255400 to 255499 - bsintek.basco.combsintek.basco.com/BriggsDocumentDisplay/Z6nqAGVJ1DajI.pdf · 17...
Transcript of 255400 to 255499 - bsintek.basco.combsintek.basco.com/BriggsDocumentDisplay/Z6nqAGVJ1DajI.pdf · 17...
COPYRIGHT by BRIGGS & STRATTON CORPORATIONAll rights reserved. No part of this material may be reproduced or transmitted,in any form or by any means, electronic or mechanical, including photocopying,recording or by any information storage and retrieval system, without permissionin writing from Briggs & Stratton Corporation.
FORM MS–8696–6/98REPLACES FORM MS–8696–10/97
FILE IN SECT. 2 OF SERVICE MANUAL
255400 to 255499
Illustrated Parts ListModel Series
255400 to 255499TYPE NUMBERS0027, 0031, 0117,0118, 0130, 0131,
0133 through 0137.
TO FINDTHE CORRECT NUMBER OF THE PART YOU NEED:
FOLLOW THE INSTRUCTIONS BELOW
A. Refer to Engine Model, Type and Code Number that is stamped on the blower housing of engine.Engine type numbers such as 0123 01 are listed only as 0123 in most instances. The two digits (01or 02, etc.) to the right of the space may be required for more accurate parts identification in someinstances. Select the Illustrated Parts List covering the correct Model Series and Type Number.
B. Refer to the Illustrations and compare the original part with Illustration. The number next to the illustration is the Reference Number. Assemblies include all parts shown in frames. All parts shownin assembly frames having individual reference numbers can be purchased separately.
C. After the Reference Number has been identified, refer to the Numerical text, where Reference andPrimary Part Number are listed. THE PRIMARY PART IS USED ON ALL TYPE NUMBERS EXCEPT THOSE TYPE NUMBERS UNDER “NOTE.”
D. If a “Note” appears below the Primary Part Number, it means that this part differs from the PrimaryPart for certain types. If your Type number is listed under “Note,” order the part referred to at the “Note.”
E. If your Engine Type Number does not appear after any part number listed under “Note,” use the Primary Part Number.
F. For Engine Type Numbers not covered by this book, check other Parts Lists having the same engine model or contact your source of supply.
PRINTED IN U.S.A.
255400 to 255499
8696–2 Assemblies include all parts shown in frames. Up Date2
1019 LABEL KIT
13
5
11
910
7
383635
337
15
552
REQUIRES SPECIAL TOOLS TO INSTALL.SEE REPAIR INSTRUCTION MANUAL.
3
6
1058 OWNER’S MANUAL
1
8
869
870 871
87
718
307
307
886
527
528
529
601
601
606890
879
306
561
880
1 399121 Cylinder Assembly3 �391086 Seal–Oil5 212916 Head–Cylinder6 225137 Washer–Flat7 ∅ �272164 Gasket–Cylinder Head8 392294 Breather Assembly9 ∅ �27803 Gasket–Breather
10 94621 Screw–Hex.11 231105 Tube–Breather13 94547 Screw–Hex.15 94239 Plug–Oil Drain87 �491323 Seal–Governor Shaft
306 222609 Shield–Cylinder307 94930 Screw–Hex.
337 492167 Plug–Spark––––––– Note –––––298809 Plug–Spark802592 Plug–Spark(Resistor Type)
383 89838 Wrench–Spark Plug527 223131 Support–Breather
Tube528 280159 Grommet–Cover529 280160 Grommet–Cover552 491893 Bushing–Gov. Crank561 92278 Nut–Hex.601 93814 Clamp–Hose606 222697 Strap–Bracket635 66538 Boot–Spark Plug718 230192 Pin–Locating
869 261463 Seat–Valve(Intake)
870 262924 Seat–Valve(Exhaust)
871 261961 Bushing–Guide(Exhaust)––––––– Note –––––231218 Bushing–Guide(Intake)
879 392290 Cover–Assy. Side880 222613 Hood–Engine886 222695 Cover–Cylinder890 222935 Bracket–Support
1019 491254 Label Kit1058 271034 Owner’s Manual
Nonemission Engines
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–3 Assemblies include all parts shown in frames. Up Date3
2726
27
3132
30
25 2928
45
3433
45
36 35
42
4140
741
357
1716
146
16 399726 Crankshaft––––––– Note –––––491644 CrankshaftUsed on Type No(s).0134.
17 291667 Bearing–Ball25 394661 Piston Assembly
(Standard)––––––– Note –––––394662 Piston Assy.(.010” O.S.)394663 Piston Assy.(.020” O.S.)394664 Piston Assy.(.030” O.S.)
26 391780 Ring Set(Standard)––––––– Note –––––392331 Ring Set(Chrome Standard)391781 Ring Set(.010” O.S.)391782 Ring Set(.020” O.S.)391783 Ring Set(.030” O.S.)
27 260924 Lock–Piston Pin28 299691 Pin–Piston
(Standard)––––––– Note –––––391286 Pin–Piston(.005” O.S.)
29 490348 Rod–Connecting––––––– Note –––––490469 Rod–Conn(.020” Undersize)
30 222329 Dipper–ConnectingRod
31 222299 Lock–Rod Screw32 95017 Screw–Connecting
Rod33 261185 Valve–Exhaust34 261462 Valve–Intake35 65906 Spring–Valve36 26828 Spring–Valve40 221596 Retainer–Valve41 292260 Retainer–Valve42 494553 Keeper–Valve45 262248 Tappet–Valve
146 94196 Key–Timing357 91540 Key–Drive Pulley741 262932 Gear–Timing
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–4 Assemblies include all parts shown in frames. Up Date4
20
15752
751
22
12
1081
758
REQUIRES SPECIAL TOOLS TO INSTALL.SEE REPAIR INSTRUCTION MANUAL.
18
19
46
220
219
15A
189
10 94621 Screw–Hex.12 �272125 Gasket–Crankcase
(.015” Thick)––––––– Note –––––�272219 Gasket–Crankcase(.005” Thick)�272220 Gasket–Crankcase(.009” Thick)
15 94239 Plug–Oil Drain15A 94916 Plug–Oil Drain
(For Ren Hole)
18 398855 Cover–Crankcase19 399264 Bushing/Seal Kit20 �291675 Seal–Oil22 93585 Screw–Hex.
––––––– Note –––––93764 Screw–Hex.(2 1/8” Long)
46 212897 Gear–Cam81 222407 Retainer–
Counterweight
189 90366 Washer–Lock219 494845 Gear–Governor
––––––– Note –––––391737 Gear–Gov.(Used Before CodeDate 91061000).
220 221551 Washer–Thrust751 22355 Washer–Seal752 93554 Plug758 491787 Counterweight
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–5 Assemblies include all parts shown in frames. Up Date5
90
105
860
434
859858
391
392
432
394
435147
117
163
617
126
136
133
104
94 118
116 99
98
130
131
141108
95
95
137
138917
198
54
244 601A
240
187
199186
625
52
52 270972 Gasket–Intake54 93812 Screw–Phillips90 392690 Carburetor94 393541 Valve–Idle Adjust95 93499 Screw–Choke/Throttle98 93860 Screw–Slotted Hex.99 260575 Spring–Friction
104 �231435 Pin–Float Hinge105 �394681 Kit–Needle Seat108 222010 Valve–Choke116 �280203 Seal–O–Ring117 231101 Screw–Bowl Mounting118 �393542 Valve–Needle126 393543 Body–Carb Assy130 221939 Valve–Throttle
131 392278 Shaft–Throttle133 299707 Float–Carb136 221995 Bowl–Float137 �270511 Gasket–Float Bowl138 222014 Washer141 392280 Shaft–Choke147 �231323 Nozzle–Carb163 �280199 Gasket–Air Cleaner186 67218 Connector–Hose187 393815 Pipe–Fuel
(Cut to RequiredLength)
198 293934 Screw–Shut-Off199 297563 Valve–Shut-Off240 394358 Filter–Fuel
244 230318 Connector–Hose391 280162 Body–Pump392 �261395 Spring–Pump394 272638 Diaphram–Pump432 �221377 Cap–Spring434 223688 Cover–Diaphram435 93829 Screw–Slotted Hex.
601A 95162 Clamp–Hose617 �270920 Seal–O–Ring625 392285 Manifold–Intake858 �270989 Diaphram–Pump859 �271025 Gasket–Fuel Pump860 �261358 Spring–Diaphram917 223271 Handle–Shutoff Valve
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–6 Assemblies include all parts shown in frames. Up Date6
202
188
305
346
270268269
271
520353
354
353352
355351
265657
259
623
624
98A99A
201
222
98A 91920 Screw–Slotted99A 26157 Spring–Friction188 94627 Screw–Hex.201 261338 Link–Mech. Gov.202 261339 Link–Throttle222 392291 Bracket–Control259 222611 Bracket–Casing Clamp265 221535 Clamp–Casing268 65616 Casing–Wire
(72” Long,Cut to RequiredLength)
269 26633 Wire–Control(Cut to RequiredLength)
270 63426 Locknut–Casing271 290568 Lever–Control305 94786 Screw–Hex.346 94896 Screw–Hex.351 93735 Screw–Slotted352 66068 Washer–Fiber353 92791 Washer–Lock354 90576 Nut–Hex.355 66554 Washer–Fiber
520 93722 Terminal–Ground623 231520 Screw–Shoulder
(Used After Code Date8712300).––––––– Note –––––93838 Screw–Shoulder(Used Before CodeDate 88010100).
624 392292 Lever–Linkage657 93496 Screw–Slotted Hex.
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–7 Assemblies include all parts shown in frames. Up Date7
592
615
616230614
562
227
524
525 523
307
209
209 260871 Spring–Governor––––––– Note –––––261126 Spring–Gov.(Governed Idle)
227 392707 Lever–Governor
230 94927 Washer–Flat307 94930 Screw–Hex.523 490665 Dipstick524 �281370 Seal–Fill Tube525 496517 Tube–Oil Fill
562 92613 Bolt–Governor Lever592 231082 Nut–Hex.614 93306 Pin–Cotter615 93307 Retainer E–Ring616 495241 Crank–Governor
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–8 Assemblies include all parts shown in frames. Up Date8
DUAL CIRCUIT TRI–CIRCUIT
877 877A
878 814
NOTE: ALL STATORS USE NO. 482 MOUNTING SCREW.
SEE
ASSEMBLYFLYWHEEL
SEE
ASSEMBLYFLYWHEEL
1054
474 474A841
851334
333
800
673
356
333 398811 Armature–Magneto334 94731 Screw–Hex.356 491391 Wire–Stop474 393474 Alternator
474A 392595 Alternator
482 93621 Screw–Hex.673 94896 Screw–Hex.800 222095 Retainer814 392606 Harness–Alternator841 393514 Clamp
851 493880 Terminal–Cable877 393456 Wire–Alternator877 393537 Wire–Alternator878 393362 Harness–Alternator
1054 280275 Tie–Cable
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–9 Assemblies include all parts shown in frames. Up Date9
165
165
445
535
305188
643
642
882
165 94289 Nut–Wing188 94627 Screw–Sem305 94786 Screw–Hex.
445 392286 Filter–A/C Cartridg535 270973 Filter–Pre Cleaner642 392288 Cover–Air Cleaner
643 222680 Retainer–Air Filter882 392289 Retainer–Air Filter
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–10 Assemblies include all parts shown in frames. Up Date10
346300
346
346
346
863
883
884
864
676
994
676A
676B
613
867
300A
868
836
650
664
305
866
300 498984 Muffler–Exhaust300A 393465 Muffler–Exhaust
305 94786 Screw–Hex.346 94896 Screw–Hex.
346A 93587 Screw–Hex.613 93840 Screw–Socket650 93873 Screw–Hex.
664 93872 Screw–Hex.676 393761 Deflector–Muffler
676A 396903 Deflector–Muffler676B 397630 Deflector–Muffler
836 93587 Screw–Hex.863 222692 Bracket–Muffler864 494447 Pipe–Exhaust
866 393551 Body–Muffler867 212235 Frame–Shroud868 93343 Screw–Hex.883 ∅ �272293 Gasket–Exhaust884 392649 Clamp994 392390 Arrester–Spark
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–11 Assemblies include all parts shown in frames. Up Date11
7671
68
70
67
24
726
363
304
305
75
37
37A38
423
38 727 23
66231
23 391988 Flywheel24 222698 Key–Flywheel37 224886 Guard–Flywheel
37A 221968 Guard–Flywheel38 94811 Screw–Slotted Hex.66 399671 Clutch–Starter67 394897 Housing–Clutch68 63770 Ball–Clutch70 298799 Ratchet–Clutch71 394506 Cover–Ratchet
75 224061 Washer–Flywheel76 68238 Seal
231 93920 Screw–Phillips304 393994 Housing–Blower
––––––– Note –––––399844 Housing–BlowerUsed on Type No(s).0134.
305 94786 Screw–Hex.363 19203 Flywheel Puller423 94073 Screw–Shoulder726 392134 Gear–Ring
(Includes MountingParts)
727 395405 Cover–Starter Drive
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–12 Assemblies include all parts shown in frames. Up Date12
75
332
78
85
189
334
73518
455
321
325
321A
73A
73B
73 224874 Screen–Rotating73A 224517 Screen–Rotating73B 222754 Screen–Rotating
––––––– Note –––––224779 Screen–RotatingUsed on Type No(s).0130.
75 224061 Washer–Flywheel78 94626 Screw–Phillips85 91386 Screw–Hex.
––––––– Note –––––92674 Screw–Hex.Used on Type No(s).0130.
189 90366 Washer–Lock321 212159 Fan–Booster
321A 212418 Fan–Booster325 280457 Pulley–Starter332 92284 Nut–Flwheel334 94731 Screw–Hex.455 222561 Cup–Flywheel518 69932 Rope–Starter
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–13 Assemblies include all parts shown in frames. Up Date13
57
56
1016
6463
58
59
37365
655
608
55
60
55 393576 Housing–RewindStarter
56 295871 Pulley–Starter(Includes 63” Rope)
57 490179 Spring–Rewind Starter
58 66894 Rope–Starter(99” Long)
59 490653 Insert–Grip60 490652 Grip–Starter Rope63 260414 Spring–Ratchet64 281204 Adapter–Spring
65 94921 Screw–Hex.373 94908 Nut–Hex.608 390391 Starter–Rewind655 222598 Anchor–Spring
1016 490817 Spacer–Rewind
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–14 Assemblies include all parts shown in frames. Up Date14
544
802
801
803
310
697
311
783
7291051
503
309510
1090
797
513
675
309 497401 Motor–Starter310 95035 Screw–Hex.311 497608 Brush Set503 806000 Strap–Starter510 497606 Drive–Starter513 398003 Clutch–Drive544 Armature–Starter
(Replace StarterMotor)
675 225137 Washer–Flat 697 94773 Screw–Torx Hex.
729 225170 Clip–Wire783 693059 Gear–Starter797 92278 Nut
(Starter Terminal)
801 497626 Cap–Drive802 497607 Cap–End803 Housing–Starter
(Replace StarterMotor)
1051 263080 Ring–Retaining1090 497605 Retainer–Brush
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION
255400 to 255499
8696–15 Assemblies include all parts shown in frames. Up Date15
524
87
358 GASKET SET
121 CARBURETOR KIT
9789
7
320
883
51
104
12
7
9
883
1095 VALVE OVERHAUL GASKET SET94 105
116
137
147
118
163
392432
617
860
859
858
3 �391086 Seal–Oil7 ∅ �272164 Gasket–Cylinder Head9 ∅ �27803 Gasket–Breather
12 �272125 Gasket–Crankcase(.015” Thick)––––––– Note –––––�272219 Gasket–Crankcase(.005” Thick)�272220 Gasket–Crankcase(.009” Thick)
20 �291675 Seal–Oil87 �491323 Seal–Governor Shaft94 �393541 Valve–Idle Adjust
104 �231435 Pin–Float Hinge105 �394681 Kit–Needle Seat116 �280203 Seal–O–Ring118 �393542 Valve–Needle121 393544 Carburetor Kit137 �270511 Gasket–Float Bowl147 �231323 Nozzle–Carb.163 �280199 Gasket–Air Cleaner
358 492654 Gasket Set392 �261395 Spring–Pump432 �221377 Cap–Spring524 �281370 Seal–Fill Tube617 �270920 Seal–O–Ring858 �270989 Diaphram859 �271025 Gasket–Fuel Pump860 �261358 Spring–Diaphram883 ∅ �272293 Gasket–Exhaust978 �271736 Gasket
1095 498537 Gasket Set–ValveOverhaul
� Included in Gasket Set–Part No. 492653.� Included in Carburetor Kit–Part No. 394989.
∅ Included in Valve Overhaul Gasket Set–Part No. 498537.
REF. PART REF. PART REF. PARTNO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION