been fairly low, owing to already strained profit margins. Added to
this, there is a great deal of decentralization in the supply chains of these sectors, with many
stocking points and strategic distribution centers spread all over the country. This will
demand infrastructure capabilities that the 3PL service providers may not be in a position to
offer. Outsourcing in these sectors has started in warehousing operations, albeit in a small
way. Certain 3PL service providers have their own freight forwarding and customs clearance
capabilities. Those that do not have, hire the services of a local freight forwarding agent to
liaison with the required authorities to have their consignments cleared. Most 3PL service
providers offer good management of information systems (MIS) capabilities to their clients.
The provision of value-added propositions along with a 3PL contract is expected to witness a
growing trend with increasing demands from the clients and 3PL service providers that want
to gain an edge in a highly competitive marketplace.
M a r k e t O v e r v i e w a n d R e s e a r c h F i n d i n g s
Total 3PL Market in India Size and Forecasts
The market for 3PL in India was worth $890.3 million in 2005. The entire 3PL market is
expected to grow at a CAGR of 21.9 percent from 2005 to 2012 and reach $3,556.7 million
in 2012. In 2005, transportation activity outsourced to a 3PL service provider accounted for
a lion's share of the revenues in the market. However, warehousing is expected to grow the
fastest among all the logistics functions outsourced to a 3PL service provider. In 2005, it
accounted for second largest share of entire market. Revenues from MIS and Other Values
Added Services accounted for third largest share of the market revenues with freight
forwarding accounting for the lowest share.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-3
Opportunities for the 3PL Service Providers in India
India has immense opportunities for 3PL service providers. The growth is expected to come
predominantly from warehousing, which is likely to be driven to a very great extent by the
implementation of value added tax (VAT), a uniform tax regime across the country. The
benefits are expected to be witnessed by the year 2010, when the central sales tax is likely to
be completely abolished. In the transportation function, the growth of express transport
could provide opportunities for the service providers. The growth is expected to be driven by
the betterment of infrastructure and increasing client requirements to provide committed and
time-bound services. Express transport has a very small share of the entire trucking market,
and hence presents immense potential for growth. Freight forwarding and MIS and Other
value-added services also present good opportunities in the market. The growth in
value-added services is expected to be driven by the growth in transportation and ware-
housing functions, and as a tool by 3PL service providers to gain a competitive edge in the
market. A majority of the revenues from value-added services in the market is expected to be
generated from growth in the warehousing function.
Competitive Analysis
The 3PL service providers in India are categorized into three tiers of competition namely
national, regional, and local service providers depending on their presence and reach in the
market. The major national 3PL service providers are the Tier I companies and they account
for the largest share of the revenues generated in this market. This can be attributed to the
relatively better rates and value propositions offered by them, which find customers predom-
inantly among large corporations. The regional 3PL service providers, or the Tier II
companies account for the second largest share of the revenues generated in this market.
These service providers offer basic logistics support and generally operate with corporations
and Tier I companies to provide access at a regional level. The local 3PL service providers, or
the Tier III companies that account for lowest share of the revenues generated in this market.
They have small clientele and provide logistics services that does not have a large reach.
Industry Challenges for the 3PL Market in India
Industry challenges are factors that have the potential to adversely affect the market growth
during the forecast period from 2006 to 2012. Though these may not have any direct bearing
on the growth of the market, they can be overcome using suitable strategies:
Geographical size and diversity
Stiff competition and pricing strategies
Security concern is a critical issue
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-4
Drivers for the 3PL Market in the India
Market drivers are factors that have the potential to drive the growth of the market during
the forecast period from 2006 to 2012.
Growing inclination to outsource logistics to specialists
Economic growth across all sectors necessitates smooth flow of supply chain
Implementation of an all India VAT system
Restraints for the 3PL Market in India
Market restraints are factors that have the potential to slow or retard the growth of the
market during the forecast period from 2006 to 2012.
High cost of logistics in India
Infrastructure bottlenecks still exist
Competition from the unorganized segment
Implications of VAT on 3PL in India
The implementation of a uniform VAT regime and the elimination of the sales tax model is
expected to indirectly benefit the supply chain management in the country. Previously state
borders were viewed as economic borders, as they posed hurdles to the sale of goods between
states. As a tax saving mechanism, companies operated on a highly decentralized model of
multiple warehouses spread across states. This ultimately led to management of more
resources and manpower, leading to costs that could otherwise have been avoided.
The original intention of the Indian Government behind implementation of VAT was to intro-
duce transparency into the taxation system; however, it has indirectly changed the course of
logistics in the country. The present model poses a problem of cascading taxes, which VAT is
expected to abolish.Companies are expected to move to newer and more centralized hub and
spoke distribution models that will be more convenient with lesser hassles. VAT is expected
to abolish the economic borders between states and enable sales between points with
geographic convenience in consideration, as opposed to the tax planning driven model that
was practiced earlier.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-5
The real benefits of VAT impacting the supply chain management in India are not likely to be
witnessed until the central sales tax is eliminated. At present, VAT coexists with the central
sales tax, which is expected to be phased out by 2010. The persistence of central sales tax
defies the logic behind shifting to the new hub and spoke model, as there is no input tax
credit available against the central sales tax in the case of inter state sales. Input tax credit is
the reimbursement of tax that can be availed under the VAT system, where tax that has
already been paid is reimbursed. This ensures that taxation happens only for the value addi-
tion. The central sales tax is expected to be eliminated by 2010, after which companies are
likely to witness a drastic reorganization in the way supply chains are managed.
The service expected to benefit the most from VAT's implementation is warehousing. Once
the hub and spoke type distribution model sets in, large multi-user zonal warehousing facili-
ties could be seen mushrooming. This could see 3PL service providers operate these facilities
and leverage economies of scale. This was not observed under the earlier sales tax system,
under which the environment was not conducive for seamless logistics
The transition to VAT could pose challenges in the form of integration of IT infrastructure
and maintenance of records. There is also competition from the unorganized sector
comprising clearing and forwarding (C&F) agents, that may reinvent themselves post VAT
implementation.
Strategic Conclusions
The 3PL market in India is poised for significant growth till the year 2012. The market has
been growing steadily at an estimated Compound Annual Growth Rate of 18.3 percent since
2002 and the growth is expected to accelerate further. Changing economic and business
scenarios, along with increasing outsourcing tendencies are expected to be the drivers for the
growth in this market.
Among the services, the warehousing function is expected to witness the fastest growth.
Investing in assets could be important as owning them, could prove to be a healthy competi-
tive edge, particularly in the transportation function. In the warehousing function,
companies could build their own warehouses or operate a warehouse built by a third party to
specification. Iinvesting in new warehouses may not be advised,, considering high real estate
costs. Choice of location of warehouse is also an important factor, considering the constant
need to reduce lead and turnaround times, which will enable clients gain a competitive edge.
The growth in the transportation is expected to be driven by better infrastructure and the
constantly reducing lead times and this is likely to lead to the emergence of express transpor-
tation. Along with this growth in revenues from value-added services, driven by the
requirement of companies to gain a competitive edge, is also expected.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 1-6
2Strategic Analysis of Total 3PL Market in
India
I n t r o d u c t i o n
Introduction and Overview of the Indian Logistics Market
Figure 2-1 and Chart 2.1 show the breakup by mode of freight in the total Indian third party
logistics market in 2005.
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 1
Total Third Party Logistics Market: Breakup by Mode of Freight (India), 2005
Mode Percent Contribution (%)
Roadways 51.0
Railways 33.0
Pipeline 8.0
Inland waterways 8.0
Total 100.0
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-1
C h a r t 2 . 1
Total Third Party Logistics Market: Breakup by Mode of Freight (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
In 2005, the Indian logistics market was worth an estimated $15.5 billion. The transporta-
tion logistics function contributed the largest share of the market followed by warehousing.
The logistics market in India is fragmented predominantly due to the large presence of the
unorganized service providers. Logistics, which is one of the lifelines of a country the size of
India, has so far been considered as a secondary activity. The industry broadly consists of
freight consolidators, transporters, warehousing specialists, and organized third party logis-
tics (3PL) solutions providers, in the increasing order of value addition to the service
Warehouse management in India follows more of a clearing and forwarding (C&F) agent
model. Most of the warehouses are in the form of depots or stocking points managed by
agents for companies on a contractual basis. These warehouse are not managed very profes-
sionally. This segment also forms a significantly large portion of the entire market, as
multiple warehousing is a very important cost saving requirement in the Indian scenario.
Warehousing has been considered as a storage function, with most companies overlooking it
as a secondary activity, neglecting the complexity of the operations involved, and the cost
benefits that can be derived. Most of these C&F depots are used by companies to facilitate
transfer of goods between stock points. Concepts such as automation, vertical space utiliza-
tion, and the use of warehouse management systems were quite unheard of; however, these
are slowly but steadily gaining prominence.
Railways33%
Pipeline8%
Roadways51%
Inland waterways8%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-2
Professional management of logistics in the form of 3PL has begun being adopted since the
last decade. These 3PL service providers have the capacity to offer a wide array of services to
their clients and help them better manage their supply chains. The 3PL service providers
assume end-to-end responsibility to manage a part or the company's entire supply chain. The
growth of 3PL service providers in India has introduced the use of global supply chain
management standards in the country. However, the 3PL service providers form a very insig-
nificant part of the entire market, comprising around 3 percent of the Indian logistics.
Roads carry the bulk of the freight in India. The roads in India have a history of being unsafe
and in very bad conditions. This is changing with the construction of the Golden Quadrilat-
eral and North-South-East-West (NSEW) highway networks, traversing the entire country.
The highway infrastructure is highly strained, comprising around 1.4 percent of the total
road network in India and carries in excess of 50 percent of the country's total freight. Roads
are flexible with easy to own assets and door-delivered consignments. Even though rail
freight is more cost effective in terms of cost per unit distance and per unit weight, the effi-
ciency of the rail freight system in India has for long been low and it has also been considered
as a secondary freight mode. Previously, rail was the most preferred mode of freight;
however, bad pricing and inflexibility have resulted in the railways experiencing a downturn.
With the Indian Government announcing plans to open up the containerized rail freight
sector to private operators this is expected to change. Companies such as APL Logistics,
Maersk Logistics, Gateway Distriparks, Central Warehousing Corporation, JM Baxi group,
Adani Logistics, and Reliance Logistics are expected to enter into this segment. The barriers
of entry for providing this service are rather low. Companies need to have a minimum turn-
over of around $22 million (INR 1 billion) in India. To get a permit license for 20 years they
need to pay the Government between $1 million and $10 million, depending on whether they
want to operate on a specific route or an all India basis. Rail freight comprises around
670 million tones, which is around 33 percent of the total domestic traffic in India. Compa-
nies in the metals, heavy machinery, and engineering and cement sectors are expected to
benefit from the opening up of the railways to private participants as these carry bulky cargo
over long distances. Previously, costs of trucking were very high as the final destination could
be in a remote corner of the country, where a backhaul arrangement would be nearly impos-
sible. In sectors such as these, costs of transportation in the entire logistics spending was as
high as 75 percent. Long distance transportation by rail can help cut costs in these sectors.
With the Railways Department mulling a separate freight corridor, this sector is likely to
experience a growing trend. This is keeping in mind that passenger trains get higher priority
over goods trains and the new corridor can run parallel to existing lines to places of heavy
activity such as ports.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-3
The large unorganized segment of the logistics industry in India poses a formidable challenge
to companies in the organized one. The unorganized segment service providers have lesser
overhead costs and are hence in a position to provide extremely competitive rates. This is
expected to have a considerably large impact in the future, posing a challenge especially to
the 3PL service providers. Entry barriers are also low, leading to the possibility of intensified
competition even in the organized sector. Complex tax laws and infrastructure bottlenecks
are also challenging issues to be dealt with.
The growth of the Indian economy, especially the rise in the manufacturing sector is one of
the key growth drivers of the logistics industry in India. Apart from this, sincere initiatives by
the Government to remove bottlenecks in the logistics infrastructure are also drivers for
growth in the sector that is expected to grow at a compound annual growth rate (CAGR) of
6.4 percent from 2005 to 2012.
Introduction to 3PL in India
3PL services in India is a relatively new concept compared to other parts of the world. The
Indian 3PL market is still in its infancy stage, though it is expected to grow at a significantly
fast pace. The major end-user verticals of 3PL services are the automotive and auto compo-
nents, machinery and heavy engineering, IT hardware and electronics, consumer durables,
pharmaceuticals, fast moving consumer goods (FMCG), and organized retailing industries.
The 3PL service providers have introduced a dimension of professionalism that was previ-
ously lacking in the industry. The Indian business houses have a better established setup in
the 3PL market. This is due to existing business relations that were there between the service
providers, an already established logistics network, and a better knowledge of the local busi-
ness environment and processes. Service providers with a prominent presence include
multinationals such as Sembcorp Logistics of Singapore, domestic service providers such as
Safexpress, GATI, Om Logistics, and TVS Logistics. Service providers such as Caterpillar
Logistics have recognized the opportunity for growth and have entered India for setting up
operations in partnership with the local service providers. Companies such as TNT, Kuehne
Nagel, Schenker, Federal Express, and Panalpina have a global presence; however, they do
not have a notable presence, or in some cases, do not operate in the Indian 3PL market, as
their main focus may be on international air express or sea freight.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-4
Evolution of 3PL Market in India
The growth of multinational operations has been one of the key drivers in the Indian logistics
market, especially in 3PL. The 3PL services concept was originally introduced by multina-
tional 3PL service providers that entered India to manage the supply chains of their key
global clients. With the emergence of India as a global manufacturing hub, there was require-
ment for seamless supply chains with time-bound deliveries in a cost-effective manner. A
number of companies such as Transport Corporation of India, Om Logistics, Total Logistics,
and Patel Logistics that were previously pure transporters realized the opportunity for
growth in 3PL services and have included it as a part of their portfolio.
The evolution of 3PL services has not been rapid; however, the market has been growing at
an expected CAGR of 18.3 percent since 2002. The growth has been spurred on as certain
companies have had to outsource logistics to remain competitive. Warehousing, a logistics
function that was previously unprofessionally managed, has witnessed noticeable growth
since 2003. Concepts such as mechanized warehousing and vertical space utilization, which
were quite unheard of in India, have now started gaining prominence. 3PL service providers
operating such warehouses have been able to significantly reduce the number of employees
per warehouse.. The transportation logistics function is also witnessing a gradual shift from
pure trucking to containerized transport with vehicle tracking solutions such as a global posi-
tioning system (GPS) or GSM mobile telephony network. Though at present GPS is not
greatly used due to prohibitive costs of equipment, GSM mobile telephony network is being
used.
Outsourcing of integrated logistics has not happened to a very great extent in India. Instead,
companies have outsourced individual or partial services to a 3PL service provider. There are
certain companies that have outsourced their entire supply chains to a 3PL service provider;
however, these are few in number. Integrated logistics outsourcing is expected to be imple-
mented in a major manner once the demand for 3PL services grow. This is expected when key
industry verticals grow, and sourcing patterns shift from price driven sourcing to sophisti-
cated sourcing that focuses on long-term vendor relationships, larger vendor bases, and
technology-driven supply chain innovation.
At present, 3PL services have grown as capital, information, and physical movement. These
three key aspects of any supply chain are being focused on as very important. The market for
3PL services in India is still in its infancy stage. It is expected to see a strong CAGR of
21.9 percent till the year 2012. Though the unorganized segment will not be completely elim-
inated, compared to the rest of the total Indian logistics market the share of 3PL is expected
to increase as the segment is growing significantly faster.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-5
Awareness and Perception of 3PL in India
The concept of 3PL was quite unheard of in India until the mid-1990s. It is still in its infancystage in India compared to the other parts of the world. However, at present there is anincreased awareness about 3PL services than in the past. Users of 3PL services have varyingperceptions about their service providers. Companies in the automotive sector consideroutsourcing logistics to a 3PL service provider as an important cost-saving tool. The samemay not be witnessed in the other industry verticals. FMCG companies still follow the dealer-stockist distribution model to a very large extent. Outsourcing takes place in individual logis-tics functions such as warehousing or freight forwarding but not to a very great extent intransportation. This is primarily because FMCG companies opine that for high volume,low-value goods such as FMCG such as personal care products, transportation to a 3PLservice provider may be an expensive option. Added to this, for a country as geographicallydiverse as India, with a large consumer base, companies opine that a single 3PL serviceprovider will not be able to offer an end-to-end solution. Retail firms consider working witha 3PL service provider a very viable option as the key to low cost modern retailing lies ineffective supply chain management with electronic surveillance to prevent damage andpilferage in transit. Some companies manufacturing IT hardware and electronics consideroutsourcing to a 3PL service provider a very convenient option, as prior to this quite a fewcompanies were facing problems with huge sums of money locked up in inventories andlonger lead times.
Cost and quality of service are the prime factors companies consider while choosing a 3PLservice provider. As a result of this, there tends to be a trade-off quality and cost. MostIndian companies that have started outsourcing consider cost as the primary factory, unlikemultinationals that have derived cost benefits from outsourcing. Outsourcing to a 3PLservice provider does attract a cost, which may be significantly higher than outsourcing to atrucker and C&F agent; however, companies that focus more on quality do not mind theextra spending to have quality delivered, as it can provide better margins by enabling costcutting. This is more the case with the larger companies that want to possess sophisticatedsupply chains to remain abreast with global competition. Companies may hence be willing tohire top quality services that have a commitment to deliver at the highest standards. Whilecost is a concern for outsourcers, companies, especially multinationals consider it as along-term proposition to work with a 3PL service provider, considering the total cost oflogistics in the whole product life cycle. The reputation of the 3PL serviced provider does actsignificantly on the outsourcer's choice of service provider. A known 3PL service provider ismore preferred giving importance to the requirements of the company.
Another issue of concern is the security of the supply chain of a company, considering thehigh incidences of pilferage and damage in transit in the Indian industries. An efficient supplymay in many cases be the difference between some companies being more successful than theothers. Some companies may be wary of third party intervention in their supply chain andhence be unwilling to outsource their logistics to a 3PL service provider. This though, is aconcern that is greatly unfounded. Meeting service commitments is a concern for a fewcompanies. Flexibility in services and compatibility and scalability of operations are factorsthat companies focus on when it comes to service-level determination.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-6
S c e n a r i o o f t h e I n d i a n 3 P L M a r k e t
Overall 3PL Usage in the Logistics Functions
Figure 2-2 and Chart 2.2 show the penetration by logistics function of 3PL in the total logis-
tics market in 2005.
Note: All figures are rounded. Source: Frost & Sullivan
C h a r t 2 . 2
Total Third Party Logistics Market : Penetration by Logistics Function (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 2
Total Third Party Logistics Market : Penetration by Logistics Function (India), 2005
Service Penetration (%)
Transportation 9.0
MIS and Other Value Added Services 4.5
Warehousing 4.0
Freight Forwarding 3.0
0
1
2
3
4
5
6
7
8
9
10
Transportation MIS and Other ValueAdded Services
Warehousing Freight Forwarding
Pene
trat
ion
(%)
Service Function
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-7
The penetration of Transportation service outsourced to a 3PL service provider is only
9.0 percent of that in the entire logistics market. This is significantly higher than the penetra-
tions in other services. The fact that transportation function outsourced to a 3PL has such a
low penetration and is still the most penetrated services shows how nascent the 3PL market
in India is. The penetration of Warehousing outsourced to a 3PL is only around 4.0 percent
of the Indian warehousing market. This is because, warehousing is still predominantly
considered a pure storage function. Organized 3PL warehousing is a concept that is new to
the Indian market, and hence the low penetration.
In India, most companies outsource only a part of their supply chain requirements to a 3PL
service provider. There may be only a small fraction of companies that outsource entirely to a
3PL service provider. Most of these companies are multinationals that have entered India and
do not have an established network and have to outsource their logistics due to the lack of
assets.
The penetration of 3PL in the total Indian market is only 5.7 percent. The degree and nature
of outsourcing of logistics to a 3PL service provider varies significantly between verticals and
depends greatly on the nature of the company. In the automotive sector, the trend of
end-to-end outsourcing is beginning to gain acceptance significantly as companies have
begun realizing the benefits of concentrating on core competencies and delegating logistics to
3PL service providers. Concepts such just-in-time (JIT) delivery to the assembly line have
gained acceptance in this sector, thereby requiring companies to hold only a few hours of
inventory. Even companies that have traditionally been known to adopt a very conservative
business outlook have started outsourcing their logistics to 3PL service providers. The pene-
tration of 3PL services is very high in the automotive sector. Likewise, the IT hardware and
electronics sector has also begun outsourcing to a 3PL service provider to a great extent. In
sectors such as FMCG and pharmaceutical industries, the penetration of the 3PL service
concept has been fairly low, owing to already strained profit margins that these companies
are experiencing. Added to this, there is a great deal of decentralization in the supply chains
of these sectors, with many stocking points and strategic distribution centers spread in
different parts of the country. This will demand infrastructure capabilities that 3PL service
providers may not be in a position to provide. Outsourcing in these sectors has started in
warehousing operations. Sector giants such as Hindustan Lever Limited, Marico Industries,
Terumo Tenpol, and Dr.Reddy's Laboratories are outsourcing their warehouse requirements
to 3PL service providers.
Certain 3PL service providers have their own freight forwarding and customs clearance capa-
bilities. Those that do not have hire the services of a local freight forwarding agent to liaison
with the required authorities in order to have their consignments cleared. Most 3PL service
providers provide good MIS capabilities to their clients. The provision of value-added propo-
sitions along with a 3PL contract is expected to witness a growing trend with clients
increasingly demanding the same.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-8
3PL Usage in Transportation
Transportation is the most outsourced service in the Indian 3PL market. In 2005,
71.7 percent of the revenues generated in the total market were from the transportation
logistics function. This is considering the fact that in any logistical activity, the prime focus is
on moving physical goods along the chain. Investing in vehicles may be a very expensive
option for a company. Outsourcing transportation to a 3PL service provider hence obviates
the need to invest in them. The 3PL service providers can afford to own vehicles, or
outsource vehicles from a local trucking service provider. According to Frost & Sullivan, the
transportation logistics function is expected to still be the most outsourced service to a 3PL
service provider till the year 2012.
At present operating margins in transportation are greatly strained. The reason is that, since
2002, while international oil prices have observed a surge in excess of 150 percent, freight
rates have seen an average increase of just over 40 percent. Along with this, severe competi-
tion in the market has forced competitors to cut rates to retain clients or acquire the
competitors' clients. For this purpose 3PL service providers have had to practice back-
hauling, sometimes at extremely low rates, where break even has to be obtained to stay from
making losses.
The traditional mode of transportation has been trucking. Outsourcing transportation to a
3PL service provider has been implemented in a major manner only in a few sectors such as
automotive. In a sector where disruptions in the supply chain can drastically affect manufac-
turing schedules, outsourcing to a 3PL service provider to have consignments delivered
just-in-time (JIT) in order to save costs is a viable option. This trend in the automotive sector
has been growing since India established itself as an important destination for automotive
component and vehicle manufacturing.
The express mode of transport is not employed to a very great extent in this market. Only a
few sectors such as IT hardware and electronics and retailing, where stocking on shelves is of
utmost importance to avoid opportunity costs use express transport. While trucking is
expected to still be the most preferred mode of transport, the express mode is likely to expe-
rience good growth. This will help companies reduce stocking points along the supply chain,
thereby reducing lead times and inventory holding costs drastically. Companies are likely to
start preferring the express transport to traditional methods if there are clear cost benefits
that can be derived such as reduced lead times and lesser inventories in the pipeline. The
growth in this sector is likely to be driven by the needs of the clients.
Industries such as pharmaceuticals and FMCG may prefer the express mode of transport to
traditional trucking; however, the profit margins are already strained in these sectors. Even
though these sectors will prefer shifting to the express mode, the capacity of 3PL service
providers to manage the large volumes generated by them is likely to be a constraint. At
present, India lacks the type of road infrastructure that can permit companies to use express
transport in a cost-effective manner. More than 60 percent of revenues in the express segment
in India still come from document couriers. The 3PL activity in express transport account for
a very insignificant part of the entire transportation in 3PL services.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-9
Most supply chain managers in the Indian companies have to negotiate freight rates and
track a multitude of trucks from different fleets. With the emergence of lead logistics players
(LLPs), this responsibility is now gradually shifting, reducing the number of agencies to
manage and thereby saving cost and time.
The use of Global Positioning System (GPS) to track vehicles in transit is being employed by
selected companies such as Safexpress in a limited number of vehicles, as technology of this
nature is expensive. Most 3PL service providers do provide their clients with track and trace
facilities, but these are through mobile communication networks such as GSM and CDMA
networks. This requires a demonstration effect of the clear economic benefits for companies
to start using these services more. Reliance logistics has an in-house telematics division that
develops software for enabling vehicle tracking through their own CDMA network. Compa-
nies are taking initiatives in this regard; however it is in its early stages of adoption.
3PL Usage in Warehousing
Warehousing is the second most outsourced logistics function to a 3PL service provider in the
Indian market. In 2005, It accounted for 16.5 percent of the revenues generated in the Indian
3PL market. It is also expected to be the logistics function where competition. will be the
stiffest. In the past warehousing was considered as just another storage function. This is
changing with companies beginning to focus on outsourcing warehouses to a 3PL service
provider as an effective measure to handle large volumes. Companies increasingly beginning
to outsource warehouses, at an expected CAGR of 23.7 percent from 2005 to 2012. One of
the reasons companies are willing to outsource to a 3PL service provider is the need for
real-time information regarding inventories that are locked up along the supply chain and to
provide flexibility in scaling of operations.
Warehousing is not as established in India as it is in the developed economies of the west, as
each state in India has a different tax regulation. This is expected to change once a nation-
wide value added tax (VAT) system is implemented, eventually resulting in the growth of 3PL
managed warehouses. The 3PL service providers are likely to shift to a new hub and spoke
type warehouse model with regional master warehouses feeding the smaller warehouses and
depots. This will be in stark contrast to the present system of state wise C&F depots necessi-
tated as a cost saving measure due to the present sales tax system in the country, which is
expected to be replaced by a uniform VAT. Once VAT is uniformly implemented, consolida-
tion in warehousing is expected to occur, which can help 3PL service providers leverage
economies of scale. Once this takes place and consequentially warehousing costs decrease,
technological improvements such as robots and conveyor belts can be possible, resulting in
better warehousing. However, this trend is not likely to be witnessed across all sectors.
Some verticals such as FMCG operate with a mixed model, persisting with the traditionalC&F agent model, as companies they want to retain a strategic distribution hub within astate, in order to avoid opportunity costs. Ultimately, even for the C&F agents to staycompetitive, they have to upgrade existing facilities similar to 3PL warehouses.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-10
The outsourcing of a company's warehousing logistics function to a 3PL service provider isbecoming a growing trend. This trend is expected to be a direct fallout of companies realizingthe complexity involved in a warehousing logistics function. The automotive sector has beenwitnessing outsourcing in warehousing logistics function to a great extent, where inventoriesneed to be replenished on an hourly basis than on a daily basis. Companies such as TataMotors have outsourced their warehousing logistics function to professional 3PL serviceproviders. Maintaining a large number of stock keeping units inside the warehouse, spreadover large areas is likely to lead to complexity in operations. In many cases, lead times insidethe warehouse can be very critical to a manufacturing or distribution operation, requiringquick retrieval. Moreover, investing in real estate may not be feasible for a company, andhence the best option for them to use a 3PL service. For example, Om logistics, a leading 3PLservice provider in India, is providing warehousing logistics function to a leading manufac-turer of refrigerators since 2003 at their warehouse in Mohali, in Punjab. Previously, thecompany had its warehouse in near Mumbai, with material not being able to be trackedeasily, effectively wasting around 30,000 sq. ft. of floor space.
The 3PL service providers in India have started investing on increasing warehouse capacitiesand the number of warehouses in the country. This is due to the intention to cash in on theopportunity provided by the implementation of a uniform national VAT system, where it isexpected that the present multistage warehouse model will shift to a model with fewer andlarger warehouses spread across the country. The 3PL service providers are also trying toexpand their warehouses vertically in order to increase the capacity, and hence shift to a'cubic feet' type one, as opposed to the 'square feet' type that is predominantly present inIndia. Sembcorp Logistics has four warehouses at Bhiwandi, Chennai, Pune, and Jamshedpurcatering to the needs of its clients. GATI has also announced plans to upgrade its warehousesat certain facilities. Companies such as MICO have also clearly drawn out plans for changingits supply chain structure after VAT is fully implemented.
A purely variable cost model was not considered a viable option in India when organizedwarehousing first entered the market around 2001, as manufacturing patterns were notsuited to that. In a pure variable cost model, Company 'A' managing inventory turns betterthan another Company 'B', which keeps a large inventory and tries to respond to marketdemand, should logically speaking be paying lesser for using lesser warehouse space. That iscompanies should be paying proportional to space utilization. Lack of uncertainty indemand, lack of proper forecasting, and rigid manufacturing patterns were primarily respon-sible for this costing model not doing very well. Even today, C&F agents follow acombination of a fixed and variable cost model, where companies pay for rent andmanpower at the warehousing facility even if no space is utilized. This is because many facil-ities are not shared and hence economies of scale are not being created. The 3PL serviceproviders are likely to practice a purely variable cost model once VAT is implementeduniformly.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-11
The use of information technology has been implemented to a good extent in warehousing.
They come in the form of special application warehouse management system This is used to
get real time data about stock availability in the warehouse. Along with this 3PL service
providers are focusing on the automated storage and retrieval systems (AS/RS) to facilitate
easier handling in the warehouse premises. This helps in storage and retrieval of bins, identi-
fying them, and sorting accordingly. Along with it, usage of robots and stacker cranes that
move on rails is also expected. These are particularly useful in case of warehouses with
vertical space utilization and those that handle large volumes and many stock keeping units
such as in the FMCG, pharmaceutical, and apparel verticals.
Improvements are expected in the technology used in a warehouse that can reduce human
interference and thereby increase warehouse efficiency. At present, in India global technology
standards such as radio frequency identification (RFID) have not been implemented to a
great extent. These have a great potential to increase warehousing efficiency and security.
There is also the possibility of hi-tech automated warehouses with zero human interference in
the future, where companies are expected to save a lot in terms of reduced, or at times nil
power consumption in the form of zero air conditioning, illumination, and manpower. At
present, this is observed in extremely few companies in India, as the cost of technology of
this nature is considered to be prohibitive at the present time.
3PL Usage in Freight Forwarding
In 2005, freight forwarding logistics function accounted for 2.2 percent of the revenues
generated in the Indian 3PL market.. The 3PL service providers that offer the freight
forwarding logistics function to their clients either possess the capabilities themselves or
employ the services of an agency that liaisons with the authorities locally. There are multina-
tional freight forwarders such as Panalpina & Kuehne Nagel that offer freight forwarding
services to 3PL service providers; however, theses are far outnumbered by the local freight
forwarding agents. Complex laws and procedures and at Indian Airports and seaports often
require 3PL service providers to outsource their freight forwarding requirements to a local
service provider, who in most cases is better acquainted with local authorities and
procedures.
3PL Usage in MIS and Other Value-added Services
In 2005, MIS and other Value-added Services accounted 9.6 percent of the revenues gener-
ated in the Indian 3PL market. Since 3PL service providers offer—added services, clients can
concentrate on their competencies. The growth of these services has been mainly driven by
the growth of outsourcing to a 3PL service provider. At present, the provision of these serv-
ices has become imperative to companies considering that service differentiation is a must in
a highly competitive atmosphere.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-12
After sales support, customs clearance, reverses logistics, kitting, packaging, repacking, labe-
ling, rate negotiation, order management, network planning, site selection, fleet
management, vendor management of inventory, and supply chain consulting are among the
many value-added services offered by 3PL service providers in India.
Vendor managed inventory (VMI) service has witnessed a strong growth in the automotive
and auto components, IT hardware, and retail sectors. Companies such as Menlo Worldwide
have set up VMI operations in the country to provide services to companies such as General
Motors. In the IT hardware sector, VMI services have helped companies decrease inventory
levels significantly, thereby helping companies cut costs. VMI provides companies with total
visibility about inventories at all points along the supply chain and help in the company
maintaining just enough merchandise required along the assembly line or by the customer.
However, not all 3PL service providers are in a position to offer all these MIS and other
value-added services, placing the ones that cannot offer them at a clear competitive disadvan-
tage when compared to companies that offer them.
M a r k e t S i z e a n d R e v e n u e F o r e c a s t s
The Total Logistics Market in India
The total logistics market in India is estimated at $15.5 billion. A vast majority of this
market is still in the unorganized segment. Companies such as VRL transporters and Navata
transporters are very good regional participants but do not have a pan-India presence. Other-
wise, the transportation is highly unorganized, with varying fleet ownership patterns. The
small fleet owners do not have operating policies and operate at extremely competitive rates.
They are generally in the form of open trucks, with no assured time schedules and improper
handling of consignments. Warehousing also has for long been in the form of C&F depots
and stocking agents, spread across the country in order to gain maximum benefit out of the
redundant sales tax system. These depots have usually been positioned more out of obtaining
tax benefits than for geographical convenience. There are a very few companies that operate
out of a single warehouse or few warehouses in the country. In the Indian warehousing
scenario, it is more of a storage function being performed and it lacks sophistication in
service.
The cost of logistics in India is very high, estimated at around 13 percent of the country's
gross domestic product (GDP). Transportation forms a predominantly large part of costs
incurred for logistics. The other two most significant cost components of logistics are ware-
housing and inventory holding costs. Together these three compose around 90 percent of the
costs incurred for logistics in the market. The other components involved are administrative
and order processing costs.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-13
The organized 3PL service providers account for a very insignificant share of the market.
These are very professionally managed, being able to offer end-to-end logistics solutions for
their clients. The concept of a 3PL service is still in its infancy stage in India and is expected
to observe a strong growth till the year 2012.
Size of the 3PL Market in the India
Figure 2-3 and Chart 2.3 show the size and revenue breakup by type of logistics function in
the total Indian third party logistics market in 2005.
Note: All figures are rounded. Source: Frost & Sullivan
C h a r t 2 . 3
Total Third Party Logistics Market: Revenue Breakup by Type of Logistics Function (India),
2005
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 3
Total Third Party Logistics Market: Revenue Breakup by Type of Logistics Function (India),
2005
Service Percentage Contribution (%) Revenues ($ Million)
Transportation 71.7 638.3
Warehousing 16.5 146.7
MIS and Other Value Added Services 9.6 85.7
Freight forwarding 2.2 19.6
Total 100.0 890.3
Transportation71.7%
Warehousing16.5%
MIS and Other Value-added Services
9.6%Freight Forwarding
2.2%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-14
In 2005, the 3PL market in India was worth $890.3 million. It has grown at CAGR of
18.3 percent since the year 2002. Transportation is the most outsourced service to a 3PL
service provider. It accounted for 71.7 percent of all service revenues in 2005. This is greatly
due to the fact that companies need not invest in vehicles and manage complex transporta-
tion activity. Moreover, India is geographically a very vast country with a large vendor base.
Clients are increasingly focusing on better and more secure transportation, with real-time
data availability. Soon 3PL companies are likely to witness a healthy growth in the transpor-
tation logistics function. The logistics function that contributed the next largest share after
transportation in the Indian 3PL market was warehousing, that accounted for 16.5 percent of
the revenues in 2005. The market for warehousing is not as mature as it is in the developed
economies of western Europe or North America, making the potential for growth immense.
Revenues from freight forwarding accounted for 2.2 percent of all revenues in the total
market. Value-added services and others accounted for the remaining 9.6 percent of the reve-
nues in 2005.
Growth History of 3PL Market in India
The 3PL market has been growing in India from the year 2002 to the year 2005 at a CAGR
of 18.3 percent. The market was worth $538.2 million in 2002 The growth has primarily
come from the usage of 3PL services in key industry sectors such as automotive and auto
components and IT hardware and electronics where the lead times have to be extremely short
to decrease manufacturing and opportunity costs.
Estimated Share of the 3PL Market
Figure 2-4 and Chart 2.4 shows the estimated share of the Third Party Logistics Market in
the entire logistics market (India), 2005.
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 4
Total Third Party Logistics Market: Estimated Shares (India), 2005
Category Market Share (%)
3PL Service Providers 5.7
Others (Trucking, C&F Agents, Depots) 94.3
Total 100.0
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-15
C h a r t 2 . 4
Total Third Party Logistics Market: Estimated Share (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
The Indian logistics market is estimated at $15.5 billion. The Indian 3PL market was worth
$890.3 in 2005 and had a share of 5.7 of the total logistics market. This is significantly lower
than that recorded in developed economies, where the share of the 3PL market may be much
higher. In 2005, the national companies had a 2.7 percent share in the entire Indian 3PL
market. The regional companies accounted for 1.9 percent and the local companies
accounted for a meager 1.1 percent share of the entire Indian 3PL market in 2005. The share
of the national 3PL companies in the total logistics market in India in 2003 was 2 percent.
This share grew to 2.7 percent because the 3PL market has been growing at a CAGR of
18.3 percent as opposed to a CAGR 6.4 percent for the entire logistics market. This share is
likely to increase further with greater growth and consolidation that is expected to take place
in the industry by 2012.
Revenue Forecasts
Figure 2-5 and Chart 2.5 show the revenue forecasts of the total Indian third party logistics
market from 2002 to 2012.
Others (Trucking, C&F Agents, Depots)
94.3%
3PL Service Providers5.7%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-16
Note: All figures are rounded; the base year is 2005. Source: Frost & Sullivan
C h a r t 2 . 5
Total Third Party Logistics Market: Revenue Forecasts (India), 2002-2012
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 5
Total Third Party Logistics Market: Revenue Forecasts (India), 2002-2012
Revenue
Revenues Growth Rate
Year ($ Million) (%)
2002 538.2 ---
2003 634.0 17.8
2004 749.4 18.2
2005 890.3 18.8
2006 1,063.9 19.5
2007 1,287.5 21.0
2008 1,563.7 21.5
2009 1,896.2 21.3
2010 2,326.2 22.6
2011 2,868.9 23.3
2012 3,556.7 24.0
Compound Annual Growth Rate (2005-2012): 21.9%
0
500
1000
1500
2000
2500
3000
3500
4000
2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012
Year
Rev
enue
s ($
mill
ion)
0.0
5.0
10.0
15.0
20.0
25.0
30.0
Gro
wth
Rat
e (%
)Revenues ($ million) Growth Rate (%)
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-17
In 2005, the total 3PL market in India was worth $890.3 million. It is expected to grow at a
CAGR of 21.9 percent from 2005 to 2012, and reach $3,556.7 million by 2012. The market
for 3PL is growing significantly faster than the entire Indian logistics market, which is
growing at an annual rate of 6.4 percent.
Revenue Forecasts Breakdown by Different Logistics Functions
R e v e n u e F o r e c a s t s f o r 3 P L i n T r a n s p o r t a t i o n F u n c t i o n
Figure 2-6 and Chart 2.6 show the revenue forecasts for the transportation logistics function
in the total Indian third party logistics market from 2002 to 2012.
Note: All figures are rounded; base year is 2005. Source: Frost & Sullivan
F i g u r e 2 - 6
Total Third Party Logistics Market: Revenue Forecasts for Transportation Logistics Function
(India), 2002-2012
Revenue
Revenues Growth Rate
Year ($ Million) (%)
2002 389.5 ---
2003 457.8 17.5
2004 539.7 17.8
2005 638.3 18.3
2006 763.9 19.7
2007 924.1 21.0
2008 1,120.2 21.2
2009 1,353.2 20.8
2010 1,655.0 22.3
2011 2,035.7 23.0
2012 2,518.7 23.7
Compound Annual Growth Rate (2005-2012): 21.7%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-18
C h a r t 2 . 6
Total Third Party Logistics Market: Revenue Forecasts for Transportation Logistics Function
(India), 2002-2012
Note: All figures are rounded. Source: Frost & Sullivan
In the 2005, the transportation logistics function outsourced to a 3PL accounted for
71.7 percent of the revenues in the market, valued at $638.3 million. It is expected to grow at
a CAGR of 21.7 percent from 2005 to 2012 to reach $2,518.7 million in 2012.
R e v e n u e F o r e c a s t s f o r 3 P L i n W a r e h o u s i n g F u n c t i o n
Figure 2-7 and Chart 2.7 show the revenue forecasts for the warehousing logistics function in
the total Indian third party logistics market from 2002 to 2012.
0
500
1000
1500
2000
2500
3000
2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012
Year
0
5
10
15
20
25Revenues ($ Million) Growth Rate (%)
Gro
wth
Rat
e (%
)
Rev
enue
s ($
Mill
ion)
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-19
Note: All figures are rounded; base year is 2005. Source: Frost & Sullivan
C h a r t 2 . 7
Total Third Party Logistics Market: Revenue Forecasts for Warehousing Logistics Function
(India), 2002-2012
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 7
Total Third Party Logistics Market: Revenue Forecasts for Warehousing Logistics Function
(India), 2002-2012
Revenue
Revenues Growth Rate
Year ($ Million) (%)
2002 81.7 ---
2003 98.8 20.9
2004 120.0 21.5
2005 146.7 22.2
2006 175.1 23.7
2007 215.9 23.3
2008 267.3 23.8
2009 330.9 24.5
2010 413.6 25.0
2011 517.4 25.1
2012 650.2 25.7
Compound Annual Growth Rate (2005-2012): 23.7%
0
100
200
300
400
500
600
700
2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012
Year
0
5
10
15
20
25
30Revenues ($ Million) Growth Rate (%)
Gro
wth
Rat
e (%
)
Rev
enue
s ($
Mill
ion)
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-20
Warehousing is expected to grow the fastest among all functions outsourced to a 3PL service
provider. In 2005, it accounted for 16.5 percent of the revenues of the entire market, that was
$146.7 million. The warehousing operations to a 3PL company are expected to grow at a
CAGR of 23.7 percent from 2005 to 2012, to reach $650.2 million in 2012.
R e v e n u e F o r e c a s t s f o r 3 P L i n F r e i g h t F o r w a r d i n g
F u n c t i o n
Figure 2-8 and Chart 2.8 show the revenue forecasts for the freight forwarding logistics func-
tion in the total Indian third party logistics market from 2002 to 2012.
Note: All figures are rounded; base year is 2005. Source: Frost & Sullivan
F i g u r e 2 - 8
Total Third Party Logistics Market: Revenue Forecasts for Freight Forwarding Logistics
Function (India), 2002-2012
Revenue
Revenues Growth Rate
Year ($ Million) (%)
2002 15.7 ---
2003 16.9 7.7
2004 18.2 7.9
2005 19.6 7.9
2006 22.9 8.0
2007 24.9 8.7
2008 27.6 10.8
2009 30.8 11.6
2010 34.6 12.3
2011 39.3 13.6
2012 44.9 14.2
Compound Annual Growth Rate (2005-2012): 12.6%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-21
C h a r t 2 . 8
Total Third Party Logistics Market: Revenue Forecasts for Freight Forwarding Logistics
Function (India), 2002-2012
Note: All figures are rounded. Source: Frost & Sullivan
In 2005, the freight forwarding operations outsourced to a 3PL accounted for 2.2 percent of
the market, that was $19.6 million. It is expected to grow at a CAGR of 12.6 percent from
2005 to 2012, to reach $44.9 million in 2012.
R e v e n u e F o r e c a s t s f o r 3 P L i n M I S a n d O t h e r
V a l u e - A d d e d S e r v i c e s
Figure 2-9 and Chart 2.9 show the revenue forecasts for the value-added and other services
logistics functions in the total Indian third party logistics market from 2002 to 2012.
0
5
10
15
20
25
30
35
40
45
50
2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012
Year
0
2
4
6
8
10
12
14
16Revenues ($ Million) Growth Rate (%)
Gro
wth
Rat
e (%
)
Rev
enue
s ($
Mill
ion)
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-22
Note: All figures are rounded; base year is 2005. Source: Frost & Sullivan
C h a r t 2 . 9
Total Third Party Logistics Market: Revenue Forecasts for Value-Added Logistics Services
and Other Services Logistics Functions (India), 2002-2012
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 2 - 9
Total Third Party Logistics Market: Revenue Forecasts for Value-added Services and Other
Services Logistics Functions (India), 2002-2012
Revenue
Revenues Growth Rate
Year ($ Million) (%)
2002 51.3 ---
2003 60.5 17.8
2004 71.5 18.2
2005 85.7 18.8
2006 102.0 19.0
2007 122.6 20.2
2008 148.6 21.2
2009 181.3 22.0
2010 223.0 23.0
2011 276.5 23.9
2012 342.9 24.0
Compound Annual Growth Rate (2005-2012): 21.9%
0
50
100
150
200
250
300
350
400
2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012
Year
0
5
10
15
20
25
30Revenues ($ Million) Growth Rate (%)
Gro
wth
Rat
e (%
)
Rev
enue
s ($
Mill
ion)
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-23
In 2005, revenues from the value-added and other services logistics functions were worth
$85.7 million and is expected to grow at CAGR of 21.9 percent from 2005 to 2012, to reach
$342.9 million in 2012
I n d u s t r y C h a l l e n g e s a n d M a r k e t D r i v e r s a n d
R e s t r a i n t s
Industry Challenges
Figure 2-10 shows the impact of the top industry challenges for the total Indian third party
logistics market from 2006 to 2012.
Source: Frost & Sullivan
G e o g r a p h i c a l S i z e a n d D i v e r s i t y
India is geographically the seventh largest country in the world, with over more than
25 states and a consumer base spread all over the country. With the Indian economy
booming, virtually every region in India is witnessing growth in economic activities,
requiring seamless supply chains. Incidences of disruptions in supply chains may be relatively
higher than in the other developed economies. Manufacturing industries source from a multi-
vendor base from various parts of the country, sometimes even from one end to the other. For
example the General Motors factory in the western Indian state of Gujarat sources a lot of
components from vendors in South India. Vehicles carrying these components may in most
cases have to pass through multiple states, each having different tax laws. Managing supply
chains and providing a good geographical reach is likely to be one of the biggest challenges
3PL service providers face.
F i g u r e 2 - 1 0
Total Third Party Logistics Market: Impact of Top Industry Challenges (India), 2006-2012
Rank Challenge 1-2 Years 3-4 Years 5-7 Years
1 Geographical Size and Diversity High High High
2 Stiff Competition and Pricing Strategies High Medium /High Medium /High
3 Multinational Companies are at a Disadvantage Compared to the Indian ones
Medium /High Medium Low/Medium
4 Integrating Supply Chains and Providing Visibility along the Entire Chain
Medium /High Medium Low/Medium
5 Security Concern is a Critical Issue Medium Low/Medium Low
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-24
S t i f f C o m p e t i t i o n a n d P r i c i n g S t r a t e g i e s
There is stiff competition among 3PL service providers in the Indian f. Service providers
would be willing to offer extremely competitive rates to companies to seize existing busi-
nesses held by their competitors. Pricing may be one of the key issues companies consider
when choosing 3PL service providers. In order to stay competitive companies may have to
constantly monitor pricing strategies.
M u l t i n a t i o n a l 3 P L C o m p a n i e s a r e a t a D i s a d v a n t a g e
C o m p a r e d t o t h e I n d i a n C o m p a n i e s
Indian 3PL service providers, by virtue of better knowledge of the local markets dynamics,
are at an advantage when compared to multinationals. Local 3PL service providers have a
better know-how of the processes and can liaison better with 2PL service providers to
provide their clients with better services. Moreover, domestic 3PL service providers have
better network access than their multinational counterparts, giving them a greater presence.
I n t e g r a t i n g S u p p l y C h a i n s a n d P r o v i d i n g V i s i b i l i t y
A l o n g t h e E n t i r e C h a i n
Companies are beginning to demand increased visibility along the supply chain to get infor-
mation about their inventories in the transit and storage points. Though service providers do
provide information services to their clients, there is definitely a lot of room for improve-
ment. This can specifically be the case where clients operate with more than one service
provider at different points along the supply chain. Enabling the smooth flow of information
from one service provider to another and provision of IT integration remains a key challenge.
S e c u r i t y C o n c e r n i s a C r i t i c a l I s s u e
Considering that supply chains are a very key area in gaining a competitive edge, companies
may prefer managing them in-house, rather than outsource it to a 3PL service provider. Other
concerns such as product theft and improper handling continue to be the dominant issues to
be addressed. Addressing these issues and reassuring the client about product safety and
confidentiality are key challenges. This is not a very formidable challenge though and over
the years the impact of this is expected to gradually wane as the market is poised for healthy
growth.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-25
Market Drivers
Figure 2-11 shows the market drivers ranked in order of impact for the total Indian third
party logistics market from 2006 to 2012.
Source: Frost & Sullivan
G r o w t h o f M u l t i n a t i o n a l O p e r a t i o n s D e m a n d
P r o f e s s i o n a l L o g i s t i c s M a n a g e m e n t
With the opening up of the Indian economy to foreign companies, entrants may not consider
it a very viable option investing in logistics infrastructure. Hence,they are likely to outsource
their logistics operations in the country to a 3PL service provider. Local 3PL service providers
such as GATI, AFL, Safexpress, and Om Logistics have excellent expertise in providing solu-
tions for a variety of industry verticals. In certain other cases 3PL service providers holding
key global partnerships with multinationals enter India together, thereby making an attempt
to establish a base in the country. Moreover, companies entering the country may not be
conversant with the complex business and tariff laws and so they require a 3PL service
provider with a grasp on such aspects.
F i g u r e 2 - 1 1
Total Third Party Logistics Market: Market Drivers Ranked in Order of Impact (India),
2006-2012
Rank Driver 1-2 Years 3-4 Years 5-7 Years
1 Growth of Multinational Operations Demands Pro-fessional Logistics Management
High High Very High
2 Growing Inclination to Outsource Logistics to Spe-cialists
High High Very High
3 Economic Growth Across Different Sectors Necessi-tates Smooth Flow of Supply Chain
High High High
4 Infrastructure Development/ Facilitates Logistics Low/Medium High Medium /High
5 Implementation of an All India VAT System Low/Medium Medium Medium /High
6 Declining 3PL Rates is Likely to Cause More Out-sourcing
Low Medium /High High
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-26
G r o w i n g I n c l i n a t i o n t o O u t s o u r c e L o g i s t i c s t o
S p e c i a l i s t s
Frost & Sullivan observes an increasing trend toward outsourcing of logistics operations of a
company to professional 3PL service providers. This is a positive trend for the 3PL service
providers and it is taking place because companies have realized the importance of concen-
trating on their core competencies, leaving logistics to the experts. This trend is still in a
fairly early stage. At present the level of outsourcing of services may vary between industrial
sectors, with some of them opting for either a partial or a full service depending on the need.
In the Indian FMCG sector, outsourcing of warehousing operation is likely to grow. This is
due to the industry giants such as Hindustan Lever and Marico Industries outsourcing a part
of their warehousing to multinational 3PL service providers such as Exel logistics and
Sembcorp Logistics. In the Indian automotive sector though, professional logistics manage-
ment is likely to witness a fairly strong growth, with concepts such as JIT delivery becoming
standard. The retail sector is also experiencing a trend in logistics outsourcing. With the
opening up of the Indian market? to foreign investment in the retail sector, it is expected that
international giants such as Wal-Mart, Carrefour, and TOPS are likely to make it mandatory
for their suppliers to supply to them through a dedicated 3PL service provider. In fact,
existing retail chains such as Lifestyle International have outsourced the vast majority of
their supply chain to dedicated 3PL service providers such as Exel and Om Logistics. It may
not be long before the entire supply chain management process is outsourced, as the volumes
handled by the retail chains are massive. In the IT hardware and electronics sector also
outsourcing is expected to be on the rise with the multinational companies such as Thomson
Electronics and Samsung and even Indian business houses such as the Apcom Group
outsourcing their logistical requirements in part or in whole.
Outsourcing of logistics to a 3PL service provider is beginning to be regarded as a move in
the right direction as companies focus on cutting costs and reducing product delivery times
significantly, thereby increasing customer satisfaction.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-27
E c o n o m i c G r o w t h A c r o s s D i f f e r e n t S e c t o r s
N e c e s s i t a t e s S m o o t h F l o w o f S u p p l y C h a i n
The Indian economy has been consistently growing at 7 to 8 percent annually for the past
couple of years. The sectors that have been driving the growth to a very great extent include
the automotive and auto components and engineering, which are the biggest users of 3PL
services, considering the criticality of time involved in their operations. The use of 3PL serv-
ices in the automotive sector is expected to grow in excess of 20 percent annually. In the
engineering and auto sectors, the vendor base is large, and is likely to possibly result in
greater logistical activity. India, along with China and Thailand is expected to be an attrac-
tive destination for manufacturing industries. In other sectors such as FMCG, even though
growth has been relatively stagnant at an annual rate of around 4 percent, a trend in
outsourcing individual services such as warehousing is witnessed. The Indian pharmaceutical
sector is expected to be one of the more promising in the world. The large volumes generated
by the pharmaceutical companies are likely to need a professional logistics management
system in the near future. There have been several instances in the past where large consign-
ments of spurious drugs have been recovered, necessitating the use of 3PL service providers
that have the necessary technology and expertise to tackle fake drugs and manage the
consignments. Another area of growth is Textiles. Textiles find a very large market in India
itself and the country is one of the top exporters in the world. A lot of the textiles reach
supermarkets and hypermarkets around the world, requiring very complex supply chains that
need to be managed efficiently and professionally. Other sectors such as IT hardware and
consumer electronics have a great potential for outsourcing as these are in the high-value
category. The Government of India has opened up cargo transportation by rail to the private
sector also, ending the monopoly previously enjoyed by Container Corporation of India
(CONCOR) a subsidiary of the Indian railways. Rail freight in India is expected to grow at
around 20 percent annually and 3PL service providers such as Reliance Logistics an APL
Logistics have expressed a keen interest in setting up inland container depots and operating
trains.
I n f r a s t r u c t u r e D e v e l o p m e n t F a c i l i t a t e s L o g i s t i c s
The present day Indian roads meet international standards. Though this is confined to only
the national highways and certain state highways, an initiative by the Government to
upgrade infrastructure is likely to be taken as a step in the right direction. The building of the
Golden Quadrilateral network of roads, connecting the four major metropolises of India
along with other major cities, and the NSEW corridor, which traverses the length and the
breadth of the country, has facilitated easier and quicker transportation. The roads in the
country are a lot safer than what they were previously. The communications infrastructure
has also made major improvements enabling services such as vehicle tracking, which are now
becoming trends across the industry. Patel Logistics has tied up with a leading mobile phone
service provider to use the existing setup available for enabling tracking through SMS.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-28
I m p l e m e n t a t i o n o f a n A l l I n d i a V A T S y s t e m
The Indian Government decision to repeal the existing sales tax system and replace it with a
uniform nationwide VAT is expected to alter the way supply chains are managed.Companies
are likely to move from an existing setup of multiple warehouses to larger and fewer ware-
houses, with even multiple companies using a single warehouse. The reorganization of the
warehouses needs professional management and this provides an opportunity 3PL service
providers.
D e c l i n i n g 3 P L R a t e s i s L i k e l y t o C a u s e M o r e
O u t s o u r c i n g
As competition increases between the 3PL service providers in the Indian market, pricing of
services becomes a key issue. Even today, clients are not hesitant to show a 3PL the rates they
have been offered by competitors. This may lead to stiff competition in the industry, with
companies reducing service rates significantly to stay competitive. These declining rates are
likely to increase outsourcing. Reducing rates may greatly strain profit margins; however,
this can be well offset by a larger customer base.
Market Restraints
Figure 2-12 shows the market restraints ranked in order of impact for the total Indian third
party logistics market from 2006 to 2012.
Source: Frost & Sullivan
F i g u r e 2 - 1 2
Total Third Party Logistics Market: Market Restraints Ranked in Order of Impact (India),
2006-2012
Rank Restraint 1-2 Years 3-4 Years 5-7 Years
1 High Cost of Logistics in India High High Medium /High
2 Existence of Infrastructural Bottlenecks High Medium /High Medium
3 Non Uniform Implementation of VAT, Complex Laws, and Sales Tax Regulations are not Favored by Compines
Medium /High Medium /High Medium
4 Outsourcing to a 3PL Service Provider Attracts a Service Tax
Medium Medium Low/Medium
5 Competition from the Unorganized Segment Medium Low/Medium Very Low
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-29
H i g h C o s t o f L o g i s t i c s i n I n d i a
The cost of logistics in India is relatively higher than the developed economies of Europe and
North America. It is estimated at 13 percent of the GDP of the country, and even a small
reduction can lead to major savings. The cost of logistics in Europe and North America is
generally around 7 to 8 percent of the GDP. The rising fuel prices, improper management of
resources, and lack of initiatives have been responsible for this to a great extent.
E x i s t e n c e o f I n f r a s t r u c t u r e B o t t l e n e c k s
The development of infrastructure by the Government of India may have started; however,
the country still has certain troubles with its logistics infrastructure. The national highways
that carry the bulk of the country's freight comprise less than 2 percent of the total road
network but it carries in excess of 40 percent of the country's freight. Due to this 3PL service
providers may not be in the best position to serve the needs of their clients. With regard to
the rail networks, until very recently, before the sector opened up, there were not many
inland container depots to cater to the need of companies. Moreover, companies that sent
consignments over long distances had to wait days before they knew the status of their ship-
ment as they were not in a position to track their delivery. Though these are concerns on the
short term, a growing economy such as India is expected to leaven out these issues in the long
term.
N o n - U n i f o r m I m p l e m e n t a t i o n o f V A T , C o m p l e x L a w s a n d
S a l e s T a x R e g u l a t i o n s a r e n o t F a v o r e d b y C o m p i n e s
The existing octroi laws in the country are not favored by 3PL service providers. This can be
observed in the Indian state of Maharashtra, where octroi is applicable to goods entering an
octroi zone. Moreover, a state can have multiple octroi zones resulting in unnecessary cost
addition. This tax is regressive in nature and has a relatively low restraining effect as states
that continue having the tax are likely to repeal it very soon. Moreover, it is not also not
practiced in many states. The present day 3PL service providers are forced to maintain ware-
houses in multiple states, thereby losing the advantages they can derive by achieving
economies of scale. The impact again is expected to be low as the sales tax system is likely to
be eliminated.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-30
O u t s o u r c i n g t o a 3 P L S e r v i c e P r o v i d e r A t t r a c t s a
S e r v i c e T a x
Outsourcing to a 3PL service provider, especially services such as Express Transport attracts
a service tax. Express transport, which is a very efficient mode for time bound safe shipment,
attracts a service tax of 12 percent. However, this is not the case with traditional trucking
services. Express transport therefore tends to become more expensive, and companies that
wish to outsource the service to a professional party may have to reconsider their decision to
outsource. This is extremely disadvantageous for 3PL services as these have tremendous
potential for growth. However, the same service tax is not applicable to rail freight and tradi-
tional trucking, hence putting 3PL service providers at a disadvantage.
C o m p e t i t i o n f r o m t h e U n o r g a n i z e d S e g m e n t
Companies in the unorganized sector do not offer sophisticated services or have human
resources with a great amount of technical expertise. These may own real estate or vehicles
and provide trucking and storage to companies at extremely competitive rates. Though this
may not be very professionally done, it still greatly serves the customers purpose. For
example, a trucking agency with just five trucks could be on a contract with a local FMCG
company for local distribution. The rates may be extremely competitive and overloading of
the vehicle may be permitted, which in certain cases may not be legal. These are not appli-
cable with a 3PL service provider as it would be violation of policy issues such as using only
containerized trucks. Instead, if the above needs to be done, 3PL companies may use the serv-
ices of a local 2PL provider, to make processes more convenient.
Major End-Users of 3PL in India
Figure 2-13 shows the top end-user sectors for the total Indian third party logistics market in
2005.
Source: Frost & Sullivan
F i g u r e 2 - 1 3
Total Third Party Logistics Market: Top End-user Sectors (India), 2005
Automotive and Auto components Sector
IT Hardware
Consumer Electronics and Durables
Pharmaceuticals
Healthcare
Retail
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-31
The industry sector that generates the maximum revenue for the 3PL market in India is theautomotive and auto components. The need of this sector for seamless logistics have caused arelatively higher penetration of 3PL services as opposed to others. Concepts such as JIT andKanban have caught up fairly well with automobile manufacturers. Outsourcing in thissector is mainly considered as an important cost-saving measure, as manufacturers do notwish to maintain more than a few hours of inventory along the assembly line. With Indiabecoming the next manufacturing destination for global automobile manufacturers such asBMW, Honda, and Suzuki, the growth potential in this sector is very good. Most of thepresent day automobile manufacturers partly or fully outsource their logistical requirementsto 3PL service providers.
After the automotive and auto components sector, the revenues generated in the Indian 3PLmarket is highest in the IT hardware and electronics sector. The level of outsourcing to a 3PLservice provider in this sector is very high. The logistical challenges faced by the sector makeit imperative to outsource to a 3PL service provider. A lot of companies have benefitted fromoutsourcing to a 3PL service provider in this sector.
Other sectors that employ 3PL services in India are the consumer durables, pharmaceuticals,FMCG, and retail sectors.
I m p l i c a t i o n s o f V A T o n 3 P L
Introduction to VAT
The recent decision of the Government of India to implement a nation wide VAT system, asopposed to the existing system of sales tax, may be seen as a step in the right direction.
The sales tax system in India until now was highly regressive in nature. There were two typesof sales tax namely the local sales tax and the central sales tax. The local sales tax had to bepaid for a sale made within a state, while the central sales tax had to be paid in the case ofinter state sale of goods.The local sales tax may vary from state to state. The company canaccordingly bill the goods in a state depending on the tax saving it can obtain. Hence, goodsmanufactured in one state are shipped to a depot or a warehouse in the state where the sale isto be made. This system has had a negative effect on supply chains in India. It has forcedcompanies to maintain warehouses or depots in several states spread across the country withan intent to save tax. Hence, the supply chain management in India has for long beengoverned by tax saving motives than geographical convenience. For example a company thatneeds to transfer goods from a depot to a retail outlet in cities close to each other but indifferent states, may find it more economical to do the same from a depot in the same state,even if the distance is greater. This is with a motive to avoid the applicability of the centralsales tax. This is also not desirable as a large number of warehouses will hold more invento-ries, more manpower and resources to be managed, thereby leading to costs that mayotherwise be avoided. The whole system has contributed to high levels of inventories in themanufacturing sector, resulting in the working capital getting locked for long durations oftime, and reducing inventories by even a small amount can release capital that is hard tocome by. A company's IT infrastructure will also need to be in position to synchronize thevast pool of resources spread across the country.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-32
Transportation, inventory, and warehousing account for the three largest cost components in
any supply chain activity. In India there are a number of taxes such as central sales tax, local
sales tax, octroi, and entry tax. Many of these taxes are governed by individual states in
India, and may hence vary between them. State borders in India are notorious for being
centers of illegal trafficking and harassment by corrupt authorities. Trucks drivers have to
wait long hours at borders for completing inter state formalities and paperwork, in the
process consuming a lot of precious corporate resources and time. The system has necessi-
tated the presence of C&F agents that are an extra step in the supply chain.
At present, the sales tax system requires that tax be paid at every stage of the value chain,
resulting in a cascading tax effect. Transactions within a single company do not attract sales
tax and hence cascading can be avoided. This would require the company to integrate back-
wards thereby, making it less efficient as compared to a value chain containing multiple firms
working in harmony. The elimination of the sales tax system and consequentially, the imple-
mentation of VAT can help in making changes to the present scenario.
The system of VAT is expected to replace the redundant sales tax system in the near future.
Though VAT has been implemented in certain states in the country, it is yet to take effect in
the others. This is likely to take place in the near future. The VAT system is expected to elim-
inate the inherent deficiencies in the Indian tax system. Tax at any point along the value
chain may be charged only for the value added at each stage, as opposed to a whole taxation.
This would make taxation more transparent, with companies requiring and recording a sale
in order to benefit a tax credit from the government. This also helps the Government to
prevent tax evasion by traders. On the whole the supply chain management in the country is
expected to benefit from the implementation of VAT.
Challenges for 3PL Service Providers due to VAT's impact
The transition to a uniform national VAT system is expected to be chaotic and it is likely to
be surrounded by a significant degree of confusion. At present, many 3PL service providers
are still in the process of gathering information on VAT. This has prompted many companies
to have multiple tax modules in place, in order to comply with the VAT system right from the
day it is implemented. Once complete, the transition is expected to set supply chains of the
country in perfect working order.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-33
R e o r g a n i z a t i o n o f I T I n f r a s t r u c t u r e m a y b e
C o m p l i c a t e d
One of the challenges that 3PL service providers may face during the transition to a fully
VAT compliant system is the reorganization of the IT infrastructure in order to maintain
records and transactions to meet VAT standards. Companies will need the right IT infrastruc-
ture to track transactions at every stage along the supply chain to gain maximum advantage
from VAT. Synchronization of IT systems on a national level may pose a formidable chal-
lenge.The sales tax departments in various states will also need significant IT restructuring to
cope up with the new tax system.
M a i n t a i n i n g L a r g e V o l u m e s o f T r a n s a c t i o n a l R e c o r d s
C o u l d b e a D i f f i c u l t T a s k
The VAT system taxes only the value addition at each stage along the value chain, as opposed
to whole taxation under the previous system. To avail input tax credit for a transaction there
needs to be proof that a sale has been made by maintaining records of same. This will entail
additional paperwork that poses as a considerable challenge. The new system will require
companies and dealers to maintain two separate records of sales and purchases. Ensuring
minimum flow of documents and paperwork could be one by enhancing IT infrastructure
which could ultimately replace all document flow. Moreover, states have varying require-
ments to maintain records under the new system. With the non-uniform implementation of
VAT across the country, the documentation requirements can vary between states, requiring
companies to maintain two sets of documents. All these will affect 3PL service providers
offering invoicing services to their clients as record keeping costs have to reach new highs.
N o n u n i f o r m i t y o f V A T I m p l e m e n t a t i o n A c r o s s t h e
N a t i o n a n d t h e C o - e x i s t e n c e o f V A T w i t h t h e C e n t r a l
S a l e s T a x s y s t e m i s C o m p l i c a t i n g
VAT has not been implemented throughout the nation uniformly, with some states reluctant
to implement the system. These states are continuing with the outdated local sales tax
system. As a result, there exist certain confusion about the VAT system. These include
deciding the appropriate supply chain model for sales between states. For example, for a sale
to be facilitated from state A to state B, one complying with VAT and the other not
complying, supply chain models that enable maximum profitability need to be worked out.
Certain states may have shown a reluctance to implement VAT as it has not been very
popular among the trading community. This is likely to change after elections in states going
to the polls, as political parties in power may not want to invite the wrath of the traders.
Change is likely to be expected and by 2008 the country is expected to have a uniform VAT
regime.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-34
At present the central sales tax payable for a sale has not been eliminated. It continues to
exist along with the VAT in the states where it has been implemented. This defies the logic
behind shifting to a new warehousing model as the motive behind having C&F agents in each
state was to avoid the applicability of the 4 percent central sales tax on the invoiced amount.
Input tax credit is presently available on purchases made; however, it cannot be claimed on
central sales tax payable on inter state transactions. Central Sales Tax is expected to be
completely phased out by 2010.
C o m p e t i t i o n f r o m t h e U n o r g a n i z e d S e g m e n t P o s e s a
S i g n i f i c a n t C h a l l e n g e t o t h e G r o w t h o f t h e s e
C o m p a n i e s
The unorganized segment that predominantly comprises the C&F agents may be seen consol-
idating gradually and moving into organized 3PL service providers. The threat from this
segment though may not be significant considering the fact that 3PL service providers have
greater technical expertise than the former. The only real competition may be in the form of
pricing strategies employed by the C&F agents, which could also be offset by the quality of
services the 3PL service providers offer. Even though a nationwide implementation of VAT
could witness reorganization in the distribution of warehouses from plenty to just a small
number of zonal warehouses. In certain industries such as pharmaceuticals and FMCG, the
C&F model is likely to be used for some more time. This is due to the fact that companies
will want to maintain a state wise strategic distribution point to stay ahead of competition.
Apart from the challenges mentioned above, there could be certain sentimental issues associ-
ated with shifting to the new system. Long-term relationships with C&F agents could come
to a halt, resulting in loss of employment. Added to this, many C&F agents have service-level
agreements with companies and shifting to the new system will be gross violation of the
agreements. In many cases, C&F agents are also distributors for companies and cannot be
removed within a short time frame for strategic reasons.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-35
Opportunities for 3PL Service Providers due to VAT's impact
The implementation of VAT is expected to witness 3PL warehousing specialists move into a
space perviously occupied by the highly unorganized C&F agents.
With the implementation of a nationwide VAT expected to be completed very soon by
2008,and the abolition of central sales tax by 2010, many companies may try to reorganize
their supply chains in order to cut costs. Previously, companies maintained stocking points at
multiple locations across the country as the sales tax gains obtained outweighed the costs of
setting up and running additional stocking locations. Multiple stocking points meant extra
usage of resources and hence additional costs in terms of manpower, resources, and invento-
ries. With the elimination of central sales tax expected to take place in the near future,
companies are moving fewer zonal warehouses, as it is more economical. Companies are
expected to start consolidating their warehouses and possibly try to outsource some of their
warehouses. The 3PL service providers can take advantage of this opportunity. Companies
can also gain by outsourcing their warehousing to 3PL service providers as they have the
required expertise in maintaining warehouses and can handle fluctuating volumes. The
present system of C&F agents, who have been thriving under the previous sales tax system,
are likely to remain for some more time. Eventually, it is expected that they will ultimately
upgrade the existing facilities to a 3PL warehouse or consolidate with 3PL service providers,
or get eliminated from operating in certain sectors. Companies are likely to find it more
convenient to manage one or more 3PL service providers compared to the past.
Post implementation of VAT, consolidation of warehouses from many spread across different
states to just a few zonal hubs is expected to take place. There is expected to be greater
volumes of goods to handle and information from fewer warehouses, which is likely to lead
to the implementation of technologies and tools such as robots, conveyor belts, cranes, and
fork-lifts imperative. The C&F agents may not be able to provide services with this level of
sophistication, placing 3PL service providers at a clear advantage.
The apparel industry may need to operate out of high capacity warehouse facilities consid-
ering the large volumes being handled. Investing in these facilities may not be economically
viable and leading brands may occupy multi-user warehouses operated by a 3PL service
provider. This can also take place in the pharmaceuticals and FMCG sectors, where margins
are already strained greatly. The retail sector is also expected to benefit as direct factory to
retail shipping will become more viable. The 3PL service providers can take advantage of the
opportunities opened up by these sectors. Large multi-user warehousing facilities can help
3PL service providers leverage economies of scale.
Implementation of VAT is also expected to start automating the supply chains in India greatly
as companies will need to record financial transactions at every point along the supply chain
and information about the physical movement of goods. This will need appropriate tech-
nology implementation, which 3PL service providers in India have already started offering.
An indirect result of this could be better managed supply chains, which is something 3PL
service providers could offer to their clients.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 2-36
3End-User Analysis—Overview of 3PL Needs
and Practices in India
O v e r v i e w o f 3 P L N e e d s a n d P r a c t i c e s i n I n d i a
3PL Usage in the Indian Automotive and Auto Components Sector
Chart 3.1 shows the logistics model followed by a leading MNC Vehicle Manufacturer in the
Indian third party logistics market in 2005.
C h a r t 3 . 1
Third Party Logistics Market: Logistics Model followed by Leading MNC Automakers
(India), 2005
Source: Frost & Sullivan
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-1
The automotive and auto components sector is the largest revenue generator in the Indian
third party logistic (3PL) market. The entire automotive and auto components sector in India
is estimated at $40 billion. With the growth of India as one of the next destinations for auto-
mobile manufacturing outside Europe and North America, the growth of 3PL operations in
this sector is driven with the increasing need for professionally managed supply chains.
Indian manufacturers are beginning to adopt global best practices and have started realizing
cost benefits that can be derived by concentrating on core competencies and delegating logis-
tics to professional agencies.
The penetration of the 3PL concept is one of the highest in this sector with manufacturers
demanding seamless logistics. Most Original Equipment Manufacturers (OEMs) source from
a large and geographically diverse vendor base. Integrating the supply chains of these
vendors seamlessly poses a formidable challenge. Inbound logistics was previously not
greatly focused on because of the complication and criticality involved in operations, consid-
ering that late deliveries could disrupt manufacturing schedules and early deliveries could
result in unnecessary inventory holding costs. One of the reasons for this was the wide
geographical spread of the vendor base. Some companies in places such as the west Indian
state of Maharashtra had vendors located as far as the south of the country. Consolidation of
the same was difficult considering the varying sales tax rates in states. Outsourcing to a 3PL
service provider has reduced these problems considerably, as these companies slightly
tweaked the sourcing patterns and managed transporters and freight providers to make the
supply chain more efficient.
Concepts such as Kanban and just-in-time (JIT) delivery to the assembly line are gaining
acceptance, Certain companies hold only a few hours of inventory and replenish stock regu-
larly. As a result, professionally managed inbound logistics solutions is being increasingly
considered as a viable cost saving option. This can be witnessed on a regular basis with
leading automobile manufacturers, where daily milk runs by 3PL service providers are
conducted to provide seamless inbound logistics, instead of waiting for the vendor to supply
it, thereby helping in reducing the number of vehicles entering the factory premises and main-
taining optimum levels of inventory.
Another trend that is beginning to be observed is the growth of vendor managed inventory
(VMI). VMI is a means of optimizing supply chain performance wherein suppliers have
access to manufacturing schedules and inventory data and are accordingly responsible for
maintaining inventory as required by the customer. In the past, OEMs have been known to
carry inventories of several days or even months, owing to the lack of visibility along the
supply chain, leading to very high levels of working capital. It increases the transparency
along the supply chain. In VMI, the 3PL service provider plays a very critical role in ensuring
that consignments are brought to the satellite warehouses for putting in bins and trans-
porting to the factory just-in-time (JIT) for assembly. It can be said that The level of IT
integration along automotive supply chains is higher than that in other sectors; however,
there is definitely a great amount of room for improvement.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-2
Outsourcing of warehousing operations to a 3PL service provider is witnessing a growing
trend in this sector. With inventories getting replenished at very short intervals in the ware-
house, a large number of stock keeping units to maintain the use of 3PL managed warehouses
could become imperative. These are highly technology driven warehouses with high-end use
of sophisticated material handling equipment. IT usage in warehouses has also gained accept-
ance with the implementation of warehouse management solutions to provide real-time
visibility about inventories in the warehouse. Adoption of technologies such as the use of
Radio Frequency Identification (RFID) tags in warehouses may just be witnessing a growing
trend. This being followed in certain warehouses of Ashok Leyland Limited at Hosur and
Maruti Udyog Limited. At present local sourcing is rife in the Indian automotive sector. India
is one of the next component sourcing destinations for global automotive giants such as
General Motors (GM). In fact GM have announced plans to source $1 billion worth of auto
components from India annually by 2008. Growth in internationally linked supply chains is
expected to be a key growth driver for 3PL services in this sector. Currently, more than
60 percent of the demand for auto components is from the aftermarket with most OEMs
having well established supply chains to cater to the same. The export channel accounts for
the smallest demand while the other demand comes from the OEMs.
The uniqueness of logistics for the automotive sector has witnessed the growth of many 3PL
service providers that operate in this niche segment. Companies such as TVS Logistics and
Transystem Logistics International are pure auto logistics companies. There are other compa-
nies such as Om Logistics that predominantly operate in the automotive sector. Pricing
strategies in the segment are highly competitive leading to increasingly lower rates offered to
clients.
The implementation of a uniform VAT system and the elimination of the present sales tax
system is expected to make auto supply chains a lot more leaner. Sourcing from other states is
expected to become cheaper and more efficient as bottlenecks such as inter-sate border legal-
ities are expected to be eliminated.
Hence, there is a major potential for growth of 3PL services in the automotive and auto
component sector. The sector continues to be one of the key drivers for the growth of 3PL
services in India.
Leading 3PL companies in this sector include Om Logistics, Total Logistics, Transystem
Logistics, and TVS Logistics.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-3
3PL Usage in the Indian IT Hardware and Electronics Sector
Chart 3.2 shows the standard model of goods flow in the IT Hardware and Electronics sector
of the Indian third party logistics market in 2005.
C h a r t 3 . 2
Third Party Logistics Market: Standard Model of Goods Flow in the IT Hardware and
Electronics Sector (India), 2005
Source: Frost & Sullivan
The India IT Hardware and electronics sector was worth $11.0 billion in 2005. The logistics
of the Indian IT hardware and electronics sector is very challenging. The competition in the
industry sector is very intense and companies consider their supply chains as a means of
gaining a competitive edge.The challenges are several. Logistics will be carried out with
minimal disruptions at the same time help in the growth of revenues and profits. The growth
of 3PL managed logistics in the sector is on a growing trend and the penetration of 3PL
service providers in the logistics of the industry is very high.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-4
In the IT sector, getting the goods to the retail shelves is of critical importance as, in many
cases, time literally translates to sales and hence capital. Opportunity costs involved in the
sector are very high. At present one of the key areas of focus in logistics of this sector is effec-
tive planning of inventory. The most affected along the supply chain in terms of inventory
costs are the value-added re-sellers and the distributors. These are experimenting with
different forecasting models to decide on a model that is most economical. Distributors and
vendors are generally inclined to plan their inventories on a monthly cycle, while the Value
Added Re-sellers (VAR) prefer it on a daily cycle. Inventory holding costs in this sector are
high. This has led to a growth in the outsourcing of inventory management in the industry.
Companies that were previously maintaining inventory levels of up to 30 days have benefited
by outsourcing to a 3PL service provider, which has helped in reducing inventory levels to a
week. Companies now determine minimum order quantities and ordering is done in three to
four cycles every month to maintain optimum inventory. Product life cycles in the IT hard-
ware sector are very low, thereby requiring very effective forecasting. Selling stocks of
leading companies is not an easy task as products have to be available with the distributor
for it to be sold. This requires very effective forecasting and logistics management.
Freight constitutes around 60 percent of the costs in the logistics. With the cost of transpor-
tation increasing annually due to hike in fuel prices worldwide, it will be cost effective to
outsource logistics management to a 3PL service provider. Distributors such as Redington,
Rashi Peripherals, and Savex have tied up with 3PL service providers such as Gati, Safex-
press, and AFL. One of the concerns expressed by companies is that there are only a few
logistics service providers that provide committed delivery schedules.
Warehousing operations are also beginning to be outsourced to 3PL service providers.
Companies generally maintain warehouses at multiple locations to enable tax savings under
the existing sales tax system. This requires large IT support infrastructure in terms of inven-
tory forecasting and control. Warehousing costs in the industry are high due to cost of
storage, insurance, depreciation, and obsolescence. Companies generally tie up with 3PL
service providers to use warehouse space and pay a fixed amount every month. In the future,
more sophisticated warehouses enabled with warehouse management systems software and
tracking devices are expected.
With the implementation of VAT,there is likely to be a change in the distribution strategies
adopted by companies as the industry will be relieved from the effects of cascading taxes and
companies could shift to centralized distribution models. Warehousing in this sector is then
expected to witness a healthy growth after the uniform VAT is implemented.
Skilled management of logistics in the industry needs effective procurement at the right price
and time. Controlling physical movement of goods is of utmost priority and hence there is a
necessity to provide track and trace facilities. Outsourcing to a 3PL service provider will help
clients achieve seamless logistics with visibility along the chain.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-5
One of the disadvantages of outsourcing to a 3PL service provider is the applicability of
service tax, especially on express transport, a service that is of importance to the IT Industry.
The logistics of the sector need professional management and hence companies are increas-
ingly outsourcing to professionals. The penetration of 3PL services in the logistics of this
sector is among the highest across all verticals.
Leading 3PL companies in this sector include AFL Logistics, Exel Logistics, Safexpress, and
SembCorp Logistics.
3PL Usage in the Indian FMCG Sector
Chart 3.3 shows the standard model of goods flow in the FMCG sector of the Indian third
party logistics market in 2005.
C h a r t 3 . 3
Third Party Logistics Market: Standard Model of Goods Flow in the FMCG Sector (India),
2005
Source: Frost & Sullivan
The Indian fast moving consumer goods (FMCG) sector was valued at $14.5 billion in 2005.
The logistical requirements of the sector are huge. The logistics of this sector has for long
been dominated by participants in the unorganized segment, with small time truckers and
C&F agents playing a very crucial role. This unorganized format of logistics is because the
volumes of goods manufactured and the geographical diversity of India's consumers. This
cannot be handled by any single logistics company. There is a very high degree of decentrali-
zation in the logistics of this sector with stockists and dealers spread all over the country.
Manufacturing Unit
Central Warehouse
State/Regional
Warehouse
District Level Stock
Point
Town Level Stock
Point
Retailer
Indian FMCG Sector - Standard Goods Flow Model
Owned by Company
Owned by Company
Owned by C&F Agent
Owned by Distributor
Owned by Wholesaler
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-6
There are around 3.3 million retail outlets to cater to by these companies. The logistics of the
FMCG sector demand that stock keeping units be made available on retail shelves to a great
extent to prevent customers switching brand loyalty. Distribution strategies employed by
companies are also very aggressive.
In spite of the nature of competition that exists in the industry, professionally managed logis-
tics is hardly seen. There could be several reasons for this. Firstly, as FMCG companies
operate on slim margins, outsourcing to a 3PL may hike up distribution costs as these service
providers charge high rates. This can result in slimming margins further. Secondly, the supply
chain is one of the most critical components of an FMCG company's operations, and
outsourcing the entire chain would mean investing all its resources with one service provider.
Any disruption in the chain could have disastrousconsequences on distribution activity and
this is something that FMCG companies cannot afford in such a competitive scenario. Clients
are also not convinced about the infrastructure capabilities of the 3PL service providers to
manage the large volumes produced.
Transportation activity in the logistics of the FMCG sector is predominantly in the done by
the unorganized sector. The activity is outsourced to local truckers who generally have a
long-term working relationships with local company depots. The activity is managed very
unprofessionally and the trucks run on full loads. There is no proper weather proofing avail-
able and the vehicles are covered with tarpaulin covers in the event of rain to prevent water
from seeping in. The disadvantages with the unorganized segment are very high. There is a
lack of accountability, and malpractices such as fuel pilferage are common. In spite of this
companies do not mind operating with the unorganized segment, as it is cost effective and
also honors a long-term relationships with the truck owner.
The warehousing operation is predominantly in the form of clearing and forwarding (C&F)
agents, whose presence has been necessitated because of the redundant sales tax system in
India. The C&F agents have flourished under the past system. Companies have used them to
effect stock transfers between states. Some companies find it very convenient with C&F
agents due to long standing relationships with them and these agents also release scarce
working capital. This type of warehousing lack professionalism and is more of a storage
function only.
Organized 3PL warehousing can be seen on the growing trend with industry leaders such as
Hindustan Lever Limited, Dabur, and Marico outsourcing their requirements, albeit in a
small way, to 3PL service providers such as Exel Logistics and Sembcorp Logistics. Most
companies have started outsourcing on purely an experimental basis. In fact Hindustan Lever
has outsourced their warehouse at Bangalore to Exel logistics after a successful experiment at
their Hyderabad warehouse.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-7
The implementation of VAT is likely to witness supply chains being altered in the FMCG
sector. One interesting opportunity that 3PL service providers can look forward to is occu-
pying a position previously held by C&F agents. The margins in the FMCG sector are already
low and hence 3PL service providers cannot expect very high margins. The growth in this
sector is expected to come from professional warehousing, with leading companies increas-
ingly outsourcing to 3PL service providers.
Leading 3PL companies in this sector include Exel Logistics, Gati, Reliance Logistics,
Sembcorp Logistics, and TCI Supply Chain Solutions
3PL Usage in the Indian Pharmaceuticals Sector
Chart 3.4 shows the standard model of goods flow in the pharmaceuticals sector of the
Indian third party logistics market in 2005.
C h a r t 3 . 4
Third Party Logistics Market: Standard Model of Goods Flow in the Pharmaceuticals Sector
(India), 2005
Source: Frost & Sullivan
The Indian pharmaceuticals sector is one of the fastest growing in the country. It was valued
at $8.3 billion in 2005. The average spend on logistics is around 3.8 to 4 percent of the total
industry turnover. The average cost of logistics is greater in the case of companies that
operate cold chains.The penetration of 3PL service providers in this sector has been fairly
low, considering that they may not be equipped with the infrastructure to handle the large
volumes and diverse distribution networks that pharmaceutical companies need.
Manufacturing Unit
Central Warehouse
State/Regional
Warehouse
District Level Stock Point
Medical Representatives
Retailer
Indian Pharmaceuticals Sector - Standard Goods Flow Model
Owned by Company
Owned by Company
Owned by C&F Agent
Owned by Distributor
Owned by Wholesaler
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-8
A majority of companies manage their logistics themselves, either using a network of C&F
gents or through their own depots.This can change if some good 3PL service providers enter
the market. At present, penetration is very low, where there are only a few companies that
outsources the entire distribution to only one party. C&F agents work at a commission of 1
to 1.5 percent of the invoiced amount. They provide only space while all the billing is done in
the name of the company. All the other responsibilities lie with the company. In a vast
majority of the cases, the penetration of the 3PL service provider has been extremely low.
On an average, a little more than half of the total cost of a pharmaceutical product in India is
in the form of raw material costs. The sourcing of raw materials for the manufacture of bulk
drugs is characteristically complex, due to the large vendor base. Certain special chemicals
required for manufacture are available only outside the country, with long lead times.
Procurement of certain chemicals from alternate sources generally tends to be a more expen-
sive process, as tax and duty structures tend to make imports significantly cheaper than
chemicals sourced locally. Hence there are formidable inbound logistics challenges to be met
such as reducing the sourcing costs.
Transportation in the pharmaceutical sector is highly unorganized. Most of the transporta-
tion is in the form of traditional trucking. The unorganized truckers treat expensive
pharmaceutical consignments just as an ordinary one. Generally the whole consignment is
carried on full truck loads and just covered with a tarpaulin cover. Extreme weather condi-
tions such as heavy rainfall can damage consignments. The pharmaceutical sector in India is
in great need of professionally managed cold chains for drugs that need controlled storage
environments.
Growth of the express mode of transport could happen if companies realize the benefits of
using it. Presently the penetration of express transport in the transportation requirements is
low. This is expected to change once the road infrastructure of the country develops and
becomes more conducive for express transport. Currently, there is requirement for express
transport, considering the highly competitive nature of the pharmaceutical sector. However,
highly strained margins may deter companies from outsourcing to a professional 3PL service
provider.l.
The hidden costs involved in logistics of the pharmaceutical sector are high and these are
often overlooked. It will be possible to eliminate these costs by outsourcing to a 3PL service
provider. For example the time and effort of accountants, who are directly not connected but
still perform a very important role in the managing of supply chains is greatly overlooked
and this is a component that can be avoided by outsourcing to a 3PL service provider.
IT infrastructure along the supply chain is very poor. The way stocks are rotated poses a huge
challenge. Clearing near expiry date stocks faster is of paramount importance and most of it
is done manually. Presently, a large pharmaceutical company may have in excess of a hundred
distributors spread all over the country, an integrating them remains a major challenge. Due
to the drug price control orders imposed by the government, it is economical to adopt tech-
nologies such as RFID.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-9
Outsourcing to a 3PL service provider has started in warehousing operations. Many compa-
nies such as Lupin Laboratories, Dr. Reddy's Laboratories, and Ranbaxy have shown a
willingness to outsource their warehousing operations albeit to only a small extent. This is
expected to grow once a nationwide VAT system is implemented, eliminating the necessity of
a C&F agent to a great extent. The C&F agents manage their resources very unprofession-
ally, and generally do not have IT systems of their own. They are mostly provided by the
company itself.
Outsourcing to a 3PL service provider is expected to gain acceptance soon as there is an
increasing requirement for professional management of logistics. Companies may operate on
very low margins and 3PL service providers may need to operate with a critical mass of at
least five to six companies to stay competitive.
Leading 3PL companies in this sector include Safexpress, Gati, and Sembcorp Logistics.
3PL Usage in the Indian Retail Sector
Chart 3.5 shows the logistics model of leading retailers in the Indian third party logistics
market in 2005.
C h a r t 3 . 5
Third Party Logistics Market: Logistics Model followed Leading Retailers (India), 2005
Source: Frost & Sullivan
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-10
The Indian retail sector is currently worth $200 billion and it contributes to around
6.0 percent of the employment in the country. Although there are 12 million outlets across
the nation, majority of them are mom and pop shops with the organized segment contrib-
uting to around 3.0 percent of the total retail market.
The logistical needs of the retail sector depends largely on the scale of operations, the
product category, and retail format. The unorganized segment of retailing still employs
truckers and fleet operators to carry out their transportation activity and maintain very less
inventory in their own warehouses, which in most cases is a part of their shop. The penetra-
tion of 3PL service providers in this segment is as low as 2.0 percent. This can be attributed
to the fact that the small shops also form a part of the distribution network of a major 3PL
service provider and hence use their services in rare occasions.
The organized segment of retailing, which is the main driver for the 3PL market in India is
expected to have a high growth rate of around 30.0 percent by 2012. The organized retailing
segment is marked by foreign direct investment, entry of multinationals, and rapid expansion
of existing outlets across the nation. This is a direct result of the increasing levels of dispos-
able incomes among the middle class consumers and their aspiration to raise their standard
of living.
With the increasing need of the organized retailing in India, the 3PL needs are also expected
to be on the rise accordingly. Currently there is a low level of 3PL service adoption even
among the organized retailers. The transportation is partly carried out by organized service
providers and partly by truckers and local transporters. With the implementation of VAT, the
warehousing activity is expected to be streamlined, which is an added advantage for the retail
sector. It is expected to increase outsourcing of warehousing operations in the future. The
multinationals entering the Indian retail market are expected to take the expertise of 3PL
service providers to meet their logistical needs at a low cost with minimal investment in the
infrastructure. The need for information management is also increasing in order to stay
competitive. It essentially helps the local and multinational participants to track their inven-
tory and maintain minimal stocks and achieve greater cost efficiency in their supply chain.
These factors are expected to drive the retail sector toward outsourcing their logistics activi-
ties to a 3PL service provider till 2012.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-11
The organized retail participants include different segments such as apparel and lifestyle,
consumer durables, food and grocery, footwear and leather, home furniture and fixtures,
health and beauty-based multi-brand retailers, stationery and gifts, watch, and jewelry. The
logistics model for each of these segments varies significantly due to the nature of product
and the product life cycle. The future opportunities of 3PL service providers depend on their
ability to customize their services to suit the unique needs of each participant of this segment
and offer competitive rates.
The opportunities offered by the retail sector are large and the expectations are high;
however, the attitude is not so favorable. The Indian retailers are still not open to
outsourcing for fear of losing control over their supply chain. The 3PL service providers
therefore have to prove their competency by offering cost effective services and build a long-
term synergetic relationship with the retailers, which will attract the new entrants into the
market to outsource as well. Though the stabilization period for the 3PL market is expected
to continue for the next five years till 2010, the growth of the market after that period is
likely to be phenomenal with the increasing need and confidence of the retailers.
Leading 3PL service providers in this sector include Safexpress, Gati, Sembcorp Logistics,
and TCI Supply Chain Solutions.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 3-12
4Competitive Analysis of the 3PL Providers in
Indian Market
I n d u s t r y S i z e
Industry Size in Terms of Number of Companies
Figure 4-1 and Chart 4.1 show the industry structure by type of service provider in the Indian
third party logistics market in 2005.
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 4 - 1
Third Party Logistics Market: 3PL Industry Structure by Type of Service Provider (India),
2005
Category Number of Companies
National 3PL Service Provider 40
Regional 3PL Service Provider 30
Local 3PL Service Provider 360
TOTAL 430
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-1
C h a r t 4 . 1
Third Party Logistics Market: 3PL Industry Structure by Type of Service Provider (India),
2005
Note: All figures are rounded. Source: Frost & Sullivan
In 2005, the total number of service providers in the Indian 3PL market was estimated at
430. National 3PL service providers accounted for around 47.7 percent of the revenues
generated in the market. In 2005, there were around 40 national 3PL service providers in the
market. They have very strong distribution networks on a national scale and are highly
known and often used by large corporations for their logistical needs. There were around
30 service providers in the regional 3PL market. The regional 3PL service providers
accounted for around 43.5 percent of the revenues generated in the market. These 3PL
service providers deal with companies on a regional or state level basis and cater to the needs
of clients in local areas, as well as to places where national 3PL service providers do not have
a reach. There were around 360 local 3PL service providers in the market. The local 3PL
service providers accounted for around 8.8 percent of the revenues generated in the market.
These service providers have relatively much smaller scales of operations compared to the
regional and the national 3PL ones. They also have very well established networks on a
district or town level.
I n d u s t r y L i f e C y c l e
Current Status of the Industry Life Cycle
Chart 4.2 shows the life cycle of 3PL service providers in the Indian third party logistics
market from 2000-2015.
Local 3PL Service Provider
360
Regional 3PL Service Provider
30
National 3PL Service Provider
40
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-2
C h a r t 4 . 2
Third Party Logistics Market: 3PL Industry Life Cycle (India), 2000-2015
Note: All figures are rounded. Source: Frost & Sullivan
The Third Party Logistics (3PL) Industry today comprises many companies competing with
each other. In 2005, there were around 360 local 3PL service providers that operated at a
level not penetrated by participants with a purely regional and national-level presence. The
30 regional service providers have well established networks in the state and deal with the
local service providers for access in remote areas. The service providers with national opera-
tions, liaison with the regional operators, in areas accessible by the latter. This shows that
there are three tiers of companies, each operating at a different level. As a result, it can be
noted that the industry is highly fragmented, as has been the case for many years now. This
fragmented scenario is expected to fade away slowly once the consolidation phase sets into
the industry. Consolidation has not set in the industry and it is expected that it will start take
place, driven by a requirement to manage fewer logistics service providers. Till then the
number of 3PL service providers in the market is expected to grow. The smaller companies
are likely to ultimately start consolidating with the bigger companies in the market, failing
which, they may be not be in a position to survive in the highly competitive environment and
eventually ceasing to exist. Mergers & Acquisitions by companies, especially multinational
3PL service providers to gain local network access is expected to take place.
Mergers & Acquisitions are already taking place on a global level, and the scenario is likely
to be replicated in India, where several 3PL service providers are catering to the needs of
their clients, assisted by smaller companies. This is likely to witness the emergence of fourth
party logistics (4PL) service provider. Though consolidation is expected to take place, the
market is still likely to remain fragmented to a substantial extent.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-3
Current Status of Market Life Cycle
Chart 4.3 shows the market life cycle of the Indian third party logistics market from
2000-2015.
C h a r t 4 . 3
Third Party Logistics Market: Market Life Cycle (India), 2000-2015
Note: All figures are rounded. Source: Frost & Sullivan
The market for 3PL is experiencing a growing trend. This is expected to be witnessed till the
year 2012, considering the various factors that are driving the market are likely to have a
greater impact than those restraining the growth. The growth is expected predominantly
from multinational companies entering India, and their increasing tendency to outsource
logistics to a professional service provider, while concentrating on core competencies. The
growth is expected to continue well without recording any retardation until the end of fore-
casted life cycle period 2015.
M a r k e t S h a r e C o m p a r i s o n a n d B r e a k u p
Competitive Scenario
Figure 4-2 and Chart 4.4 show the revenue breakup by type of service provider in the Indian
third party logistics market in 2005.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-4
Note: All figures are rounded. Source: Frost & Sullivan
C h a r t 4 . 4
Third Party Logistics Market: Revenue Breakup by Type of Service Provider (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
Figure 4-3 and Chart 4.5 show the revenue share breakup between national 3PL service
providers in the Indian third party logistics market in 2005.
F i g u r e 4 - 2
Third Party Logistics Market: Revenue Breakup by Type of 3PL Service Provider (India),
2005
Category 2005 (%)
National 3PL Service Provider 47.7
Regional 3PL Service Provider 43.5
Local 3PL Service Provider 8.8
TOTAL 100.0
Local 3PL Service Provider
8.8%
Regional 3PL Service Provider43.5%
National 3PL Service Provider47.7%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-5
Note: All figures are rounded. Source: Frost & Sullivan
C h a r t 4 . 5
Third Party Logistics Market: Revenue Share Breakup Between National 3PL Service
Providers (India), 2005
Note: All figures are rounded. Source: Frost & Sullivan
F i g u r e 4 - 3
Third Party Logistics Market: Revenue Share Breakup Between National 3PL Service Provid-
ers (India), 2005
Company 2005 (%)
Gati 11.8
Safexpress 9.4
Om Logistics 8.2
TVS Logistics 7.0
SembCorp Logistics 6.1
AFL Logistics 5.6
Reliance Logistics 4.7
Patel Logistics 4.2
Transystem Logistics 3.6
DHL 2.6
Take Solutions 1.4
Others (Bax Global, Kochi Logistics, Prologis, Lemuir, Linfox etc.) 35.4
Total 100.0
Others (Bax Global, Kochi Logistics,
Prologis, Lemuir, Linfox etc.)
35.4%
Take Solutions 1.4% DHL 2.6%
Transystem Logistics 3.6%
Patel Logistics 4.2%
Reliance Logistics 4.7%
AFL Logistic 5.6%
SembCorp Logistics 6.1%
Om Logistics 8.2%
Safexpres 9.4%
Gati 11.8%
TVS Logistics 7%
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-6
The national 3PL service providers accounted for 47.7 percent of the revenues generated in
the market in 2005. They have the largest share of the market and generally cater to large
corporations. This can be attributed to the relatively more expensive rates offered by them,
which find customers predominantly among the large corporations. The regional 3PL service
providers accounted for 43.5 percent of the revenues generated in the market. The local 3PL
service providers accounted for 8.8 percent of the revenues generated in the market.
S e r v i c e s C o m p a r i s o n
National 3PL Service Providers
Figure 4-4 shows the service comparison between national 3PL service providers in the
Indian third party logistics market in 2005.
F i g u r e 4 - 4
Third Party Logistics Market: Services Comparison between National 3PL Service Providers
(India), 2005
Company Name
Range of Services Offered for FMCG Sector in each Function
Major Verticals ServedWarehousing Transportation Freight Forwarding MIS/Others
DHL—Exel Distribution Consolidation and Mega Warehouse Management
Partial-Primary Transportation from Factory to Regional Ware-house
Complete export Import Logistics Management
MIS, Back Office Operations, Pro-curement Logis-tic, Reverse Logistics
Service Parts Logistic-sSpare Parts Logistics-Medical ElectronicsTelecommuni-cationsFMCGRetailTex-tile and Apparel
SembCorp Logis-tics
Warehouse Management and Storage Solutions
Partial-Primary Transportation from factory to Regional Ware-house
Complete export Import Logistics Management
MIS, Customer Support, Packag-ing Solutions
FMCGRetail IT Hard-ware & ElectronicsPhar-maceuticals and HealthcareConsumer DurablesAutomotive and Auto Components
Reliance Logis-tics
Warehousing and Distribu-tion Manage-ment
Multi-modal pri-mary Transporta-tion Management
Export—Import logistics support
Customized MIS Services
FMCGRetailChemicals and PetrochemicalsCon-sumer Durables
TCI Supply Chain Solutions
Warehousing Services
Primary and Sec-ondary Transpor-tation Services up to Distribution Centers
Standard Freight Forwarding serv-ices
MIS, e-Logistics, Kitting, Reverse Logistics
FMCGConsumer Dura-blesAutomotive and Auto Components
Gati Customized Warehousing Solutions
Primary and Sec-ondary Transpor-tation Services up to Distribution Canters
Customs clearance and cargo Manage-ment Services
MIS solutions, Returns Manage-ment, Supply Chain Consulting
AutomotivePharmaceuti-calsRetailConsumer Elec-tronicsConsumer DurablesIT Hardware-FMCG
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-7
Source: Frost & Sullivan
The national service providers have the capacity to offer end-to-end supply chain solutions to
their clients, acting as a single point stop for all logistics requirements. They have pan India
operations.They offer extremely sophisticated services and provide solutions such as vehicle
tracking and vendor management of inventory. Other 3PL service providers may not be in a
position to offer these service. Their services are highly professional in nature and are gener-
ally with large corporations whose supply chain performances are extremely critical and time
bound. The level of technology adoption by these service providers is relatively higher than
the service providers in the other two tiers. The warehousing solutions offered by these
service providers also meet global standards. There is use of material handling equipment
such as fork-lifts, cranes, and conveyor belts for facilitating better logistics inside the ware-
house. The use of equipment to manage space more effectively inside the warehouse to enable
utilization of vertical spaces is also gaining acceptance. The adoption of technologies such as
Radio Frequency Identification (RFID) too is expected to witness a growing trend with these
service providers, as the demand is expected to be driven by increasing requirements to
provide visibility along the supply chain. In areas not accessible by them, they liaison with
the regional 3PL service providers to provide reach. The level of Information technology
usage is relatively higher than in the other two tiers.
Om Logistics Standard Ware-house Manage-ment
Primary and Sec-ondary Transpor-tation Management up to Distribution Centers
Customs clearance and Cargo Manage-ment services
Standard MIS Services
AutomotiveConsumer DurablesRetailConsumer ElectronicsPharmaceuti-calsFMCG
AFL Logistics Warehousing and Distribu-tion Services
Multi-modal Pri-mary Transporta-tion Management
Standard Freight Forwarding Serv-ices
MIS, Sales Pro-motion
Automotive & Auto com-ponentsIT HardwareCon-sumer ElectronicsTelecommuni-cationsFMCGPharmaceu-ticalsRetail
Safexpress Centralized Warehouse Management
Primary and Sec-ondary Transpor-tation Management up to Distribution Centers
Customs clearance and Cargo Manage-ment Services
Standard MIS Services, Consult-ing
Retail & ApparelIT Hardware & Electronic-sAutomotive & Auto componentsPharmaceuti-calsFMCGConsumer Durables
Patel Logistics Basic Ware-housing and Distribution Services
Primary and Sec-ondary Transpor-tation Services up to Distribution Centers
Basic Freight For-warding Services through Partners
Basic MIS AutomotiveEngineer-ingFMCG
F i g u r e 4 - 4 ( C o n t i n u e d )
Third Party Logistics Market: Services Comparison between National 3PL Service Providers
(India), 2005
Company Name
Range of Services Offered for FMCG Sector in each Function
Major Verticals ServedWarehousing Transportation Freight Forwarding MIS/Others
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-8
Regional 3PL Service Providers
Regional 3PL service providers operate only at a regional level. Hence, they do not provide
services of high standards set by the national 3PL service providers. They have lesser
resources at their behest, and hence the scale of operations is also much lower than that of
national 3PL service providers. These companies generally operate a fleet of trucks and
operate warehouses that predominantly serve as stocking points as opposed to technology-
enabled warehousing activity. They have hubs in major towns in various states and cater to
the regions surrounding them. The level of technology adoption here is restricted to the use
of information management systems and (Enterprise Resource Planning) ERP systems linked
by Very Small Aperture Terminals (VSAT) to the client's location.The use of technology t is
relatively lower when compared to the national companies. For transportation activity, these
companies generally own a small feet of trucks that operate regionally. The portfolio of
value-added services is also not vast as they do not have the capacity to provide these serv-
ices. Most of these companies provide logistical services to companies that cater to region-
specific markets and to national level 3PL service providers that do not have access to these
areas.
Local 3PL Service Providers
The local 3PL service providers operate in the interiors of a state or district where other
national and regional service providers do not have any reach. They offer very basic trucking
and storage solution. They generally operate out of a depot and own a small fleet of trucks.
The level of technology adoption is very low with these companies and there is relatively
much lower visibility along the supply chains they manage, when compared to the national
and regional 3PL service providers. The warehousing services offered by them are in the form
of very small depots, where deployment of warehouse management solutions( WMS) may not
be economically viable.
P r o f i l e s o f t h e M a j o r 3 P L S e r v i c e P r o v i d e r s
i n I n d i a
AFL Logistics
Name of the Company: AFL Logistics
Estimated 3PL Revenues in 2005: $24 million
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-9
Industry Segment Focus:
Automotive and Auto components
IT Hardware
Consumer Electronics
Telecommunications
FMCG
Pharmaceuticals
Retail
Clientele:
Sona Koyo Steering
MICO BOSCH
Tata Motors
NEI
APCOM
HP
Sansui
Blue Star
Venky's
LG
Warehousing Capacity: Around 45 warehouses in 29 states with over 1 million square feet of
warehousing space.
Company Background: AFL Logistics is a part of the AFL Group of companies consisting of
two other companies namely AFL WIZ couriers and AFL Cargo services. The company occu-
pies a leading position in the 3PL services market in India and boasts of a prestigious
clientele. Around 7 to 10 percent of the its revenues are generated from providing logistics
solutions to the automotive sector. The dominant part of company's revenues are from the IT
hardware sector, which contributes around 40 to 45 percent of the its revenues. The company
is one of the oldest integrated logistics solution providers and has established networks and
serves a prestigious clientele.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-10
DHL
Name of the Company: DHL
Estimated 3PL Revenues in 2005: $11 million
Industry Segment Focus:
Service Parts Logistics
Spare Parts Logistics
Medical Electronics
Telecommunications
FMCG
Retail
Textile and Apparel
Mergers & Acquisitions: Global Acquisition of Exel Logistics
Clientele:
Siemens
Hewlett Packard
Cisco
Nortell Networks
General Electric Company
Phillips Medical
Exel Logistics' Clientele:
Hindustan Lever Limited
Hindustan Motors
Mahindra & Mahindra
Daimler Chrysler
Lifestyle International
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-11
Warehousing Capacity: 500,000 square feet
Company Background: DHL-Exel was created by the DHL's global acquisition of the
UK-based Exel Logistics. The acquisition has created the world's single largest 3PL service
provider. Prior to the acquisition, DHL's Indian operations were primarily focused on Inter-
national Air Express, which still forms a significant portion of the company's revenues in the
country. DHL does provide service parts logistics and spare parts logistics to its multina-
tional clients operating in India. The company is in the process of setting up warehouses and
is reported to have imported material handling equipment to install in the same. Exel logis-
tics is one of the leading warehouse solutions providers in the country, and is reported to be
investing innetworks to strengthen its foothold in the country. The company also specializes
in managing clients' inbound supply chains. The company also manages aftermarket opera-
tions for its certain clients. This strategic acquisition is expected to witness DHL-Exel emerge
as a market leader in the future.
Dynamic Logistics
Name of the Company: Dynamic Logistics
Estimated 3PL Revenues in 2005: N/A
Industry Segment Focus:
Automotive
Pharmaceuticals
Retail
Consumer Electronics
Consumer Durables
Metals
FMCG
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-12
Clientele:
Alpha Laval
Atlas Copco India
Bajaj Electricals Limited
Behr
Coca Cola
Crompton Greaves Ltd.
Delphi
DGP Hinoday Industries Ltd.
Emerson India
Finolex
Fleetguard Inc.
Ford India Private Limited
Godrej Industries Ltd.
HLL
Hoechst Roussel Vet.Pvt. Ltd.
Kirloskar
ISSAL
Lipton
Nestle
Shree Precoated Steels Ltd.
Tata Sons Ltd.
Tetra Pak
Thermax
Timken India
Whirlpool
Voltas Limited
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-13
Warehousing Capacity: Over 1 million square feet of warehousing space
Company Background: Dynamic Logistics is a part of the Talera Group. The company is
widely regarded as one of the pioneers of 3PL services in India, The company offers a wide
variety of logistical and value-added services and provides good technological support to its
clients. It has an established network in place. The company is a specialist in the automotive
and auto components sector, though it serves other verticals also. It has its own in-house
technology services division responsible for producing systems such as warehouse manage-
ment systems and transportation management systems. The company also operates a
container freight Station, thereby facilitating import-export logistics.
GATI
Name of the Company: Gati Ltd.
Estimated 3PL Revenues in 2005: $50 million
Industry Segment Focus:
Automotive
Pharmaceuticals
Retail
Consumer Electronics
Consumer Durables
IT Hardware
FMCG
Clientele:
Ashok Leyland
3M
Ford
Maruti Udyog Limited
General Motors
Rane TRW Steering
Indian Terrain
Whirlpool
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-14
Lifestyle
Titan Industries
Pantaloon Retail
Godrej GE Appliances
Sony
Hitachi Home and Life Solutions
Warehousing Capacity: Around 600,000 square feet spread over 27 modern warehouses.
Fleet Size: Over 2,000 vehicles
Company Background: Gati is one of India's largest express distribution service providers.
The company aims to achieve 25 to 30 percent Year-on-Year growth in revenues in the
coming years. A majority of the its profits come from the express distribution and supply
chain and the company is in the process of building express distribution centers to cater to
the needs of its 3PL clients. The company is focusing on better warehouse space utilization
and is investing in mechatronic warehouses to enable sophisticated material handling. It is
investing close to $10 million to upgrade certain facilities. With a presence in 580 out of
590 districts in the country, Gati has the best network in the country. The company's main
industry focus is the retail sector, which contributes around 30 percent of its 3PL revenues.
The company has also invested heavily in information technology to provide clients extensive
IT support and visibility along the supply chain.
Geo Logistics
Name of the Company: Geo Logistics
Industry Segment Focus:
Consumer Electronics
Consumer Durables
IT Hardware
Automotive and Autocomponents
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-15
Clientele:
Sansui India Ltd.
Hyundai Electronics Limiteg
ETA General Air-conditioners India (Pvt.) Ltd.
Crompton Greaves
Hewlett Packard
Akai
Goodyear Tires
Warehousing Capacity:Over 1 million square feet
Company Background:
Geo Logistics started operations in India around 1998 as a C&F and Freight Management
Company and has ever since grown into providing end to end supply chain solutions for
Indian Industry. They were globally acquired by PWC Logistics in 2005.The company
provides excellent warehousing facilities and reach to its clients. The company operates out
of more than 18 offices located at key transportation hubs in the country and offers a whole
gamut of value added services to clients.
Om Logistics
Name of the Company: Om Logistics
Estimated 3PL Revenues in 2005: $35 million
Industry Segment Focus:
Automotive
Consumer Durables
Retail
Consumer Electronics
Pharmaceuticals
FMCG
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-16
Clientele:
General Motors
Tata
TVS Group
Subros Ltd.
Mahindra & Mahindra
Bajaj Auto Limited
Eicher Motors
Skoda
3M
Yamaha
Escorts
Hero Honda
Maruti Udyog Limited
Ashok Leyland
Motherson Sumi
LG
GEC
Zydus Cadilla
Glaxo Smithkline
Auro Textiles
ITC
Pepsi
Godrej
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-17
Warehousing Capacity: Around 5 million square feet
Fleet Size:Over 3,000 vehicles
Company Background: Om Logistics is one of the leading providers of 3PL services in India.
The majority of Om Logistics' revenue comes from the automotive sector. It is a company
that specializes in automotive logistics, with the sector accounting for nearly 65 percent of
their revenues. It is among the market leaders in providing logistics solutions to the automo-
tive industry. Om Logistics has the advantage of owning assets that give it a competitive
edge. The company has access to around 1,000 strategic locations in the country. It operates
out of 240 branch offices and 200 franchisees. With a fleet size exceeding 3,000 vehicles, and
a pan-national presence Om logistics is a definitely a big force to reckon with in the Indian
3PL market.
Patel Logistics
Name of the Company: Patel Logistics
Estimated 3PL Revenues in 2005: $18 million
Industry Segment Focus:
Automotive
Engineering
FMCG
Clientele:
Tata Motors
OTIS
FAG Bearings
Maruti Udyog Limited
Parle Ltd.
Emami Ltd.
Warehousing Capacity: Around 14 warehouses with area in excess of 2,0000 square feet and
380 stocking points with areas in the range of 500 square feet and 7000 square feet.
Fleet Size: Around 94 vehicles owned by company, other transportation requirements
outsourced
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-18
Company Background: Patel Logistics is a division of Patel Roadways Limited, which was
founded in 1959. The company adopts a highly customer-centric approach and caters to a
highly prestigious clientele. The company has the advantage of a strong and well-established
network in the country, covering over 1,000 locations. The company provides containerized
trucking solutions for high-value consignments.
Reliance Logistics
Company: Reliance Logistics
Estimated 3PL Revenues in 2005: $20 million
Industry Segment Focus:
FMCG
Retail
Chemicals and Petrochemicals
Consumer Durables
Clientele:
Hindustan Lever Limited
Metro
Parle
Nestle
Cargill
Reliance Industries Limited
Godrej
ITC
IPCL
ISPAT
Warehousing Capacity: Around 460,000 square feet spread over 55 warehouses
Fleet Size: Around 5,000 vehicles
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-19
Company Background: Reliance Logistics is a company that operates mainly on the full truck
load segment, though they do offer 3PL services and 4PL services. A fairly big part of the
company's revenues is from inside the Reliance Group of companies, the company offers
solutions for companies in other verticals also. Though the entire revenues of the company
exceed $400 million, the company's 3PL revenues contribute a relatively small share to the
total revenues. Reliance Logistics through its sophisticated setup of 55 warehouses all over
the country, caters to the needs of its prestigious clientele. The company offers a host of serv-
ices that include warehouse start-up and management, distribution management, inventory
management, provision of IT support, and other value-added services.
Safexpress
Name of the Company: Safexpress
Estimated 3PL Revenues in 2005: $40 million
Industry Segment Focus:
Retail and Apparel
IT Hardware & Electronics
Automotive and Auto components
Pharmaceuticals
FMCG
Consumer Durables
Clientele:
NIIT
Acer
Benetton
Blue Star
Canon
ColorPlus
Dell Computers
Escorts Communication
Ford
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-20
General Motors
Hilti
Hewlett Packard
Hughes
IBM
Kirloskar Oil
LG FMCG
Madura Garments
Reebok
Ricoh
Sansui
Wipro
Fleet Size: Around 3,100 trucks
Warehousing Capacity: Around 4 million square feet
Company Background: Safexpress has an extremely strong presence in the Indian 3PL market
and caters to a wide range of industry segments. The apparel and automotive sectors
contribute an estimated 20 percent of the company's 3PL service revenues, while the IT hard-
ware segment contributes another 20 percent. The company's presence in the retail sector is
also very strong and it boasts of a prestigious clientele. The company has witnessed very
strong growth in a short period of time and expects to have a growth of 35 percent in its
revenues annually.
SembCorp Logistics
Name of the Company: SembCorp Logistics
Estimated 3PL Revenues in 2005: $26 million
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-21
Industry Segment Focus:
FMCG
Retail
IT Hardware and Electronics
Pharmaceuticals and Healthcare
Consumer Durables
Automotive
Clients:
Coca Cola
ITC Ltd
Marico Industries Ltd.
Dabur Ltd.
Colgate Palmolive
Duncan Tea
Lupin Laboratories
Toshiba
Nortel
Ranbaxy
Phillips
Glaxo Smithkline
Winsome Group
TCL (Thomson)
DuPont
Warehousing Capacity: Around four logistic centers at Pune, Chennai, Jamshedpur, and
Bhiwandi. Managing in excess of 1 million square feet of warehousing space.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-22
Company Background: Sembcorp Logistics India is a wholly owned subsidiary of Sembcorp
Logistics Singapore. The company was set up in India in 1996, and has since established a
strong pan-India network, enabling them provide seamless solutions to clients. The company
is a force to reckon with in the FMCG sector, where volumes are large. The major logistics
centers of the company are shared facilities equipped with state-of-the-art material handling
equipment and racking systems. The company possesses the expertise to develop a custom-
ized supply chains solution for its clients and it offers a host of other value-added services as
a part of its portfolio.
Take Solutions
Name of the Company: Take Solutions
Estimated 3PL Revenues in 2005: $6 million
Industry Segment Focus:
Food Retail
Automotive and Auto components
Consumer Durables
Machinery and Engineering
Clientele:
Pizza Corner India
Hatsun Agro
Whirlpool
Saint-Gobain Glass India Limited
Philips India Limited
Parle Products Private Limited
MK Electric (India) Limited
ITC Limited
Ashok Leyland Ltd
CavinKare Private Limited
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-23
Company Background: Take Solutions offers a wide gamut of Supply Chain Management
services, helping clients concentrate on their core competencies.It is a company following a
model where they take title to the goods and execute logistics. The company is presently
concentrating on the food retail sector and may loot to venture into the Engineering retail
sector, with an increased focus on niche services The company offers a wide scope of end to
end services that inlcude inventory management, expiry management and temperature
management.. It is a multinational company with offices in South East Asia and the Middle
east. The company offers warehousing solutions of very good quality. The company adopts a
highly customer focused, process enabled and technology driven approach to supply chain
optimization. Other services include Strategic Sourcing, Product Availability Management
and Transaction Processing.
TCI Supply Chain Solutions
Name of the Company: TCI Supply Chain Solutions
Estimated 3PL Revenues in 2005: N/A
Industry Segment Focus:
Automotive
Telecommunications
FMCG
Clientele:
Bridgestone Tires
Goodyear
Nestle India Ltd.
ITC Limited
Hindustan Lever Limited
Company Background: TCI Supply Chain Solutions is a part of the Transport Corporation of
India Group. This division of the group handles the 3PL services and caters to clients across
different verticals. Services offered include offerings of vendor managed inventory solutions
for automotive clients, cross-docked warehousing, and stock buffering for FMCG clients,
and telecommunications equipment distribution. The company offers end-to-end supply
chain solutions and services such as transport management, warehouse management, C&F
management, and other value-added services.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-24
Total Logistics
Name of the Company: Total Logistics
Estimated 3PL Revenues in 2005: $11 million
Industry Segment Focus:
Automotive and Auto components
Retail
Consumer Durables
Machinery and Engineering
Clientele:
TELCON Ltd.
L.G. Electronics Ltd.
Voltas Ltd.
Goodyear India Ltd.
Modicare India Ltd.
Thermax Ltd.
Electrolux Ltd.
Rane Brakes Ltd.
SKF Bearing Ltd.
Kirloskar Oil Engines Ltd.
Akzo Nobel Explosives Ltd.
Lifestyle
Tata Steel
Josts Engg.Company Ltd.
Bombay Swadeshi Stores
Atul Ltd.
Eureka Forbes Ltd.
Exide Ltd.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-25
Tata Motors Limited
Larsen & Toubro Ltd.
ABB Limited.
Bharat Forge Limited.
Warehousing Capacity: Around 900,000 square feet
Fleet Size: Around 600 trucks
Company Background: The company has a formidable network of 74 branches and hence has
an excellent market reach. Total Logistics has experience in the field of logistics and has the
requisite expertise in handling all statutory requirements. The company offers clients good
MIS support to enable demand planning and ensure visibility. Total Logistics created a speci-
ality automotive logistics business unit in 2005 to cater to the needs of the automotive sector,
which is the largest contributor to 3PL services revenue of the company.
Transystem Logistics International
Name of the Company: Transystem Logistics International
Estimated 3PL Revenues in 2005: $15.5 million
Industry Segment Focus: Automotive and Auto components
Clientele: Toyota Kirloskar Motor Limited
Fleet Size: Around 270 trucks
Company Background: Transystem Logistics International is a joint venture between Mitsui
Logistics, which holds a 51 percent equity in the company and Transport Corporation of
India (TCI), which holds the rest of the 49 percent. The company was created exclusively to
cater to the logistical needs of Toyota Kirloskar Motor Limited, and handles the complete
supply chain, right from component procurement from vendors to transporting built-up vehi-
cles. The company has the advantage of TCI's geographical reach and Mitsui's expertise in
automotive Logistics. The company offers its clients inbound logistics involving procure-
ment, segregation, and transportation of parts just-in-time (JIT) to the assembly line, knock
down logistics, and spare parts logistics.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-26
TVS Logistics
Name of the Company: TVS Logistics
Estimated 3PL Revenues in 2005: $30 million
Industry Segment Focus: Automotive and Auto components
C l i e n t e l e :
Pricol
Delphi TVS
Ashok Leyland
Ford
JCB
Mahindra & Mahindra
Royal Enfield
TVS Motor Company
Tata Motors
Rane Group
Cummins
Sundram Fasteners
Warehousing Capacity: Around 17 warehouses
Fleet Size: Around 3,100 trucks
Company: TVS Logistics is a wholly owned subsidiary of TV Sundaram Iyengar and Sons.
The company was started initially as a backward integration to cater to the logistics needs of
the TVS group, majors in Auto Ancillaries. The company has now diversified its client port-
folio to include leading vehicle manufacturers. The company is a niche participant in the
automotive sector and holds a very dominant position in it. Though a significantly large
chunk of the company's revenues are still from within the TVS group. This scenario is
expected to change and more companies are likely to be included from outside the group.
TVS logistics aims to be a $100 million company in the near future. With the increase of
India's automotive exports, the company is expected to witness a good growth and
strengthen its position to become the market leader for 3PL solutions in the automotive
sector.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 4-27
5Recommendations and Growth Strategies for
3PL Providers in India
O p p o r t u n i t i e s f o r 3 P L S e r v i c e P r o v i d e r s i n
I n d i a
Types of Services with Potential
Figure 5-1 shows the top ten services with high growth potential in the Indian third party
logistics market in 2005.
Source: Frost & Sullivan
F i g u r e 5 - 1
Third Party Logistics Market: Top Ten 3PL Services with High Growth Potential (India),
2005
Rank Service
1 Inbound/Outbound Warehousing
2 Consignment Tracking And Telematics
3 Vendor Managed Inventory
4 End-To-End Supply Integrated Supply Chain Management
5 Procurement Logistics
6 Reverse Logistics
7 Customer Service/Support
8 Import/Export Logistics
9 Order Processing
10 Marketing And Sales Promotion
#4C77-18 © 2006 Frost & Sullivan www.frost.com 5-1
The warehousing service has the greatest potential for growth is in the Indian third party
logistics (3PL) market. It is expected to grow at a compound annual growth rate (CAGR) of
23.7 percent from 2005 to 2012. Value-added services are expected to be having similar
potential as warehousing. Transportation too is expected to grow at a healthy pace, though
not as fast as warehousing. The growth in transportation is expected with the rise in express
transport and increasing requirements by customers to get committed deliveries by 3PL
service providers. The potential in freight forwarding is relatively lesser compared to the
other services. Value-added services are expected to have a strong growth potential over the
forecast period from 2006 to 2012
Potential of Services during the Forecast Period
Figure 5-2 shows the top ten services ranked in order of potential in the Indian third party
logistics market from 2006 to 2012.
Source: Frost & Sullivan
F i g u r e 5 - 2
Third Party Logistics Market: Top Ten 3PL Services Ranked in Order of Potential (India),
2006-2012
Rank Service 1-2 Years 3-4 Years 5-7 Years
1 Inbound/Outbound Warehousing High High Very High
2 Consignment Tracking and Telematics Medium/High High High
3 Vendor Managed Inventory Medium/High High Very High
4 End-to-end Supply Integrated Supply Management Medium/High High Very High
5 Procurement Logistics Medium/High High Very High
6 Reverse Logistics Medium/High Medium/High High
7 Customer Service/Support Medium/High High Very High
8 Import/Export Logistics Medium/High Medium/High High
9 Order Processing Medium/High High Very High
10 Marketing And Sales Promotion Medium/High Medium/High High
#4C77-18 © 2006 Frost & Sullivan www.frost.com 5-2
Increasing requirements for vehicle telematics are expected during the forecast period from
2006 to 2012.Global Position Systems (GPS) systems are likely to become less expensive with
the introduction of Galileo, which is the European version of the same. Vendor managed
inventory (VMI) is presently witnessed in industries such as automotive and auto compo-
nents. The trend is expected to catch up with other sectors where supply chain processes are
extremely critical. In the present day it is observed that most companies outsource only a
portion of their supply chain processes to 3PL service providers. This is likely to change over
a period of time, and companies could be seen outsourcing their entire supply chains. This
trend is expected to witness only a gradual growth in services such as procurement logistics,
reverse logistics, customer service and support, marketing promotions, and rate negotiation.
Import-export logistics also have a good potential for growth and are expected to perform
well.
Warehousing, the service with the greatest growth potential has a high growth potential in
the short term. This is due to a general trend where many companies are accepting the serv-
ices of professionally-managed warehouses. This trend is expected to witness a surge post
2010, when a national uniform VAT system is implemented, bringing with it a new hub and
spoke warehousing and distribution model. After the implementation of VAT, companies are
expected to shift to multi-user facilities, which could lead to the emergence of better ware-
housing facilities. The 3PL service providers can leverage on the economies of scale once VAT
is implemented uniformly. After 2010, the growth is expected to continue, though the
increase in growth rate is not likely to be very significant, as the initial effects of VAT may
subside gradually. Value-added services are expected to experience similar growth as ware-
housing. Moreover, there is good growth potential from value-added services.A strong
growth in revenues from value-added services is expected in the short term. In the medium
term, the growth is expected to be accelerated faster due to increased outsourcing and
increasing requirements of clients for provision of the same. Transportation is still expected
to remain in the unorganized sector to a great extent. The growth in transportation in the
short term is expected to be relatively slower than in warehousing. This is due to the infra-
structure and increasing fuel prices.. Transportation by a 3PL service provider is significantly
more expensive than outsourcing to smaller truckers. Transportation by a 3PL service
provider is expected to witness growth once there is an increased demand for express trans-
port and efficient multi-modal transport. This is likely to be driven by development
infrastructure.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 5-3
B u s i n e s s M o d e l
Suggested Business Model
In transportation, some companies such as Om logistics predominantly follow an asset-based
model. The owning of assets can prove to be a healthy competitive edge as it obviates the
need to approach 2PL truckers to a great extent and hence lesser problems. Companies need
to have a balance between owned and outsourced infrastructure. Multinational 3PL service
providers generally prefer outsourcing their transportation to second party logistics (2PL)
companies. Managing the 2PL service providers is a formidable task and most multinationals
are disadvantaged compared to domestic participants regarding transportation. In ware-
housing, companies may build their own warehouses or operate a leased third party
warehouse built according to their specification. Cost of investing in warehousing may be
prohibitive, and hence outsourced real estate managed by the 3PL service provider is a better
option. Choice of location of warehouse is also an important factor, considering the
constantly reducing lead and turnaround times and thus helping clients to gain a competitive
edge.
P r i c i n g a n d P o s i t i o n i n g
Suggested Pricing Strategy
Companies are suggested to initially operate at extremely competitive rates to gain market
access. The rates offered may be extremely low; however, at the same time it is likely to
capture more customers. Profit margins are likely to be very lean initially; however, it can
help the company gain market share. Such a strategy is not advisable to be applied for long,
as due to the leaner margins, employees are likely to get paid lesser and hence may switch
companies. Companies should concentrate on increasing their client base as a means of
increasing revenues and profits. Focusing on minimum profit margins is advisable. Aiming
very high margins can directly mean expensive rates, and consequentially lesser revenues.
Suggested Positioning Strategy
One of the key areas needed to be addressed by companies is the range of value-added serv-
ices. The provision of these services is expected to be a part of the standard portfolio offered
by service providers in the future. One of the key aspects to be focused on is the ownership of
assets. Till the introduction of 3PL services in India, companies approached small fleet
owners and truckers. After outsourcing, if a 3PL service provider were to approach the same
category of truckers,then there would be no value addition for the client. Service quality is of
utmost importance and it would be apt if the companies can show the cost savings they
derive by outsourcing to the 3PL service provider.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 5-4
S t r a t e g i c A l l i a n c e s J o i n t V e n t u r e s a n d
P a r t n e r s h i p s
Suggested Strategy for Forming Alliances Joint Ventures and
Partnerships
It is highly recommended that multinational companies seek joint ventures and alliances in
order to establish themselves in India. Companies willing to enter joint ventures and partner-
ships need to consider the presence and capabilities of their prospective partners. These
include asset capabilities, network capabilities, IT support, reputation, and clientele. The
companies should look for service capabilities that they do not possess and should accord-
ingly ally with freight forwarders, local transporters, distributors, and other such agents.
The 3PL industry in India is moving toward consolidation and it has already started.
Although there is no specific strategy that can be suggested, there are a few trends that can be
well observed and that which have a major impact in the industry. Currently, the Indian
logistics market is opened for foreign investments. The existing local giants in the country are
striving to expand their business in two ways. One is the acquisitions of regional or local
companies, thereby consolidating the industry size and making the market less fragmented.
Another is that, the domestic companies are looking forward for alliances and joint ventures
with multinationals in order to combine the best of the expertise and technology and thereby
offer customized integrated services for customers. This in a way helps the multinationals
also, since the domestic knowledge, asset utilization, and the domain expertise of the local
giants brings them the competitive advantage.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 5-5
6Database of Key Industry Participants
M a r k e t P a r t i c i p a n t s — 3 P L S e r v i c e P r o v i d e r s
A F L P V T. LT D .
AFL House,
Lok Bharati Complex,
Marol Maroshi Road,
Andheri (East),
Mumbai 400 059. India
Phone: 91-22-5646 3500
Website: www.afl.co.in
A P L L O G I S T I C S ( I N D I A ) P V T
LT D
3rd Floor
A-11, Kailash Colony
New Delhi 110 048. India
Phone: 91-11-5163 4190/ 4197
Website: www.apllogistics.com
D H L - E X E L S U P P LY C H A I N
S O L U T I O N S I N D I A
8th Floor, Leela Galleria,
Andheri Kurla Road, Andheri (East),
Mumbai 400 059, India
Phone: 91-22-5695 5000
Website: www.dhl.co.in
G A T I L I M I T E D
H.No: 1-7-293,M.G.Road,
Secunderabad - 500 003.
A.P., India
Phone: 91-40-2784 4284
Website: www.gati.com
O M L O G I S T I C S L I M I T E D
130, Transport Center
Ring Road, Near Punjabi Bagh Flyover,
New Delhi 110035
India
Phone: 91-11-5433222/5116143
Website: www.omlogistics.co.in
P A T E L L O G I S T I C S
A Unit of Patel Roadways Limited
Patel House,
Plot No 48,
Gazdhar Bandh,
North Avenue, Santa Cruz (W),
Mumbai 400 054, India
Phone: 91-22-2605 0021/ 2605 3915/ 2605
2915
Website: www.patel-roadways.com
#4C77-18 © 2006 Frost & Sullivan www.frost.com 6-1
R E L I A N C E L O G I S T I C S
L I M I T E D
17 ST Road, near Khira Industrial Estate,
off SV Road, Santacruz (W)
Mumbai 400 054, India
Phone: 91-22 - 30611700
Website: www.reliancelogistics.com
S A F E X P R E S S P R I VA T E
L I M I T E D
Safex Cargo Complex,
National Highway No. 8.
Mahipalpur Extension
New Delhi 110 037, India
Phone: 91-11-26783281 (10 lines)
Website: www.safexpress.com/home.asp
S E M B C O R P L O G I S T I C S
( I N D I A ) P R I VA T E L I M I T E D
2nd floor, No.51, Montieth Road
Egmore, Chennai 600 008, India
Phone: 91-44-28542000
Website: www.semblogindia.com
T C I S U P P LY C H A I N
S O L U T I O N S
TCI House,
69, Institutional Area
Sector-32, Gurgaon 122001
Haryana, India
Phone: 91-124-2381603 to 07
Website:www.tcil.com
L E E & M U I R H E A D P V T LT D
10 GN Chetty Road,
T.Nagar, Chennai 600 017, India
Phone : 91-44-2828 1844
Website: www.lemuir.com
T V S L O G I S T I C S
#54, Mount Poonamalle Road
St. Thomas Mount
Chennai 600016 India
Phone: 91-44-22320605
Website : www.tvslogistics.com
G E O L O G I S T I C S P V T LT D
3rd Floor, Vaman Centre, Makwana Road
Andheri-Kurla Road, Marol, Andheri East
Mumbai
India 400 059
Phone: 91-22-28596646
Website: www.geologistics.com
G E O D I S O V E R S E A S P V T. LT D .
2B & 2C, Ega Trade Center,
New No. 318, Old No.809
Poonamallee High Road, Kiplauk,
Chennai 600 010
India
Phone: 91-44-30513030
Website: www.geodis.com
T O T A L L O G I S T I C S P V T LT D
Viraj Impex House,47 p.d'mello road,
Mumbai 400009,
India
Phone: 91-22-375 9595
Website: www.tlipl.com
DY N A M I C L O G I S T I C S P R I VA T E
L I M I T E D
14, Motilal Talera Road,
Pune 411 001,
Maharashtra, India
Phone: 91-20-26113572
Website: www.dynamiclogistics.com
#4C77-18 © 2006 Frost & Sullivan www.frost.com 6-2
S C H E N K E R I N D I A P R I VA T E
L I M I T E D
93-94, Kapashera,
New Delhi 110 037,
India
Phone: 91-11-5102 5102
Website: www.schenler.com
M A E R S K L O G I S T I C S I N D I A
P R I VA T E L I M I T E D
#57/58, Transport House,
IInd Cross, Kalasipalayam New Extension,
Bangalore 560002,
India
Phone: 91-80-22222311-13
Website: www.maersk.com
T R A N S Y S T E M L O G I S T I C S
I N T E R N A T I O N A L L I M I T E D
#57/58, Transport House
IInd Cross, Kalasipalayam New Extension
Bangalore 560002,
India
Phone: 91-80-22222311-13
Website: www.tcil.com/trans.asp
B A X G L O B A L I N D I A P V T. LT D .
Gr. Floor, Wing - B, Radisson Commercial
Complex,
Radisson Hotel,
Mahipalpur,
New Delhi 11 00037
India
Phone: 91-11-55118200 - 04
Website: www.baxworld.com
P R O - L O G I S T I C S I N D I A P V T.
LT D .
C-8,Laxmi Towers
Bandra-Kurla Complex
Mumbai 400 051
India
Phone: 91-22 5679 1111
Website: www.pro-logistics.com
#4C77-18 © 2006 Frost & Sullivan www.frost.com 6-3
7Decision Support Database
C o m p a r i t i v e T a b u l a t i o n o f I n f r a s t r u c t u r e
a n d I n d u s t r y F i g u r e s
Tabulation of Infrastructural Figures
Figure 7-1 presents the comparative tabulation of economic and infrastructural figures of
India such as the GDP, road network, rail network, airports, pipeline network and marine
capacities.
#4C77-18 © 2006 Frost & Sullivan www.frost.com 7-1
F i g u r e 7 - 1
Decision Support Database: Tabulation of Economic and Infrastructural Figures
GDP AND ECONOMIC GROWTH FIGURES
Measure 2004 2005
GDP (Purchasing Power Parity) $3.100 trillion $3.678 trillion
Real GDP $690 billion $740 billion
Real GDP Growth 6.90% 7.10%
Percapita Income $620 $740
Country Airports Heliports Total Airports and Heliports
International Airports
International Seaports
InternationalPorts
TotalDomesticSea Ports
Domestic Sea Ports by State
Total Sea Ports
Infrastructure
India 334 27 361 Bangalore, Chennai,Hyderabad, Kochi,Kolkata, Mumbai,New Delhi and Thiruvananthapuram
12 Chennai, Cochin, Ennore, Jawaharlal Nehru, Kandla, Kolkata, Mormugao, Mumbai, New Mangalore, Paradip, Tuticorin and Visakhapatnam
188 Andhra Pradesh (13)Andaman & Nicobar (23) Daman & Diu (2) Goa (5)Gujarat (40)karnataka (10)Kerala (13) Lakshadweep (10) Maharashtra (54)Orissa(2)Pondicherry(1)Tamil Nadu (15)
200
Country Paved Runways Unpaved Runways
Airports
India 235 39
Country Type Kilometres
Road Network Paved Roadways 2.41 million
India Un Paved Roadways 1.44 million
Total Roadways Network 3.85 million
Note: India's road network is the second largest in the world after US with 6.4 million km, and ahead of China with 1.8 million km
Country Type Kilometres
Rail Network Broad Guage (1.5 m) 45,718
India Metre Guage (1.0 m) 14,406
Narrow Guage (0.75 m) 3,106
Electrified (16,693 km)
Total Railway Network 63,230
#4C77-18 © 2006 Frost & Sullivan www.frost.com 7-2
Note: All figures are rounded. Source: Frost & Sullivan
These figures are useful in ascertaining the capability of each of India in offering a conducive
environment for logistics activities
Country Type Kilometres
Pipeline Network Gas 6,171
India Liquid Petroleum Gas 1,195
Oil 5,613
Refined Products 5,567
Total Pipeline Network 18,546
Country Type Number
Merchant Marine Capacity Foreign Owned 10
India Registered in Other Countries 30
Domestic Owned 299
Total Sea Ports 339
Country Type Number
Domestic Merchant Marine Split
India Roll On / Roll Off 1
Petroleum Tanker 91
Passenger 3
Passenger / Cargo 9
Container 7
Liquified Gas 14
Combination—Ore/Oil 1
Chemical Tanker 13
Cargo 75
Bulk Carrier 85
#4C77-18 © 2006 Frost & Sullivan www.frost.com 7-3
Tabulation of Major Industry Sectors Size
Figure 7-2 provides the size of major industrial sectors in India, in terms of value, as of 2005.
Note: All Figures are rounded. Source: Frost & Sullivan
These values are useful in understanding the potentiality of each industrial sector for logistics
activities.
F i g u r e 7 - 2
Decision Support Database: Value of Major Industrial Sectors in India, as of 2005
Sector Size ($ billion)
Name of the Industry Sector in India (in 2005)
Auto Components $9.50
Consumer Durables $4.44
Consumer Electronics $3.82
IT Hardware and electronics $7.32
FMCG $14.50
Pharmaceuticals and Healthcare $6.00
Retail $6.00
#4C77-18 © 2006 Frost & Sullivan www.frost.com 7-4