2.0L/2.5L/3.0L Electrical Guide - Jagrepair.com · ECT SENSOR Engine Coolant ... The “Battery...

BY APPOINTMENT TOHER MAJESTY QUEEN ELIZABETH II

MANUFACTURERS OF DAIMLER AND JAGUAR CARSJAGUAR CARS LIMITED COVENTRY

BY APPOINTMENT TOHER MAJESTY QUEEN ELIZABETH

THE QUEEN MOTHERMANUFACTURERS OF DAIMLER AND JAGUAR CARS

JAGUAR CARS LIMITED COVENTRY

BY APPOINTMENT TOHIS ROYAL HIGHNESS THE PRINCE OF WALES

MANUFACTURERS OF DAIMLER AND JAGUAR CARSJAGUAR CARS LIMITED COVENTRY

Jaguar Cars Limited

2.0L/2.5L/3.0LElectrical Guide

2.5L & 3.0L – 2001.5 Model Year;2.0L – 2002.25 Model Year

Published by Parts and Service Communications

Publication Part Number – JJM 10 38 20 / 22

1DATE OF ISSUE: December 2001

Jaguar X-TYPE 2.0L/2.5L/3.0L Table of Contents

Table of Contents: Figures ................................................................................................................... 2 – 3

Abbreviations and Acronyms ............................................................................................................... 4

Introduction ........................................................................................................................................ 5

Component Index ............................................................................................................................... 6 – 9

User Instructions ............................................................................................................................... 10 – 11

Symbols and Codes ........................................................................................................................... 12 – 14

Network Configuration ...................................................................................................................... 15

Relay and Fuse Location .................................................................................................................... 16

Fuse Box Connectors ......................................................................................................................... 17

Main Power Distribution ................................................................................................................... 18

Harness Layout ................................................................................................................................. 19

Ground Point Location ...................................................................................................................... 20

Control Module Location ................................................................................................................... 21

Control Module Pin Identification ...................................................................................................... 22 – 27

Electrical Guide Figures and Data ............................................................................ follows after page 27(pages are numbered by Figure number)

Appendix (CAN and SCP Messages) ................................................................... follows Figures and Data

2 DATE OF ISSUE: December 2001

Jaguar X-TYPE 2.0L/2.5L/3.0LTable of Contents: Figures

FIGURESFig. Description Variant

01 Power DistributionFig. 01.1 ...... Main Power Distribution ............................................................................ All VehiclesFig. 01.2 ...... Battery Power Distribution ......................................................................... All VehiclesFig. 01.3 ...... Ignition Switched Power Distribution: I (Accessory) ..................................... All VehiclesFig. 01.4 ...... Ignition Switched Power Distribution: II (Run) ............................................. All VehiclesFig. 01.5 ...... Ignition Switched Power Distribution: Battery Saver .................................... All VehiclesFig. 01.6 ...... Engine Management System Switched Power Distribution ........................... All Vehicles

02 Battery; Starter; GeneratorFig. 02.1 ...... Battery; Starter; Generator: 2.5L & 3.0L ...................................................... 2.5L & 3.0L VehiclesFig. 02.2 ...... Battery; Starter; Generator: 2.0L ................................................................. 2.0L Vehicles

03 Engine ManagementFig. 03.1 ...... Engine Management: 2.5L & 3.0L – Part 1................................................... 2.5L & 3.0L VehiclesFig. 03.2 ...... Engine Management: 2.5L & 3.0L – Part 2................................................... 2.5L & 3.0L VehiclesFig. 03.3 ...... Engine Management: 2.0L – Part 1 ............................................................. 2.0L VehiclesFig. 03.4 ...... Engine Management: 2.0L – Part 2 ............................................................. 2.0L Vehicles

04 TransmissionFig. 04.1 ...... Automatic and Manual Transmissions: Early Production ............................. 2.5L & 3.0L VehiclesFig. 04.2 ...... Automatic and Manual Transmissions: Later Production ............................. All Vehicles (Later Production)Fig. 04.3 ...... Automatic and Manual Transmissions: Later Production VIN D15361 ..... All Vehicles (Later Production)

05 ChassisFig. 05.1 ...... Anti-Lock Braking ...................................................................................... 2.5L & 3.0L ABS VehiclesFig. 05.2 ...... Dynamic Stability Control .......................................................................... DSC VehiclesFig. 05.3 ...... Anti-Lock Braking / Traction Control ........................................................... 2.0L ABS/TC Vehicles

06 Climate ControlFig. 06.1 ...... Manual Climate Control System; Glass Heaters ........................................... Manual Climate Control VehiclesFig. 06.2 ...... Automatic Climate Control System; Glass Heaters ....................................... Automatic Climate Control Vehicles

07 InstrumentationFig. 07.1 ...... Instrument Cluster ..................................................................................... All VehiclesFig. 07.2 ...... Audible Warnings ...................................................................................... All Vehicles

08 Exterior LightingFig. 08.1 ...... Exterior Lighting: Front – Autolamps .......................................................... Autolamp VehiclesFig. 08.2 ...... Exterior Lighting: Front – Non Autolamps; .................................................. Non Autolamp Vehicles;

Exterior Lighting: Front – Daytime Running Lamps ...................................... Daytime Running Lamp VehiclesFig. 08.3 ...... Exterior Lighting: Rear ................................................................................ All VehiclesFig. 08.4 ...... Exterior Lighting: Rear – European Trailer Towing ....................................... EUR Trailer Towing VehiclesFig. 08.5 ...... Exterior Lighting: Rear – U.K. Trailer Towing ............................................... U.K. Trailer Towing VehiclesFig. 08.6 ...... Exterior Lighting: Rear – NAS Trailer Towing ............................................... NAS Trailer Towing VehiclesFig. 08.7 ...... Headlamp Leveling .................................................................................... Headlamp Leveling Vehicles

09 Interior LightingFig. 09.1 ...... Interior Lighting ......................................................................................... All VehiclesFig. 09.2 ...... Dimmer-Controlled Lighting ....................................................................... All Vehicles

10 Steering; Mirrors; HeatersFig. 10.1 ...... Variable Assist Steering; Electrochromic Rear View Mirror ........................... All VehiclesFig. 10.2 ...... Door Mirrors: Movement, Fold-Back .......................................................... All Vehicles


Jaguar X-TYPE 2.0L/2.5L/3.0L Table of Contents: Figures

FIGURESFig. Description Variant

11 Seat SystemsFig. 11.1 ...... Powered Seats: 8-Way Movement .............................................................. 8-Way Powered Seat VehiclesFig. 11.2 ...... Powered Seats: 2-Way Movement .............................................................. 2-Way Powered Seat VehiclesFig. 11.3 ...... Seat Heaters .............................................................................................. Heated Seat Vehicles

12 Door Locking; SecurityFig. 12.1 ...... Central Door Locking: Double Locking ....................................................... Double Locking VehiclesFig. 12.2 ...... Central Door Locking: Non Double Locking ................................................ Non Double Locking VehiclesFig. 12.3 ...... Security System ......................................................................................... All Vehicles

13 Wash / WipeFig. 13.1 ...... Wash / Wipe System .................................................................................. Non Rain Sensing VehiclesFig. 13.2 ...... Wash / Wipe System with Rain Sensing ....................................................... Rain Sensing Vehicles

14 Powered Windows; Sliding RoofFig. 14.1 ...... Powered Windows: LHD............................................................................ LHD VehiclesFig. 14.2 ...... Powered Windows: RHD ........................................................................... RHD VehiclesFig. 14.3 ...... Sliding Roof ............................................................................................... Sliding Roof Vehicles

15 In-Car EntertainmentFig. 15.1 ...... In-Car Entertainment: Standard .................................................................. Standard ICE VehiclesFig. 15.2 ...... In-Car Entertainment: Premium ................................................................. Premium ICE Vehicles

16 TelematicsFig. 16.1 ...... Telephone System: ROW ........................................................................... ROW VehiclesFig. 16.2 ...... Telephone System: NAS ............................................................................. NAS VehiclesFig. 16.3 ...... Telephone System with Voice: ROW .......................................................... ROW VehiclesFig. 16.4 ...... Telephone System with Voice: NAS ............................................................ NAS VehiclesFig. 16.5 ...... Voice Control System ................................................................................. Voice Only VehiclesFig. 16.6 ...... Navigation System (except Japan) ............................................................... NAV Vehicles except JapanFig. 16.7 ...... Navigation System: Japan ........................................................................... Japan NAV Vehicles

17 Occupant ProtectionFig. 17.1 ...... Advanced Restraint System ........................................................................ All Vehicles

18 Driver AssistFig. 18.1 ...... Parking Aid System .................................................................................... Parking Aid Vehicles

19 AncillariesFig. 19.1 ...... Ancillaries: Horn, Cigar Lighter, Accessory Connectors,

Garage Door Opener ................................................................................. All Vehicles

20 Vehicle Multiplex SystemsFig. 20.1 ...... Controller Area Network ............................................................................ All VehiclesFig. 20.2 ...... Standard Corporate Protocol Network; Serial Data Link .............................. All VehiclesFig. 20.3 ...... D2B Network: Part 1 ................................................................................. All VehiclesFig. 20.4 ...... D2B Network: Part 2 ................................................................................. All Vehicles


Jaguar X-TYPE 2.0L/2.5L/3.0LAbbreviations and Acronyms

The following abbreviations and acronyms are used throughout this Electrical Guide:

A/C Air ConditioningA/CCM Air Conditioning Control Module

ABS Anti-Lock BrakingABS/TC Anti-Lock Braking / Traction Control

APP SENSOR Accelerator Pedal Position SensorAPP1 Accelerator Pedal Position Sensor Element 1APP2 Accelerator Pedal Position Sensor Element 2

AUTO Automatic TransmissionB+ Battery Voltage

BANK 1 RH Cylinder Bank (Cylinders 1, 3, 5)BANK 2 LH Cylinder Bank (Cylinders 2, 4, 6)

CAN Controller Area NetworkCKP SENSOR Crankshaft Position Sensor

CM Control ModuleCMP SENSOR / 1 Camshaft Position Sensor / Bank 1CMP SENSOR / 2 Camshaft Position Sensor / Bank 2

D2B Fiber Optic NetworkDSC Dynamic Stability ControlECM Engine Control Module

ECT SENSOR Engine Coolant Temperature SensorEFT SENSOR Engine Fuel Temperature SensorEGT SENSOR Exhaust Gas Temperature SensorEOT SENSOR Engine Oil Temperature Sensor

EVAP CANISTER CLOSE VALVE Evaporative Emission Canister Close ValveEVAP CANISTER PURGE VALVE Evaporative Emission Canister Purge Valve

FTP SENSOR Fuel Tank Pressure SensorGECM General Electronic Control Module

GPS Global Positioning SystemHID High Intensity Discharge

HO2 SENSOR 1 / 1 Heated Oxygen Sensor – Bank 1 / UpstreamHO2 SENSOR 1 / 2 Heated Oxygen Sensor – Bank 1 / DownstreamHO2 SENSOR 2 / 1 Heated Oxygen Sensor – Bank 2 / UpstreamHO2 SENSOR 2 / 2 Heated Oxygen Sensor – Bank 2 / Downstream

IAT SENSOR Intake Air Temperature SensorICE In-Car Entertainment System

IMT VALVE / 1 Intake Manifold Tuning Valve / TopIMT VALVE / 2 Intake Manifold Tuning Valve / Bottom

IC Instrument ClusterIP SENSOR Injection Pressure Sensor

KS Knock SensorLH Left Hand

LHD Left Hand DriveMAF SENSOR Mass Air Flow Sensor

MAN Manual TransmissionMAP SENSOR Manifold Absolute Pressure Sensor

N/A Normally AspiratedNAS North American Specification

PATS Passive Anti-Theft SystemPWM Pulse Width Modulated

RH Right HandRHD Right Hand Drive

ROW Rest of WorldSCP Standard Corporate Protocol Network

TCM Transmission Control ModuleTP SENSOR Throttle Position Sensor

TP1 Throttle Position Sensor Element 1TP2 Throttle Position Sensor Element 2

TURN Turn SignalTV TelevisionV6 V6 Engine

VEMS Vehicle Emergency Message SystemVICS Vehicle Information Control System

VVT VALVE / 1 Variable Valve Timing Valve / Bank 1VVT VALVE / 2 Variable Valve Timing Valve / Bank 2

+ve Positive–ve Negative

–ve BUS Central Junction Fuse Box Ground Bus


Jaguar X-TYPE 2.0L/2.5L/3.0L Introduction

Electrical Guide Format

This Electrical Guide is made up of two major sections. The first section, at the front of the book, provides general information for and aboutthe use of the book, and information and illustrations to aid in the understanding of the Jaguar X-TYPE electrical / electronic systems, as wellas the location and identification of components.

The second section includes the Figures, which are the basis of the book. Each Figure is identified by a Figure Number (i.e. Fig. 01.1) andTitle, and is accompanied by a page of data containing information specific to that Figure.

It is recommended that the user read through the front section of the book to develop a familiarity with the layout of the book and with thesystem of symbols and abbreviations used. The Table of Contents should help to guide the user.

Vehicle Identification Numbers (VIN)

VIN ranges are presented throughout the book in the following manner:

VIN 123456 indicates “up to VIN 123456”; VIN 123456 indicates “from VIN 123456 on”.

Jaguar X-TYPE Electrical System Architecture

Power SuppliesThe Jaguar X-TYPE electrical system is a supply-side switched system. The ignition switch directly carries much of the ignition switched powersupply load. Power supply is provided via three methods: direct battery power supply, ignition switched power supply, and “Battery Saver”power supply. The “Battery Saver” power supply circuit is controlled via GECM (General Electronic Control Module) internal timer circuits.Refer to Figure 01.5 for circuit activation details.

Fuse BoxesThe electrical harness incorporates a hard-wired Power Distribution Fuse Box in the engine compartment and a serviceable Central JunctionFuse Box in the front left-hand foot well. All fuses and relays (except the trailer towing accessory kit) are located in the two fuse boxes.

Vehicle NetworksThe Jaguar X-TYPE employs three different networks: a CAN (Controller Area Network) for high-speed powertrain communications, an SCP(Standard Corporate Protocol) network for slower speed body systems communications, and a D2B (Optical) Network for very high-speed“real-time” audio data transfer. The D2B Network is a fiber optic network with a gateway to the remaining vehicle networks via the AudioUnit (Radio Head Unit). Technician access to the three networks and the Serial Data Link is via the Data Link Connector.

Ground StudsCircuit ground connections are made at body studs located throughout the vehicle. There are no separate power and logic grounding systems;however, there are a certain number of components that use unique ground points.

X-TYPE INSTRUMENT PANEL


Jaguar X-TYPE 2.0L/2.5L/3.0LComponent Index

Accessory Power Relay .......................................................... Fig. 01.3Active Security Sounder ......................................................... Fig. 12.3Air Conditioning Blower Relay ............................................... Fig. 06.1Air Conditioning Blower Relay ............................................... Fig. 06.2Air Conditioning Compressor Clutch ...................................... Fig. 03.2............................................................................................. Fig. 03.4

Air Conditioning Compressor Clutch Relay ............................. Fig. 03.2Air Conditioning Control Module (Automatic, Panel) .............. Fig. 06.2............................................................................................. Fig. 09.2............................................................................................. Fig. 20.1

Air Conditioning Control Module (Manual, Panel) .................. Fig. 06.1............................................................................................. Fig. 09.2............................................................................................. Fig. 20.1

Air Conditioning Control Module (Remote) ............................. Fig. 06.2............................................................................................. Fig. 20.1

Air Conditioning Pressure Sensor ........................................... Fig. 03.2............................................................................................. Fig. 03.4

Air Temperature Blend Actuator ............................................ Fig. 06.1............................................................................................. Fig. 06.2

Airbag Deactivated Indicator Lamp – Passenger ...................... Fig. 17.1Ambient Temperature Sensor ................................................. Fig. 06.2Antenna Module .................................................................... Fig. 15.1............................................................................................. Fig. 15.2

Anti-Lock Braking System Control Module .............................. Fig. 05.1............................................................................................. Fig. 20.1

Anti-Lock Braking / Traction Control Control Module ............. Fig. 05.3............................................................................................. Fig. 20.1

APP Sensor ............................................................................ Fig. 03.1Audio Control Switches ......................................................... Fig. 15.1............................................................................................. Fig. 15.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.5

Audio Unit ............................................................................ Fig. 09.2............................................................................................. Fig. 12.3............................................................................................. Fig. 15.1............................................................................................. Fig. 15.2............................................................................................. Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.5............................................................................................. Fig. 20.2............................................................................................. Fig. 20.3............................................................................................. Fig. 20.4

Autolamps Sensor .................................................................. Fig. 08.1Automatic Transmission ......................................................... Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3

Battery Saver Relay ................................................................ Fig. 01.5Battery .................................................................................. Fig. 01.1............................................................................................. Fig. 02.1............................................................................................. Fig. 02.2

Blower (Automatic) ................................................................ Fig. 06.2Blower (Manual) .................................................................... Fig. 06.1Blower Series Resistor ............................................................ Fig. 06.1Brake Cancel Switch .............................................................. Fig. 03.2............................................................................................. Fig. 03.4

Brake Fluid Switch ................................................................. Fig. 07.1Brake On / Off Switch ............................................................ Fig. 03.1............................................................................................. Fig. 03.3............................................................................................. Fig. 03.4............................................................................................. Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Brake Pressure Sensor ............................................................ Fig. 05.2

Cabin Accessory Connector ................................................... Fig. 19.1Capacitor (ABS / DSC / TC) ..................................................... Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3Caravan Connector ................................................................ Fig. 08.5CD Autochanger .................................................................... Fig. 15.1............................................................................................. Fig. 15.2............................................................................................. Fig. 20.3............................................................................................. Fig. 20.4Cellular Phone Control Module .............................................. Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 20.3............................................................................................. Fig. 20.4Central Junction Fuse Box ...................................................... Fig. 01.1............................................................................................. Fig. 01.2............................................................................................. Fig. 01.3............................................................................................. Fig. 01.4............................................................................................. Fig. 01.5............................................................................................. Fig. 03.1............................................................................................. Fig. 03.3............................................................................................. Fig. 03.4............................................................................................. Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3............................................................................................. Fig. 06.1............................................................................................. Fig. 06.2............................................................................................. Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6Cigar Lighter .......................................................................... Fig. 09.2............................................................................................. Fig. 19.1CKP Sensor ............................................................................ Fig. 03.1............................................................................................. Fig. 03.3Clutch Cancel Switch ............................................................. Fig. 03.2............................................................................................. Fig. 03.4............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3Clutch Pedal Safety Switch ..................................................... Fig. 02.1............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3CMP Sensors ......................................................................... Fig. 03.1............................................................................................. Fig. 03.3Cooling Fans .......................................................................... Fig. 03.2............................................................................................. Fig. 03.4Cooling Fan Module .............................................................. Fig. 03.2............................................................................................. Fig. 03.4Curtain Airbag Igniters ........................................................... Fig. 17.1Data Link Connector .............................................................. Fig. 20.1............................................................................................. Fig. 20.2Defrost Door Actuator ........................................................... Fig. 06.1............................................................................................. Fig. 06.2Dip Beam Relay ..................................................................... Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.7Discharge Temperature Sensor ............................................... Fig. 06.1............................................................................................. Fig. 06.2Door Courtesy Lamps ............................................................ Fig. 09.1Door Latch Assembly – LH Front ............................................ Fig. 07.2............................................................................................. Fig. 09.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3............................................................................................. Fig. 14.1............................................................................................. Fig. 14.2............................................................................................. Fig. 14.3


Jaguar X-TYPE 2.0L/2.5L/3.0L

Door Latch Assembly – RH Front ............................................ Fig. 07.2............................................................................................. Fig. 09.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3............................................................................................. Fig. 14.3

Door Latch Assemblies – Rear ................................................ Fig. 09.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3

Door Mirrors ......................................................................... Fig. 06.1............................................................................................. Fig. 06.2............................................................................................. Fig. 10.2

Door Switch Pack – Driver ..................................................... Fig. 09.2............................................................................................. Fig. 10.2............................................................................................. Fig. 14.1............................................................................................. Fig. 14.2

Door Switch Pack – Passenger ................................................ Fig. 09.2............................................................................................. Fig. 14.1............................................................................................. Fig. 14.2

Door Switch Packs – Rear ....................................................... Fig. 09.2............................................................................................. Fig. 14.1............................................................................................. Fig. 14.2

Dual Airbag Igniters ............................................................... Fig. 17.1Dynamic Stability Control Control Module ............................. Fig. 05.2Dynamic Stability Control Switch ........................................... Fig. 05.2............................................................................................. Fig. 09.2

ECT Sensor ............................................................................ Fig. 03.1............................................................................................. Fig. 03.3

EFT Sensor ............................................................................. Fig. 03.1Electrochromic Rear View Mirror ........................................... Fig. 10.1EMS Control Relay ................................................................. Fig. 01.6Engine Control Module (2.5L & 3.0L) ...................................... Fig. 02.1............................................................................................. Fig. 03.1............................................................................................. Fig. 03.2............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 12.3............................................................................................. Fig. 20.1............................................................................................. Fig. 20.2

Engine Control Module (2.0L) ................................................. Fig. 02.2............................................................................................. Fig. 03.3............................................................................................. Fig. 03.4............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 12.3............................................................................................. Fig. 20.1............................................................................................. Fig. 20.2

EOT Sensor ........................................................................... Fig. 03.1............................................................................................. Fig. 03.3

EVAP Canister Close Valve ..................................................... Fig. 03.1EVAP Canister Purge Valve .................................................... Fig. 03.1............................................................................................. Fig. 03.3

Evaporator Temperature Sensor ............................................. Fig. 06.1Evaporator Temperature Sensor ............................................. Fig. 06.2Fog Lamps ............................................................................. Fig. 08.1............................................................................................. Fig. 08.2

Fold Flat Module ................................................................... Fig. 10.2Footwell Lamps ..................................................................... Fig. 09.1Fresh / Recirculation Flap Actuator ......................................... Fig. 06.1............................................................................................. Fig. 06.2

Front Axle Sensor .................................................................. Fig. 08.7Front Impact Sensor .............................................................. Fig. 17.1FTP Sensor ............................................................................ Fig. 03.1Fuel Injectors ......................................................................... Fig. 03.2............................................................................................. Fig. 03.4

Fuel Level Sensors ................................................................. Fig. 07.1

Fuel Pump (2.5L & 3.0L) ......................................................... Fig. 03.2Fuel Pump (2.0L) ................................................................... Fig. 03.4Fuel Pump Module (2.5L & 3.0L) ............................................ Fig. 03.2Fuel Pump Relay (2.0L) .......................................................... Fig. 03.4General Electronic Control Module ........................................ Fig. 01.5............................................................................................. Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 07.1............................................................................................. Fig. 07.2............................................................................................. Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6............................................................................................. Fig. 09.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3............................................................................................. Fig. 13.1............................................................................................. Fig. 13.2............................................................................................. Fig. 14.1............................................................................................. Fig. 14.2............................................................................................. Fig. 14.3............................................................................................. Fig. 19.1............................................................................................. Fig. 20.2

Generator .............................................................................. Fig. 02.1............................................................................................. Fig. 02.2

Glove Box Lamp .................................................................... Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 09.1

Handset Receiver (NAS) ......................................................... Fig. 16.2............................................................................................. Fig. 16.4

Handset Receiver (ROW) ........................................................ Fig. 16.1............................................................................................. Fig. 16.3

Hazard Switch ....................................................................... Fig. 08.2............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Hazard, Seat Heater Switches ................................................. Fig. 09.2Headlamp Leveling Control Module ....................................... Fig. 08.7............................................................................................. Fig. 20.1............................................................................................. Fig. 20.2

Headlamp Units .................................................................... Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.7

Heated Rear Window ............................................................ Fig. 06.1............................................................................................. Fig. 06.2............................................................................................. Fig. 15.1............................................................................................. Fig. 15.2

Heated Rear Window Relay ................................................... Fig. 06.1............................................................................................. Fig. 06.2

High Mount Stop Lamp .......................................................... Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

HO2 Sensors ......................................................................... Fig. 03.1............................................................................................. Fig. 03.3

Hood Security Switch ............................................................. Fig. 12.3Horn Relay ............................................................................ Fig. 12.3............................................................................................. Fig. 19.1

Horn Switch .......................................................................... Fig. 19.1Horns .................................................................................... Fig. 12.3............................................................................................. Fig. 19.1

Idle Speed Control Valve ........................................................ Fig. 03.3Ignition Capacitor .................................................................. Fig. 03.2............................................................................................. Fig. 03.4

Ignition Modules and Coils ..................................................... Fig. 03.2............................................................................................. Fig. 03.4

Ignition Relay ........................................................................ Fig. 01.4

Component Index



Ignition Switch ....................................................................... Fig. 01.1............................................................................................. Fig. 01.3............................................................................................. Fig. 01.4............................................................................................. Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 07.2............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3

IMT Solenoid Valves .............................................................. Fig. 03.1............................................................................................. Fig. 03.3

In-Car Temperature Sensor .................................................... Fig. 06.2Inclination Sensor .................................................................. Fig. 12.3Inertia Switch ........................................................................ Fig. 01.1............................................................................................. Fig. 01.4............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2

Instrument Cluster ................................................................. Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 07.1............................................................................................. Fig. 07.2............................................................................................. Fig. 08.3............................................................................................. Fig. 09.2............................................................................................. Fig. 10.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3............................................................................................. Fig. 20.1............................................................................................. Fig. 20.2

IP Sensor ............................................................................... Fig. 03.1J Gate Assembly ..................................................................... Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 07.2............................................................................................. Fig. 09.2............................................................................................. Fig. 20.1

JaguarNet GPS Antenna ......................................................... Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4

Knock Sensor ........................................................................ Fig. 03.1............................................................................................. Fig. 03.3

License Plate Lamps ............................................................... Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

MAF Sensor ........................................................................... Fig. 03.1............................................................................................. Fig. 03.3

Main Beam / Front Fog Relay .................................................. Fig. 08.1............................................................................................. Fig. 08.2

MAP Sensor ........................................................................... Fig. 03.1............................................................................................. Fig. 03.3

Master Lighting Switch ........................................................... Fig. 07.1............................................................................................. Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6............................................................................................. Fig. 08.7............................................................................................. Fig. 09.2

Mid Bass Speakers ................................................................. Fig. 15.2Navigation Control Module .................................................... Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.6............................................................................................. Fig. 16.7............................................................................................. Fig. 20.2............................................................................................. Fig. 20.3............................................................................................. Fig. 20.4

Navigation GPS Antenna ........................................................ Fig. 16.6............................................................................................. Fig. 16.7Oil Pressure Switch ................................................................ Fig. 07.1Output Speed Sensor ............................................................. Fig. 04.1Panel / Floor Actuator ............................................................ Fig. 06.1............................................................................................. Fig. 06.2Parking Aid Control Module ................................................... Fig. 18.1............................................................................................. Fig. 20.2Parking Aid Sensors ............................................................... Fig. 18.1Parking Aid Sounder .............................................................. Fig. 18.1Passive Anti-Theft System Transceiver .................................... Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 12.3Passive Security Sounder ........................................................ Fig. 12.3Power Distribution Fuse Box .................................................. Fig. 01.1............................................................................................. Fig. 01.2............................................................................................. Fig. 01.3............................................................................................. Fig. 01.6............................................................................................. Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 03.1............................................................................................. Fig. 03.2............................................................................................. Fig. 03.4............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 06.1............................................................................................. Fig. 06.2............................................................................................. Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.7............................................................................................. Fig. 12.3............................................................................................. Fig. 13.1............................................................................................. Fig. 13.2............................................................................................. Fig. 19.1Power Wash Pump ................................................................ Fig. 13.1............................................................................................. Fig. 13.2Power Wash Pump Relay ....................................................... Fig. 13.1............................................................................................. Fig. 13.2Rain Sensing Control Module ................................................. Fig. 13.2Rain Sensor ........................................................................... Fig. 13.2Rear Axle Sensor .................................................................... Fig. 08.7Rear Interior Lamp ................................................................. Fig. 09.1Restraints Control Module ..................................................... Fig. 07.1............................................................................................. Fig. 07.2............................................................................................. Fig. 20.2Reverse Lamps Relay .............................................................. Fig. 08.3Reverse Lamps Switch ............................................................ Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 08.3Roof Console ......................................................................... Fig. 09.1............................................................................................. Fig. 09.2............................................................................................. Fig. 12.3............................................................................................. Fig. 14.3............................................................................................. Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.5............................................................................................. Fig. 16.7............................................................................................. Fig. 19.1............................................................................................. Fig. 20.2Seat Back Heaters .................................................................. Fig. 11.3Seat Belt Pretensioner Igniters ................................................ Fig. 17.1Seat Belt Switches .................................................................. Fig. 17.1Seat Cushion Heaters ............................................................. Fig. 11.3Seat Heater Modules .............................................................. Fig. 11.3Seat Heater Switches ............................................................. Fig. 11.3Seat Lumbar Pumps ............................................................... Fig. 11.1Seat Lumbar Switch Packs ...................................................... Fig. 11.1

Component Index



Seat Movement Motors .......................................................... Fig. 11.1............................................................................................. Fig. 11.2

Seat Position Switch – Driver .................................................. Fig. 17.1Seat Switch Packs .................................................................. Fig. 11.1............................................................................................. Fig. 11.2

Seat Weight Pressure Sensor – Passenger ................................ Fig. 17.1Seat Weight Sensing Control Module – Passenger ................... Fig. 17.1Security Indicator .................................................................. Fig. 12.3Side Airbag Igniters ................................................................ Fig. 17.1Side Impact Sensors ............................................................... Fig. 17.1Side Marker Lamp – Front ...................................................... Fig. 08.1............................................................................................. Fig. 08.2

Side Marker Lamp – Rear ....................................................... Fig. 08.3............................................................................................. Fig. 08.6

Sliding Roof Control Module .................................................. Fig. 14.3Solar Sensor .......................................................................... Fig. 06.2Speakers ................................................................................ Fig. 15.1Speed Control Switches ......................................................... Fig. 03.2............................................................................................. Fig. 03.4

Speed Control Control Module .............................................. Fig. 03.4Starter Motor ......................................................................... Fig. 02.1............................................................................................. Fig. 02.2

Starter Relay .......................................................................... Fig. 02.1............................................................................................. Fig. 02.2

Steering Angle Sensor ............................................................ Fig. 05.2............................................................................................. Fig. 20.1

Steering Wheel ...................................................................... Fig. 09.2Sub Woofer ........................................................................... Fig. 15.2Tail Lamp Units ..................................................................... Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

TCM Relay ............................................................................. Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3

Telematics Display ................................................................. Fig. 09.2............................................................................................. Fig. 16.1............................................................................................. Fig. 16.2............................................................................................. Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.6............................................................................................. Fig. 16.7

Telephone Antenna, Bumper (NAS) ........................................ Fig. 16.2............................................................................................. Fig. 16.4

Telephone Antenna, Bumper (ROW) ...................................... Fig. 16.1............................................................................................. Fig. 16.3

Telephone Antenna, JaguarNet (NAS) ..................................... Fig. 16.2............................................................................................. Fig. 16.4

Telephone Antenna, JaguarNet (ROW) ................................... Fig. 16.1............................................................................................. Fig. 16.3

Television Antennas and Amplifiers ........................................ Fig. 16.7Throttle Body ........................................................................ Fig. 03.1Throttle Motor ....................................................................... Fig. 03.1Throttle Motor Relay .............................................................. Fig. 03.1TP Sensor (2.5L & 3.0L) .......................................................... Fig. 03.1TP Sensor (2.0L) ..................................................................... Fig. 03.3Traction Control Switch ......................................................... Fig. 05.3Trailer Connector .................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Trailer Towing Control Module .............................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Trailer Towing Rear Accessory Connector ............................... Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Transit Isolation Device .......................................................... Fig. 01.1

Transmission Control Module ................................................ Fig. 04.1............................................................................................. Fig. 04.2............................................................................................. Fig. 04.3............................................................................................. Fig. 20.1

Transmission Range Sensor .................................................... Fig. 02.1............................................................................................. Fig. 02.2............................................................................................. Fig. 04.1............................................................................................. Fig. 04.2

Trunk Accessory Connector ................................................... Fig. 19.1Trunk Lamp ........................................................................... Fig. 09.1Trunk Lock Motor .................................................................. Fig. 09.1............................................................................................. Fig. 12.1............................................................................................. Fig. 12.2............................................................................................. Fig. 12.3

Trunk Release Switch ............................................................. Fig. 12.1............................................................................................. Fig. 12.2

Turn Repeaters ...................................................................... Fig. 08.1............................................................................................. Fig. 08.2

Turn Signal Switch ................................................................. Fig. 07.1............................................................................................. Fig. 08.1............................................................................................. Fig. 08.2............................................................................................. Fig. 08.3............................................................................................. Fig. 08.4............................................................................................. Fig. 08.5............................................................................................. Fig. 08.6

Tweeters ............................................................................... Fig. 15.2Vacuum Module .................................................................... Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3

Vacuum Pump ....................................................................... Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3

Vanity Mirror Lamps .............................................................. Fig. 09.1Variable Assist Servo .............................................................. Fig. 10.1Vehicle Information Antenna and Amplifier ........................... Fig. 16.7Vehicle Information Control Module ...................................... Fig. 16.7Vehicle Information Sensor .................................................... Fig. 16.7Voice Activation Control Module ........................................... Fig. 16.3............................................................................................. Fig. 16.4............................................................................................. Fig. 16.5............................................................................................. Fig. 20.3............................................................................................. Fig. 20.4

VVT Solenoid Valves .............................................................. Fig. 03.1............................................................................................. Fig. 03.3

Washer Fluid Level Switch ..................................................... Fig. 07.1Wheel Speed Sensors ............................................................. Fig. 05.1............................................................................................. Fig. 05.2............................................................................................. Fig. 05.3

Window Motor Assemblies .................................................... Fig. 14.1............................................................................................. Fig. 14.2

Windshield Heaters ............................................................... Fig. 06.1............................................................................................. Fig. 06.2

Windshield Heater Relay ........................................................ Fig. 06.1............................................................................................. Fig. 06.2

Windshield Washer Pump ..................................................... Fig. 13.1............................................................................................. Fig. 13.2

Windshield Wiper Motor Relay .............................................. Fig. 13.1............................................................................................. Fig. 13.2

Wiper Motor Assembly .......................................................... Fig. 13.1............................................................................................. Fig. 13.2

Wiper Switch Assembly .......................................................... Fig. 13.1............................................................................................. Fig. 13.2

Yaw Rate Sensor .................................................................... Fig. 05.2............................................................................................. Fig. 20.1

Component Index


Jaguar X-TYPE 2.0L/2.5L/3.0LUser Instructions

Figure and Data Page Layout

Figure PagesEach Figure represents a specific electrical system of the vehicle. The Figures are arranged numerically by system (01 - Power Distribution,02 - Battery; Starter; Generator, etc.) with variations in the system identified by a numeral following a decimal point (01.1, 01.2, etc.).Refer to the Table of Contents: Figures for a complete list of the Figures.

The Figures 01 - Power Distribution detail the distribution of power to each of the systems. Numbered reference symbols refer the userto a specific Figure and from a specific Figure back to the Power Distribution Figures. This method eliminates the need to include detailedPower Distribution information on each of the Figures. The reference symbols are defined on page 12.

Each Figure appears on a right-hand page with a corresponding Data page to the left. The Figure and Data pages are folding pages. The usermust fold out both pages in order to access all the information provided.

Data PagesThe Data page includes information to assist the user in identifying and locating components, connectors and grounds. This information issupplemented by the illustrations in this front section of the book.

When network data is required for the understanding of a particular circuit, the user is directed to the Appendix.

Most circuits that incorporate a control module include pinout information. The characteristics listed are approximately those that can beexpected at the control module connector pins with all circuit connections made and all components connected and fitted. This informationis provided to assist the user in understanding circuit operation and should be used FOR REFERENCE ONLY.


Jaguar X-TYPE 2.0L/2.5L/3.0L User Instructions

The following abbreviations are used to represent values for Control Module Pin-Out data

I Input PG Power Ground CAN CAN Network D Serial and Encoded DataO Output SS Sensor / Signal Supply V SCP SCP Network V Voltage (DC)B+ Battery Voltage SG Sensor / Signal Ground D2 D2B Network PWM Pulse Width Modulated

CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FORREFERENCE ONLY.

NOTE: The characteristics listed are approximately those that can be expected at the control module connector pins with all circuit connections made and allcomponents connected and fitted.

Refer to the front of this book for detailed information and illustrations regarding the location and identification of harnesses, relays, fuses, grounds, controlmodules and control module pins.

DATE OF ISSUE: December 2001

Fig. 02.1

COMPONENTS

Component Connector(s) Connector Description LocationBATTERY — — ENGINE COMPARTMENT

CLUTCH PEDAL SAFETY SWITCH PA5 2-WAY / BLACK TOP OF CLUTCH PEDAL

ENGINE CONTROL MODULE (2.5L & 3.0L) EN16 134-WAY / BLACK ENGINE COMPARTMENT, FRONT BULKHEAD RH SIDE

GENERAL ELECTRONIC CONTROL MODULE CA86 23-WAY / GREY BEHIND INSTRUMENT PANEL RH SIDECA87 23-WAY / GREENIP5 23-WAY / BROWNIP6 23-WAY / WHITEJB172 23-WAY / BLUE

GENERATOR EN49 4-WAY / BLACK ENGINE BANK 1, FRONT

IGNITION SWITCH IP18 7-WAY / BLACK STEERING COLUMN

INSTRUMENT CLUSTER IP10 26-WAY / YELLOW INSTRUMENT PANELIP11 26-WAY / YELLOW

PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER IP15 4-WAY / GREEN STEERING COLUMN, IGNITION SWITCH

POWER DISTRIBUTION FUSE BOX — — ENGINE COMPARTMENT LH SIDE

STARTER MOTOR (EARLY PRODUCTION) ST2 1-WAY EYELET ENGINE BLOCK RH SIDEST3 1-WAY EYELET

STARTER MOTOR (LATER PRODUCTION) EN700 1-WAY EYELET ENGINE BLOCK RH SIDEST2 1-WAY EYELET

STARTER RELAY — — POWER DISTRIBUTION FUSE BOX R10

TRANSMISSION RANGE SENSOR JB156 10-WAY / BLACK TOP OF TRANSMISSION

HARNESS IN-LINE CONNECTORS

Connector Connector Description Location

EN700 1-WAY / JUNCTION BOX HARNESS TO ENGINE HARNESS STARTER SOLENOID

JB1 42-WAY / BLACK / JUNCTION BOX HARNESS TO ENGINE HARNESS ADJACENT TO LH SUSPENSION TURRET

JB2 16-WAY / GREEN / JUNCTION BOX HARNESS TO CABIN HARNESS ADJACENT TO CENTRAL JUNCTION FUSE BOX

JB129 22-WAY / GREY / INSTRUMENT PANEL HARNESS TO JUNCTION BOX HARNESS LH LOWER A POST

JB145 8-WAY / BLACK / ENGINE HARNESS TO JUNCTION BOX HARNESS ADJACENT TO CENTRAL JUNCTION FUSE BOX

GROUNDS

Ground Location

G13 ENGINE COMPARTMENT / ENGINE BLOCK

G16 ENGINE COMPARTMENT / UNDER BATTERY TRAY

G37 PASSENGER COMPARTMENT / LH CROSS CAR BEAM

FOR CONTROL MODULE PIN-OUT INFORMATION, UNFOLD PAGE TO LEFT.

CONTROL MODULE PIN-OUT INFORMATION

General Electronic Control Module

Pin Description and CharacteristicS IP5-18 SCP –

S IP5-19 SCP +

I IP6-8 KEY-IN IGNITION SWITCH: B+ WHEN KEY IN

Instrument Cluster

Pin Description and CharacteristicD IP10-3 PATS 1: ENCODED COMMUNICATION

D IP10-4 PATS 2: ENCODED COMMUNICATION

I IP10-5 PATS GROUND: GROUND

O IP10-6 PATS TRANSCEIVER POWER: B+

C IP10-17 CAN +

C IP10-18 CAN –

S IP10-22 SCP +

S IP10-23 SCP –

I IP11-7 BATTERY POWER SUPPLY: B+

I IP11-8 POWER GROUND: GROUND

I IP11-11 IGNITION SWITCHED POWER SUPPLY (II): B+

Engine Control Module (2.5L & 3.0L)

Pin Description and CharacteristicI EN16-006 ENGINE CRANK: B+

I EN16-031 PARK / NEUTRAL SWITCH (AUTOMATIC TRANSMISSION): NORMALLY CLOSED / GROUND WHEN ACTIVATED

I EN16-031 CLUTCH PEDAL SAFETY SWITCH (MANUAL TRANSMISSION): NORMALLY OPEN / B+ WHEN ACTIVATED

O EN16-041 STARTER RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND

I EN16-053 GENERATOR CHARGE: VARIABLE VOLTAGE

O EN16-065 GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION

I EN16-079 GENERATOR LOAD: B+ = NORMAL, AFTER-START SWITCH-ON; GROUND = GENERATOR FAILURE, AFTER-START SWITCH-ON

C EN16-123 CAN –

C EN16-124 CAN +

NOTE: Refer to the Appendix at the rear of this book for Network Messages.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output

Sensor/Signal Supply V CAN

SCP Serial and Encoded DataAllDecember 2001

B+

1 13 14 64 12 63 64 74B BII III I

Fig. 01.1 Fig. 01.2 Fig. 01.3 Fig. 01.4 Fig. 01.5 Fig. 01.6

I

O

+

–

C

S

D2

DP1 11 75 96

E ESensor/Signal Ground

D2B NetworkInput Battery Voltage

Power Ground

Battery; Starter; Generator: 2.5L & 3.0L Battery; Starter; Generator: 2.5L & 3.0L Fig. 02.1

R

B

YIP18-7

IP18-5

IP18-4

I

II

III

4

IP11-7

O

OIP10-4IP15-4

S

SIP10-23

IP10-2220.2

20.2U

Y

S

SIP5-18

IP5-1920.2

20.2U

Y

WGIP10-3IP15-3

IP10-5IP15-2

IP15-1

G

IP11-8G37AL

(G36BL)

D

D

BIP6-8

I

B

GIP10-6

BJB160

EN16-123

EN16-124

EN16-79

EN16-53

Y

G

ST2

B

B

EN49-2

EN49-1

EN49-4

GR

RG

U

ST4

Y

I

I

41II

EN16-65 EN49-3

OGO

20.1

20.1

C

CIP10-17

IP10-1820.1

20.1Y

GC

C

JB156-6

JB156-10

NB

39II

JB129-11 JBS34

JB2-16

GO BRW(NAS)

(ROW)

(NAS)

(ROW)

Y Y

I

I

P, N

EN16-31

Y

B

EN16-41

GO O

Y

GO

OY

Y

28

JB1-40

GO

Y

JB1-34

(AUTO)

(MAN)W

U

PA5-2PA5-1

EN16-6

BG12A

G16AS

BG12B

G13AS

7

JB145-5

JB2-12

14II

IP11-11

GR

61

15II

B

3

1

R10

2

5

4

N

P

EN700

JB1-42

Y

YB

B

B

P

YEN700-1ST3

(2)

(1)

BATTERY

KEY-IN

IGNITION SWITCH(III)

TRANSMISSIONRANGE SENSOR

PASSIVE ANTI-THEFTSYSTEM TRANSCEIVER

CLUTCH PEDALSAFETY SWITCH

SECURITY

GENERAL ELECTRONICCONTROL MODULE

PASSIVEANTI-THEFT

SYSTEM

PATS POWER

PATS GROUND

INSTRUMENT CLUSTER

O.K. TO START

O.K. TO START

STARTERRELAY

POWER DISTRIBUTION FUSE BOX

STARTER MOTOR

GENERATOR WARNING

ENGINECONTROL MODULE

GENERATOR

STARTENGINE

CRANKENGINEREQUEST

NOTE: ECM power supplies andgrounds shown on Fig. 03.1.

FIELD

CHARGE

GENERATORLOAD

2.5L & 3.0L Vehicles

NOTATION:

(1) Early production vehicles(2) Later production vehicles

CONTROL MODULE PIN OUT INFORMATION FIGURE NUMBER COMPONENT, CONNECTOR ANDGROUND INFORMATION

DATE OF ISSUE

DATA PAGE

FIGURE MODEL RANGE AND YEAR TITLE FIGURE NUMBER

KEY TO REFERENCE SYMBOLS VARIANT, VIN RANGE ANDDATE OF ISSUEFIGURE PAGE


Jaguar X-TYPE 2.0L/2.5L/3.0LSymbols and Codes

NOTE: In the examples on this page, an ‘X’ is used where a number would appear on an actual Figure.

Reference Symbols

Battery power supply

Ignition switched auxiliary power supply (key I)

Ignition switched power supply (key II, III)

Ignition switched Battery Saver power supply

Engine Management System power supply

Figure number reference

Controller Area Network

Standard Corporate Protocol network

D2B network

Wiring Symbols

Simplified splice

Bulb

Capacitor

Connector

Diode

Eyelet and stud

Fuse

Ground

Hall effect sensor

Motor

Potentiometer

Power distribution box terminal

Pressure transducer

Resistor

Solenoid

Suppression diode

Suppression resistor

Thermistor

Transistor

Wire continued

Zener diode

X

XX.X

SCP

CAN

D2B

XI

XII

EX

BX

H

Light emitting diode (LED)

Splice

Control Module Pin Symbols

Input CAN network

Output SCP network

Battery voltage D2B network

Power ground Serial and encoded data

Sensor/signal supply V *

Sensor/signal ground **

* May also indicate Reference Voltage.

** May also indicate Reference Ground or Logic Ground.

Refer to Control Module Pin-Out Information.

I

O

C

S

+

–

D

D2

B+

P


Jaguar X-TYPE 2.0L/2.5L/3.0L Symbols and Codes

Wiring Color Codes

N Brown O Orange

B Black S Slate

W White L Light

K Pink U Blue

G Green P Purple

R Red BRD Braid

Y Yellow BOF Fiber optic (D2B Network)

Code Numbering

When numbering connectors, grounds and splices, Jaguar Engineer-ing uses a three-position format: AC001, AC002, etc. Because spaceis limited in this Electrical Guide the codes have, in most cases, beenshortened. Thus AC001-001 becomes AC1-1, AC002-001 becomesAC2-1, etc.

Harness Codes

AC Climate Control

AL LH Side Airbag

AR RH Side Airbag

BL LH Rear Door

BR RH Rear Door

CA Cabin

EN Engine

FB Front Bumper

FL LH Front Door

FR RH Front Door

FT Fuel Tank

GC Cooling Pack

IL Injector Rail

IP Instrument Panel

JB Junction Box

LF LH Front Wheel Speed Sensor

LR LH Rear Wheel Speed Sensor

LS LH Front Seat

NA Navigation System

PA Pedals

PH Telephone

RB Rear Bumper

RC Roof Console

RF RH Front Wheel Speed Sensor

RR RH Rear Wheel Speed Sensor

RS RH Front Seat

TL Trunk Lid

TM Trunk Main

VM Vacuum Module

VP Vacuum Pump


Jaguar X-TYPE 2.0L/2.5L/3.0LSymbols and Codes

Grounds

There may be up to three eyelets on one ground stud. A, B and C are used to indicate the position of the eyelet on the stud: A – first (bottom),B – second (middle), C – third (top). Two eyelet variations are used: a single eyelet and an eyelet pair. The single eyelet has a single ‘leg’,which is identified by an S; the eyelet pair has two ‘legs’, identified as L (left) or R (right).

EXAMPLE:

S L R

SINGLE EYELET EYELET PAIR

G15AS G30CR

Ground

Ground stud number 15

Single eyelet

First eyelet on stud

Ground

Ground stud number 30

Eyelet pair, RH leg

Third eyelet on stud

On figures where LHD and RHD circuits are combined and the ground designation differs from LHD to RHD, the RHD ground is shown inparentheses. If the ground designation is the same for LHD and RHD, only one ground designation is used.

EXAMPLE:

G15AR(G4AR)

G30ASLHD Vehicles

RHD VehiclesSame for LHD and RHD Vehicles

Relays

All relays are located in the Power Distribution Fuse Box and the Central Junction Fuse Box. Relays do not have a separate relay connector(base). All relays use the ISO pin numbering system (1, 2, 3, 4, 5). Each relay in the vehicle is identified by a unique “R” number.

EXAMPLE:

3

1

5

2

R6 4

3

1

5

2

R2

CHANGE-OVER RELAY NORMALLY OPEN RELAY

Fuses

All fuses are located in the Power Distribution Fuse Box and the Central Junction Fuse Box. Each fuse in the vehicle is identified by a unique “F” number.

EXAMPLE:F67 30A

Networks

In most instances, networks are shown as a broken grey line to indicate that there is network communication between the depicted controlmodules. Refer to Figures 20.1, 20.2, 20.3 and 20.4 for circuit details.

EXAMPLE:

S

SIP5-2

IP5-120.2

20.2 20.2

IP10-1

IP10-2

S

SU

Y

U

Y20.2

SCP

MESSAGE(S)

MESSAGE(S)

MESSAGE(S)

MESSAGE(S)

CONTROL MODULE CONTROL MODULE



CAN SCP

D2B

Network Configuration

RESTRAINTSCONTROL MODULE

PARKING AIDCONTROL MODULE

ROOFCONSOLE

ABS, ABS/TC OR DSCCONTROL MODULE

DSCYAW RATE SENSOR

HEADLAMP LEVELINGCONTROL MODULE

DSCSTEERING ANGLE

SENSOR

J GATE

NETWORK GATEWAY

VOICE ACTIVATIONCONTROL MODULE

CELLULAR PHONECONTROL MODULE

CDAUTOCHANGER

AUDIO UNIT

NETWORK GATEWAY

NAVIGATIONCONTROL MODULE

SERIAL DATA LINK

DATA LINK CONNECTOR

CAN NETWORK

SCP NETWORK

D2B NETWORK

SERIAL DATA LINK

NOTE: TYPICAL NETWORK CONFIGURATION.REFER TO FIGURES 20.1, 20.2, 20.3 AND 20.4 FOR CIRCUIT DETAILS.


TRANSMISSIONCONTROL MODULE

AIR CONDITIONINGCONTROL MODULE

INSTRUMENTCLUSTER GENERAL ELECTRONIC

CONTROL MODULE



F20

5AF21

15A

F13

30A

F22

20AF23

10A

F15

30A

F24

15A

F16

20A

F25

15A

F17

20AF18

20AF19

15A

F26

15AF27

10AF28

15A

D2F36

10AF37

15A

F29

30A

F38

30A

F30

30A

F39

5A

F31

10A

F40

15A

F32

5A

F41

10AF42

30A

R11 R8

R5

R6

R4

R3

R9 R7

R10

R1R2

F1

20AF2

50AF3

60AF4

30AF5

30AF6

30AF7

50AF9

50A F8

80A

F10

20A

F66

30AF67

5AF64

7.5AF63

7.5AF62

7.5AF61

20AF60

20AF68

15A

F75

7.5AF74

15AF78

5AF77

7.5AF73

15AF72

15AF71

15AF70

30AF69

7.5A

F87

15AF86

7.5AF85

7.5AF84

5AF83

15AF82

10AF81

20AF80

7.5A79

10A

F97

7.5AF96

7.5AF95

10AF99

10AF98

10AF94

20AF93

30AF92

10AF91

10AF90

7.5A

R21R15

R17

R18

R20

R19

Relay and Fuse Location


R1 WINDSHIELD WIPER MOTOR RELAY

R2 WINDSHIELD HEATER RELAY

R3 HORN RELAY

R4 ACCESSORY POWER RELAY

R5 POWER WASH PUMP RELAY

R6 A/C COMPRESSOR CLUTCH RELAY

R7 EMS CONTROL RELAY

R8 TCM RELAY

R9 DIP BEAM RELAY

R10 STARTER RELAY

R11 THROTTLE MOTOR RELAY (2.5L & 3.0L);FUEL PUMP RELAY (2.0L)

FRONT OF VEHICLE

CENTRAL JUNCTION FUSE BOX

R15 MAIN BEAM / FRONT FOG RELAY

R16 NOT USED

R17 REVERSE LAMPS RELAY

R18 IGNITION RELAY

R19 HEATED REAR WINDOW RELAY

R20 A/C BLOWER RELAY

R21 BATTERY SAVER RELAY


Jaguar X-TYPE 2.0L/2.5L/3.0L Fuse Box Connectors

CENTRAL JUNCTION FUSE BOX – FRONT CENTRAL JUNCTION FUSE BOX – REAR

IP4

IP2

IP1

IP3 JB51

JB52 CA77

CA75

JB50

CA76

CA78

14 8

17

1 4

85

14 8

17

16 9

1

1 2

3 4

1 2

1 2

2 1

8

1 8

169

1 8

169

1 8

169



–

–

–

+

Main Power Distribution

BATTERY

BATTERY CHASSIS GROUND(UNDER BATTERY TRAY)

POWER DISTRIBUTIONFUSE BOX

JUNCTION BOX HARNESS: JB

CENTRAL JUNCTIONFUSE BOX

CABIN HARNESS: CA

GENERATOR

STARTER

BATTERY ENGINE GROUND

ENGINE HARNESS: EN


Jaguar X-TYPE 2.0L/2.5L/3.0L Harness Layout

VACUUM MODULE HARNESS: VM

VACUUM PUMP HARNESS: VP

ENGINE HARNESS: EN

LH FRONT WHEELSPEED SENSOR HARNESS: LF

JUNCTION BOX HARNESS: JB

LH FRONT DOOR HARNESS: FL

INSTRUMENT PANEL HARNESS: IP

ROOF HARNESS: RC

CABIN HARNESS: CA

NAVIGATION SYSTEMHARNESS: NA

LH REAR DOOR HARNESS: BL

TELEPHONE HARNESS: TL

LH REAR WHEELSPEED SENSOR HARNESS: LR

FRONT BUMPER HARNESS: FB

COOLING PACK HARNESS: GC

INJECTOR RAIL HARNESS: IJ

RH FRONT WHEELSPEED SENSOR HARNESS: RF

PEDAL HARNESS: PA

AIR CONDITIONING HARNESS: AC

RH FRONT DOOR HARNESS: FR

RHD INSTRUMENT PACKHARNESS DEVIATION

RH SEAT HARNESS: RS

LH SEAT HARNESS: LS

RH REAR DOOR HARNESS: BR

RH REAR WHEELSPEED SENSOR HARNESS: RR

TRUNK MAIN HARNESS: TM

REAR BUMPER HARNESS: RB

TRUNK LID HARNESS: TL


Jaguar X-TYPE 2.0L/2.5L/3.0LGround Point Location

G32 – UNDERLH HEADLAMP ASSEMBLY

(HID GROUND)

G11 – UNDERLH HEADLAMP ASSEMBLY

G16 – UNDER BATTERY TRAY(BATTERY CHASSIS GROUND)

G13 – ENGINE BLOCK(BATTERY ENGINE GROUND)

G14 – REARWARD OF POWERDISTRIBUTION FUSE BOX

G37 – LH CROSS CAR BEAM

G15 – LH ‘A’ POST, LOWER

G35 – LH ‘E’ POST, LOWER(FUEL PUMP GROUND)

G38 – ROOF, TOP OF LH ‘E’ POST(HIGH MOUNT

STOP LAMP GROUND)

G3 – LH ‘E’ POST(HEATED REAR WINDOW

GROUND)

G39 – TRUNK, LH REAR




G18 – UNDERRH HEADLAMP ASSEMBLY

G10 – UNDERRH HEADLAMP ASSEMBLY

G17 – ON GENERATOR BRACKET(A/C COMPRESSOR CLUTCHGROUND)

G33 – BEHINDRH HEADLAMP ASSEMBLY(HID GROUND)

G8 – RH FRONTINNER WHEEL ARCH

G36 – RH CROSS CAR BEAM

G5 – RH ‘A’ POST, LOWER

G4 – RH ‘A’ POST, LOWER

NOTE: UNIQUE GROUND STUDS ARE NOTED IN PARENTHESES.


Jaguar X-TYPE 2.0L/2.5L/3.0L Control Module Location

COOLING FAN MODULE

VACUUM MODULE


(COMBINED WITHCONTROL PANEL)

RAIN SENSINGCONTROL MODULE


INSTRUMENT CLUSTER: LHD

LH SEAT HEATER MODULE

FUEL PUMP MODULE

TRAFFIC MASTERCONTROL MODULE




VEHICLE INFORMATIONCONTROL MODULE

ABS, ABS/TC OR DSCCONTROL MODULE

ENGINE CONTROL MODULE


INSTRUMENT CLUSTER: RHD

RH SEAT HEATER MODULE

TRAILER TOWING MODULE


SPEED CONTROLCONTROL MODULE



YAW RATE SENSOR

J GATE MODULE

AIR CONDITIONINGCONTROL MODULE(REMOTE)



107

Y10

8 P10

9R

W11

0G

111

B11

2—

113

BG

114

BO

115

BG

116

B11

7—

118

BO

119

BW

120

BW

81 B82 B

83 Y84 P

85 —86 —

87 GU

88 GW

89 GR

90 —91 B

92 U93 U

Y

79 Y80 U

Y81 I

82 —83 —

84 WG

85 B86 G

87 N88 G

89 Y90 —

91 B

53 N54 N

55 BR

56 GW

57 GU

58 —59 O

60 B61 P

62 Y63 GO

64 B65 BG

27 N28 W

29 BW

30 GW

31 BW

32 —33 —

34 GO

35 U36 GU

37 N38 BG

39 W

1 BW

2W

U3 BG

4 B5 B

6 Y7 U

8 OG

9 —10 —

11 OY

12 YG

13 YG

92 BW

93 BW

94 BO

95 G96 RW

97 G98 R

99 GR

100

—10

1—

102

B10

3G

O10

4R

U

66 BO

67 BG

68 GO

69 B70 O

Y71 O

Y72 —

73 —74 U

Y75 B

76 GO

77 RU

78 B

40 GU

41 GW

42 GR

43 RG

44 WU

45 —46 U

Y47 U

48 B49 —

50 P51 Y

52 B

14 GU

15 GW

16 GR

17 G18 B

19 B20 BG

21 NR

22 WG

23 WG

24 —25 P

26 Y

55 GO

56 GO

57 —58 —

59 —60 —

61 GU

62 GW

63 GR

64 —65 OG

66 UY

67 O

29 B30 B

31 B32 —

33 WG

34 BG

35 —36 P

37 Y38 O

Y39 O

Y40 B

41 GO

1 RU

2 RU

3 —4 B

5 B6 Y

7 GO

8 GO

9 U10 GU

11 —12 O

Y13 Y

14 —

121

WU

122

—12

3G

124

Y12

5—

126

—12

7B

W12

8N

129

N13

0B

R13

1Y

G13

2Y

G13

3B

G13

4R

W

94 O95 B

96 —97 —

98 N99 —

100

BG

101

—10

2R

103

Y10

4R

G10

5W

106

R

68 G69 N

70 UY

71 O72 —

73 U74 —

75 P76 Y

77 —78 Y

79 U80 G

42 —43 BG

44 GW

45 BW

46 BW

47 YR

48 YG

49 —50 U

51 WU

52 GR

53 RG

54 B

15 —16 —

17 B18 B

19 BG

20 BG

21 —22 N

R23 W

G24 W

G25 W

26 WU

27 N28 —

EN

16

EN

65

18 R17 B

16 O15 N

14 N13 G

12 G11 —

10 W9 B

8 R7 O

6 UY

5 N4 U

3 G2 —

1 —

36 WU

35 —34 Y

33 Y32 —

31 —30 U

29 —28 —

27 Y26 G

25 W24 N

23 —22 —

21 N20 B

19 —

54 WU

53 Y52 G

51 —50 —

49 —48 —

47 OY

46 O45 BW

44 U43 —

42 Y41 —

40 —39 W

38 B37 —

JB

131

Control Module Pin IdentificationE

NG

INE

CO

NT

RO

L M

OD

ULE

: 2.5

L &

3.0

L

EN

16 /

134-W

AY

/ B

LA

CK

TR

AN

SM

ISS

ION

CO

NT

RO

L M

OD

ULE

JB

131 /

54-W

AY

/ B

LU

E

EN

GIN

E C

ON

TR

OL M

OD

ULE

: 2.0

L

EN

65 /

104-W

AY

/ B

LA

CK



11 —12 W

13 GB

14 WU

15 NR

16 WR

17 —18 —

19 —20 —

21 U*

22 —23 GW

24 Y25 B

26 WG

27 B28 N

29 —30 NG

31 WG

32 GO

33 —34 —

35 —36 —

37 —38 —

39 GW

40 G41 —

42 GB

1 B2 R

3 —4 —

5 B6 R

7 —8 —

9 —10 —

JB

185

11 —12 W

13 GB

14 WU

15 NR

16 WR

17 —18 —

19 —20 —

21 —22 —

23 GW

24 Y25 —

26 —

27 —28 N

29 —30 N

G31 W

G32 G

O33 —

34 —35 —

36 —37 —

38 —39 —

40 G41 —

42 —

1 B2 R

3 —4 —

5 B6 R

7 —8 —

9 —10 —

11 —12 W

13 GB

14 WU

15 NR

16 WR

17 —18 —

19 —20 —

21 —22 —

23 GW

24 Y25 —

26 —

27 B28 N

29 —30 N

G31 W

G32 G

O33 —

34 —35 —

36 —37 —

38 —39 —

40 G41 —

42 —

1 B2 R

3 —4 —

5 B6 R

7 —8 —

9 —10 —

JB

45

/ J

B1

97

Control Module Pin Identification

DS

CC

ON

TR

OL M

OD

ULE

JB

185 /

42-W

AY

/ B

LU

E

AB

S O

R A

BS

/TC

CO

NT

RO

L M

OD

ULE

JB

45 /

42-W

AY

/ B

RO

WN

(A

BS

CO

NT

RO

L M

OD

ULE

)

JB

197 /

42-W

AY

/ B

RO

WN

(A

BS

/TC

CO

NT

RO

L M

OD

ULE

)* B

– e

arl

y p

rod

ucti

on

veh

icle

s.



IP101

AC

1

14 G15 U

Y16 B

17 —18 —

19 —20 GU

21 GB

22 OG

23 O24 RW

25 RG

26 OY

1 —2 —

3 —4

GW

5 U6 GR

7 GO

8 RU

9 R10 W

B11 W

12 Y13 R

14 G15 U

Y16 B

17 —18 —

19 —20 GU

21 GB

22 OG

23 O24 RW

25 RG

26 OY

1 —2 —

3 —4

GW

5 U6 GR

7 GO

8 RU

9 R10 W

B11 W

12 Y13 R

14 U15 B

16 W17 B

18 B19 B

20 O21 W

22 Y23 G

1 OY

2 WR

3 B4 B

5 BW

6 B7 BW

8 —9 Y

10 G

14 U15 B

16 W17 B

18 B19 B

20 O21 W

22 Y23 G

1 OY

2 WR

3 B4 B

5 BW

6 B7 BW

8 —9 Y

10 G

IP101

AC

1

Control Module Pin IdentificationA

IR C

ON

DIT

ION

ING

CO

NT

RO

L M

OD

ULE

(R

EM

OT

E)

AC

1 /

26-W

AY

/ Y

ELLO

WIP

101 /

26-W

AY

/ Y

ELLO

W

AIR

CO

ND

ITIO

NIN

G C

ON

TR

OL M

OD

ULE

(A

UT

OM

AT

IC, P

AN

EL)

AC

1 /

26-W

AY

/ Y

ELLO

WIP

101 /

26-W

AY

/ Y

ELLO

W



2 B4 BK

1 GB

1 BW

2 BO

6 BG

3 BR

14 G15 U

Y16 B

17 —18 —

19 —20 G

U21 G

B22 O

G23 O

24 RW

25 RG

26 OY

1 —2 —

3 —4

GW

5 U6 GR

7 GO

8 RU

9 R10 W

B11 W

12 Y13 R

14 U15 B

16 —17 —

18 —19 —

20 O21 —

22 Y23 G

1 OY

2 WR

3 B4 B

5 —6 —

7 BW

8 —9 Y

10 G

IP135

IP39

IP1

01

AC

1


AIR

CO

ND

ITIO

NIN

G C

ON

TR

OL M

OD

ULE

(M

AN

UA

L, P

AN

EL)

AC

1 /

26-W

AY

/ Y

ELLO

WIP

135 /

2-W

AY

/ G

RE

EN

IP39 /

6-W

AY

/ G

RE

YIP

101 /

26-W

AY

/ Y

ELLO

W



1 OG

2 OY

3 BK

4 YB

5 B

6 —7 —

8 —9 —

10 —11 —

12 —13 —

U —15 —

16 G17 G

18 Y19 O

20 Y21 —

22 N23 W

1 B2 O

3 YB

4 O5 WB

6 —7 —

8 —9 —

10 —11 —

12 —13 —

14 —15 Y

16 W17 W

G18 —

19 —20 U

21 —22 —

23 —

1 OY

2 WB

3 O4 OY

5 O

6 —7 —

8 —9 —

10 —11 —

12 —13 —

14 —15 —

16 —17 —

18 U19 —

20 —21 B

22 —23 G

U

1 B2 —

3 —4 W

5 GR

6 —7 —

8 B9 G

10 R11 BW

12 —13 U

14 —15 Y

16 —17 BG

18 O19 BG

20 BG

21 R22 R

23 BO

1*

WB

2 —3 B

4 GU

5*

WG

6 —7 —

8 —9 —

10 —11 —

12 —13 —

14 B15 —

16 U17 —

18 U19 Y

20 B21 W

G22 O

Y23 —

CA

86

CA

87

JB

17

2IP

6IP

5


GE

NE

RA

L E

LE

CT

RO

NIC

CO

NT

RO

L M

OD

ULE

CA

86 /

23-W

AY

/ G

RE

Y

CA

87 /

23-W

AY

/ G

RE

EN

JB

172 /

23-W

AY

/ B

LU

EIP

6 /

23-W

AY

/ W

HIT

E

IP5 /

23-W

AY

/ B

RO

WN

* N

OT

E: LH

D s

ho

wn

. R

HD

veh

icle

s: P

in 1

– W

G, P

in 5

– W

B.



13 YU

12 —11 G

R10 —

9 —8 B

7 O6 —

5 B4 —

3 GB

2 —1 —

26 —25 R

24 GR

23 U22 —

21 O20 —

19 U18 —

17 OY

16 —15 OG

14 —

14 —15 B

16 B17 Y

18 G19 U

20 WU

21 —22 Y

23 U24 Y

25 W26 —

1 GB

2 OY

3W

G4 O

5 B6 G

7W

U8 WB

9 B10 U

11 B12 B

13 —

IP11

IP1O


INS

TR

UM

EN

T C

LU

ST

ER

IP11 /

26-W

AY

/ Y

ELLO

WIP

10 /

26-W

AY

/ Y

ELLO

W



Fig. 01.1

COMPONENTS


CENTRAL JUNCTION FUSE BOX CA75 8-WAY / GREY PASSENGER COMPARTMENT, FRONT BULKHEAD LH SIDE

CA76 16-WAY / GREEN

CA77 2-WAY / GREY

CA78 16-WAY / GREY

IP1 14-WAY / GREEN

IP2 16-WAY GREY

IP3 2-WAY / GREY

IP4 14-WAY / GREY

JB50 4-WAY / GREY

JB51 16-WAY / BLUE

JB52 2-WAY / BLACK


INERTIA SWITCH IP132 3-WAY / BLACK LOWER RH A POST


TRANSIT ISOLATION DEVICE JB186 2-WAY / BLACK BATTERY



JB3 14-WAY / BLUE / JUNCTION BOX HARNESS TO INSTRUMENT PANEL HARNESS BELOW INSTRUMENT PANEL LH SIDE

JB130 22-WAY / GREEN / JUNCTION BOX HARNESS TO INSTRUMENT PANEL HARNESS ADJACENT TO CENTRAL JUNCTION FUSE BOX

GROUNDS

Ground LocationG13 ENGINE COMPARTMENT / UNDER BATTERY TRAY

G16 ENGINE COMPARTMENT / ENGINE BLOCK



Fig. 01.2

COMPONENTS

Component Connector(s) Connector Description LocationCENTRAL JUNCTION FUSE BOX CA75 8-WAY / GREY PASSENGER COMPARTMENT, FRONT BULKHEAD LH SIDE

CA76 16-WAY / GREENCA77 2-WAY / GREYCA78 16-WAY / GREYIP1 14-WAY / GREENIP2 16-WAY / GREYIP3 2-WAY / GREYIP4 14-WAY / GREYJB50 4-WAY / GREYJB51 16-WAY / BLUEJB52 2-WAY / BLACK




CA10 22-WAY / GREY / ENGINE HARNESS TO CABIN HARNESS BELOW THE GLOVEBOX

CA20 20-WAY / BLACK / DOOR HARNESS TO CABIN HARNESS DRIVER SIDE A POST

CA25 14-WAY / NATURAL / REAR DOOR HARNESS TO CABIN HARNESS LH B/C POST

CA30 14-WAY / NATURAL / DOOR LOCK LINK LEAD RH B/C POST

CA36 16-WAY / GREEN / CABIN HARNESS TO ROOF HARNESS LH LOWER A POST

CA65 18-WAY / BLACK / CABIN HARNESS TO SEAT HARNESS BELOW RH FRONT SEAT

CA70 18-WAY / BLACK / CABIN HARNESS TO SEAT HARNESS BELOW LH FRONT SEAT

CA169 4-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS BELOW THE GLOVEBOX

CA407 16-WAY / GREEN / TELEPHONE HARNESS TO CABIN HARNESS BELOW LH REAR SEAT CUSHION

CA414 16-WAY / BLUE / TELEPHONE HARNESS TO CABIN HARNESS BELOW LH REAR SEAT CUSHION




JB188 2-WAY / BLACK / JUNCTION BOX HARNESS TO COOLING FAN MODULE LINK LEAD ADJACENT TO RADIATOR LH SIDE



Fig. 01.3

COMPONENTS

Component Connector(s) Connector Description LocationACCESSORY POWER RELAY — — POWER DISTRIBUTION FUSE BOX R4

CENTRAL JUNCTION FUSE BOX CA75 8-WAY / GREY PASSENGER COMPARTMENT, FRONT BULKHEAD LH SIDECA76 16-WAY / GREENCA77 2-WAY / GREYCA78 16-WAY / GREYIP1 14-WAY / GREENIP2 16-WAY / GREYIP3 2-WAY / GREYIP4 14-WAY / GREYJB50 4-WAY / GREYJB51 16-WAY / BLUEJB52 2-WAY / BLACK





CA129 12-WAY / GREY / CABIN HARNESS TO REAR BUMPER HARNESS SPARE WHEEL WELL

CA170 16-WAY / GREEN / IN-LINE CONNECTOR LH LOWER A POST

CA230 16-WAY / BLUE / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER A POST

CA240 12-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER A POST

CA241 22-WAY / GREEN / INSTRUMENT PANEL HARNESS TO CABIN HARNESS ADJACENT TO CENTRAL JUNCTION FUSE BOX




GROUNDS

Ground Location

G14 ENGINE COMPARTMENT / REARWARD OF POWER DISTRIBUTION FUSE BOX



Fig. 01.4

COMPONENTS



IGNITION RELAY — — CENTRAL JUNCTION FUSE BOX R18





CA1 22-WAY / NATURAL / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER A POST

















GROUNDS

Ground Location

G15 PASSENGER COMPARTMENT / LH LOWER A POST







Fig. 01.5

COMPONENTS

Component Connector(s) Connector Description LocationBATTERY SAVER RELAY — — CENTRAL JUNCTION FUSE BOX R21




Connector Connector Description LocationCA16 20-WAY / BLACK / DOOR HARNESS TO CABIN HARNESS DRIVER SIDE A POST



GROUNDS

Ground Location

G4 PASSENGER COMPARTMENT / RH LOWER A POST





Pin Description and CharacteristicPG CA86-5 POWER GROUND: GROUND

O IP5-20 BATTERY SAVER RELAY DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND

SG IP6-1 LOGIC GROUND: GROUND

B+ JB172-5 BATTERY POWER SUPPLY (TURN SIGNALS): B+



Fig. 01.6

COMPONENTS

Component Connector(s) Connector Description LocationEMS CONTROL RELAY — — POWER DISTRIBUTION FUSE BOX R7




CA5 12-WAY / BLACK / CABIN HARNESS TO FUEL TANK LINK LEAD TOP OF FUEL TANK


EN4 12-WAY / BLACK / ENGINE HARNESS TO INJECTOR RAIL HARNESS ADJACENT TO THE TRANSMISSION BELL HOUSING









Fig. 02.1

COMPONENTS










STARTER MOTOR ST2 1-WAY EYELET ENGINE BLOCK RH SIDEST3 / EN700 1-WAY EYELET










GROUNDS

Ground LocationG13 ENGINE COMPARTMENT / ENGINE BLOCK







S IP5-19 SCP +


Instrument Cluster





C IP10-17 CAN +

C IP10-18 CAN –

S IP10-22 SCP +

S IP10-23 SCP –












C EN16-123 CAN –

C EN16-124 CAN +








Fig. 02.2

COMPONENTS


ENGINE CONTROL MODULE (2.0L) EN16 134-WAY / BLACK ENGINE COMPARTMENT, FRONT BULKHEAD RH SIDE







STARTER MOTOR (EARLY PRODUCTION) ST2 1-WAY EYELET ENGINE BLOCK RH SIDEST3 / EN700 1-WAY EYELET









JB196 1O-WAY / GREY / JUNCTION BOX HARNESS TO CABIN HARNESS ADJACENT TO FOOT PEDALS

GROUNDS

Ground LocationG13 ENGINE COMPARTMENT / ENGINE BLOCK







S IP5-19 SCP +


Instrument Cluster





C IP10-17 CAN +

C IP10-18 CAN –

S IP10-22 SCP +

S IP10-23 SCP –




Engine Control Module (2.0L)







I EN65-085 CLUTCH SAFETY CIRCUIT (MANUAL TRANSMISSION): B+

C EN65-088 CAN –

C EN65-089 CAN +








Fig. 03.1

COMPONENTS

Component Connector(s) Connector Description LocationAPP SENSOR PA1 6-WAY / BLACK ABOVE ACCELERATOR PEDAL

BRAKE ON / OFF SWITCH PA3 3-WAY / BLACK TOP OF BRAKE PEDAL


CKP SENSOR EN12 2-WAY / BLACK ADJACENT TO ENGINE CRANKSHAFT PULLEY

CMP SENSOR 1 EN43 2-WAY / BLACK BANK 1 CYLINDER HEAD, FRONT


ECT SENSOR EN18 2-WAY / BLACK ENGINE VEE, FRONT

EFT SENSOR IL8 2-WAY / BLACK FUEL RAIL, FRONT


EOT SENSOR EN25 2-WAY / BLACK ADJACENT TO ENGINE OIL FILTER

EVAP CANISTER CLOSE VALVE FT5 2-WAY / BLACK REARWARD OF FUEL TANK

EVAP CANISTER PURGE VALVE JB170 2-WAY / BLACK REARWARD OF FUEL TANK

FTP SENSOR FT1 3-WAY / BLACK TOP OF FUEL TANK

HO2 SENSOR DOWNSTREAM 1/2 EN14 4-WAY / BLACK BANK 1 EXHAUST


HO2 SENSOR UPSTREAM 1/1 EN37 4-WAY / GREY BANK 1 EXHAUST


IMT SOLENOID VALVE 1 EN999 2-WAY / BLACK INTAKE MANIFOLD TOP

IMT SOLENOID VALVE 2 EN998 2-WAY / BLACK INTAKE MANIFOLD BOTTOM

IP SENSOR IL7 3-WAY / BLACK FUEL RAIL REAR

KNOCK SENSOR EN23 2-WAY / BLACK ENGINE VEE

MAF SENSOR EN6 5-WAY / BLACK ENGINE AIR INTAKE DUCT

MAP SENSOR EN8 4-WAY / BLACK INTAKE MANIFOLD, REAR


THROTTLE BODY EN10 2-WAY / BLACK ENGINE INTAKE MANIFOLDEN13 4-WAY / BLACK

THROTTLE MOTOR EN10 2-WAY / BLACK ENGINE INTAKE MANIFOLD

THROTTLE MOTOR RELAY — — POWER DISTRIBUTION FUSE BOX R11

TP SENSOR (2.5L & 3.0L) EN13 4-WAY / BLACK ENGINE INTAKE MANIFOLD

VVT SOLENOID VALVE 1 EN61 2-WAY / BLACK BANK 1 CYLINDER HEAD



Connector Connector Description LocationCA5 12-WAY / BLACK / CABIN HARNESS TO FUEL TANK LINK LEAD TOP OF FUEL TANK






GROUNDS

Ground Location

G8 ENGINE COMPARTMENT / RH INNER WHEEL ARCH




Pin Description and CharacteristicO EN16-001 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 ms, VARIABLE DUTY CYCLE

O EN16-002 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 ms, VARIABLE DUTY CYCLE

PG EN16-004 POWER GROUND 1: GROUND


I EN16-006 ENGINE CRANK: B+

I EN16-007 IGNITION ON: B+

I EN16-008 BRAKE ON / OFF SWITCH: NORMALLY OPEN / B+ WHEN ACTIVATED

I EN16-010 INERTIA SWITCH: NORMALLY CLOSED / OPEN CIRCUIT WHEN ACTIVATED

SS EN16-012 SENSOR POWER SUPPLY 1: NOMINAL 5 V


SG EN16-017 SMALL SIGNAL GROUND 1: GROUND


SG EN16-019 SENSOR GROUND 1: GROUND


B+ EN16-022 BATTERY POWER SUPPLY: B+

B+ EN16-023 EMS SWITCHED POWER SUPPLY 1: B+


SG EN16-029 HO2 SENSOR HEATER GROUND – 1/1: GROUND




I EN16-036 CRANKSHAFT SENSOR SIGNAL: PULSED SIGNAL, 70 PULSES PER ENGINE CYCLE

SG EN16-037 CRANKSHAFT SENSOR SIGNAL GROUND: GROUND

O EN16-038 INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 1 / TOP: GROUND WHEN ACTIVATED

O EN16-039 INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 2 / BOTTOM: GROUND WHEN ACTIVATED

O EN16-040 EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND


SG EN16-043 TP AND APP SIGNALS SHIELD: GROUND

I EN16-044 MASS AIR FLOW SENSOR SIGNAL: NOMINAL 0 – 5 V BY ENGINE OPERATING CONDITION

SG EN16-045 MASS AIR FLOW SENSOR GROUND: GROUND


I EN16-050 ENGINE FUEL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

O EN16-052 THROTTLE MOTOR RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND

O EN16-053 GENERATOR CHARGE: VARIABLE VOLTAGE

SG EN16-054 THROTTLE MOTOR GROUND: GROUND



I EN16-065 GENERATOR FIELD RETURN SIGNAL: VARIABLE VOLTAGE BY GENERATOR OPERATING CONDITION

O EN16-066 EVAP CANISTER PURGE VALVE DRIVE: PWM, 10 Hz, POSITIVE DUTY CYCLE RANGE 0.04% – 100%

O EN16-067 EVAP CANISTER CLOSE VALVE DRIVE: TO CLOSE, ECM SWITCHES CIRCUIT TO GROUND

I EN16-068 BANK 2 CAMSHAFT SENSOR SIGNAL: PULSED SIGNAL, 4 PULSES PER ENGINE CYCLE

SG EN16-069 BANK 2 CAMSHAFT SENSOR GROUND: GROUND

I EN16-070 ENGINE COOLANT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I EN16-071 INTAKE AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I EN16-073 INJECTION PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: POTENTIOMETER – VOLTAGE DECREASES AS PRESSURE INCREASES

I EN16-075 THROTTLE POSITION SENSOR 1 SIGNAL: IDLE = 0.74 V; FULL THROTTLE = 3.97 V

I EN16-076 THROTTLE POSITION SENSOR 2 SIGNAL: IDLE = 1.65 V; FULL THROTTLE = 4.20 V

I EN16-078 ENGINE OIL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES


O EN16-080 THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR



I EN16-083 HO2 SENSOR 1/1 SIGNAL: VARIABLE CURRENT

I EN16-084 HO2 SENSOR 1/1 SIGNAL: CONSTANT CURRENT

SG EN16-091 HO2 SENSOR HEATERS 1/2, 2/2 GROUND: GROUND

O EN16-092 HO2 SENSOR HEATER CONTROL – 1/2: PWM, 1 CYCLE PER 256 ms, POSITIVE DUTY CYCLE RANGE 0 ms = 0%, 77 ms = 30%, 256 ms = 100%

O EN16-093 HO2 SENSOR HEATER CONTROL – 2/2: PWM, 1 CYCLE PER 256 ms, POSITIVE DUTY CYCLE RANGE 0 ms = 0%, 77 ms = 30%, 256 ms = 100%



I EN16-098 KNOCK SENSOR SIGNAL: PULSED SIGNAL

SG EN16-100 SENSOR SHIELD: GROUND

I EN16-102 ACCELERATOR PEDAL POSITION SENSOR 1 SIGNAL: FOOT OFF = 0.97 V; FULLY DEPRESSED = 3.33 V

I EN16-103 ACCELERATOR PEDAL POSITION SENSOR 2 SIGNAL: FOOT OFF = 3.97 V; FULLY DEPRESSED = 0.84 V

I EN16-104 FUEL TANK PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE DECREASES AS PRESSURE INCREASES

D EN16-105 SERIAL DATA LINK: SERIAL COMMUNICATION

O EN16-106 THROTTLE MOTOR DRIVE: B+ TO ACTIVATE MOTOR



O EN16-109 BANK 1 VVT SOLENOID VALVE: PWM, 300 Hz, POSITIVE DUTY CYCLE RANGE 0% – 100%

O EN16-110 BANK 2 VVT SOLENOID VALVE: PWM, 300 Hz, POSITIVE DUTY CYCLE RANGE 0% – 100%

SG EN16-111 BANK 1 FUEL INJECTORS (1, 3, 5) GROUND: GROUND


C EN16-123 CAN –

C EN16-124 CAN +

I EN16-127 MAP SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS MANIFOLD ABSOLUTE PRESSURE INCREASES

I EN16-128 HO2 SENSOR 1/2 SIGNAL, NOMINAL 1 V SWING: 0.1 – 0.9 V SWING


SG EN16-130 HO2 SENSORS SHIELD: GROUND

B+ EN16-134 THROTTLE MOTOR POWER SUPPLY: B+ WHEN RELAY ACTIVATED








Fig. 03.2

COMPONENTS

Component Connector(s) Connector Description LocationAIR CONDITIONING COMPRESSOR CLUTCH RELAY — — POWER DISTRIBUTION FUSE BOX R6

AIR CONDITIONING COMPRESSOR CLUTCH EN30 2-WAY / BLACK ADJACENT TO ENGINE OIL FILTER

AIR CONDITIONING PRESSURE SENSOR JB106 4-WAY / BLACK BEHIND FRONT LH WHEEL ARCH LINER

BRAKE CANCEL SWITCH PA2 2-WAY / BLACK TOP OF BRAKE PEDAL

CLUTCH CANCEL SWITCH PA4 5-WAY / BLACK TOP OF CLUTCH PEDAL

COOLING FAN – LH GC2 2-WAY / BLACK COOLING PACK LH SIDE

COOLING FAN – RH GC1 2-WAY / BLACK COOLING PACK RH SIDE

COOLING FAN MODULE JB188 2-WAY / BLACK ADJACENT TO RADIATOR LH SIDEPWM1 4-WAY


FUEL INJECTOR 1 IL1 2-WAY / BLACK FUEL RAIL






FUEL PUMP FT2 4-WAY / BLACK FUEL TANK

FUEL PUMP MODULE CA105 10-WAY / BLACK UNDER REAR SEAT LH SIDE

IGNITION CAPACITOR EN94 2-WAY / BLACK BELOW AIR INTAKE

IGNITION MODULE AND COIL 1 EN51 4-WAY BANK 1 CYLINDER HEAD







SPEED CONTROL SWITCHES SW5 4-WAY / BLACK STEERING WHEEL












GROUNDS

Ground Location


G11 ENGINE COMPARTMENT / UNDER LH HEADLAMP ASSEMBLY

G17 ENGINE COMPARTMENT / ON GENERATOR BRACKET

G35 PASSENGER COMPARTMENT / LH LOWER E POST




Pin Description and CharacteristicI EN16-009 BRAKE CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED



I EN16-025 FUEL PUMP MODULE MONITOR: PWM, 1 Hz, 50% POSITIVE DUTY CYCLE = NORMAL, 25% POSITIVE DUTY CYCLE = NO CONTROL SIGNAL, 75% POSITIVE DUTY CYCLE = FUEL PUMP INOPERATIVE

O EN16-027 FUEL PUMP MODULE CONTROL: PWM, 250 Hz, NORMAL POSITIVE DUTY CYCLE RANGE = 4% – 51%

I EN16-033 CLUTCH CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED

O EN16-034 AIR CONDITIONING COMPRESSOR CLUTCH RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND

I EN16-047 SPEED CONTROL SWITCH REQUEST: STEPPED RESISTANCE

SG EN16-048 SPEED CONTROL SWITCHES SIGNAL GROUND: GROUND

O EN16-051 COOLING FAN MODULE CONTROL: PWM, 140 Hz, POSITIVE DUTY CYCLE RANGE 7% – 95%

O EN16-061 IGNITION COIL ACTIVATE – CYLINDER 2: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND






O EN16-113 FUEL INJECTOR DRIVE – CYLINDER 5: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND






I EN16-121 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES

I EN16-131 IGNITION MONITOR BANK 1 (1, 3, 5): PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE

I EN16-132 IGNITION MONITOR BANK 2 (2, 4, 6): PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE

SG EN16-133 FUEL PUMP CONTROL CIRCUIT SHIELD: GROUND







Fig. 03.3

COMPONENTS

Component Connector(s) Connector Description LocationBRAKE ON / OFF SWITCH PA3 3-WAY / BLACK TOP OF BRAKE PEDAL


CKP SENSOR EN12 2-WAY / BLACK ADJACENT TO ENGINE CRANKSHAFT PULLEY



ECT SENSOR EN18 2-WAY / BLACK ENGINE VEE, FRONT


EOT SENSOR EN25 2-WAY / BLACK ADJACENT TO ENGINE OIL FILTER

EVAP CANISTER PURGE VALVE JB170 2-WAY / BLACK REARWARD OF FUEL TANK





IDLE SPEED CONTROL VALVE EN87 2-WAY / BLACK THROTTLE ASSEMBLY

IMT SOLENOID VALVE 1 EN999 2-WAY / BLACK INTAKE MANIFOLD TOP

IMT SOLENOID VALVE 2 EN998 2-WAY / BLACK INTAKE MANIFOLD BOTTOM

KNOCK SENSOR EN23 2-WAY / BLACK ENGINE VEE

MAF SENSOR EN6 5-WAY / BLACK ENGINE AIR INTAKE DUCT

MAP SENSOR EN8 4-WAY / BLACK INTAKE MANIFOLD, REAR

TP SENSOR (2.0L) EN88 3-WAY / BLACK ENGINE INTAKE MANIFOLD









GROUNDS

Ground Location





Pin Description and CharacteristicI EN65-001 MAP SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS MANIFOLD ABSOLUTE PRESSURE INCREASES

I EN65-002 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES

SG EN65-003 SENSOR GROUND: GROUND

SG EN65-004 SMALL SIGNAL GROUND1: GROUND


I EN65-006 ENGINE CRANK: B+

SS EN65-011 SENSOR POWER SUPPLY: NOMINAL 5 V



B+ EN65-021 BATTERY POWER SUPPLY: B+





I EN65-027 THROTTLE POSITION SENSOR SIGNAL: CLOSED THROTTLE = 0.89 V; FULL THROTTLE = 4.50 V



I EN65-030 MASS AIR FLOW SENSOR SIGNAL: NOMINAL 0 – 5 V BY ENGINE OPERATING CONDITION




I EN65-036 INERTIA SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED

I EN65-037 KNOCK SENSOR SIGNAL: PULSED SIGNAL


D EN65-039 SERIAL DATA LINK: SERIAL COMMUNICATION


O EN65-044 COOLING FAN MODULE CONTROL: PWM, 140Hz, POSITIVE DUTY CYCLE RANGE 7% – 95%

O EN65-046 HO2 SENSOR HEATER CONTROL – 2/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100%

O EN65-047 HO2 SENSOR HEATER CONTROL – 1/2: PWM, 1 CYCLE PER 256 mS, POSITIVE DUTY CYCLE RANGE 0 mS = 0%, 77 mS = 30%, 256 mS = 100%

SG EN65-048 HO2 SENSOR HEATER GROUND – 1/2 AND 2/2: GROUND






SG EN65-055 HO2 SENSORS SHIELD: GROUND



I EN65-061 CRANKSHAFT SENSOR SIGNAL: PULSED SIGNAL, 70 PULSES PER ENGINE CYCLE

SG EN65-062 CRANKSHAFT SENSOR SIGNAL GROUND: GROUND

I EN65-063 IGNITION ON: B+



O EN65-069 EMS CONTROL RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND

O EN65-070 INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 2 / BOTTOM: GROUND WHEN ACTIVATED

O EN65-071 INTAKE MANIFOLD TUNING VALVE SOLENOID DRIVE – 1 / TOP: GROUND WHEN ACTIVATED

O EN65-074 EVAP CANISTER PURGE VALVE DRIVE: PWM, 10 Hz, POSITIVE DUTY CYCLE RANGE 0.04% – 100%


O EN65-077 HO2 SENSOR HEATER CONTROL – 1/1: PWM, 1 CYCLE PER 128 mS, VARIABLE DUTY CYCLE


I EN65-079 ENGINE OIL TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I EN65-080 ENGINE COOLANT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I EN65-081 INTAKE AIR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I EN65-085 PARK / NEUTRAL SWITCH (AUTOMATIC TRANSMISSION) : NORMALLY CLOSED / GROUND WHEN ACTIVATED

I EN65-085 CLUTCH SAFETY CIRCUIT (MANUAL TRANSMISSION) : B+



C EN65-088 CAN –

C EN65-089 CAN +


O EN65-095 BANK 2 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100%

O EN65-096 BANK 1 VVT SOLENOID VALVE: PWM, 300Hz, POSITIVE DUTY CYCLE RANGE 0% – 100%

O EN65-097 IDLE SPEED CONTROL VALVE MOTOR DRIVE (–): PWM

O EN65-098 IDLE SPEED CONTROL VALVE MOTOR DRIVE (+): PWM











Fig. 03.4

COMPONENTS

Component Connector(s) Connector Description LocationAIR CONDITIONING COMPRESSOR CLUTCH RELAY — — POWER DISTRIBUTION FUSE BOX R6

AIR CONDITIONING COMPRESSOR CLUTCH EN30 2-WAY / BLACK ADJACENT TO ENGINE OIL FILTER

AIR CONDITIONING PRESSURE SENSOR JB106 4-WAY / BLACK BEHIND FRONT LH WHEEL ARCH LINER

BRAKE CANCEL SWITCH PA2 2-WAY / BLACK TOP OF BRAKE PEDAL



CLUTCH CANCEL SWITCH PA4 5-WAY / BLACK TOP OF CLUTCH PEDAL

COOLING FAN – LH GC2 2-WAY / BLACK COOLING PACK LH SIDE

COOLING FAN – RH GC1 2-WAY / BLACK COOLING PACK RH SIDE

COOLING FAN MODULE JB188 2-WAY / BLACK ADJACENT TO RADIATOR LH SIDEPWM1 4-WAY








FUEL PUMP (2.0L) CA415 6-WAY / BLACK FUEL TANK

FUEL PUMP RELAY — — POWER DISTRIBUTION FUSE BOX R11

IGNITION CAPACITOR EN94 2-WAY / BLACK BELOW AIR INTAKE








SPEED CONTROL SWITCHES SW5 4-WAY / BLACK STEERING WHEEL

SPEED CONTROL CONTROL MODULE JB161 10-WAY / BLACK ENGINE COMPARTMENT, BULKHEAD LH SIDE


Connector Connector Description LocationCA5 12-WAY / BLACK / CABIN HARNESS TO FUEL TANK LINK LEAD TOP OF FUEL TANK









GROUNDS

Ground Location



G17 ENGINE COMPARTMENT / ON GENERATOR BRACKET

G35 PASSENGER COMPARTMENT / LH LOWER E POST




Pin Description and CharacteristicI EN65-002 AIR CONDITIONING PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: TRANSDUCER – VOLTAGE INCREASES AS PRESSURE INCREASES

SG EN65-003 SENSOR GROUND: GROUND

I EN65-007 BRAKE CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED

SS EN65-011 SENSOR POWER SUPPLY: NOMINAL 5 V

I EN65-012 IGNITION MONITOR BANK 1 (1, 3, 5) : PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE

I EN65-013 IGNITION MONITOR BANK 2 (2, 4, 6) : PULSED SIGNAL, 3 PULSES PER ENGINE CYCLE




I EN65-017 INTELLIGENT SPEED SIGNAL (VEHICLE SPEED) : PWM, DUTY CYCLE RANGE 30% to 70 %

O EN65-020 AIR CONDITIONING COMPRESSOR CLUTCH RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND





O EN65-044 COOLING FAN MODULE CONTROL: PWM, 140Hz, POSITIVE DUTY CYCLE RANGE 7% – 95%

I EN65-056 SPEED CONTROL STATUS 1 ON / OFF: GROUND = ON; 5 V = OFF

I EN65-057 SPEED CONTROL STATUS 2 ACTIVE / INACTIVE: GROUND = ACTIVE; 5 V = INACTIVE








O EN65-099 FUEL PUMP RELAY DRIVE: TO ACTIVATE, ECM SWITCHES CIRCUIT TO GROUND







Fig. 04.1

COMPONENTS: Automatic Transmission

Component Connector(s) Connector Description LocationAUTOMATIC TRANSMISSION JB155 18-WAY / BLACK ENGINE COMPARTMENT


J GATE ASSEMBLY IP14 16-WAY / GREEN CENTER CONSOLE


TCM RELAY — — POWER DISTRIBUTION FUSE BOX R8

TRANSMISSION CONTROL MODULE JB131 37-WAY / BLUE LOWER LH A POST


COMPONENTS: Manual Transmission

Component Connector(s) Connector Description LocationCLUTCH CANCEL SWITCH PA4 5-WAY / BLACK TOP OF CLUTCH PEDAL



OUTPUT SPEED SENSOR EN86 3-WAY / BLACK DIFFERENTIAL OUTPUT SHAFT HOUSING

REVERSE LAMPS SWITCH EN85 2-WAY / BLACK TOP OF TRANSMISSION


Connector Connector Description LocationJB1 42-WAY / BLACK / JUNCTION BOX HARNESS TO ENGINE HARNESS ADJACENT TO LH SUSPENSION TURRET





GROUNDS

Ground Location






Transmission Control Module

Pin Description and CharacteristicO JB131-03 2 / 4 BRAKE PRESSURE CONTROL SOLENOID DRIVE: PWM, 1.25 kHz, POSITIVE DUTY CYCLE 5 – 95%

O JB131-04 2 / 4 BRAKE TIMING SOLENOID DRIVE: B+ TO ACTIVATE

I JB131-05 OUTPUT SPEED SENSOR SIGNAL: 18 PULSES PER OUTPUT SHAFT REVOLUTION

B+ JB131-06 BATTERY POWER SUPPLY: B+

I JB131-07 RANGE SENSOR – 3: 3 = GROUND; NOT IN 3 = OPEN CIRCUIT


PG JB131-09 POWER GROUND: GROUND

O JB131-10 REDUCTION TIMING SOLENOID DRIVE: B+ TO ACTIVATE

C JB131-12 CAN – 1

C JB131-13 CAN – 2

O JB131-14 SHIFT SOLENOID B DRIVE: B+ TO ACTIVATE

O JB131-15 SHIFT SOLENOID A DRIVE: B+ TO ACTIVATE

O JB131-16 TCC PRESSURE CONTROL SOLENOID DRIVE: PWM, 1.25 kHz, POSITIVE DUTY CYCLE 5 – 95%

SG JB131-17 SOLENOID GROUND RETURN: GROUND

O JB131-18 LINE PRESSURE CONTROL SOLENOID DRIVE: PWM, 1.25 kHz, POSITIVE DUTY CYCLE 5 – 95%

SG JB131-20 SENSOR GROUND: GROUND

I JB131-21 INTERMEDIATE SPEED SENSOR SIGNAL: 54 PULSES PER INTERMEDIATE SHAFT REVOLUTION*

I JB131-24 TURBINE SPEED SENSOR SIGNAL: 36 PULSES PER ENGINE REVOLUTION

I JB131-25 RANGE SENSOR – N: N = GROUND; NOT IN N = OPEN CIRCUIT

I JB131-26 RANGE SENSOR – R: R = GROUND; NOT IN R = OPEN CIRCUIT

I JB131-27 RANGE SENSOR – D: D = GROUND; NOT IN D = OPEN CIRCUIT

I JB131-30 RANGE SENSOR – P: P = GROUND; NOT IN P = OPEN CIRCUIT

C JB131-33 CAN + 1

C JB131-34 CAN + 2

B+ JB131-36 IGNITION SWITCHED POWER SUPPLY: B+


I JB131-39 FLUID TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I JB131-45 D – 4 SWITCH: SWITCH ACTIVATED = GROUND

I JB131-47 MODE SWITCH: “SPORT” SELECTED = GROUND

O JB131-52 SHIFT SOLENOID C DRIVE: B+ TO ACTIVATE

O JB131-53 LOW CLUTCH TIMING SOLENOID DRIVE: B+ TO ACTIVATE


* IN 1ST – 4TH AND R, THE INTERMEDIATE SHAFT SPEED IS THE SAME AS THE OUTPUT SHAFT SPEED. IN 5TH, THE INTERMEDIATE SHAFT SPEED IS MULTIPLIED BY 1.2.


Pin Description and CharacteristicSG EN16-019 SENSOR GROUND 1: GROUND

I EN16-026 MANUAL TRANSMISSION OUTPUT SPEED SENSOR SIGNAL: PULSED SIGNAL, 26 PULSES PER TRANSMISSION REVOLUTION










Fig. 04.2





















GROUNDS

Ground Location















C JB131-12 CAN – 1

C JB131-13 CAN – 2













C JB131-33 CAN + 1

C JB131-34 CAN + 2














Pin Description and CharacteristicI EN65-084 CLUTCH CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED



Pin Description and CharacteristicI EN16-031 CLUTCH PEDAL SAFETY SWITCH (MANUAL TRANSMISSION): NORMALLY OPEN / B+ WHEN ACTIVATED








DATE OF ISSUE: November 2002

Fig. 04.3





















GROUNDS

Ground Location















C JB131-12 CAN – 1

C JB131-13 CAN – 2













C JB131-33 CAN + 1

C JB131-34 CAN + 2














Pin Description and CharacteristicI EN65-084 CLUTCH CANCEL SWITCH: NORMALLY CLOSED / GROUND WHEN ACTIVATED



Pin Description and CharacteristicI EN16-031 CLUTCH PEDAL SAFETY SWITCH (MANUAL TRANSMISSION): NORMALLY OPEN / B+ WHEN ACTIVATED









Fig. 05.1

COMPONENTS

Component Connector(s) Connector Description LocationANTI-LOCK BRAKING SYSTEM CONTROL MODULE JB45 42-WAY / BROWN ENGINE COMPARTMENT RH SIDE


CAPACITOR (ABS / DSC) JB195 2-WAY ADJACENT TO MODULATOR


VACUUM MODULE VM1 — UNDER BATTERY TRAYVM2 —VM3 —

VACUUM PUMP VPU — ADJACENT TO BRAKE SERVO

WHEEL SPEED SENSOR – LH FRONT LF1 2-WAY / BLACK LH FRONT WHEEL HUB

WHEEL SPEED SENSOR – LH REAR CA55 2-WAY / BLACK LH REAR WHEEL HUB

WHEEL SPEED SENSOR – RH FRONT RF1 2-WAY / BLACK RH FRONT WHEEL HUB

WHEEL SPEED SENSOR – RH REAR CA60 2-WAY / BLACK RH REAR WHEEL HUB






JB15 2-WAY / BLACK / ABS LINK LEAD BEHIND FRONT LH WHEELARCH LINER

JB133 2-WAY / BLACK / ABS LINK LEAD BEHIND LH WHEELARCH LINER

VP1 2-WAY / VACUUM PUMP LINK LEAD ENGINE COMPARTMENT, LH REAR

GROUNDS

Ground LocationG14 ENGINE COMPARTMENT / REARWARD OF POWER DISTRIBUTION FUSE BOX

G18 ENGINE COMPARTMENT / UNDER RH HEADLAMP ASSEMBLY



Anti-Lock Braking Control Module

Pin Description and CharacteristicPG JB45-01 MOTOR GROUND: GROUND

B+ JB45-02 BATTERY POWER SUPPLY – MOTOR: B+



I JB45-12 LH FRONT WHEEL SPEED SENSOR SIGNAL: 32 PULSES PER WHEEL REVOLUTION

SS JB45-13 LH REAR WHEEL SPEED SENSOR SUPPLY VOLTAGE: B+

I JB45-14 LH REAR WHEEL SPEED SENSOR SIGNAL: 32 PULSES PER WHEEL REVOLUTION

SS JB45-15 RH FRONT WHEEL SPEED SENSOR SUPPLY VOLTAGE: B+

I JB45-16 RH FRONT WHEEL SPEED SENSOR SIGNAL: 32 PULSES PER WHEEL REVOLUTION


C JB45-24 CAN +

O JB45-28 LH FRONT WHEEL SPEED SENSOR SUPPLY VOLTAGE: B+

O JB45-30 RH REAR WHEEL SPEED SENSOR SUPPLY VOLTAGE: B+

I JB45-31 RH REAR WHEEL SPEED SENSOR SIGNAL: 32 PULSES PER WHEEL REVOLUTION

I JB45-32 BRAKE ON / OFF SWITCH: NORMALLY OPEN / B+ WHEN ACTIVATED

C JB45-40 CAN –








Fig. 05.2

COMPONENTS


BRAKE PRESSURE SENSOR JB89 3-WAY / BLACK ON DYNAMIC STABILITY CONTROL MODULATOR



DYNAMIC STABILITY CONTROL CONTROL MODULE JB185 42-WAY / BLUE ENGINE COMPARTMENT RH SIDE

DYNAMIC STABILITY CONTROL SWITCH IP29 6-WAY / BLACK INSTRUMENT PANEL

STEERING ANGLE SENSOR IP19 4-WAY / BLACK STEERING COLUMN



WHEEL SPEED SENSOR – LH FRONT (ALL) LF1 2-WAY / BLACK LH FRONT WHEEL HUB

WHEEL SPEED SENSOR – LH REAR (2.5L & 3.0L) CA55 2-WAY / BLACK LH REAR WHEEL HUB

WHEEL SPEED SENSOR – LH REAR (2.0L) LR1 2-WAY / BLACK LH REAR WHEEL HUB

WHEEL SPEED SENSOR – RH FRONT (ALL) RF1 2-WAY / BLACK RH FRONT WHEEL HUB

WHEEL SPEED SENSOR – RH REAR (2.5L & 3.0L) CA60 2-WAY / BLACK RH REAR WHEEL HUB

WHEEL SPEED SENSOR – RH REAR (2.0L) RR1 2-WAY / BLACK RH REAR WHEEL HUB

YAW RATE SENSOR IP20 4-WAY / BLACK BEHIND CENTER CONSOLE




CA55 2-WAY / BLACK / 2.0L LH REAR WHEEL SPEED SENSOR LINK LEAD LH REAR WHEEL HUB

CA60 2-WAY / BLACK / 2.0L RH REAR WHEEL SPEED SENSOR LINK LEAD RH REAR WHEEL HUB









GROUNDS






Dynamic Stability Control Control Module










SG JB185-21 SENSOR GROUND – YAW RATE, STEERING ANGLE SENSORS: GROUND


C JB185-24 CAN +

SG JB185-25 SENSOR GROUND – BRAKE PRESSURE SENSOR: GROUND

I JB185-26 BRAKE PRESSURE SENSOR SIGNAL, NOMINAL 0 – 5 V: VOLTAGE INCREASES AS PRESSURE INCREASES

I JB185-27 DYNAMIC STABILITY CONTROL SWITCH: NORMALLY OPEN / GROUND WHEN ACTIVATED





SS JB185-39 YAW RATE, STEERING ANGLE SENSORS SUPPLY VOLTAGE: B+

C JB185-40 CAN –

SS JB185-42 BRAKE PRESSURE SENSOR SUPPLY VOLTAGE: NOMINAL 5 V








Fig. 05.3

COMPONENTS

Component Connector(s) Connector Description LocationANTI-LOCK BRAKING / TRACTION CONTROL CONTROL MODULE JB197 42-WAY / BROWN ENGINE COMPARTMENT RH SIDE




TRACTION CONTROL SWITCH IP29 6-WAY / BLACK INSTRUMENT PANEL



WHEEL SPEED SENSOR – LH FRONT LF1 2-WAY / BLACK LH FRONT WHEEL HUB

WHEEL SPEED SENSOR – LH REAR LR1 2-WAY / BLACK LH REAR WHEEL HUB

WHEEL SPEED SENSOR – RH FRONT RF1 2-WAY / BLACK RH FRONT WHEEL HUB

WHEEL SPEED SENSOR – RH REAR RR1 2-WAY / BLACK RH REAR WHEEL HUB




CA55 2-WAY / BLACK / 2.0L LH REAR WHEEL SPEED SENSOR LINK LEAD LH REAR WHEEL HUB

CA60 2-WAY / BLACK / 2.0L RH REAR WHEEL SPEED SENSOR LINK LEAD RH REAR WHEEL HUB







GROUNDS






Anti-Lock Braking Control Module











C JB197-24 CAN +

I JB197-27 TRACTION CONTROL SWITCH: NORMALLY OPEN / GROUND WHEN ACTIVATED





C JB197-40 CAN –








Fig. 06.1

COMPONENTS

Component Connector(s) Connector Description LocationAIR CONDITIONING BLOWER RELAY — — CENTRAL JUNCTION FUSE BOX R20

AIR CONDITIONING CONTROL MODULE (MANUAL, PANEL) AC1 26-WAY / YELLOW BEHIND CLIMATE CONTROL PANELIP39 6-WAY / GREYIP101 26-WAY / YELLOWIP135 2-WAY / GREY

AIR TEMPERATURE BLEND ACTUATOR AC2 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

BLOWER (MANUAL) IP58 2-WAY / GREY BEHIND INSTRUMENT PANEL, RH SIDE / LHD, LH SIDE / RHD

BLOWER SERIES RESISTOR IP121 6-WAY / GREY ADJACENT TO BLOWER MOTOR


DEFROST DOOR ACTUATOR AC4 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

DISCHARGE TEMPERATURE SENSOR AC6 2-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

DOOR MIRROR – LH FL5 22-WAY / BLACK LH FRONT DOOR

DOOR MIRROR – RH FR4 22-WAY / BLACK RH FRONT DOOR

EVAPORATOR TEMPERATURE SENSOR AC5 2-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

FRESH / RECIRCULATION FLAP ACTUATOR AC7 4-WAY / BLACK LH SIDE OF AIR DISTRIBUTION UNIT (LHD)RH SIDE OF AIR DISTRIBUTION UNIT (RHD)

HEATED REAR WINDOW ZA1 — REAR WINDOWZA10 —

HEATED REAR WINDOW RELAY — — CENTRAL JUNCTION FUSE BOX R19

PANEL / FLOOR ACTUATOR AC3 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT


WINDSHIELD HEATER – LH JB95 2-WAY / BLACK WINDSHIELD

WINDSHIELD HEATER – RH JB96 2-WAY / BLACK WINDSHIELD

WINDSHIELD HEATER RELAY — — POWER DISTRIBUTION FUSE BOX R2





CA127 2-WAY / GREY / CABIN HARNESS TO HEATED REAR WINDOW BEHIND LH E POST TRIM

GROUNDS

Ground LocationG3 PASSENGER COMPARTMENT / LH E POST




G36 PASSENGER COMPARTMENT / RH CROSS CAR BEAM




Air Conditioning Control Module: Manual

Pin Description and CharacteristicO AC1-04 FRESH / RECIRCULATION FLAP ACTUATOR DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO B+ OR TO GROUND

O AC1-05 FRESH / RECIRCULATION FLAP ACTUATOR DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO B+ OR TO GROUND

O AC1-06 DEFROST DOOR ACTUATOR STEPPER COIL 1 DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND


O AC1-08 PANEL / FLOOR ACTUATOR STEPPER COIL 1 DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND


O AC1-10 AIR TEMPERATURE BLEND ACTUATOR STEPPER COIL 1 DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND


O AC1-12 AIR TEMPERATURE BLEND ACTUATOR POWER SUPPLY: B+

O AC1-13 DEFROST DOOR ACTUATOR POWER SUPPLY: B+

I AC1-14 EVAPORATOR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I AC1-15 DISCHARGE TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

SG AC1-16 SENSOR GROUND: GROUND







O AC1-26 PANEL / FLOOR ACTUATOR POWER SUPPLY: B+

B+ IP101-01 BATTERY SAVER POWER SUPPLY: B+

B+ IP101-02 IGNITION SWITCHED POWER SUPPLY: B+

O IP101-03 WINDSHIELD HEATER RELAY DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND

O IP101-04 HEATED REAR WINDOW RELAY DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND

I IP101-07 BLOWER SPEED SENSE: B+ WHEN BLOWER OFF, 0 V WHEN BLOWER RUNNING

C IP101-09 CAN +

C IP101-10 CAN –

B+ IP101-14 BATTERY POWER SUPPLY: B+

PG IP101-15 POWER GROUND: GROUND

I IP101-20 DIMMER CONTROLLED ILLUMINATION: PWM, 80Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE

C IP101-22 CAN +

C IP101-23 CAN –

O IP135-1 BLOWER SPEED CONTROL 1: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND

PG IP135-2 BLOWER GROUND: GROUND













Fig. 06.2

COMPONENTS

Component Connector(s) Connector Description LocationAIR CONDITIONING BLOWER RELAY — — CENTRAL JUNCTION FUSE BOX R20

AIR CONDITIONING CONTROL MODULE (AUTOMATIC, PANEL) AC1 26-WAY / YELLOW BEHIND CLIMATE CONTROL PANELIP101 26-WAY / YELLOW

AIR CONDITIONING CONTROL MODULE (REMOTE) AC1 26-WAY / YELLOW RH SIDE OF AIR DISTRIBUTION UNITIP101 26-WAY / YELLOW

AIR TEMPERATURE BLEND ACTUATOR AC2 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

AMBIENT TEMPERATURE SENSOR JB105 2-WAY / BLACK FRONT CROSS MEMBER, ADJACENT TO RADIATOR LH SIDE

BLOWER (AUTOMATIC) IP134 6-WAY / BLACK BEHIND INSTRUMENT PANEL RH SIDE


DEFROST DOOR ACTUATOR AC4 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

DISCHARGE TEMPERATURE SENSOR AC6 2-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT



EVAPORATOR TEMPERATURE SENSOR AC5 2-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT

FRESH / RECIRCULATION FLAP ACTUATOR AC7 4-WAY / BLACK LH SIDE OF AIR DISTRIBUTION UNIT (LHD)RH SIDE OF AIR DISTRIBUTION UNIT (RHD)


HEATED REAR WINDOW RELAY — — CENTRAL JUNCTION FUSE BOX R19

IN-CAR TEMPERATURE SENSOR IP66 4-WAY / BLACK BELOW INSTRUMENT PANEL CENTER RIGHT

PANEL / FLOOR ACTUATOR AC3 6-WAY / BLACK RH SIDE OF AIR DISTRIBUTION UNIT


SOLAR SENSOR IP38 2-WAY / BLACK TOP CENTER OF INSTRUMENT PANEL

WINDSHIELD HEATER – LH JB95 2-WAY / BLACK WINDSHIELD

WINDSHIELD HEATER – RH JB96 2-WAY / BLACK WINDSHIELD

WINDSHIELD HEATER RELAY — — POWER DISTRIBUTION FUSE BOX R2




CA127 2-WAY / GREY / CABIN HARNESS TO HEATED REAR WINDOW BEHIND LH E POST TRIM



GROUNDS

Ground Location

G3 PASSENGER COMPARTMENT / LH E POST








Air Conditioning Control Module: Automatic

Pin Description and CharacteristicO AC1-04 FRESH / RECIRCULATION FLAP ACTUATOR DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO B+ OR TO GROUND

O AC1-05 FRESH / RECIRCULATION FLAP ACTUATOR DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO B+ OR TO GROUND







O AC1-12 AIR TEMPERATURE BLEND ACTUATOR POWER SUPPLY: B+

O AC1-13 DEFROST DOOR ACTUATOR POWER SUPPLY: B+

I AC1-14 EVAPORATOR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I AC1-15 DISCHARGE TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

I AC1-16 SENSOR GROUND: GROUND







O AC1-26 PANEL / FLOOR ACTUATOR POWER SUPPLY: B+

B+ IP101-01 BATTERY SAVER POWER SUPPLY: B+

B+ IP101-02 IGNITION SWITCHED POWER SUPPLY: B+

O IP101-03 WINDSHIELD HEATER RELAY DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND

O IP101-04 HEATED REAR WINDOW RELAY DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO GROUND

I IP101-05 ASPIRATOR MOTOR DRIVE: PERMANENTLY CONNECTED TO GROUND; A/CCM MONITORS CIRCUIT FOR MOTOR RUNNING CONDITION

O IP101-06 BLOWER MOTOR CONTROL: PWM, 400 Hz, APPROXIMATELY 8% – 90%; HIGHER DUTY CYCLE = HIGHER BLOWER SPEED

I IP101-07 BLOWER MOTOR SPEED SENSE: FREQUENCY = RPM / 20; FREQUENCY PROPORTIONAL TO BLOWER SPEED

C IP101-09 CAN +

C IP101-10 CAN –



I IP101-16 IN CAR TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES

SG IP101-17 SENSOR GROUND: GROUND

I IP101-18 SOLAR SENSOR SIGNAL, NOMINAL 0 – 5 V: DARKER = HIGHER VOLTAGE

I IP101-19 AMBIENT TEMPERATURE SENSOR SIGNAL, NOMINAL 0 – 5 V: NTC SENSOR – VOLTAGE DECREASES AS TEMPERATURE INCREASES


O IP101-21 AIR CONDITIONING BLOWER RELAY DRIVE: TO ACTIVATE, A/CCM SWITCHES CIRCUIT TO B+

C IP101-22 CAN +

C IP101-23 CAN –








Fig. 07.1

COMPONENTS

Component Connector(s) Connector Description LocationBRAKE FLUID SWITCH JB70 3-WAY / BLACK BRAKE MASTER CYLINDER

FUEL LEVEL SENSOR 1 (2.5L & 3.0L) FT2 4-WAY / BLACK FUEL TANK

FUEL LEVEL SENSOR 2 (2.5L & 3.0L) FT3 4-WAY / BLACK FUEL TANK

FUEL LEVEL SENSOR (2.0L) CA415 4-WAY / BLACK FUEL TANK



MASTER LIGHTING SWITCH IP17 16-WAY / BLACK INSTRUMENT PANEL

OIL PRESSURE SWITCH EN19 1-WAY / BLACK ADJACENT TO ENGINE OIL FILTER

RESTRAINTS CONTROL MODULE CA165 40-WAY / BLACK UNDER CENTER CONSOLEIP74 24-WAY / BLACK

TURN SIGNAL SWITCH IP53 10-WAY / GREY STEERING COLUMN

WASHER FLUID LEVEL SWITCH JB103 2-WAY / BLACK ENGINE COMPARTMENT RH FRONT





CA169 4-WAY / GREY / CABIN HARNESS TO INSTRUMENT PANEL HARNESS BELOW THE GLOVEBOX



GROUNDS

Ground LocationG10 ENGINE COMPARTMENT / UNDER RH HEADLAMP ASSEMBLY








S IP5-19 SCP +

I IP6-18 SEAT BELT AND AIRBAG AUDIBLE WARNING REQUEST: AUDIBLE WARNING REQUEST ACTIVE = GROUND

Instrument Cluster

Pin Description and CharacteristicI IP10-7 FUEL LEVEL SENSOR 1 SIGNAL: VARIABLE RESISTANCE: 20 Ω = EMPTY; 160 Ω = FULL

I IP10-8 FUEL LEVEL SENSOR 2 SIGNAL: VARIABLE RESISTANCE: 20 Ω = EMPTY; 160 Ω = FULL

SG IP10-9 FUEL LEVEL SENSOR REFERENCE: GROUND

I IP10-10 MAIN BEAM STATUS: B+ WHEN ACTIVATED

I IP10-11 WASHER FLUID LEVEL LOW SIGNAL: FLUID LEVEL LOW = GROUND

I IP10-12 BRAKE FLUID LEVEL WARNING SIGNAL: FLUID LEVEL LOW = GROUND

I IP10-15 PARKING BRAKE SIGNAL: PARKING BRAKE ON = GROUND

I IP10-16 TRIP COMPUTER CYCLE SWITCH: GROUND WHEN ACTIVATED

C IP10-17 CAN +

C IP10-18 CAN –

I IP10-19 FRONT FOG STATUS (HARD WIRED TO INDICATOR): B+ WHEN ACTIVATED

I IP10-20 REAR FOG STATUS (HARD WIRED TO INDICATOR): B+ WHEN ACTIVATED

S IP10-22 SCP +

S IP10-23 SCP –

I IP10-24 TRIP COMPUTER MODE SIGNAL: STEPPED RESISTANCE

SG IP10-25 TRIP COMPUTER SWITCH PACK REFERENCE: GROUND

I IP11-5 ENGINE OIL PRESSURE SIGNAL: ENGINE OIL PRESSURE PRESENT = GROUND




I IP11-13 IGNITION SWITCHED POWER SUPPLY (I): B+

I IP11-15 SIDE LAMPS STATUS: B+ WHEN ACTIVATED

I IP11-17 DIP BEAM STATUS: B+ WHEN ACTIVATED

I IP11-19 AIR BAG WARNING: HARD WIRED TO AIR BAG INDICATOR

I IP11-21 DIMMER CONTROLLED ILLUMINATION: PWM, 80 Hz, GROUND = 0% DUTY CYCLE, B+ = 100% DUTY CYCLE; HARD WIRED TO BACK LIGHTING; MICRO SENSED FOR DISPLAY








Fig. 07.2

COMPONENTS

Component Connector(s) Connector Description LocationDOOR LATCH ASSEMBLY – LH FRONT FL3 8-WAY / BLACK LH FRONT DOOR

FL9 2-WAY / BLACK

DOOR LATCH ASSEMBLY – RH FRONT FR3 8-WAY / BLACK RH FRONT DOORFR9 2-WAY / BLACK







Connector Connector Description LocationCA1 22-WAY / NATURAL / CABIN HARNESS TO INSTRUMENT PANEL HARNESS LH LOWER A POST



GROUNDS

Ground Location









S IP5-18 SCP –

S IP5-19 SCP +



I IP6-15 NOT-IN-PARK SWITCH: PARK = OPEN CIRCUIT; NOT-IN-PARK = GROUND

I IP6-18 SEAT BELT AND AIRBAG AUDIBLE WARNING REQUEST: AUDIBLE WARNING REQUEST ACTIVE = GROUND

I IP6-22 DRIVER DOOR AJAR: DOOR OPEN = OPEN CIRCUIT; DOOR CLOSED = GROUND









Fig. 08.1

COMPONENTS

Component Connector(s) Connector Description LocationAUTOLAMPS SENSOR RC5 5-WAY / BLACK BEHIND REAR VIEW MIRROR


DIP BEAM RELAY — — POWER DISTRIBUTION FUSE BOX R9

FOG LAMP – LH FRONT FB1 2-WAY / BLACK UNDER FRONT BUMPER

FOG LAMP – RH FRONT FB3 2-WAY / BLACK UNDER FRONT BUMPER


GLOVE BOX LAMP IP25 2-WAY / BROWN GLOVE BOX

HEADLAMP UNIT – LH JB84 10-WAY / BLACK LH FRONT OF VEHICLE

HEADLAMP UNIT – RH JB85 10-WAY / BLACK RH FRONT OF VEHICLE

MAIN BEAM / FRONT FOG RELAY — — CENTRAL JUNCTION FUSE BOX R15



SIDE MARKER LAMP – LH FRONT FB2 2-WAY / BLACK FRONT BUMPER LH SIDE

SIDE MARKER LAMP – RH FRONT FB4 2-WAY / BLACK FRONT BUMPER RH SIDE

TURN REPEATER – LH JB132 2-WAY / BLACK LH FRONT FENDER

TURN REPEATER – RH JB98 2-WAY / BLACK RH FRONT FENDER






JB171 8-WAY / BLACK / FRONT END HARNESS TO BUMPER LINK LEAD BEHIND FRONT LH WHEEL ARCH LINER

GROUNDS

Ground Location







G33 ENGINE COMPARTMENT / BEHIND RH HEADLAMP ASSEMBLY







I IP5-3 EXTERNAL ANTENNA

S IP5-18 SCP –

S IP5-19 SCP +

O IP5-22 TURN SIGNAL AUDIBLE WARNING: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


I IP6-11 MAIN BEAM SWITCH: GROUND WHEN SELECTED

O IP6-13 MAIN BEAM / FRONT FOG RELAY DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

I IP6-17 LH TURN SIGNAL SWITCH: GROUND WHEN SELECTED

I IP6-19 RH TURN SIGNAL SWITCH: GROUND WHEN SELECTED

I IP6-23 HAZARD SWITCH: GROUND WHEN SELECTED

O JB172-3 RH FRONT TURN SIGNAL: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

O JB172-4 LH FRONT TURN SIGNAL: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+









Fig. 08.2

COMPONENTS



DIP BEAM RELAY — — POWER DISTRIBUTION FUSE BOX R9

FOG LAMP – LH FRONT FB1 2-WAY / BLACK UNDER FRONT BUMPER

FOG LAMP – RH FRONT FB3 2-WAY / BLACK UNDER FRONT BUMPER



HAZARD SWITCH IP51 6-WAY / BLACK CENTER CONSOLE



MAIN BEAM / FRONT FOG RELAY — — CENTRAL JUNCTION FUSE BOX R15



SIDE MARKER LAMP – LH FRONT FB2 2-WAY / BLACK FRONT BUMPER LH SIDE

SIDE MARKER LAMP – RH FRONT FB4 2-WAY / BLACK FRONT BUMPER RH SIDE

TURN REPEATER – LH JB132 2-WAY / BLACK LH FRONT FENDER

TURN REPEATER – RH JB98 2-WAY / BLACK RH FRONT FENDER



Connector Connector Description LocationJB129 22-WAY / GREY / INSTRUMENT PANEL HARNESS TO JUNCTION BOX HARNESS LH LOWER A POST

JB171 8-WAY / BLACK / FRONT END HARNESS TO BUMPER LINK LEAD BEHIND FRONT LH WHEEL ARCH LINER

GROUNDS

Ground Location







G33 ENGINE COMPARTMENT / BEHIND RH HEADLAMP ASSEMBLY






P Pin Description and CharacteristicPG CA86-5 POWER GROUND: GROUND


S IP5-18 SCP –

S IP5-19 SCP +



I IP6-11 MAIN BEAM SWITCH: GROUND WHEN SELECTED

O IP6-13 MAIN BEAM / FRONT FOG RELAY DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+













Fig. 08.3

COMPONENTS





HIGH MOUNT STOP LAMP CA304 2-WAY / BLACK REAR WINDOW


LICENSE PLATE LAMP – LH TM4 2-WAY / BLACK TRUNK LID

LICENSE PLATE LAMP – RH TM5 2-WAY / BLACK TRUNK LID


REVERSE LAMPS RELAY — — CENTRAL JUNCTION FUSE BOX R17


SIDE MARKER LAMP – LH REAR RB5 2-WAY / BLACK REAR BUMPER LH SIDE

SIDE MARKER LAMP – RH REAR RB6 2-WAY / BLACK REAR BUMPER RH SIDE

TAIL LAMP UNIT – LH CA137 7-WAY / BLACK TRUNK LH REAR

TAIL LAMP UNIT – RH CA138 7-WAY / BLACK TRUNK RH REAR






CA45 6-WAY / GREY / CABIN HARNESS TO TRUNK LID HARNESS TRUNK LH REAR






TL10 6-WAY / GREY / TRUNK LID HARNESS BELOW PARCEL SHELF LH SIDE

GROUNDS

Ground LocationG1 TRUNK / LH REAR

G2 TRUNK / LH REAR





G38 PASSENGER COMPARTMENT / TOP OF LH E POST




Pin Description and CharacteristicO CA86-2 LH REAR TURN SIGNAL: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

PG CA86-5 POWER GROUND: GROUND

O CA87-4 RH REAR TURN SIGNAL: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

S IP5-18 SCP –

S IP5-19 SCP +







Instrument Cluster

Pin Description and CharacteristicI IP10-1 REVERSE LAMP SWITCH: B+ WHEN ACTIVATED

C IP10-17 CAN +

C IP10-18 CAN –

O IP11-3 REVERSE LAMPS RELAY DRIVE: TO ACTIVATE, IC SWITCHES CIRCUIT TO GROUND








Fig. 08.4

COMPONENTS









TAIL LAMP UNIT – LH TT4 7-WAY / BLACK TRUNK LH REAR

TAIL LAMP UNIT – RH TT5 7-WAY / BLACK TRUNK RH REAR

TRAILER CONNECTOR T5011 — TRUNK RH REART312N —T6US1 —

TRAILER TOWING CONTROL MODULE TT1 — SPARE WHEEL WELLTT2 —TT3 —

TRAILER TOWING REAR ACCESSORY CONNECTOR T3001 — TRUNK RH REART4001 —T5001 —



Connector Connector Description LocationCA45 6-WAY / GREY / CABIN HARNESS TO TRUNK LID HARNESS TRUNK LH REAR


CA146 3-WAY / BLACK / ACCESSORY SOCKET ADJACENT TO LH REAR TAIL LAMP


CA175 TRAILER TOWING CONNECTOR TRUNK


CA302 2-WAY / GREY / CABIN HARNESS TO TRAILER HARNESS ADJACENT TO LH REAR TAIL LAMP




TT6 TRAILER TOWING CONNECTOR TRUNK

GROUNDS

Ground Location

G1 TRUNK / LH REAR

G2 TRUNK / LH REAR












S IP5-18 SCP –

S IP5-19 SCP +














Fig. 08.5

COMPONENTS


CARAVAN CONNECTOR T412S — TRUNK RH REAR

























T3001 TRAILER TOWING CONNECTOR TRUNK




GROUNDS

Ground Location

G1 TRUNK / LH REAR

G2 TRUNK / LH REAR












S IP5-18 SCP –

S IP5-19 SCP +














Fig. 08.6

COMPONENTS









SIDE MARKER LAMP – LH REAR RB5 2-WAY / BLACK REAR BUMPER LH SIDE

SIDE MARKER LAMP – RH REAR RB6 2-WAY / BLACK REAR BUMPER RH SIDE



















GROUNDS

Ground Location

G1 TRUNK / LH REAR

G2 TRUNK / LH REAR












S IP5-18 SCP –

S IP5-19 SCP +










Fig. 08.7

COMPONENTS

Component Connector(s) Connector Description LocationDIP BEAM RELAY — — POWER DISTRIBUTION FUSE BOX R9

FRONT AXLE SENSOR JB140 6-WAY / BLACK LH FRONT SUSPENSION

HEADLAMP LEVELING CONTROL MODULE IP130 26-WAY / YELLOW BEHIND INSTRUMENT PANEL LH SIDE





REAR AXLE SENSOR HI1 6-WAY / BLACK LH REAR SUSPENSION









GROUNDS

Ground LocationG10 ENGINE COMPARTMENT / UNDER RH HEADLAMP ASSEMBLY










Fig. 09.1

COMPONENTS

Component Connector(s) Connector Description LocationDOOR COURTESY LAMP – LH FL7 2-WAY / WHITE LH FRONT DOOR

DOOR COURTESY LAMP – RH FR6 2-WAY / WHITE RH FRONT DOOR

DOOR LATCH ASSEMBLY – LH FRONT FL3 8-WAY / BLACK LH FRONT DOORFL9 2-WAY / BLACK

DOOR LATCH ASSEMBLY – LH REAR BL3 8-WAY / BLACK LH REAR DOORBL6 2-WAY / BLACK


DOOR LATCH ASSEMBLY – RH REAR BR3 8-WAY / BLACK RH REAR DOORBR6 2-WAY / BLACK

FOOTWELL LAMP – LH IP27 2-WAY / WHITE INSTRUMENT PANEL LH SIDE

FOOTWELL LAMP – RH IP26 2-WAY / WHITE INSTRUMENT PANEL RH SIDE



REAR INTERIOR LAMP RC11 2-WAY / BLACK REAR HEAD LINERRC20 1-WAY / RED

ROOF CONSOLE RC22 22-WAY / BLACK ROOF, CENTER FRONTRC30 4-WAY / BLACKRC31 2-WAY / BLACKRC33 4-WAY / BLACKRC34 6-WAY / BLACK

TRUNK LAMP CA132 2-WAY / BLACK TRUNK RH SIDE

TRUNK LOCK MOTOR TM6 5-WAY / NATURAL TRUNK LID

VANITY MIRROR LAMP – LH RC9 2-WAY / BLACK LH SUN VISOR

VANITY MIRROR LAMP – RH RC8 2-WAY / BLACK RH SUN VISOR













GROUNDS

Ground Location

G1 TRUNK / LH REAR








Pin Description and CharacteristicO CA86-1 LH AND RH DOOR COURTESY LAMPS : TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND

O CA86-3 INTERIOR LAMPS : TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND


I CA86-14 RESET SWITCH: OPEN CIRCUIT / GROUND

I CA86-16 SET SWITCH: OPEN CIRCUIT / GROUND

I CA86-18 RH REAR DOOR AJAR: DOOR OPEN = OPEN CIRCUIT; DOOR CLOSED = GROUND

I CA87-15 LH REAR DOOR AJAR: DOOR OPEN = OPEN CIRCUIT; DOOR CLOSED = GROUND


S IP5-18 SCP –

S IP5-19 SCP +


I IP6-21 PASSENGER DOOR AJAR: DOOR OPEN = OPEN CIRCUIT; DOOR CLOSED = GROUND


B+ JB172-1 BATTERY POWER SUPPLY (LOCKING): B+




Fig. 09.2

COMPONENTS

Component Connector(s) Connector Description LocationAIR CONDITIONING CONTROL MODULE (AUTOMATIC, PANEL) AC1 26-WAY / YELLOW BEHIND CLIMATE CONTROL PANEL

IP101 26-WAY / YELLOW


AUDIO UNIT ID1 2-WAY / BLACK INSTRUMENT PANEL CENTERIP65 20-WAY / BLACKIP106 2-WAY / COAXIAL

CIGAR LIGHTER IP42 2-WAY / ORANGE ASH TRAY

DOOR SWITCH PACK – DRIVER FL1 20-WAY / BLACK DRIVER DOOR ARM RESTFR1 20-WAY / BLACK

DOOR SWITCH PACK – LH REAR BL1 8-WAY / BLACK LH REAR DOOR

DOOR SWITCH PACK – PASSENGER FL10 8-WAY / BLACK PASSENGER DOOR

DOOR SWITCH PACK – RH REAR BR1 8-WAY / BLACK RH REAR DOOR

DYNAMIC STABILITY CONTROL SWITCH IP29 6-WAY / BLACK INSTRUMENT PANEL

HAZARD, SEAT HEATER SWITCHES IP51 6-WAY / BLACK CENTER CONSOLE





STEERING WHEEL SW4 6-WAY / BLACK STEERING COLUMN

TELEMATICS DISPLAY IP70 22-WAY / BLACK CENTER CONSOLEIP136 2-WAYIP137 2-WAYIP138 2-WAYIP139 2-WAY











GROUNDS

Ground Location













Fig. 10.1

COMPONENTS

Component Connector(s) Connector Description LocationELECTROCHROMIC REAR VIEW MIRROR RC5 5-WAY / BLACK REAR VIEW MIRROR


VARIABLE ASSIST SERVO EM91 2-WAY STEERING RACK PINION HOUSING






GROUNDS

Ground Location






Instrument Cluster

Pin Description and CharacteristicC IP10-17 CAN +

C IP10-18 CAN –


I IP11-23 VARIABLE ASSIST POWER STEERING FEEDBACK: CLOSED LOOP

I IP11-24 IGNITION SWITCHED POWER SUPPLY: B+

O IP11-25 VARIABLE ASSIST POWER STEERING DRIVE: 864 mA = MAXIMUM ASSIST; 0 mA = MINIMUM ASSIST




Fig. 10.2

COMPONENTS

Component Connector(s) Connector Description LocationDOOR SWITCH PACK – DRIVER FL1 20-WAY / BLACK DRIVER DOOR ARM REST

FR1 20-WAY / BLACK

FOLD FLAT MODULE CA270 7-WAY / GREY BEHIND PASSENGER AIR BAG











GROUNDS

Ground Location





Fig. 11.1

COMPONENTS

Component Connector(s) Connector Description LocationSEAT LUMBAR PUMP – LH LS19 3-WAY / WHITE LH SEAT

SEAT LUMBAR PUMP – RH RS19 3-WAY / WHITE RH SEAT

SEAT LUMBAR SWITCH PACK – LH LS16 7-WAY / BLACK LH FRONT SEAT

SEAT LUMBAR SWITCH PACK – RH RS16 7-WAY / BLACK RH FRONT SEAT

SEAT MOVEMENT MOTORS – LH LS2 2-WAY / BLACK BELOW LH SEATLS4 2-WAY / REDLS5 2-WAY / BLACKLS6 2-WAY / RED

SEAT MOVEMENT MOTORS – RH RS2 2-WAY / BLACK BELOW RH SEATRS4 2-WAY / REDRS5 2-WAY / BLACKRS6 2-WAY / BLACK

SEAT SWITCH PACK – LH LS1 12-WAY / GREY LH SEAT

SEAT SWITCH PACK – RH RS1 12-WAY / GREY RH SEAT





GROUNDS

Ground LocationG4 PASSENGER COMPARTMENT / RH LOWER A POST




Fig. 11.2

COMPONENTS

Component Connector(s) Connector Description LocationSEAT MOVEMENT MOTOR – LH LS10 2-WAY / RED BELOW LH SEAT

SEAT MOVEMENT MOTOR – RH RS10 2-WAY / RED BELOW RH SEAT

SEAT SWITCH PACK – LH LS1 12-WAY / GREY LH SEAT

SEAT SWITCH PACK – RH RS1 12-WAY / GREY RH SEAT





GROUNDS





Fig. 11.3

COMPONENTS

Component Connector(s) Connector Description LocationSEAT BACK HEATER – LH LS7 4-WAY / GREY BELOW LH SEAT

SEAT BACK HEATER – RH RS7 4-WAY / GREY BELOW RH SEAT

SEAT CUSHION HEATER – LH LS7 4-WAY / GREY BELOW LH SEAT

SEAT CUSHION HEATER – RH RS7 4-WAY / GREY BELOW RH SEAT

SEAT HEATER MODULE – LH LS13 12-WAY / GREY BELOW LH SEAT

SEAT HEATER MODULE – RH RS13 12-WAY / GREY BELOW RH SEAT

SEAT HEATER SWITCH – LH IP51 6-WAY / BLACK CENTER CONSOLE

SEAT HEATER SWITCH – RH IP56 6-WAY / BLACK CENTER CONSOLE






GROUNDS











Fig. 12.1

COMPONENTS


FL9 2-WAY / BLACK









TRUNK RELEASE SWITCH TM8 2-WAY / WHITE TRUNK LID












GROUNDS









Pin Description and CharacteristicO CA86-4 CENTRAL LOCKING MOTORS DRIVE – DOUBLE LOCKING: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+





I CA86-19 LOCK SWITCH: OPEN CIRCUIT / GROUND

I CA86-22 TRUNK LID AJAR: TRUNK OPEN = OPEN CIRCUIT; TRUNK CLOSED = GROUND

O CA87-2 TRUNK LOCK MOTOR DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

O CA87-3 CENTRAL LOCKING MOTORS DRIVE – LOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

O CA87-5 CENTRAL LOCKING REAR MOTORS DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


I CA87-16 UNLOCK SWITCH: OPEN CIRCUIT / GROUND

O IP5-1 PASSENGER DOORS LOCK MOTOR DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


O IP5-5 DRIVER DOOR LOCK MOTOR DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

I IP5-16 TRUNK RELEASE SWITCH: GROUND WHEN SELECTED

S IP5-18 SCP –

S IP5-19 SCP +






Instrument Cluster

Pin Description and CharacteristicI IP10-13 EMERGENCY UNLOCK: B+ WHEN ACTIVATED

S IP10-22 SCP +

S IP10-23 SCP –










Fig. 12.2

COMPONENTS


FL9 2-WAY / BLACK









TRUNK RELEASE SWITCH TM8 2-WAY / WHITE TRUNK LID












GROUNDS
















O CA87-3 CENTRAL LOCKING MOTORS DRIVE – LOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+

O CA87-5 CENTRAL LOCKING REAR MOTORS DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


I CA87-16 UNLOCK SWITCH: OPEN CIRCUIT / GROUND

O IP5-1 PASSENGER DOORS LOCK MOTOR DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


O IP5-5 DRIVER DOOR LOCK MOTOR DRIVE – UNLOCK: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+


S IP5-18 SCP –

S IP5-19 SCP +






Instrument Cluster

Pin Description and CharacteristicI IP10-13 EMERGENCY UNLOCK: B+ WHEN ACTIVATED

S IP10-22 SCP +

S IP10-23 SCP –










Fig. 12.3

COMPONENTS

Component Connector(s) Connector Description LocationACTIVE SECURITY SOUNDER JB70 6-WAY / BLACK BEHIND FRONT LH WHEEL ARCH LINER









HOOD SECURITY SWITCH JB81 2-WAY / BLACK ADJACENT TO RH FRONT SUSPENSION TURRET

HORN RELAY — — POWER DISTRIBUTION FUSE BOX R3

HORNS JB87 2-WAY / BLACK ADJACENT TO BATTERY


INCLINATION SENSOR CA190 6-WAY / BLACK TRUNK LH REAR



PASSIVE SECURITY SOUNDER SL1 1-WAY LH FRONT OF VEHICLESL2 1-WAY



SECURITY INDICATOR IP29 6-WAY / BLACK CENTER CONSOLE












JB79 6-WAY / BLACK / SECURITY SOUNDER LINK LEAD BEHIND FRONT LH WHEELARCH LINER



GROUNDS

Ground Location

G1 TRUNK / LH REAR












I CA86-17 INCLINATION SENSOR SENSE: ALARM TRIGGERED = GROUND; ALARM NOT TRIGGERED = B+



O CA86-20 INCLINATION AND INTRUSION SENSORS POWER SUPPLY: B+


I CA86-23 INTRUSION SENSOR SENSE: ALARM TRIGGERED = GROUND; ALARM NOT TRIGGERED = B+

O CA87-1 PASSIVE SECURITY SOUNDER DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO B+




O IP5-14 HORN RELAY DRIVE : TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND


S IP5-18 SCP –

S IP5-19 SCP +



I IP6-9 HEADLAMP FLASH SWITCH: GROUND WHEN SELECTED

I IP6-10 AUDIO UNIT PRESENCE SENSE: GROUND WHEN RADIO INSTALLED







D JB172-18 ACTIVE SECURITY SOUNDER DRIVE: ENCODED COMMUNICATIONS

I JB172-21 HOOD AJAR: HOOD OPEN = OPEN CIRCUIT; HOOD CLOSED = GROUND

Instrument Cluster

Pin Description and CharacteristicO IP10-2 SECURITY INDICATOR DRIVE: TO ACTIVATE, IC SWITCHES CIRCUIT TO B+





C IP10-17 CAN +

C IP10-18 CAN –

S IP10-22 SCP +

S IP10-23 SCP –











Fig. 13.1

COMPONENTS

Component Connector(s) Connector Description LocationGENERAL ELECTRONIC CONTROL MODULE CA86 23-WAY / GREY BEHIND INSTRUMENT PANEL RH SIDE

CA87 23-WAY / GREENIP5 23-WAY / BROWNIP6 23-WAY / WHITEJB172 23-WAY / BLUE


POWER WASH PUMP JB65 2-WAY / GREY BEHIND RH FRONT WHEEL ARCH LINER

POWER WASH PUMP RELAY — — POWER DISTRIBUTION FUSE BOX R5

WINDSHIELD WASHER PUMP JB109 2-WAY / WHITE ENGINE COMPARTMENT RH FRONT

WINDSHIELD WIPER MOTOR RELAY — — POWER DISTRIBUTION FUSE BOX R1

WIPER MOTOR ASSEMBLY JB63 5-WAY / BLACK BASE OF WINDSHIELD LH SIDE

WIPER SWITCH ASSEMBLY IP16 10-WAY / GREY STEERING COLUMN






GROUNDS

Ground Location











I IP5-4 INTERMITTENT WIPE INTERVAL: 1 = 0.5 – 4 kΩ; 2 = 4 – 14 kΩ; 3 = 14 – 24 kΩ; 4 = 24 – 34 kΩ; 5 = 34 – 43 kΩ; 6 = 43 – 57 kΩ

S IP5-18 SCP –

S IP5-19 SCP +

O IP5-21 WINDSHIELD WIPER RELAY DRIVE: TO ACTIVATE, CIRCUIT SWITCHED TO GROUND


I IP6-4 INTERMITTENT WIPE: B+ WHEN SELECTED

I IP6-5 WASHER SWITCH: WASHER ON = GROUND; WASHER OFF = B+


I JB172-2 WIPER MOTOR PARK SWITCH: PARKED = GROUND; NOT PARKED = B+


O JB172-23 POWER WASH PUMP RELAY DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND








Fig. 13.2

COMPONENTS




POWER WASH PUMP JB65 2-WAY / GREY BEHIND RH FRONT WHEEL ARCH LINER

POWER WASH PUMP RELAY — — POWER DISTRIBUTION FUSE BOX R5

RAIN SENSING CONTROL MODULE CA6 12-WAY / BLACK BEHIND INSTRUMENT PANEL LH SIDE

RAIN SENSOR RC15 3-WAY / BLACK BEHIND REAR VIEW MIRROR

WINDSHIELD WASHER PUMP JB109 2-WAY / WHITE ENGINE COMPARTMENT RH FRONT

WINDSHIELD WIPER MOTOR RELAY — — POWER DISTRIBUTION FUSE BOX R1

WIPER MOTOR ASSEMBLY JB63 5-WAY / BLACK BASE OF WINDSHIELD LH SIDE

WIPER SWITCH ASSEMBLY IP16 10-WAY / GREY STEERING COLUMN




CA35 10-WAY / GREY / CABIN HARNESS TO ROOF HARNESS RH LOWER A POST





GROUNDS

Ground Location












I IP5-4 INTERMITTENT WIPE INTERVAL: 1 = 0.5 – 4 kΩ; 2 = 4 – 14 kΩ; 3 = 14 – 24 kΩ; 4 = 24 – 34 kΩ; 5 = 34 – 43 kΩ; 6 = 43 – 57 kΩ

S IP5-18 SCP –

S IP5-19 SCP +

O IP5-21 WINDSHIELD WIPER RELAY DRIVE: TO ACTIVATE, CIRCUIT SWITCHED TO GROUND


I IP6-4 INTERMITTENT WIPE: B+ WHEN SELECTED

I IP6-5 WASHER SWITCH: WASHER ON = GROUND; WASHER OFF = B+


I JB172-2 WIPER MOTOR PARK SWITCH: PARKED = GROUND; NOT PARKED = B+


O JB172-23 POWER WASH PUMP RELAY DRIVE: TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND








Fig. 14.1

COMPONENTS


FL9 2-WAY / BLACK

DOOR SWITCH PACK – DRIVER (LHD) FL1 20-WAY / BLACK DRIVER DOOR ARM REST


DOOR SWITCH PACK – PASSENGER (LHD) FR10 8-WAY / BLACK PASSENGER DOOR



WINDOW MOTOR ASSEMBLY – LH FRONT FL2 8-WAY / GREY LH FRONT DOOR

WINDOW MOTOR ASSEMBLY – LH REAR BL2 8-WAY / GREY LH REAR DOOR

WINDOW MOTOR ASSEMBLY – RH FRONT FR2 8-WAY / GREY RH FRONT DOOR

WINDOW MOTOR ASSEMBLY – RH REAR BR2 8-WAY / GREY RH REAR DOOR







GROUNDS

Ground Location







Pin Description and CharacteristicI CA86-16 SET SWITCH: OPEN CIRCUIT / GROUND

O CA87-17 GLOBAL CLOSE REQUEST: 20 ms PULSED SIGNAL










Fig. 14.2

COMPONENTS


FL9 2-WAY / BLACK

DOOR SWITCH PACK – DRIVER (LHD) FL1 20-WAY / BLACK DRIVER DOOR ARM REST


DOOR SWITCH PACK – PASSENGER (LHD) FR10 8-WAY / BLACK PASSENGER DOOR



WINDOW MOTOR ASSEMBLY – LH FRONT FL2 8-WAY / GREY LH FRONT DOOR

WINDOW MOTOR ASSEMBLY – LH REAR BL2 8-WAY / GREY LH REAR DOOR

WINDOW MOTOR ASSEMBLY – RH FRONT FR2 8-WAY / GREY RH FRONT DOOR

WINDOW MOTOR ASSEMBLY – RH REAR BR2 8-WAY / GREY RH REAR DOOR







GROUNDS

Ground Location


















Fig. 14.3

COMPONENTS






SLIDING ROOF CONTROL MODULE RC14 10-WAY / GREY ROOF CONSOLE








GROUNDS

Ground Location






Control Module



O CA87-20 VEHICLE SPEED SIGNAL: PULSED SIGNAL, 8000 PULSES PER MPH


S IP5-18 SCP –

S IP5-19 SCP +










Fig. 15.1

COMPONENTS

Component Connector(s) Connector Description LocationANTENNA MODULE CA117 — BEHIND LH E POST TRIM

AUDIO CONTROL SWITCHES SW4 6-WAY / BLACK STEERING WHEEL


CD AUTOCHANGER CA301 3-WAY / BLACK TRUNK LH REARCD2 2-WAY / BLACK


SPEAKER – LH FRONT FL6 2-WAY / WHITE LH FRONT DOOR CASING

SPEAKER – LH REAR BL4 2-WAY / WHITE LH REAR DOOR CASING

SPEAKER – RH FRONT FR5 2-WAY / WHITE RH FRONT DOOR CASING

SPEAKER – RH REAR BR4 2-WAY / WHITE RH REAR DOOR CASING







CA189 2-WAY / COAXIAL / AUDIO SYSTEM ANTENNA LH LOWER A POST




GROUNDS

Ground Location

G1 TRUNK / LH REAR





Audio Unit

Pin Description and CharacteristicD2 ID1-1 D2B NETWORK TRANSMIT

D2 ID1-2 D2B NETWORK RECEIVE


B+ IP65-2 IGNITION SWITCHED POWER SUPPLY (I): B+

O IP65-3 LH REAR AUDIO +

O IP65-4 LH REAR AUDIO -

O IP65-5 RH REAR AUDIO +

O IP65-6 RH REAR AUDIO -

I IP65-7 TELEPHONE MUTE SIGNAL

O IP65-8 SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED

S IP65-9 SCP +

S IP65-10 SCP –


O IP65-13 LH FRONT AUDIO -

O IP65-14 LH FRONT AUDIO +

O IP65-15 RH FRONT AUDIO -

O IP65-16 RH FRONT AUDIO +


I IP65-18 STEERING WHEEL SWITCHES: STEPPED RESISTANCE

O IP65-19 D2B NETWORK WAKE-UP








Fig. 15.2

COMPONENTS

Component Connector(s) Connector Description LocationANTENNA MODULE CA117 — BEHIND LH E POST TRIM

AUDIO CONTROL SWITCHES SW4 6-WAY / BLACK STEERING WHEEL




MID BASS SPEAKER – LH FRONT FL6 2-WAY / WHITE LH FRONT DOOR CASING

MID BASS SPEAKER – LH REAR BL4 2-WAY / WHITE LH REAR DOOR CASING

MID BASS SPEAKER – RH FRONT FR5 2-WAY / WHITE RH FRONT DOOR CASING

MID BASS SPEAKER – RH REAR BR4 2-WAY / WHITE RH REAR DOOR CASING

SUB WOOFER CA124 14-WAY / GREY PARCEL SHELF

TWEETER – LH FRONT FL8 2-WAY / WHITE LH FRONT DOOR CASING

TWEETER – LH REAR BL5 2-WAY / WHITE LH REAR DOOR CASING

TWEETER – RH FRONT FR8 2-WAY / WHITE RH FRONT DOOR CASING

TWEETER – RH REAR BR8 2-WAY / WHITE RH REAR DOOR CASING







CA189 2-WAY / COAXIAL / AUDIO SYSTEM ANTENNA LH LOWER A POST




GROUNDS

Ground Location

G1 TRUNK / LH REAR

G2 TRUNK / LH REAR





Audio Unit

Pin Description and CharacteristicD2 ID1-1 D2B NETWORK TRANSMIT

D2 ID1-2 D2B NETWORK RECEIVE


B+ IP65-2 IGNITION SWITCHED POWER SUPPLY (I): B+

O IP65-3 LH REAR AUDIO +

O IP65-4 LH REAR AUDIO -

O IP65-5 RH REAR AUDIO +

O IP65-6 RH REAR AUDIO -

I IP65-7 TELEPHONE MUTE SIGNAL

O IP65-8 SECURITY SYSTEM GROUND SENSING: GROUND WHEN AUDIO UNIT INSTALLED

S IP65-9 SCP +

S IP65-10 SCP –


O IP65-12 AMPLIFIER ENABLE

O IP65-13 LH FRONT AUDIO -

O IP65-14 LH FRONT AUDIO +

O IP65-15 RH FRONT AUDIO -

O IP65-16 RH FRONT AUDIO +


I IP65-18 STEERING WHEEL SWITCHES: STEPPED RESISTANCE

O IP65-19 D2B NETWORK WAKE-UP








Fig. 16.1

COMPONENTS

Component Connector(s) Connector Description LocationAUDIO UNIT ID1 2-WAY / BLACK INSTRUMENT PANEL CENTER

IP65 20-WAY / BLACKIP106 2-WAY / COAXIAL

CELLULAR PHONE CONTROL MODULE CD3 2-WAY / BLACK TRUNK LH REARPH1 32-WAY / BLACKPH3 2-WAY / COAXIALPH5 2-WAY / COAXIAL

HANDSET RECEIVER (ROW) PP1 — CENTER CONSOLE

JaguarNet GPS ANTENNA PH5 2-WAY / COAXIAL BEHIND LH REAR QUARTER TRIM PANEL

NAVIGATION CONTROL MODULE CD5 2-WAY / BLACK TRUNK LH REARNA1 26-WAY NATURALNA2 12-WAY / BLACKNA6 2-WAY / COAXIALNA7 20-WAY / BLACK


TELEMATICS DISPLAY IP70 22-WAY / BLACK CENTER CONSOLE

TELEPHONE ANTENNA, BUMPER (ROW) — — REAR BUMPER

TELEPHONE ANTENNA, JaguarNet (ROW) PH13 2-WAY / COAXIAL PARCEL SHELF







CA406 3-WAY / GREY / TELEPHONE HARNESS TO CABIN HARNESS BELOW LH REAR SEAT CUSHION



PH11 10-WAY / GREY / CELLULAR TELEPHONE LINK LEAD LH LOWER A POST

GROUNDS

Ground Location


G39 TRUNK / LH REAR



Cellular Phone Control Module

Pin Description and CharacteristicO PH1-1 PHONE BATTERY CHARGING SUPPLY

O PH1-3 PHONE ON / OFF (RESPONSE TO INCOMING AUDIO)

O PH1-4 MUTE COMMAND

— PH1-7 COMPUTER

— PH1-8 COMPUTER

PG PH1-9 POWER GROUND: GROUND

SG PH1-11 MICROPHONE SHIELD: GROUND

B+ PH1-12 BATTERY POWER SUPPLY: B+


B+ PH1-14 IGNITION SWITCHED POWER SUPPLY (I): B+

I PH1-15 JaguarNet ASSISTANCE REQUEST

O PH1-16 JaguarNet ASSISTANCE CALL INDICATOR

I PH1-17 MICROPHONE +

I PH1-18 MICROPHONE -

D PH1-20 TELEPHONE SERIAL COMMUNICATIONS DATA


I PH1-23 D2B NETWORK WAKE-UP

— PH1-24 COMPUTER

I PH1-25 POWER GROUND: GROUND

I PH1-26 TELEPHONE LOGIC GROUND: GROUND

I PH1-29 IGNITION SWITCHED POWER SUPPLY (II): B+

I PH1-30 AIRBAG DEPLOYED SIGNAL

I PH1-31 JaguarNet INFORMATION REQUEST

O PH1-32 JaguarNet INFORMATION CALL INDICATOR

D2 CD3-1 D2B NETWORK RECEIVE

D2 CD3-2 D2B NETWORK TRANSMIT







Fig. 16.2

COMPONENTS




HANDSET RECEIVER (NAS) PH9 — LH A POSTPH10 10-WAY / GREY LH A POST




TELEMATICS DISPLAY IP70 22-WAY / BLACK CENTER CONSOLE

TELEPHONE ANTENNA, BUMPER (NAS) PH4 2-WAY REAR BUMPER

TELEPHONE ANTENNA, JaguarNet (NAS) PH12 2-WAY / COAXIAL PARCEL SHELF









GROUNDS

Ground Location


G39 TRUNK / LH REAR





O PH1-2 HANDS FREE AUDIO TO PHONE



I PH1-5 MANUAL TEST DATA

I PH1-6 PHONE BATTERY VOLTAGE


SG PH1-10 ANALOG GROUND: GROUND



























Fig. 16.3

COMPONENTS

Component Connector(s) Connector Description LocationAUDIO CONTROL SWITCHES SW4 6-WAY / BLACK STEERING WHEEL



HANDSET RECEIVER (ROW) PP1 — CENTER CONSOLE





TELEPHONE ANTENNA, BUMPER (ROW) — — REAR BUMPER

TELEPHONE ANTENNA, JaguarNet (ROW) PH13 2-WAY / COAXIAL PARCEL SHELF

VOICE ACTIVATION CONTROL MODULE PH2 22-WAY / GREY TRUNK LH REAR











PH11 10-WAY / GREY / CELLULAR TELEPHONE LINK LEAD LH LOWER A POST

GROUNDS

Ground Location



G39 TRUNK / LH REAR







— PH1-7 COMPUTER

— PH1-8 COMPUTER













— PH1-24 COMPUTER









Voice Activation Control Module

Pin Description and CharacteristicI PH2-1 MICROPHONE +

SG PH2-2 MICROPHONE SHIELD

B+ PH2-6 IGNITION SWITCHED POWER SUPPLY (II) (START / RUN STATUS)

B+ PH2-8 IGNITION SWITCHED POWER SUPPLY (I)

PG PH2-11 POWER GROUND


O PH2-14 D2B NETWORK WAKE UP

B+ PH2-22 BATTERY POWER SUPPLY









Fig. 16.4

COMPONENTS




HANDSET RECEIVER (NAS) PH9 — LH A POSTPH10 10-WAY / GREY LH A POST





TELEPHONE ANTENNA, BUMPER (NAS) PH4 2-WAY REAR BUMPER

TELEPHONE ANTENNA, JaguarNet (NAS) PH12 2-WAY / COAXIAL PARCEL SHELF











GROUNDS

Ground LocationG15 PASSENGER COMPARTMENT / LH LOWER A POST

G39 TRUNK / LH REAR





O PH1-2 HANDS FREE AUDIO TO PHONE



I PH1-5 MANUAL TEST DATA

I PH1-6 PHONE BATTERY VOLTAGE


SG PH1-10 ANALOG GROUND: GROUND






































Fig. 16.5

COMPONENTS











GROUNDS


















Fig. 16.6

COMPONENTS

Component Connector(s) Connector Description LocationNAVIGATION CONTROL MODULE CD5 2-WAY / BLACK TRUNK LH REAR

NA1 26-WAY NATURALNA2 12-WAY / BLACKNA6 2-WAY / COAXIALNA7 20-WAY / BLACK

NAVIGATION GPS ANTENNA NA12 2-WAY / COAXIAL BELOW PARCEL SHELF, LH SIDE


TRAFFIC MASTER CONTROL MODULE NA15 5-WAY / GREEN TRUNK LH REAR


Connector Connector Description LocationNA24 16-WAY / GREEN / NAVIGATION HARNESS TO INSTRUMENT PANEL HARNESS BELOW INSTRUMENT PANEL LH SIDE

GROUNDS

Ground Location


G40 TRUNK / LH REAR



Fig. 16.7

COMPONENTS

Component Connector(s) Connector Description LocationNAVIGATION CONTROL MODULE CD5 2-WAY / BLACK TRUNK LH REAR

NA1 26-WAY NATURALNA2 12-WAY / BLACKNA6 2-WAY / COAXIALNA7 20-WAY / BLACK

NAVIGATION GPS ANTENNA NA12 2-WAY / COAXIAL BELOW PARCEL SHELF, LH SIDE



TELEVISION ANTENNA AND AMPLIFIER 1 NA20 2-WAY TELEVISION ANTENNA




VEHICLE INFORMATION ANTENNA AND AMPLIFIER NA11 2-WAY BEHIND RH E POST

VEHICLE INFORMATION CONTROL MODULE NA9 10-WAY / NATURAL TRUNK LH REAR

VEHICLE INFORMATION SENSOR CA222 2-WAY TOP OF INSTRUMENT PANEL LH SIDE





NA24 16-WAY / GREEN / NAVIGATION HARNESS TO INSTRUMENT PANEL HARNESS BELOW INSTRUMENT PANEL LH SIDE

NA25 8-WAY / COAXIAL / INSTRUMENT PANEL HARNESS TO NAVIGATION HARNESS BELOW CENTRAL JUNCTION FUSE BOX

GROUNDS

Ground LocationG37 PASSENGER COMPARTMENT / LH CROSS CAR BEAM

G40 TRUNK / LH REAR



Fig. 17.1

COMPONENTS

Component Connector(s) Connector Description LocationAIRBAG DEACTIVATED INDICATOR LAMP – PASSENGER IP140 3-WAY / BLACK PASSENGER AIRBAG COVER

CURTAIN AIRBAG IGNITER – DRIVER CA144 2-WAY / BLACK DRIVER SIDE E POST

CURTAIN AIRBAG IGNITER – PASSENGER CA145 2-WAY / BLACK PASSENGER SIDE E POST

DUAL AIRBAG IGNITER – DRIVER SW1 2-WAY / BLACK STEERING WHEELSW2 2-WAY / BLACK

DUAL AIRBAG IGNITER – PASSENGER IP36 2-WAY / BROWN INSTRUMENT PANEL PASSENGER SIDEIP37 2-WAY / BLACK

FRONT IMPACT SENSOR JB93 2-WAY / BLACK ADJACENT TO HOOD CATCH

SEAT BELT PRETENSIONER IGNITER – DRIVER CA65 18-WAY / BLACK DRIVER SIDE B/C POST

SEAT BELT PRETENSIONER IGNITER – PASSENGER CA70 18-WAY / BLACK PASSENGER SIDE B/C POST

SEAT BELT SWITCH – DRIVER CA65 18-WAY / BLACK DRIVER SEAT BELT

SEAT BELT SWITCH – PASSENGER CA70 18-WAY / BLACK PASSENGER SEAT BELT

SEAT POSITION SWITCH – DRIVER CA65 18-WAY / BLACK DRIVER SEAT TRACK

SEAT WEIGHT PRESSURE SENSOR – PASSENGER WS18 3-WAY UNDER PASSENGER SEAT

SEAT WEIGHT SENSING CONTROL MODULE – PASSENGER WS17 12-WAY UNDER PASSENGER SEAT

SIDE AIRBAG IGNITER – DRIVER AL1 2-WAY / BLACK DRIVER SEAT BACK

SIDE AIRBAG IGNITER – PASSENGER AD1 2-WAY / BLACK INSTRUMENT PANEL PASSENGER SIDE

SIDE IMPACT SENSOR – DRIVER CA215 2-WAY / BLACK DRIVER SIDE LOWER B/C POST

SIDE IMPACT SENSOR – DRIVER REAR CA140 2-WAY / BLACK ADJACENT TO DRIVER SIDE REAR LOWER SAFETY BELT ANCHOR

SIDE IMPACT SENSOR – PASSENGER CA216 2-WAY / BLACK DRIVER SIDE LOWER B/C POST

SIDE IMPACT SENSOR – PASSENGER REAR CA131 2-WAY / BLACK ADJACENT TO PASSENGER SIDE REAR LOWER SAFETY BELT ANCHOR


Connector Connector Description LocationCA10 22-WAY / GREY / ENGINE HARNESS TO CABIN HARNESS BELOW THE GLOVEBOX


GROUNDS

Ground Location










Fig. 18.1

COMPONENTS

Component Connector(s) Connector Description LocationPARKING AID CONTROL MODULE RB7 26-WAY / YELLOW SPARE WHEEL WELL

PARKING AID SENSOR – LH RB1 3-WAY / BLACK REAR BUMPER

PARKING AID SENSOR – LH CENTER RB2 3-WAY / BLACK REAR BUMPER

PARKING AID SENSOR – RH RB4 3-WAY / BLACK REAR BUMPER

PARKING AID SENSOR – RH CENTER RB3 3-WAY / BLACK REAR BUMPER

PARKING AID SOUNDER CA136 2-WAY / WHITE PARCEL SHELF




GROUNDS




Control Module

Pin Description and CharacteristicB+ RB7-1 IGNITION SWITCHED POWER SUPPLY: B+

PG RB7-3 POWER GROUND: GROUND

D RB7-5 SERIAL DATA LINK

I RB7-8 TRAILER CONNECTED STATUS: GROUND = TRAILER CONNECTED

I RB7-9 REVERSE LAMPS STATUS: B+ = REVERSE LAMPS ON

D RB7-10 LH CENTER SENSOR SIGNAL DATA

D RB7-11 LH SENSOR SIGNAL DATA

O RB7-14 PARKING AID SOUNDER +

O RB7-15 SENSOR POWER SUPPLY: B+

O RB7-16 SENSOR GROUND: GROUND

O RB7-17 PARKING AID SOUNDER

D RB7-23 RH CENTER SENSOR SIGNAL DATA

D RB7-24 RH SENSOR SIGNAL DATA







Fig. 19.1

COMPONENTS

Component Connector(s) Connector Description LocationCABIN ACCESSORY CONNECTOR IP24 3-WAY / BLACK BEHIND GLOVE BOX

CIGAR LIGHTER IP42 2-WAY / ORANGE ASH TRAY


HORN RELAY — — POWER DISTRIBUTION FUSE BOX R3

HORN SWITCH SW6 2-WAY / BLACK STEERING WHEEL

HORNS JB87 2-WAY / BLACK ADJACENT TO BATTERY



TRUNK ACCESSORY CONNECTOR CA146 3-WAY / BLACK TRUNK LH REAR


Connector Connector Description LocationCA36 16-WAY / GREEN / CABIN HARNESS TO ROOF HARNESS LH LOWER A POST


GROUNDS

Ground Location

G1 TRUNK / LH REAR











O IP5-14 HORN RELAY DRIVE : TO ACTIVATE, GECM SWITCHES CIRCUIT TO GROUND

I IP6-20 STEERING WHEEL HORN SWITCH: GROUND WHEN SELECTED




Fig. 20.1

COMPONENTS

Component Connector(s) Connector Description LocationANTI-LOCK BRAKING SYSTEM CONTROL MODULE JB45 42-WAY / BROWN ENGINE COMPARTMENT RH SIDE

ANTI-LOCK BRAKING / TRACTION CONTROL CONTROL MODULE JB197 42-WAY / BROWN ENGINE COMPARTMENT RH SIDE


AIR CONDITIONING CONTROL MODULE (AUTOMATIC, PANEL) AC1 26-WAY / YELLOW BEHIND CLIMATE CONTROL PANELIP101 26-WAY / YELLOW

AIR CONDITIONING CONTROL MODULE (REMOTE) AC1 26-WAY / YELLOW RH SIDE OF AIR DISTRIBUTION UNITIP101 26-WAY / YELLOW

DATA LINK CONNECTOR IP22 16-WAY / BLACK BELOW STEERING COLUMN






STEERING ANGLE SENSOR IP19 4-WAY / BLACK STEERING COLUMN


YAW RATE SENSOR IP20 4-WAY / BLACK BEHIND CENTER CONSOLE





GROUNDS

Ground LocationG36 PASSENGER COMPARTMENT / RH CROSS CAR BEAM




Fig. 20.2

COMPONENTS



DATA LINK CONNECTOR IP22 16-WAY / BLACK BELOW STEERING COLUMN







PARKING AID CONTROL MODULE RB7 26-WAY / YELLOW SPARE WHEEL WELL












GROUNDS

Ground Location





Fig. 20.3

COMPONENTS












CD1 2-WAY / BLACK / FIBER OPTIC CONNECTOR LH LOWER A POST

CD6 2-WAY / BLACK / FIBER OPTIC CONNECTOR TRUNK LH REAR



Fig. 20.4

COMPONENTS









CD1 2-WAY / BLACK / FIBER OPTIC CONNECTOR LH LOWER A POST

CD6 2-WAY / BLACK / FIBER OPTIC CONNECTOR TRUNK LH REAR

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

IP2-1

B

JB186-1

G12A

JB186-2

G16AS

B G12B

G13AS

W

UY

BB 7 02.1

JBS42W

JB130-5

W

F27 10AJB35-49 JB35-50

F28 15A JB35-52JB35-51

JBS41

UY

UY

R

GOIP18-1

IP18-4

I

II

III

4JB3-1

R R

JB180

JB160

B 04.1

JB182

G12A

G12B

8

GUIPS45

GO

IPS44

GUIP3-1

F67 5A

23II

6

OYJBS29

OY

OY

1

JB184

UY

W

F4 30A

JB35-6 JB35-5F2 50A

JB35-16 JB35-15

R

R

F6 30A

JB35-10 JB35-9

F7 50A

JB35-14 JB35-13

R

R

JB52-1

JB52-2

JB50-4

JB50-1

5

R

R

R

R

01.2

06.1 06.2

01.4

06.1 06.2

9

10

11

12

2

13

01.201.2

01.6

06.1 06.2

06.1 06.2

06.1 06.2

IP132-1

IP132-3

IP132-2

OY

3 03.1OG

F18 20AJB35-32 JB35-3103.4

02.2

04.2

Main Power Distribution Main Power Distribution Fig. 01.1

All Vehicles

ENGINEGROUND

CHASSISGROUND

BATTERY

TIMER

TRANSIT ISOLATIONRELAY

BATTERY-ve POST

NOTE: JBS41 – Automatic Transmission vehicles only.

BAT

TER

Y P

OW

ER B

US

2

BA

TTER

Y P

OW

ER B

US

1


KEY-IN

IGNITION SWITCH

INERTIA SWITCH

STARTER


BA

TTER

Y P

OW

ER B

US


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

CA25-4

6

5

F22 20AJB35-39 JB35-40

NR

F5 30AJB35-12 JB35-11

OY

F26 15AJB35-47 JB35-48

O

F25 15AJB35-45 JB35-46

OY

F24 15AJB35-43 JB35-44

R

F3 60AJB35-8 JB35-7

R

F21 15AJB35-37 JB35-38

RU

F23 10AJB35-41 JB35-42

GO

F1 20AJB35-4 JB35-3

GB

F20 5AJB35-35 JB35-36

NR

F32 5AJB34-84 JB34-85

N

F30 30AJB34-80 JB34-81

B

F8 80AJB34-72 JB34-73

OY

F60 20A

OY

F29 30AJB34-78 JB34-79

UF10 20AJB34-76 JB34-77

WU

F31 10AJB34-82 JB34-83

WG

F9 50AJB34-74 JB34-75

OY

F61 20A

19

15

23

22

21

14

18

20

17

24

JB188-1

NR

JB3-5

RJB3-12

GB

JB1-31

NR

JB3-14

NNN

CA169-3

28N

IPS42

32

27

26

25NG

01.6

13.1

02.1

01.6

01.3

05.2

12.3

08.1

12.1

05.1

08.1

03.2

08.1

16.6

03.2

19.1

08.4

03.1

CA78-7

CA407-9

NR

14.1

OYIP4-1

19.1

08.1

01.5

F70 30A

F71 15A

CA78-5

CA76-10 CAS72NR NR

15.1

14.3

11.1

OY

F72 15A

F73 15A

F74 15A

IP1-6

CA78-2 CA36-14

O O

JB129-5

U

11.1

N

F75 7.5A CA76-11

NW

16.3

20.1

16.6

CA15-8

OY OYCA78-6

CA30-4

OY OYCA78-12

CA20-8

OY OYCA78-11

CA70-15

OY

15.2

02.1

NRCA414-1

NR

PHS1

NR

NR

NR

IP1-14

CA414-3

CA78-1

CAS60

OY OY

OY

15.1

15.1

CA78-3

NR

O

IP1-9

CA76-12

UIP2-15

U

10.2

12.3

06.1

OY

OY OY

NW

OY

N

NR

O

U

WR

O

OY

R

CA65-15

OG

F66 30A CA77-1

OG

OG

OG 11.1

LSS2

(1)

11.3

11.1

OG

OG(2)

OY

OY

OY

11.1

RSS2

(3) 11.1

11.3OY

OY(4)

(7)

(5)

(6) 16.6CA414-3

OY OY

OY

01.535

34

33

05.205.1

06.2

08.2

08.2

07.1

08.2

08.3 08.4 08.5

08.5

08.2

OY

16.1

16.1

OG

09.2

07.2

11.2 11.3

11.2

11.2 11.3

11.2

12.2 13.1

08.3 13.1

12.3 13.2 14.1 14.2

08.4 13.2

14.3

13.2

14.2

14.1 14.2

14.1 14.2

14.1 14.2

12.3

20.2

15.2

15.2

15.2

16.7

16.7

16.4

16.2 16.3 16.4

16.2 16.3 16.4

16.7

16.7

19.1

19.1

F68 15A

16NR

NR

JBS63

36

37

38

41

40

39

42

64

43

63

62

47

46

48

49

45

54

50

53

55

57

56

60

59

58

44

52

51

61

04.1

19.1

08.7

01.5 08.5 09.1 12.3

16.5

12.1 12.2

13

29

3031

08.6

08.6

08.6

05.3

05.3

03.4

03.4

02.2

03.3

02.2

04.2

Battery Power Distribution Battery Power Distribution Fig. 01.2

BA

TTER

Y P

OW

ER B

US

1B

ATT

ERY

PO

WER

BU

S 2

NOTE: JBS63 – Automatic Transmissionvehicles only.


BAT

TER

Y P

OW

ER B

US


NOTATION:

(1) Single Function LH Seat(2) Powered LH Seat with Heater(3) Single Function RH Seat(4) Powered RH Seat with Heater(5) CD Autochanger and Navigation(6) Navigation Only(7) CD Only

NOTE: CAS72 – VICS only.

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Ignition Switched Power Distribution: I (Accessory) Ignition Switched Power Distribution: I (Accessory) Fig. 01.3

JBS55

NAS2

NGNG

NGNG CA240-9

IPS33

CA170-16

CAS39

CAS27

RIP18-6IP18-4

I

II

III

4 GWIPS53

GW GWJB129-18

F69 7.5A

IP4-6

YU

YGIP4-5

IP2-14

3I

20 WR

B B

G14AL

NG

1I

2I

19.1

08.4

GW07.1

YG

YG

YG YG

YU

CA230-1

16.6

15.1 15.2

18.1

16.1

16.3

16.7

YG YG

YG YGYG

YGCA129-1

YG YG

YGYG

YG

CA414-02

CA241-12

PHS4CA407-10

08.5

3

1

5

2

R4 4

15.1 15.2

16.7

16.6 16.7

16.4 16.5

16.2 16.3 16.4

19.1

9I

10I

11I

8I

4I

5I

6I

7I

08.6

KEY-IN

IGNITION SWITCH(1)

ACCESSORYPOWER RELAY



NOTE: CAS39 – VICS, Navigation, and/orReverse Parking Aid only.

NOTE: NAS2 – VICS only.

NOTE: PHS4 – Voice only.

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Ignition Switched Power Distribution: II (Run) Ignition Switched Power Distribution: II (Run) Fig. 01.4

All Vehicles

-ve BUS

RW

CA170-14

N

JB130-20

NRJB2-2 (2.5, 3.0 L)JB196-2 (2.0 L)

WR

Y

CA65-9

W

RW

CA10-11

N

IPS63

GB

GR

CA407-8

CA407-11

JB130-5

Y

WR

GW

OY

R

GOIP18-1

IP18-4

I

II

III

4

IP132-1

IP132-3

GUIP132-2IPS45 GO

IPS44

GUIP3-1

GO GO GOJB129-19 JB1-32

03.1

02.1JB3-2

GO GO

GU GU GUJB129-12 JB1-15

03.1

GO

F84 5A IP1-8

F95 10A JB51-8

F96 7.5A JB51-10

17.1

05.1

02.1

17.1

17.1

03.2

08.3

02.1

10.1

03.2

02.1

04.1

04.1

03.2

06.1

06.1

20.1

16.3

11.3

16.1

01.1

12.3

05.1

08.1

19.1

GR

GR

GR

9

F78 5A

IP4-9

F77 7.5A IP2-6

F67 5A IP2-1

F90 7.5A CA76-16

F68 15A IP4-1

F91 10A CA78-14

F62 7.5A IP1-7

CA76-9

GJB3-8

G

GW GW

JB51-11

JB51-1

WR

WJBS42

W

W

W

W

CA170-13

NRPAS3 NR

NRNR

03.2

03.1

CAS70

F92 10A

IP2-12

CA76-15

WUCA78-13 CA36-12

RW

JBS21JB1-30

JB2-14 (2.5, 3.0 L)JB196-5 (2.0 L)

RW

RW RW

O

F83 15A IP4-14 JB3-6

O

NG

F81 20A CA78-9

GB

IP1-10

NG

GB

GB

F82 10A JB51-13

GRJB51-14 JB1-13

JB1-2

GB

GR

GRIP2-8

GR

JB51-15

WR

F94 20A

IP4-10

WR

CA75-4

08.7

08.3

10.1

10.2 14.2

14.3

CA78-10

F80 7.5A CA75-5

WRCA230-14

WRIPS64

WR

WR

WR

WR

13.1

GUCA78-15

FRS4

GU

CAS20

WU

WU** BR

OY

14.1 14.2

10.2

CA30-5

GU

GUGU

GU

FLS3

GW

CAS71CA25-5

GW

GWGW

GW

G15AR*G15AL

30II

29II

BCA76-5

BCAS10

-ve BUS

04.1

04.1

05.2

06.2

WR 06.2

04.1

05.1 05.2

05.2

07.1

08.3

08.3

08.4 08.5

08.3 08.4 08.5

08.2 08.7

IP1-1

IP1-4 CA1-3 CA70-3

GR GR

F93 30A

13.1

13.1

13.1

GR

GR

GR

JBS25GR

GW

JB51-9

IP2-7

12.3

11.3

14.2

14.1 14.2

14.1

14.2

14.1

13.2

13.2

13.2

20.2

16.4

16.2 16.3 16.4

16.5

W 04.124II

12II

28II

27II

26II

25II

23II

22II

21II

15II

14II

13II

18II

17II

16II

19II

20II

CA240-2

GBGB GB

GB GBCA70-9

3

2

5

1

R18

13.2

(LHD)

(RHD)CA20-9

GU 14.1

GU

(RHD)

(LHD)CA15-9

GW

GW

GR 12.1 12.2

08.6

08.6

03.3

03.3

02.2

02.2

03.4

03.4

02.2

02.2

03.4

03.3 03.4

03.4CA10-7

IPS70

13.2GW 13.1

JB3-6

GW 13.2GW 13.1

04.2

04.2

04.2

04.2

04.2

04.2

05.3

05.3

05.3

63II

62II

59II

60II

61II

57II

56II

55II

54II

58II

53II

52II

51II

47II

42II

43II

41II

31II

39II

40II

38II

37II

36II

35II

34II

32II

50II

44II

49II

45II

46II

48II

33II

KEY-IN

IGNITION SWITCH(II)

INERTIA SWITCH

UNLOCK DOORS

INTERNAL POWER SUPPLYCONTINUED FROM THE RIGHT

NOTE: The Central Junction Fuse Boxincorporates a negative (ground)bus bar. Circuits completed toground via the bus are identifiedby the code “-ve BUS”.

CENTRAL JUNCTION FUSE BOX(CONTINUES)

* NOTE: G15AR – early production vehicles.

CENTRAL JUNCTION FUSE BOX(CONTINUED)

INTERNAL POWER SUPPLYCONTINUES TO THE LEFT

IGNITIONRELAY


NOTE: JBS21 – Manual Transmission only.

NOTE: CAS20 – Rear PowerWindows only.

NOTE: CAS71 – Rear PowerWindows only.

** NOTE: WU – early production vehicles.

NOTE: PAS3 – Cruise Control only.

NOTE: CA10-7 – 2.0L only.

NOTE: IPS70 – Later Production vehicles only.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Ignition Switched Power Distribution: Battery Saver Ignition Switched Power Distribution: Battery Saver Fig. 01.5

B

IPS12OY

OY

RCS3OY

OYCAS30

OY

CA21-4

CA16-4

OY

IP4-3IP5-2035

34

F99 10A CA76-6

CA76-14

IP4-11

B

OY

OY

OY

CA36-16

OY

OY

OY

OY

OYOY

OY

06.1 06.2

09.1

O

23 OJB172-5

09.1

09.1

09.1

09.1

09.1

09.1

09.1

3

1

5

2

R21 4

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

09.1

B

P

19.1

WR 06.2

B74

B65

B64

B69

B68

B67

B66

B73

B72

B71

B70

BATTERYSAVER

CONTROL


BATTERY SAVERRELAY

NOTE:

“Battery Saver” provides automatic switch-off of the Courtesy Lamps after 10 minutes andautomatic switch-off of the Demand Lighting and Audible Warning after 30 minutes.

GECM timers are started when the ignition key has been switched to the I (accessory)or 0 (off) position. When the timers expire at 10 and 30 minutes, the feature(s) is / are switched off.

When one of the following actions is detected, all features are enabled and thebattery saver timer is reset:

• the ignition is switched to II (run) or III (start).• any door or trunk lid becomes ajar or is opened.• any unlock is activated.

Battery saver is also active when GECM diagnostic mode is entered.


NOTE: CAS30 – Door Courtesy Lamps only.

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

NR

B B

NR

WU

JBS47

WGWG

JB1-33 ILS1

WR

WG

JB1-9 ENS4

WG

WG

JB1-35 ENS11

JBS46

WG

WR

WG

5

WU

F31 10AJB34-82 JB34-83

WG

F9 50AJB34-74 JB34-7526

03.1JB34-90 JB34-91

31 WU

WG

JB1-41

F41 10AJB34-102 JB34-103

WU

F38 30AJB34-96 JB34-97

WU

F42 30AJB34-104 JB34-105

WU

NGF39 5AJB34-98 JB34-99

WU

WG

F37 15AJB34-94 JB34-95

WU

GU

F36 10AJB34-92 JB34-93

WU

EN4-6

NR GR

GW

GY

GU

GR

GB

GN

03.2

03.2

03.2

03.2

03.2

03.2

03.1

03.1

03.1

03.1

03.1

03.1

JB1-1

WR

WR

ENS13WG

WR

NGJB1-11 ENS27

NGNG

NG

WGJB187-2

03.1

03.1

04.1

03.2

WG

WG

WG

JBS44

GU

GU

GU

GU

GU

GU 13.1

03.2

03.1

03.1

03.1

03.1GU

GU

GU

GUCA5-10

JB1-5

CA10-2

GU

WG

WG

GU

GU

GU

3

1

5

2

R7

13.2

03.3

03.4

03.3

03.4

03.4

03.4

03.4

03.4

03.3

03.3

03.3

03.3

03.3

03.4

03.3

03.3

03.3

03.3

03.4

03.4

E94

E95

E93

E92

E91

E90

E96

E75

E79

E78

E77

E76

E81

E80

E85

E84

E83

E82

E88

E87

E86

E89

Engine Management System Switched Power Distribution Engine Management System Switched Power Distribution Fig. 01.6

BA

TTER

Y P

OW

ER B

US

2

D2(EMS DIODE)

EMS CONTROLRELAY

ECM CONTROL(CIRCUIT CONTINUED)


All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Battery; Starter; Generator: 2.5L & 3.0L Battery; Starter; Generator: 2.5L & 3.0L Fig. 02.1

R

B

YIP18-7

IP18-5

IP18-4

I

II

III

4

IP11-7

O

OIP10-4IP15-4

S

SIP10-23

IP10-2220.2

20.2U

Y

S

SIP5-18

IP5-1920.2

20.2U

Y

WGIP10-3IP15-3

IP10-5IP15-2

IP15-1

G

IP11-8G37AL

(G36BL)

D

D

BIP6-8

I

B

GIP10-6

BJB160

EN16-123

EN16-124

EN16-79

EN16-53

Y

G

ST2

B

B

EN49-2

EN49-1

EN49-4

GR

RG

U

ST4

Y

I

I

41II

EN16-65 EN49-3

OGO

20.1

20.1

C

CIP10-17

IP10-1820.1

20.1Y

GC

C

JB156-6

JB156-10

NB

39II

JB129-11 JBS34

JB2-16

GO BRW(NAS)

(ROW)

(NAS)

(ROW)

Y Y

I

I

P, N

EN16-31

Y

B

EN16-41

GO O

Y

GO

OY

Y

28

JB1-40

GO

Y

JB1-34

(AUTO)

(MAN)W

U

PA5-2PA5-1

EN16-6

BG12A

G16AS

BG12B

G13AS

7

JB145-5

JB2-12

14II

IP11-11

GR

61

15II

B

3

1

R10

2

5

4

N

P

EN700

JB1-42

Y

YB

B

B

P

YEN700-1ST3

(2)

(1)

BATTERY

KEY-IN





SECURITY


PASSIVEANTI-THEFT

SYSTEM

PATS POWER

PATS GROUND

INSTRUMENT CLUSTER

O.K. TO START

O.K. TO START

STARTERRELAY


STARTER MOTOR

GENERATOR WARNING


GENERATOR

STARTENGINE

CRANKENGINEREQUEST


FIELD

CHARGE

GENERATORLOAD


NOTATION:

(1) Early production vehicles(2) Later production vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Battery; Starter; Generator: 2.0L Battery; Starter; Generator: 2.0L Fig. 02.2

R

B

YIP18-7

IP18-5

IP18-4

I

II

III

4

IP11-7

O

OIP10-4IP15-4

S

SIP10-23

IP10-2220.2

20.2U

Y

S

SIP5-18

IP5-1920.2

20.2U

Y

WGIP10-3IP15-3

IP10-5IP15-2

IP15-1

G

IP11-8G37AL

(G36BL)

D

D

BIP6-8

I

B

GIP10-6

BJB160

EN65-088

EN65-089

EN65-035

EN65-043

Y

G

ST2

EN700

B

B

EN49-2

EN49-1

EN49-4

GR

RG

U

ST4

Y

I

I

41II

EN65-008 EN49-3

OGO

20.1

20.1

C

CIP10-17

IP10-1820.1

20.1Y

GC

C

JB156-6

JB156-10

NB

39II

JB129-11 JBS34

JB196-4

GO B

Y Y

I

I

P, N

EN65-085

Y

B

EN65-068

GO O

Y

GO

OY

Y

28

JB1-40

GO

Y

JB1-34

(AUTO)

(MAN)

EN65-006

BG12A

G16AS

BG12B

G13AS

7

JB145-5

JB196-6

14II

IP11-11

GR

61

15II

B

3

1

R10

2

5

4

N

P

JB1-42

Y

YB

B

B

P

U

BATTERY

KEY-IN




SECURITY


PASSIVEANTI-THEFT

SYSTEM

PATS POWER

PATS GROUND

INSTRUMENT CLUSTER

O.K. TO START

O.K. TO START

STARTERRELAY


STARTER MOTOR

GENERATOR WARNING

STARTENGINE

CRANKENGINEREQUEST



FIELD

CHARGE

GENERATORLOAD

GENERATOR

2.0L Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Engine Management: 2.5L & 3.0L – Part 1 Engine Management: 2.5L & 3.0L – Part 1 Fig. 03.1

EN16-053

EN16-006

EN16-007

EN16-010

RG

GU

GO

Y

ENS1 ENS22

G8AL G8AR

B

B

B

B

B

BBB

B

B

BB

EN16-116

EN16-111

EN16-091

EN16-082

EN16-081

EN16-054

EN16-030

EN16-029

EN16-018

EN16-017

EN16-005

EN16-004

RWEN16-109

GEN16-110

OYEN16-038

OYEN16-039

UYEN16-066

OEN16-067

PEN16-075

YEN16-076

BGEN16-043

YEN16-013

BGEN16-020

RGEN16-104

UEN16-050

UEN16-073

YEN16-078

UYEN16-070

BGEN16-019

OEN16-071

BWEN16-046

BWEN16-045

GWEN16-044

GOEN16-055

PEN16-108

YEN16-107

PEN16-084

YEN16-083

BREN16-130

RUEN16-002

RUEN16-001

EN16-123

G

EN16-124

Y

EN16-105

W

EN16-134

RW

EN16-052

GR O

JB1-38

JB1-39

RW

GR

3 OG

GU

C

C

D

20.1

20.1

20.2

EN16-031

EN16-065

EN16-079

EN16-041

B

GO

U

OG

02.1

13II

I

I

O

I

I

02.1

02.1

02.1

02.1

I02.1

EN16-022

NR32

EN23 -1

EN37 EN32-3 -4 -2-1 -3 -4 -2-1

EN6 -1 -3 -2EN12-1

EN18 -2 -1-5-4

υ

2/11/1IATS

υ

EN25 -1 -2

υ

EN14 EN9-4 -3 -2-1 -4 -3 -2-1

λ

2/2

λ

1/2

U U

E81

E83

E82

E84

Y P RU

WG

Y P GO

WR

N W U WG

N W UY

WR

GW

BW

O BG

NEN16-129

UEN16-092

NEN16-128

GOEN16-056

UYEN16-093

I

I

I

I

O

O

O

O

O

OEN16-040

B O01.6

EN43-1

EN33-1

21

Y P O B G N W N

EN12-2

EN43-2

EN33-2

-2

NEN16-098

NEN16-069

GEN16-068

BGEN16-100

BEN16-095

OEN16-094

PEN16-036

YEN16-037

–

+

O

GU

ENS6

E93

I

I

IL7 -3 -2 -1

υ

FT5 -2 -1

TP1

EN10-2

EN10-1EN13 -3-1 -2 -4

TP2

REN16-102

YEN16-103

OYEN16-012

BWEN16-127

UY

BG

Y BG

WG

WG

YG

WU

NU

IL8 -1 -2 FT1 -2 -1-3EN8 -2 -1 -4

RG

OY

BG

OY

BW

BG

I

I

ENS7

ILS2

EN4-11

BG

BG

EN4-12

EN4-4

U OY

I

BGJBS20

BG

BG

BG

JB2-8

BG

BG

JBS45JB1-18

OY OY

JB1-17

JB2-7

OY

OY

EN4-10

U

I

CA5-4

CA10-18

JB1-14

RG

RG

I

CA5-6

CA10-13

CA5-5

CA10-19

OY

OY

I

APP1

-4-6 -1-5

APP2

PA1 -2 -3

YRBG

Y

JB2-6

JB2-5

JB1-8

JB1-7

RYI

I

ENS15

I

I

I

I

WJB1-6

WJB2-4

JB2-15JB1-12

JB2-13JB1-3

YBG

P Y R G

REN16-106

GEN16-080O

O

I

I

W W

JB170 -2 -1EN42 -2 -1EN61 -2 -1

21

RW G

UY

GU

O GU

OY

BG

BG

BG

O

O

E92

E91

EN998 -2 -1EN999 -2 -1

21

NG

NG

OY

OY

E86

E85

O

O

O

OJB1-29

JB1-10

OCA170-5

O

CA5-9

I

EN16-024

WGEN16-023

WG

CA75

-7-6CA10-20JB1-23 JBS4

GOEN16-008I

PA3 -1 -3

57II

GW

NR

JB2-1

CA170-15

GO GO GO GW GW

E94

12II

I

I

3

1

5

2

R11 4

E89

E90

ENS3

ENS2

ENS10

BRBR BR

BR

BGBGENS26

BG BGBG BG

ENS5

BRD

ENS47

BB B

B

B

B

B

P

P

HO2 SENSORSUPSTREAM

HO2 SENSORSDOWNSTREAM CKP

SENSORCMP

SENSORSKNOCK

SENSORMAF

SENSORECT

SENSOREOT

SENSORIP

SENSOREFT

SENSORMAP

SENSORFTP

SENSOR*

VIA INERTIA SWITCH

ENGINE CRANK

EMS CONTROL RELAY(CIRCUIT CONTINUED)

GENERATOR: CHARGE

GENERATOR: FIELD

GENERATOR: LOAD

STARTER RELAY DRIVE

PARK; NEUTRAL

THROTTLE MOTORRELAY


ENGINE CONTROLMODULE

(CONTINUED Fig. 03.2)

VVTSOLENOID VALVES

IMTSOLENOID VALVES(1 TOP; 2 BOTTOM)

EVAPCANISTER

PURGE VALVE

EVAPCANISTER

CLOSE VALVE*

CENTRALJUNCTIONFUSE BOX

NOTES:

* EVAP Canister Close Valve and Fuel TankPressure Sensor – NAS vehicles only.

Shielding shown as dashed lines are braidedwires.

BRAKEON / OFFSWITCH

TP SENSOR

THROTTLEMOTOR

THROTTLE BODY

APP SENSOR


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Engine Management: 2.5L & 3.0L – Part 2 Engine Management: 2.5L & 3.0L – Part 2 Fig. 03.2

B

YREN16-047

YGEN16-048

WEN16-025

WUEN16-051

NEN16-027

BGEN16-034

WGEN16-033

UEN16-009

BGEN16-113

BOEN16-114

BGEN16-115

BWEN16-119

GWEN16-088

GUEN16-087

BOEN16-118

BWEN16-120

YGEN16-131

BGEN16-019

OYEN16-012

WUEN16-121

GREN16-063

YGEN16-132

GWEN16-062

GUEN16-061

GREN16-089

IL1 -1 -2 IL2 -1 -2 IL3 -1 -2 IL4 -1 -2 IL5 -1 -2 IL6 -1 -2

NW

GW

N GY

NR

GU

NU

GR

NG

GB

NY

GN

1 3 5 2 4 6

EN4-1

EN4-7

EN4-2

EN4-8

EN4-3

EN4-9

BG

BO

BG

BW

BW

BO

1

EN51 -4 -2 -3 -1

3

EN52 -4 -2 -3 -1

5

EN53 -4 -2 -3 -1

2

EN54 -4 -2 -3 -1

4

EN55 -4 -2 -3 -1

6

EN56 -4 -2 -3 -1

G8ALENS17 ENS16

GU

YG

B RW

GW

YG

B RW

GR

YG

B RW

GU

YG

B RW

GW

YG

B RW

GR

YG

B RW

JB106 -3 -2 -1 PA2 -1 -2

56II

U NR

PA4 -3 -1

38II

W RW

ENS7

JBS45

OY

OY

OY

ENS6

JB1-19

JBS20

JB1-18

JB1-17

BG

WU

BG

BG

WU

I

O

O

O

O

O

O

O

O

O

O

O

O

I

I

JB2-10

JB1-28

JB2-11

JB1-4

U WG

OY

BG

U

WG

I

I

RG

BG

RU

GU

JB1-37

O

RGEN30-2

B

G17AS

EN30-1

JB1-36

1κ Ω SW4-12.2κ Ω 510 Ω 300 Ω 180 Ω 120 Ω

YR

YGSW4-3SW5-2

SW5-4

YR

BSWS1

B

YR

YG

YR

YG

I

JB145-7

WG

WU

OG

OY

B

25

JB187-1

JB188-2

B

G11AS

I

O

O

GC2-A GC2-B

E87

R

G

O

O

GC1-B GC1-A

WUWUO

BG

E95

21

CA105-9

NG

CA105-1

N

CA105-10

R

CA105-3

Y

CA105-2

B

G35AS

I

O

O

FT2-2

N

N

58II

CA170-2JB1-27

CA105-7

WW

W

CA10-15JB145-1O

R

Y

O

I

JB129-13

JB1-25

JB129-14

JB1-24

IP34-6

IP34-8

B

ENS18

BBBBB

ENS19

RW

RWRWRWRWRWRW

CA5-8

CA5-7

E76

E75

E80

E79

E78

E77

5

2

R6

1

3

4

37II

RW

B

EN94 -1 -2

CA105-5

BRD

FT2-4

KB

B

W

BGEN16-133

BG

JB1-26

BGCA170-1

BG BGBRD

BRD

BRD BGCA105-4

PWM1-3

PWM1-2

NG

BG

2

4

6

1

3

5

B

P

P

B

B

FUEL INJECTORS IGNITION MODULES AND COILS


(CONTINUED FROM Fig. 03.1)

NOTE: ECM power supplies and grounds shown on Fig. 03.1.

ON RESUME SET + SET - OFFCANCEL

SPEED CONTROL SWITCHES

STEERING WHEEL

CASSETTE

CASSETTE

AIR CONDITIONINGCOMPRESSOR CLUTCH

RELAY

IGNITIONCAPACITOR POWER DISTRIBUTION FUSE BOX

AIR CONDITIONINGPRESSURE SENSOR

BRAKECANCELSWITCH

CLUTCHCANCEL

SWITCH*

* NOTE: Clutch Cancel Switch –Manual Transmission vehicles only.


LH COOLING FAN

RH COOLING FAN

COOLING FANMODULE


FUEL PUMP

FUEL TANK

FUEL PUMPMODULE

FRONT OFENGINE

CYLINDER NUMBERING

FANS

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Engine Management: 2.0L – Part 1 Engine Management: 2.0L – Part 1 Fig. 03.3

EN65-043

EN65-006

EN65-063

EN65-036

RG

GU

GO

Y

ENS1 ENS22

G8AL G8AR

B

B

B

B

B

BBB

B

BB

EN65-091

EN65-064

EN65-102

EN65-078

EN65-052

EN65-048

EN65-075

EN65-005

EN65-004

EN65-019

EN65-018

RWEN65-096

GEN65-095

OYEN65-071

OYEN65-070

UYEN65-074

NEN65-027

WEN65-028

YEN65-079

UYEN65-080

BGEN65-003

OEN65-081

BWEN65-031

BWEN65-029

GWEN65-030

GOEN65-076

PEN65-025

YEN65-026

PEN65-050

YEN65-051

BREN65-055

RUEN65-104

RUEN65-077

EN65-088

G

EN65-089

Y

EN65-039

W

C

C

D

20.1

20.1

20.2

EN65-085

EN65-008

EN65-035

EN65-068

B

GO

U

OG

02.2

13II

I

I

O

I

I

02.2

02.2

02.2

02.2

I02.2

EN65-021

NR32

EN23 -1

EN37 EN32-3 -4 -2-1 -3 -4 -2-1

EN6 -1 -3 -2EN12-1

EN18 -2 -1-5-4

υ

2/11/1IATS

υ

EN25 -1 -2

υ

EN14 EN9-4 -3 -2-1 -4 -3 -2-1

λ

2/2

λ

1/2

U U

E81

E83

E82

E84

Y P RU

WG

Y P GO

WR

N W U WG

N W UY

WR

GW

BW

O BG

NEN65-054

UEN65-047

NEN65-053

GOEN65-103

UYEN65-046

I

I

I

I

O

O

O

O

O

OEN65-069

B O01.6

EN43-1

EN33-1

21

Y P O B G N W N

EN12-2

EN43-2

EN33-2

-2

NEN65-037

NEN65-087

GEN65-086

BGEN65-038

BEN65-060

OEN65-059

PEN65-061

YEN65-062

–

+

O

GU

ENS6

E93

I

I

EN87-2

EN87-1

EN88-1

OYEN65-011

BWEN65-001

UY

BG

Y BG

EN8 -2 -1 -4

OY

BW

BG

I

I

ENS7

BG

OY

I

ENS15

I

I

I

I

N R G

REN65-098

GEN65-097O

O

I

JB170 -2 -1EN42 -2 -1EN61 -2 -1

21

RW G

UY

GUBG

BG

O

O

E91

EN998 -2 -1EN999 -2 -1

21

NG

NG

OY

OY

E86

E85

O

O

OJB1-10

I

EN65-023

WGEN65-022

WG

CA75

-7-6CA10-20JB1-23 JBS4

GOEN65-034I

PA3 -1 -3

57II

GW

NR

JB196-1

CA170-15

GO GO GO GW GW

12II

I

I

E89

E90

ENS3

ENS2

ENS10

BRBR BR

BR BG BGBG BG

ENS5

BRD

ENS47

BB B

B

B

B

P

P

EN88-2

EN88-3

HO2 SENSORSUPSTREAM

HO2 SENSORSDOWNSTREAM CKP

SENSORCMP

SENSORSKNOCK

SENSORMAF

SENSORECT

SENSOREOT

SENSORMAP

SENSOR

VIA INERTIA SWITCH

ENGINE CRANK

EMS CONTROL RELAY(CIRCUIT CONTINUED)

GENERATOR: CHARGE

GENERATOR: FIELD

GENERATOR: LOAD

STARTER RELAY DRIVE

PARK; NEUTRAL


(CONTINUED Fig. 03.4)

VVTSOLENOID VALVES

IMTSOLENOID VALVES(1 TOP; 2 BOTTOM)

EVAPCANISTER

PURGE VALVE


NOTE:

Shielding shown as dashed linesare braided wires.

BRAKEON / OFFSWITCH

TP SENSOR IDLE SPEEDCONTROL VALVE

2.0L Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

B

GEN65-017

GUEN65-057

WUEN65-044

GREN65-099

BGEN65-020

WGEN65-084

UEN65-007

BGEN65-067

BOEN65-066

BGEN65-065

BWEN65-093

GWEN65-015

GUEN65-014

BOEN65-094

BWEN65-092

YGEN65-012

BGEN65-003

OYEN65-011

WUEN65-002

GREN65-042

YGEN65-013

GWEN65-041

GUEN65-040

GREN65-016

IL1 -1 -2 IL2 -1 -2 IL3 -1 -2 IL4 -1 -2 IL5 -1 -2 IL6 -1 -2

NW

GW

N GY

NR

GU

NU

GR

NG

GB

NY

GN

1 3 5 2 4 6

EN4-1

EN4-7

EN4-2

EN4-8

EN4-3

EN4-9

BG

BO

BG

BW

BW

BO

1

EN51 -4 -2 -3 -1

3

EN52 -4 -2 -3 -1

5

EN53 -4 -2 -3 -1

2

EN54 -4 -2 -3 -1

4

EN55 -4 -2 -3 -1

6

EN56 -4 -2 -3 -1

G8ALENS17 ENS16

GU

YG

B RW

GW

YG

B RW

GR

YG

B RW

GU

YG

B RW

GW

YG

B RW

GR

YG

B RW

JB106 -3 -2 -1PA2 -1 -2

56II

U NR

PA4 -3 -1

38II

W RW

ENS7

OY

OY

ENS6

JB1-19

JB1-18

JB1-17

BG

WU

BG

WU

I

O

O

O

O

O

O

O

O

O

O

O

O

I

I

JB196-10

JB1-28

JB196-3

JB1-4

OY

BG

U

WG

I

I

RG

BG

RU

GU

JB1-37

O

RGEN30-2

B

G17AS

EN30-1

JB1-36

1κ Ω SW4-12.2κ Ω 510 Ω 300 Ω 180 Ω 120 Ω

YR

YGSW4-3SW5-2

SW5-4

YR

BSWS1

B

I

JB145-7

WG

WU

OG

OY

B

25

JB187-1

JB188-2

B

G11AS

I

O

O

GC2-A GC2-B

E87

R

G

O

O

GC1-B GC1-A

WUWUO

BG

E95

21

G35AS

CA415-1

JB1-39

GO

B

O

JB129-13

JB161-A

JB129-14

JB161-B

IP34-6

IP34-8

B

ENS18

BBBBB

ENS19

RW

RWRWRWRWRWRW

CA170-1

E76

E75

E80

E79

E78

E77

5

2

R6

1

3

4

37II

RW

B

EN94 -1 -2

CA415-5

PWM1-3

PWM1-2

NG

2

4

6

1

3

5

P

B

B

GO

GR

OG

NG

3

59II

5

2

R11

1

3

4

JBS50

JBS51

U

WG

CA75

-7-6CA10-20JB1-23 JBS4

GOEN65-034I

PA3 -1 -3

57II

GW

NR

JB196-1

GO GO GO GW

GW

CA170-15

U

WG

GWEN65-056I

YR

YG

JB161-E

BJBS55

YR

YG

B

JB161-D

JB161-C

JB161-G

GO

UJB161-C

(AUTO)

I

I

I

I

I

I

B

O

O

JB161-K

JB161-J

JB161-H

JB161-F

G

GU

GW

GUE

94

JB145-6

JB1-38

JB1-14

B

G14AL

(MAN)

I

O

Engine Management: 2.0L – Part 2 Engine Management: 2.0L – Part 2 Fig. 03.4

FRONT OFENGINE

CYLINDER NUMBERING

FUEL INJECTORS IGNITION MODULES AND COILS


(CONTINUED FROM Fig. 03.3)

NOTE: ECM power supplies and groundsshown on Fig. 03.3.

SPEED CONTROLCONTROL MODULE

ON RESUME SET + SET - CANCEL OFF

SPEED CONTROL SWITCHES

STEERING WHEEL

CASSETTE

CASSETTE


NOTE: JBS51 –Speed Controlvehicles only.

BRAKEON / OFFSWITCH

BRAKECANCELSWITCH

CLUTCHCANCEL

SWITCH*

AIR CONDITIONINGPRESSURE SENSOR


RELAY

* NOTE: Clutch Cancel Switch –Manual Transmission vehicles only.

POWER DISTRIBUTION FUSE BOXIGNITION

CAPACITOR


LH COOLING FAN

RH COOLING FAN

FANS

COOLING FANMODULE

FUEL PUMP

FUEL TANK

FUEL PUMPRELAY


2.0L Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Automatic and Manual Transmissions: Early Production Automatic and Manual Transmissions: Early Production Fig. 04.1

JB131-13

G

JB131-12

JB131-6

JB131-33

JB131-36

JB131-54

BB

BB

B

BR

D

ORY

GUNNNBWUWYGROGNBB

Y

G

WU

WU

UY

IP14-2

IP14-6

OY

B

B

JB131-34

Y

8

20.1

20.1

20.1

20.1

–

+

–

+

JB155-7

JB155-18

JB155-9

JB155-10

JB155-11

JB155-17

JB155-16

JB155-8

JB155-15

JB155-12

JB155-13

JB155-14

υ

JB155-2

JB155-1

JB155-4

JB155-3

JB155-6

JB155-5

BR

D

BR

D

B

JBS35

W

JB131-17

JB131-15

JB131-14

JB131-52

JB131-16

JB131-18

JB131-03

JB131-53

JB131-10

JB131-04

JB131-39

JB131-20

JB131-24

JB131-21

JB131-05

JB131-30

JB131-26

JB131-25

JB131-27

JB131-08

JB131-07

JB131-09

JB131-38

C

C

C

C

OYBWJB131-45

JB131-47

JB156-9

JB156-7

JB156-2

JB156-1

JB156-8

JB156-3

JB156-4

NJB156-10

JB156-6

IP14-5

BW

IP14-4

Y

IP14-10

G

IP14-9

Y

IP14-12

G

IP14-11

Y

C

C

C

C

–

+

–

+

IP14-1

WR

IPS68B

IP14-3

O

P

R

N

D

2

3

G37BL

OY

BW

JB129-10

JB130-6

JBS55

G14AL

I

I

I

I

O

O

O

O

O

O

O

O

O

I

I

I

I

I

I

I

I

BBB NNN

ORYGU W B

WUWYGROGNBB B

WUEN16-026

BGEN16-019

EN86 -1 -2 -3

ENS6

WU

WG

BG

I

E88

JB2-12

B GOW(NAS)

(ROW)

(NAS)

(ROW)

RW

U

PA5-1PA5-2 JB2-16

14II

BEN16-031I

JB145-5

GB GBEN85-02EN85-01

08.340II

WGEN16-033

PA4 -3 -1

38II

W RW

JB2-11JB1-4I WG

RIP18-4

UIP18-3

O

I

IP14-16

I

O

O

4

09.2

07.2

36II

20.1

20.1

20.1

20.1

JBS65

H

F40 15A

WU WR

B

NR

W 24II

17

B

JBS55

B

G15BLG15BR

PR

D

23

N

P

N

39II

02.1

A B C

G14AL

5

2

R8

1

3

4

B

B

B

P

P

B

B

TCM RELAY



AUTOMATIC TRANSMISSION

TRANSMISSION CONTROL VALVES

SHIFTSOLENOIDS

PRESSURE CONTROLSOLENOIDS

(DUTY CYCLE)TIMING

SOLENOIDS

TCC

LIN

E

2 / 4

BR

AK

E

LOW

CLU

TCH

RED

UC

TIO

N

2 / 4

BR

AK

E

FLUIDTEMPERATURE

SENSORTURBINE

SPEED SENSORINTERMEDIATESPEED SENSOR

OUTPUTSPEED SENSOR

TRANSMISSION RANGE SENSOR

ECM: STARTERCIRCUIT


NOTE: ECM power supplies andgrounds shown on Fig. 03.1. OUTPUT SPEED

SENSORCLUTCH CANCEL

SWITCH


REVERSE LAMPSWITCH

REVERSE LAMPS

MANUAL TRANSMISSION

MODE SWITCH

D – 4SWITCH

NOT-IN-PARKSWITCH

GEARSHIFTINTERLOCKSOLENOID

J GATE ASSEMBLY

GECM:KEY-IN AUDIBLE WARNING

KEY LOCKSOLENOID

IGNITION SWITCH

CAN MESSAGES:• GEAR SELECTOR POSITIONS• BRAKE ON / OFF

GEAR SELECTORILLUMINATION

2.5L & 3.0L VehiclesEarly Production Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output


SCP Serial and Encoded Data November 2002

B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

JB131-13

G

JB131-12

JB131-6

JB131-33

JB131-36

JB131-54

BB

BR

D

ORY

GU

N

N

NBWUWYGROGNBB

Y

G

WU

WU

UY

IP14-2

IP14-6

OY

B

B

JB131-34

Y

8

20.1

20.1

20.1

20.1

–

+

–

+

JB155-7

JB155-18

JB155-9

JB155-10

JB155-11

JB155-17

JB155-16

JB155-8

JB155-15

JB155-12

JB155-13

JB155-14

υ

JB155-2

JB155-1

JB155-4

JB155-3

JB155-6

JB155-5

BR

D

BR

D

W

JB131-17

JB131-15

JB131-14

JB131-52

JB131-16

JB131-18

JB131-03

JB131-53

JB131-10

JB131-04

JB131-39

JB131-20

JB131-24

JB131-21

JB131-05

JB131-30

JB131-26

JB131-25

JB131-27

JB131-08

JB131-07

JB131-09

JB131-38

C

C

C

C

OYBWJB131-45

JB131-47

JB156-9

JB156-7

JB156-2

JB156-1

JB156-8

JB156-3

JB156-4

NJB156-10

JB156-6

IP14-5

BW

IP14-4

Y

IP14-10

G

IP14-9

Y

IP14-12

G

IP14-11

Y

C

C

C

C

–

+

–

+

IP14-1

WR

IPS68B

IP14-3

O

P

R

N

D

2

3

G37BL

OY

BW

JB129-10

JB130-6

JBS55

G14AL

I

I

I

I

O

O

O

O

O

O

O

O

O

I

I

I

I

I

I

I

I

YOU NNN

ORYGU W B

WUWYGROGN B

JB2-12

B GOW(NAS)

(ROW)

(NAS)

(ROW)

RW

U

PA5-1PA5-2 JB2-16

14II

BEN16-031I

JB145-5

GB GBEN85-02EN85-01

08.340II

WGEN16-033

PA4 -3 -1

38II

W RW

JB2-11JB1-4I WG

RIP18-4

UIP18-3

O

I

IP14-16

I

O

O

4

09.2

07.2

36II

20.1

20.1

20.1

20.1

JBS65

F40 15A

WU WR

B

NR

W 24II

17

BJBS55

B

G15BLG15BR

PR

D

23

N

P

N

39II

02.1

A B C

G14AL

5

2

R8

1

3

4

B

B

B

P

P

B

B

UJB131-44

OJB131-46

YJB131-42

02.2

JB196-6

B GOJB196-4

14II

BEN65-085I

JB145-5

U

(2.5L, 3.0L)

(2.0L)

WGEN65-084

JB196-3JB1-4I WG

(2.5 L, 3.0L)

(2.0 L)

Automatic and Manual Transmissions: Later Production Automatic and Manual Transmissions: Later Production Fig. 04.2

TCM RELAY



AUTOMATIC TRANSMISSION (VIN C72268 D15361)


SHIFTSOLENOIDS


(DUTY CYCLE)TIMING

SOLENOIDS

TCC

LIN

E

2 / 4

BR

AK

E

LOW

CLU

TCH

RED

UC

TIO

N

2 / 4

BR

AK

E

FLUIDTEMPERATURE

SENSORTURBINE


OUTPUTSPEED SENSOR

TRANSMISSION RANGE SENSOR

ECM: STARTERCIRCUIT


NOTE: ECM power supplies andgrounds shown on Fig. 03.1 or Fig. 03.3.

CLUTCH CANCELSWITCH


REVERSE LAMPSWITCH

REVERSE LAMPS

MANUAL TRANSMISSION (VIN C43293 )

MODE SWITCH

D – 4SWITCH

NOT-IN-PARKSWITCH


J GATE ASSEMBLY


KEY LOCKSOLENOID

IGNITION SWITCH



All Vehicles (Later Production)Later Production Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output


SCP Serial and Encoded Data November 2002

B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Automatic and Manual Transmissions: Later Production VIN D15361 Automatic and Manual Transmissions:Later Production VIN D15361 Fig. 04.3

JB131-33

G

JB131-12

JB131-6

JB131-33

JB131-36

JB131-34

BB

BR

D

ORY

GU

N

N

NBWUWYGROGNBB

Y

G

WU

WU

UY

IP14-2

IP14-6

OY

B

B

JB131-34

Y

8

20.1

20.1

20.1

20.1

–

+

–

+

JB155-7

JB155-18

JB155-9

JB155-10

JB155-11

JB155-17

JB155-16

JB155-8

JB155-15

JB155-12

JB155-13

JB155-14

υ

JB155-2

JB155-1

JB155-4

JB155-3

JB155-6

JB155-5

BR

D

BR

D

W

JB131-17

JB131-15

JB131-14

JB131-52

JB131-16

JB131-18

JB131-03

JB131-53

JB131-10

JB131-04

JB131-39

JB131-20

JB131-24

JB131-21

JB131-05

JB131-30

JB131-26

JB131-25

JB131-27

JB131-08

JB131-07

JB131-09

JB131-38

C

C

C

C

OYBWJB131-45

JB131-47

JB156-9

JB156-7

JB156-2

JB156-1

JB156-8

JB156-3

JB156-4

NJB156-10

JB156-6

IP14-5

BW

IP14-4

Y

IP14-10

G

IP14-9

Y

IP14-12

G

IP14-11

Y

C

C

C

C

–

+

–

+

IP14-1

WR

IPS68B

IP14-3

O

P

R

N

D

2

3

G37BL

OY

BW

JB129-10

JB130-6

JBS55

G14AL

I

I

I

I

O

O

O

O

O

O

O

O

O

I

I

I

I

I

I

I

I

YOU NNN

ORYGU W B

WUWYGROGN B

JB2-12

B GOW(NAS)

(ROW)

(NAS)

(ROW)

RW

U

PA5-1PA5-2 JB2-16

14II

BEN16-031I

JB145-5

GB GBEN85-02EN85-01

08.340II

WGEN16-033

PA4 -3 -1

38II

W RW

JB2-11JB1-4I WG

RIP18-4

UIP18-3

O

I

IP14-16

I

O

O

4

09.2

07.2

36II

20.1

20.1

20.1

20.1

JBS65

F40 15A

WU WR

B

NR

W 24II

17

BJBS55

B

G15BLG15BR

PR

D

23

N

P

N

39II

02.1

A B C

G14AL

5

2

R8

1

3

4

B

B

B

P

P

B

B

UJB131-44

OJB131-46

YJB131-42

02.2

JB196-6

B GOJB196-4

14II

BEN65-085I

JB145-5

U

(2.5L, 3.0L)

(2.0L)

WGEN65-084

JB196-3JB1-4I WG

(2.5 L, 3.0L)

(2.0 L)

IP14-14

IP14-15

O

R

JBS72

JBS71

O R

JB129-22

JB129-20

O

O

P

TCM RELAY


AUTOMATIC TRANSMISSION (VIN D15361 )


SHIFTSOLENOIDS



(DUTY CYCLE)TIMING

SOLENOIDS

TCC

LIN

E

2 / 4

BR

AK

E

LOW

CLU

TCH

RED

UC

TIO

N

2 / 4

BR

AK

E

FLUIDTEMPERATURE

SENSORTURBINE


OUTPUTSPEED SENSOR

TRANSMISSION RANGE SENSOR (VIN D15361 )

ECM: STARTERCIRCUIT


NOTE: ECM power supplies andgrounds shown on Fig. 03.1 or Fig. 03.3.

CLUTCH CANCELSWITCH


REVERSE LAMPSWITCH

REVERSE LAMPS

MANUAL TRANSMISSION (VIN C43293 )

MODE SWITCH

D – 4SWITCH

NOT-IN-PARKSWITCH


J GATE ASSEMBLY (VIN D15361 )

SECONDGEAR

THIRDGEAR


KEY LOCKSOLENOID

IGNITION SWITCH



All Vehicles (Later Production)VIN D15361

NOTE: Transmission Range Sensor positions 2 and 3 inoperative.Gear selection on “manual side” of J-Gate transmitted to TCMvia D – 4 Switch and 2nd and 3rd gear outputs from the J-Gate Module.

Range Sensor 2nd (R) and 3rd (O) gear circuits to splices JBS71 andJBS72 will be deleted in a future production running change.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Anti-Lock Braking Anti-Lock Braking Fig. 05.1

CA75

-7-6CA10-20JBS4

PA3-1

57II

GW NR

JB2-1

CA170-15

GW

GW

GO GO GW

21II 16

GO W NR R S

VPU-1

VPU-2

G14AL

B

VM2-1

VM1-1

VM1-5

VM2-2

VM3-1

VM3-2

B

JB45-6

RJB45-2

R

GW

Y

G

20.1

20.1

15

LF1-2

RF1-2

W N W R

CA55-2

CA60-2

CA55-1

CA60-1

JB15-1

CA10-16

JB15-2

CA10-17

LF1-1

RF1-1

WU GB WG NG

G18AL

JB45-23

JB45-24

JB45-40

C

C

JB45-12

JB45-28

JB45-16

JB45-15

JB45-14

JB45-13

JB45-31

JB45-30

JB45-32

WNWRNRWUGBWGNGGO

RJBS27

19II

JB45-05 B

JB45-01 B

G18AR

I

PA3-3

JB133-1

CA170-6

JB133-2

CA170-7

I

I

I

I

CAN

VP1-2

VP1-1

R S

B B

JBS66

B

RJB195-1

JB195-2

H H H H

B

B

B

P

P

LH FRONTWHEEL SPEED

SENSOR

RH FRONTWHEEL SPEED

SENSOR

LH REARWHEEL SPEED

SENSOR

RH REARWHEEL SPEED

SENSOR

DRIVER WARNINGS;VEHICLE SPEED;

ENGINE TORQUE REDUCTION

CAPACITOR

ANTI-LOCK BRAKINGCONTROL MODULE

PRESSUREPUMP

CONTROLVALVES


VACUUMPUMP

Activates Vacuum Pump ifIntake Manifold vacuum

falls to 0.450 bar (13.29 in. hg);switches pump off at 0.650 bar (19.20 in. hg).

VACUUM MODULE *BRAKE

ON / OFF SWITCH

2.5L & 3.0L ABS Vehicles

* NOTE: Vacuum Module, Vacuum Pump and circuit –early production vehicles only.

MOTOR

SOLENOIDS

MOTOR

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

CA75

-7-6CA10-20JBS4

PA3-1

57II

GW NR

JB2-1 (2.5, 3.0 L)JB196-1 (2.0 L)

CA170-15

GW

GW

GO GO GW

21II 16

GO W NR R S

VPU-1

VPU-2

B

VM2-1

VM1-1

VM1-5

VM2-2

VM3-1

VM3-2

B

JB185-6

RJB185-2

R

GW

Y

G

20.1

20.1

15

BBJB185-27IP29-2IP29-5 JB130-7

B

LF1-2

RF1-2

W N W R

CA55-2

CA60-2

CA55-1

CA60-1

JB15-1

CA10-16

JB15-2

CA10-17

LF1-1

RF1-1

WU GB WG NG

JB89-2

JB89-3

JB89-1

WG GB B

IP20-1

IP20-4

IP20-3

GWY

IP19-3

IP19-1

IP19-2

YB***

GW

JB129-9

JB129-16

I

JB185-23

JB185-24

JB185-40

C

C

JB185-21

JB185-39

JB185-26

JB185-42

JB185-25

JB185-12

JB185-28

JB185-16

JB185-15

JB185-14

JB185-13

JB185-31

JB185-30

JB185-32

B*** UGWWGGBBWNWRNRWUGBWGNGGO

RJBS68

19II

IPS68

B

G37BL

IP20-2

G

IP19-4

G

B***GW

IPS7

IPS6

20.1

20.1

20.1

20.1

C C C C

CAN

I

JB185-05 B

JB185-01 B

I

PA3-3

JB133-1

CA170-6

JB133-2

CA170-7

I

I

I

I

VP1-2

VP1-1

R S

G14AL

B

G18ALG18AR

B B

JBS67

B

RJB195-1

JB195-2

H H H H

P

P

B

B

B

U

U

CA55-2

CA60-2

CA55-1

CA60-1

CA10-16

CA10-17

WU GB WG NG

CA170-6

CA170-7

H H

LR1-2

R W R W

LR1-1

RR1-2

RR1-1

B***U

Dynamic Stability Control Dynamic Stability Control Fig. 05.2

YAW RATESENSOR

STEERING ANGLESENSOR

BRAKE PRESSURESENSOR

LH FRONTWHEEL SPEED

SENSOR

RH FRONTWHEEL SPEED

SENSOR

LH REARWHEEL SPEED

SENSOR

RH REARWHEEL SPEED

SENSOR

YAW RATE

STEERING ANGLE



DYNAMIC STABILITY CONTROLSWITCH

CAPACITOR **

MOTOR

SOLENOIDS

MOTOR

DYNAMICSTABILITY CONTROLCONTROL MODULE

PRESSUREPUMP

CONTROLVALVES


VACUUMPUMP



VACUUM MODULE *BRAKE ON / OFF

SWITCH

DSC Vehicles

* NOTE: Vacuum Module, Vacuum Pump and circuit –2.0L vehicles and early production 2.5L and 3.0L vehicles only.

** NOTE: Capacitor and circuit –early production vehicles only.

*** NOTE: B – early production vehicles.

LH REARWHEEL SPEED

SENSOR

RH REARWHEEL SPEED

SENSOR

2.0L VEHICLES

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Anti-Lock Braking / Traction Control Anti-Lock Braking / Traction Control Fig. 05.3

CA75

-7-6CA10-20JBS4

PA3-1

57II

GW NR

JB196-1

CA170-15

GW

GW

GO GO GW

21II 16

GO W NR R S

VPU-1

VPU-2

G14AL

B

VM2-1

VM1-1

VM1-5

VM2-2

VM3-1

VM3-2

B

JB197-6

RJB197-2

R

GW

Y

G

20.1

20.1

15

LF1-2

RF1-2

W N W R

CA55-2

CA60-2

CA55-1

CA60-1

JB15-1

CA10-16

JB15-2

CA10-17

LF1-1

RF1-1

WU GB WG NG

G18AL

JB197-23

JB197-24

JB197-40

C

C

JB197-12

JB197-28

JB197-16

JB197-15

JB197-14

JB197-13

JB197-31

JB197-30

JB197-32

WNWRNRWUGBWGNGGO

RJBS69

19II

JB197-05 B

JB197-01 B

G18AR

I

PA3-3

JB133-1

CA170-6

JB133-2

CA170-7

I

I

I

I

CAN

VP1-2

VP1-1

R S

B B

JBS70

B

RJB195-1

JB195-2

H H H H

B

B

B

P

P

BBJB197-27IP29-2IP29-5 JB130-7

B IIPS68

B

G37BL

R W R W

LR1-2

RR1-2

LR1-1

RR1-1

LH FRONTWHEEL SPEED

SENSOR

RH FRONTWHEEL SPEED

SENSOR

LH REARWHEEL SPEED

SENSOR

RH REARWHEEL SPEED

SENSOR



TRACTION CONTROLSWITCH

CAPACITOR

MOTOR

SOLENOIDS

MOTOR

ANTI-LOCK BRAKING /TRACTION CONTROLCONTROL MODULE

PRESSUREPUMP

CONTROLVALVES


VACUUMPUMP



VACUUM MODULEBRAKE

ON / OFF SWITCH

2.0L ABS/TC Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Manual Climate Control System; Glass Heaters Manual Climate Control System; Glass Heaters Fig. 06.1

B

G14BL

IP101-22

Y

AC1-15

IP101-9

IP101-14

IP101-10

IP101-1

IP101-2

IP39-03

BB

BW

BW

BGBOBKBR

RGOYROGRUORGOGUGRGBUGWGBUY

G

Y

WR

OY

U

FLS1B

G15AR

ZA10-1ZA1-1

AC6-2

AC6-1

AC5-1

AC5-2

AC4-1

AC4-6

AC4-3

AC4-4

AC4-5

AC3-1

AC3-6

AC3-3

AC3-4

AC3-5

AC2-1

AC2-6

AC2-3

AC2-4

AC2-5

62

B64

32II

IP101-23

G

IP101-20

O

C

C

C

C

AC1-16

AC1-14

AC1-04

AC1-05

AC1-21

AC1-06

AC1-20

AC1-07

AC1-13

AC1-23

AC1-08

AC1-22

AC1-09

AC1-26

AC1-25

IP135-01

IP101-07

IP101-04

IP101-03

AC7-2

AC7-4

AC7-4

AC7-2

υ

B

YWRWWBAC1-10

AC1-24

AC1-11

AC1-12

A/CCM

20.1

20.1

20.1

20.1

υ

ACS2

I

I

(LHD)

(RHD)

UGWGBUY B RGOYROGRUORGOGUGRGB YWRWWB

C1C4 C3 C2 C1C4 C3 C2 C1C4 C3 C2

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

G37BR

O

I

09.2

O

O

OY

WR

12

-ve BUSIP2-16

IP3-2

JB96-2JB96-1

JB95-2JB95-1

FR4-10FR4-9

FL5-10FL5-9

2

1 OY

OY

F13 30AJB35-21 JB35-22

F15 30AJB35-25 JB35-26

R

R

R

JBS28

GU

GW

B

JB130-21

10CA77-2

11IP2-13

B

F98 10A CA76-1

GU

GO

GUCA127-1

GU

CAS84

CA15-17

CA20-17

GO GO

GO GOCAS10

B B BCA15-2

FRS1B

G4AL

B BCA20-2

G3BS

B

G14BR

B

34II

IP39-04O

IP39-02O

IP39-06O

IP101-15

B

G36AR

IP135-2

GBIP39-01O

IP58-1

IP58-2

GB GB

5 4 3 2 16

IP121-2 IP121-5 IP121-6 IP121-4 IP121-3 IP121-1

IPS37

IPS55

BW

5

1

3

2

R204 3

1

5

2

R2

5

2

3

1

R194

B

B

B

I

P

P

DISCHARGETEMPERATURE

SENSOR

EVAPORATORTEMPERATURE

SENSORFRESH / RECIRCULATION

FLAP ACTUATOR

DEFROST DOORACTUATOR

STEPPER COILS

PANEL / FLOORACTUATOR

STEPPER COILS

AIR TEMPERATURE BLENDACTUATOR

STEPPER COILS

NOTE: The A/CCM incorporates the control panelfor the Climate Control System.

CONTROL PANELILLUMINATION

BLOWER


AIR CONDITIONINGBLOWER

RELAY


BLOWER

BLOWER SERIES RESISTOR

HEATEDREAR WINDOW

RELAY


WINDSHIELD HEATERRELAY


+veWAVE TRAP

LH DOOR MIRROR

RH DOOR MIRROR

HEATED REAR WINDOW

RH WINDSHIELD HEATER

LH WINDSHIELD HEATER

NOTES:Refer to Fig. 03.2 or 03.4 for A/C Compressor Clutch and Cooling Fan circuits.Check market specification for fitment of Heated Windshield.

Manual Climate Control Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

B

G14BL

IP101-22

Y

AC1-15

IP101-9

IP101-14

IP101-10

IP101-1

IP101-2

IP101-05

BB

BWB

W

BBBWBW

RGOYROGRUORGOGUGRGBUGWGBUY

G

Y

WR

OY

U

FLS1B

G15ALG15AR**

ZA10-1ZA1-1

B

OY

B

IP134-2 (LHD)IP134-1 (RHD)

IP38-1

IP38-2

AC6-2

AC6-1

IP66-2

IP66-1

AC5-1

AC5-2

JB105-2

JB105-1

AC4-1

AC4-6

AC4-3

AC4-4

AC4-5

AC3-1

AC3-6

AC3-3

AC3-4

AC3-5

AC2-1

AC2-6

AC2-3

AC2-4

AC2-5

62

B64

32II

IP101-23

G

IP101-20

O

C

C

C

C

AC1-16

AC1-14

AC1-04

AC1-05

AC1-21

AC1-06

AC1-20

AC1-07

AC1-13

AC1-23

AC1-08

AC1-22

AC1-09

AC1-26

AC1-25

IP101-16

IP101-17

IP101-18

IP101-19

IP101-21

IP101-06

IP101-07

IP101-04

IP101-03

AC7-2

AC7-4

AC7-4

AC7-2

υυ

IP66-3

IP66-4

υ

B

YWRWWBAC1-10

AC1-24

AC1-11

AC1-12

IP101-15

20.1

20.1

20.1

20.1

υ

ACS2

I

I

(LHD)

(RHD)

UGWGBUY B RGOYROGRUORGOGUGRGB YWRWWB

C1C4 C3 C2 C1C4 C3 C2 C1C4 C3 C2

IPS27

33II

WR

JB3-9

JB3-10

I

I

I

O

B

B

B

WBW

B

B B B B

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

O

IP134-6 (LHD)IP134-4 (RHD)

IP134-3 (LHD)IP134-5 (RHD)

IP134-1 (LHD)IP134-2 (RHD)

B+

G36AR

G37BR

BW

O

O

I

09.2

O

O

OY

W

12

-ve BUSIP2-16

IP3-2

JB96-2JB96-1

JB95-2JB95-1

FR4-10FR4-9

FL5-10FL5-9

2

1 OY

OY

F13 30AJB35-21 JB35-22

F15 30AJB35-25 JB35-26

R

R

R

JBS28

GU

GW

B

JB130-21

10CA77-2

11IP2-13

B

F98 10A CA76-1

GU

GO

GUCA127-1

GU

CAS84

CA15-17

CA20-17

GO GO

GO GOCAS10

B B BCA15-2

FRS1B

G4AL

B BCA20-2

G3BS

B

G14BR

B

5

1

3

2

R204

3

1

5

2

R2

5

2

3

1

R194

B

B

B

I

P

67II

Automatic Climate Control System; Glass Heaters Automatic Climate Control System; Glass Heaters Fig. 06.2

DISCHARGETEMPERATURE

SENSOR

EVAPORATORTEMPERATURE

SENSORFRESH / RECIRCULATION

FLAP ACTUATOR

DEFROST DOORACTUATOR

STEPPER COILS

PANEL / FLOORACTUATOR

STEPPER COILS

AIR TEMPERATURE BLENDACTUATOR

STEPPER COILS

IN-CARTEMPERATURE

SENSORSOLAR

SENSOR

AMBIENTTEMPERATURE

SENSOR

NOTE:

Vehicles without Navigation “Touch Screen” – the A/CCMincorporates the Control Panel for the Climate Control System.

Vehicles with Navigation “Touch Screen” – The A/CCM is remotelymounted on the Climate Control Unit. Driver control inputs arereceived via Network communication.

CONTROL PANELILLUMINATION *


AIR CONDITIONINGBLOWER

RELAY


CONTROL

SENSE

BLOWER

HEATEDREAR WINDOW

RELAY

WINDSHIELD HEATERRELAY



+veWAVE TRAP

LH DOOR MIRROR

RH DOOR MIRROR

HEATED REAR WINDOW

RH WINDSHIELD HEATER

LH WINDSHIELD HEATER

Automatic Climate Control Vehicles

NOTES:Refer to Fig. 03.2 or Fig. 03.4 for A/C Compressor Clutch and Cooling Fan circuits.Check market specification for fitment of Heated Windshield.

* NOTE: Control Panel Illumination circuit –not used on “Touch Screen” vehicles.

NOTE: 33 – earlyproduction vehicles.

** NOTE: G15AR – early production vehicles.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Instrument Cluster Instrument Cluster Fig. 07.1

IP10-9

IP10-8

U

Y20.2

20.2

IP10-22

IP10-23

S

S

B

WB

JB129-4

IP11-7O

JB129-3

G37AL(G36BL)

B

IP11-13YU

IP11-11GR

IP10-10

U

IP11-17

OY

61

3I

15II

G

Y20.1

20.1

IP10-17

IP10-18

C

C

IP11-8

I

I

IP11-19

U

IP11-21

O

I

I

IP10-1

GB

IP10-20

WU

I

I

IP10-19

U

IP11-15

OG

I

I

17.1

09.2

08.1

08.1

08.1

08.108.4

IP10-7

IP10-15

WU

B

IP10-12

B

IP10-11

IP11-5

B

BEN19-1

P

B

IP72-1

FT2-1

FT2-3FE 160Ω20Ω

B

FT3-1

FT3-3FE 160Ω20Ω

B

WB

WU

JB103-2JB103-1

B

G10AL

G14AL

JB70-2JB70-1

B

BJB1-16

I

I

I

I

I

I

JB129-1

CA1-14

CA1-13

CA169-1

BJBS54

JBS55

B

BB

B

B

CA5-1

CA5-2

CA5-11

CA5-3

IP10-16

BIIP53-7

IP10-25

W

IP53-10

B

B

WB

WU

IP80-5

IP80-6

IP10-24

YO

G36BL

BRIPS69

B

A / B

MLS / KM

SCP

U

Y20.2

20.2

IP5-19

IP5-18

S

S

OIP6-18

OIP74-22

OIP165-25

RIP165-26

I

I

17.1

17.1

08.7

08.208.3

08.3

08.4 08.3

08.2

08.2

08.2

08.5

08.5

D

D

08.6

08.6

B

B

B

P

2.0 L

WB

B

CA415-2

CA415-4FE 160Ω20Ω

B

2.5, 3.0 L

2.0 L

2.5, 3.0 L

DRIVER SEAT BELT SWITCH

PASSENGER SEAT BELT SWITCH



(CIRCUITS CONTINUED)

DIMMER MODULE

REAR EXTERIOR LIGHTING:REVERSE LAMPS STATUS

ADVANCED RESTRAINT SYSTEM:AIRBAG WARNING

FRONT EXTERIOR LIGHTING:MAIN BEAM STATUS

FRONT EXTERIOR LIGHTING:DIP BEAM STATUS

FRONT EXTERIOR LIGHTING:FRONT FOG LAMPS STATUS

EXTERIOR LIGHTING:SIDE LAMPS STATUS

REAR EXTERIOR LIGHTING:REAR FOG LAMPS STATUS

INSTRUMENT CLUSTERILLUMINATION

AIRBAG WARNING LAMP

MAIN BEAM INDICATOR

FRONT FOG LAMPS INDICATOR

REAR FOG LAMPS INDICATOR

INSTRUMENT CLUSTER

OIL PRESSURESWITCH

WASHER FLUIDLEVEL SWITCH

BRAKE FLUIDLEVEL SWITCH

PARKING BRAKESWITCH

TRIP COMPUTERCYCLE SWITCH

TURN SIGNALSWITCH

RESET

MASTER LIGHTINGSWITCH

FUEL LEVEL SENSOR 1

FUEL LEVEL SENSOR 2

All Vehicles

FUEL LEVEL SENSOR (2.0L)

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Audible Warnings Audible Warnings Fig. 07.2

U

Y20.2

20.2

IP10-22

IP10-23

S

S

SCPU

Y20.2

20.2

IP5-19

IP5-18

S

S

OIP6-18

OIP74-22

OIP165-25

RIP165-26

I

I

17.1

17.1

23 OJB172-5

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

R

IP18-5

IP18-4

I

II

III

4

BIP6-8

I

IP14-2

BIP14-4

YIPS68

B

G37BL

IIP6-22

BFL9-1FL9-2

B R RCA15-20 CA1-7

IIP6-22

BFR9-1FR9-2

B R RCA20-20 CA1-5

G4AL

BFRS1

B BCA20-2

CAS10B

G15AR

BFLS1

B BCA15-2

LHD

RHD

IIP6-15

O

P

B

I

KEY-IN

IGNITION SWITCH

NOT-IN-PARKSWITCH

J GATE ASSEMBLY

DOOR AJARSWITCH

LH FRONT DOORLATCH ASSEMBLY

DOOR AJARSWITCH

RH FRONT DOORLATCH ASSEMBLY

DRIVER SEAT BELT SWITCH

PASSENGER SEAT BELT SWITCH


AUDIBLEWARNINGCONTROL


INSTRUMENT CLUSTER

HEADLAMPS ON

AUDIBLE WARNINGS:• Seat Belt• Airbag• Ignition Key-in• Not-in-Park• Headlamps on• Delay Entry (combined Alarm state and Driver Door Ajar status)

NOTE: Refer to Figs. 08.1 – 08.5 for Turn Signal audible warning.

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Exterior Lighting: Front – Autolamps Exterior Lighting: Front – Autolamps Fig. 08.1

IP6-13 IPS16

IP6-9

GU

U

GB

GB

GWIP2-2

JBS10

OG

G

IP17-13

IP17-8

GB

R

IPS56

IPS67 (LHD)IPS69 (RHD)

B

19

IP17-6

BB

G37BL(G36BL)

IP17-15

IP17-14

G

IP17-7

OY

IP17-5

RIP17-4

RIP17-11

GW

F85 7.5A

IP17-12

U

33

-ve BUS

F86 7.5A

F87 15A

IP4-13

U

Y20.2

20.2

IP5-19

IP5-18

S

S O

23 OJB172-5

IP53-6

IP53-2

BWIP53-8

BGIP53-1

BGIP53-3

BIP53-5

BRIP53-7

OYIP53-4

IPS65

G36AL(G5AR)

B

G37BL(G36BL)

I

I

I

I

O

JB172-4

IP6-11

OYO

JB172-3

IP6-17

OOIP6-19

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

U07.1

GO

GW

JB51-12

JB51-16

14

22II

GU

GUJBS36

OY

GO

F16 20A

F17 20A

OY

GWW

GO

GBRC5-5

GCA36-3 CA1-18

RC5-4 CA36-15 CA1-17

GB

G

GB

GI

O

U07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4IP4-4

IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

OG

OY

OG07.1

G5AS(G5AR)

CA86-5

B

G4AL

JB129-21

GW

OY

OY

JBS37JB129-17

GWJBS9

GW

GW

OY07.1

IPS47

OYIP17-3

JB132-1 JB132-2

FB2-1 FB2-2

JB84-9

JB84-7

JB84-5

JB84-10JB84-1

FB1-1 FB1-2

FB3-1 FB3-2

JB98-1 JB98-2

FB4-1 FB4-2

JB85-9

JB85-7

JB85-5

JB85-1 JB85-10

GW

GW

JB171-2

JB171-3

GO

GB

IP25-1 IP25-2

OY

OY

JBS17OY

JB171-1

OY

G11AR

B

G11AL

B

G14AL

B

G10AR

B

JBS55B

G10AL

BJBS54

B

BJB171-4

B

BJB171-6

B

BJB171-8

B

G5AS(G37BL)

BOY

O

OG

O

OG

GW

JBS11

JBS16 JB171-5

OGJB171-7

BJBS56

B08.7

JB84-5 JB84-8

G32AS

B

OY

JB84-9

JB84-7

JB84-10JB84-1

G11AL

B

JB85-5 JB85-8

G33AS

B

JB85-9

JB85-7

JB85-10JB85-1

G10AR

B

SCP

4R15

1

5

2

3

3

1

5

2

R9 4

IP5-3

B


B

GBJB129-15


B

B

P

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

I

MAIN BEAM STATUS(CIRCUIT CONTINUED)

LIGHTING MESSAGES

FLASH

MAIN BEAM

LH TURN

RH TURN

TURN SIGNALAUDIBLE WARNING

TURN SIGNAL SWITCH

HAZARD SWITCH

NOTE: IPS65 – LHD only.

SIDE LAMPS STATUS(CIRCUIT CONTINUED)

FRONT FOG STATUS(CIRCUIT CONTINUED)

DIP BEAM STATUS(CIRCUIT CONTINUED)

REAR FOG LAMPS

FRONT FOG LAMPS

SIDE LAMPS

AUTOLAMPS

AUTO (SENSOR)

DIP BEAM


AUTOLAMPSSENSOR

LIGHTING

LIGHTINGCONTROL

REMOTEHEADLAMPS


MAIN BEAM / FRONT FOGRELAY


NOTE: JBS17 – Side Marker only.



DIP BEAMRELAY


LH TURN REPEATER

LH FRONT SIDE MARKER LAMP

NOTE: JBS10 – Repeater only.

TURN

SIDE

DIP

MAIN

LH HEADLAMP UNIT

LH FRONTFOG LAMP

RH FRONTFOG LAMP

GLOVE BOX LAMPNOTE: JBS11 – Repeater only.

RH TURN REPEATER

RH FRONT SIDE MARKER LAMP

TURN

SIDE

DIP

MAIN

RH HEADLAMP UNIT

TURN

SIDE

MAIN

BALLAST

DIP

LH HEADLAMP UNIT(HID VARIANT) *

* NOTE: HID variant – V supplycircuit for all lamps unchanged.

TURN

SIDE

MAIN

BALLAST

DIP

RH HEADLAMP UNIT(HID VARIANT) *

Autolamp Vehicles

EXTERNAL ANTENNA(JAPAN, S. KOREA)

REMOTEHEADLAMPS

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Exterior Lighting: Front – Non Autolamps; Daytime Running Lamps Exterior Lighting: Front –Non Autolamps; Daytime Running Lamps Fig. 08.2

IP6-13 IPS16

IP6-9

GU

U

GB

GB

GWIP2-2

JBS10

OG

G

IP17-13

IP17-8

GB

R

B

19

IP17-6

IP17-15

IP17-7

OY

IP17-5

RIP17-4

RIP17-11

GW

F85 7.5A

IP17-12

U

33

-ve BUS

F86 7.5A

F87 15A

IP4-13

U

Y20.2

20.2

IP5-19

IP5-18

S

S O

23 OJB172-5

IP53-6

IP53-2

BWIP53-8

BGIP53-1

BGIP53-3

BIP53-5

BRIP53-7

OYIP53-4

I

I

I

I

O

JB172-4

IP6-11

OYO

JB172-3

IP6-17

OOIP6-19

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

U07.1

GO

GW

JB51-12

JB51-16

14

22II

GU

GUJBS36

OY

GO

F16 20A

F17 20A

OY

GWW

GO

U07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4IP4-4

IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

OG

OY

OG07.1

CA86-5

B

G4AL

JB129-21

GW

OY

OY

JBS37JB129-17

GWJBS9

GW

GW

OY07.1

IPS47

OYIP17-3

JB132-1 JB132-2

FB2-1 FB2-2

JB84-9

JB84-7

JB84-5

JB84-10JB84-1

FB1-1 FB1-2

FB3-1 FB3-2

JB98-1 JB98-2

FB4-1 FB4-2

JB85-9

JB85-7

JB85-5

JB85-1 JB85-10

GW

GW

JB171-2

JB171-3

GO

GB

IP25-1 IP25-2

OY

OY

JBS17OY

JB171-1

OY

G11AR

B

G11AL

B

G14AL

B

G10AR

B

JBS55B

G10AL

BJBS54

B

BJB171-4

B

BJB171-6

B

BJB171-8

B

G5AS(G37BL)

BIPS66 (LHD)IPS68 (RHD)

BOY

O

OG

O

OG

GW

JBS11

JBS16 JB171-5

OGJB171-7

BJBS56

B08.7

JB84-5 JB84-8

G32AS

B

OY

JB84-9

JB84-7

JB84-10JB84-1

G11AL

B

JB85-5 JB85-8

G33AS

B

JB85-9

JB85-7

JB85-10JB85-1

G10AR

B

SCP

3

2

5

1

R15 4

3

1

5

2

R9 4

IP5-3

B


BB

G37BL(G36BL)

IPS65

G36AL(G5AR)

B

G37BL(G36BL)

G5AS(G5AR)


B

JB129-15

GB

B

P

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

I

MAIN BEAM STATUS(CIRCUIT CONTINUED)

LIGHTING MESSAGES

FLASH

MAIN BEAM

LH TURN

RH TURN


TURN SIGNAL SWITCH

HAZARD SWITCH



FRONT FOG STATUS(CIRCUIT CONTINUED)


REAR FOG LAMPS

FRONT FOG LAMPS

SIDE LAMPS

DIP BEAM

NON DAYTIMERUNNING LAMPS

DIP BEAM

CANADA DAYTIMERUNNING LAMPS

DIP BEAM

SCANDINAVIA DAYTIMERUNNING LAMPS


LIGHTING

LIGHTINGCONTROL

REMOTEHEADLAMPS


MAIN BEAM / FRONT FOGRELAY





DIP BEAMRELAY


LH TURN REPEATER

LH FRONT SIDE MARKER LAMP

NOTE: JBS10 – Repeater only.

TURN

SIDE

DIP

MAIN

LH HEADLAMP UNIT

LH FRONTFOG LAMP

RH FRONTFOG LAMP

GLOVE BOX LAMPNOTE: JBS11 – Repeater only.

RH TURN REPEATER

RH FRONT SIDE MARKER LAMP

TURN

SIDE

DIP

MAIN

RH HEADLAMP UNIT

TURN

SIDE

MAIN

BALLAST

DIP

LH HEADLAMP UNIT(HID VARIANT) *

* NOTE: HID variant – V supplycircuit for all lamps unchanged.

TURN

SIDE

MAIN

BALLAST

DIP

RH HEADLAMP UNIT(HID VARIANT) *

Non Autolamp Vehicles; Daytime Running Lamp Vehicles


REMOTEHEADLAMPS

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Exterior Lighting: Rear Exterior Lighting: Rear Fig. 08.3

GB

GB

OG

IP17-8

R

B

19

IP17-16

IP17-5

RIP17-4

R

IP17-9

GWIP17-10

WU

U

Y20.2

20.2

IP5-19

IP5-18

S

S

23 OJB172-5

IP53-2

BGIP53-1

BGIP53-3

BIP53-5

OYIP53-4

I

I

O

CA86-2

OYO

CA87-4

IP6-17

OO

IP6-19

GB

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

GB

WU

07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4

IP4-4 IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

O

O

OG

07.1

CA86-5

B

G4AL

44II

SCP

GWCA1-21

GB GBEN85-02EN85-01

40II

(MAN)

(AUTO)CAS26

GB

CA76-13

F79 10A

IP1-12

CA78-8

IP1-13

29II

30II

18.1

GB

GB

OY

O

GW

GWCAS80

O OTMS1

O

O

OYCAS82

OY

CAS81

O

57II

NR GWPA3-1PA3-3 CA75-7

GWGWJB2-1 (2.5, 3.0 L)JB196-1 (2.0 L)

CA170-15

CA76-2

GR

CA76-3

O

CA76-4

OG OG

BTM4-1 TM4-2

BTM5-1 TM5-2

CA137-3

CA137-7

CA137-1

CA137-2

CA137-6

BRB5-1 RB5-2

CA137-5

CA138-5

CA138-1

CA138-7

CA138-6

CA138-2

BRB6-1 RB6-2

CA138-3

BCA304-2 CA304-1

O

OY

CA45-1

CA45-2

TMS2

O

B

BCAS9

B

BG1AR

B

RBS10

B

G2AL

GR

O

G38AS

GB

CA1-22

10.1 GB

5

2

3

1

R174

GB

CA129-3

IPS65

G36AL(G5AR)

B

G37BL(G36BL)

G5AS(G5AR)


B

B

CA129-7

G

Y20.1

20.1

IP10-17

IP10-18

C

CCAN

OIP11-3

IP10-1

GBI (MAN)

CA10-6

GBJB145-4

GB

OYCA129-6

CA129-10

O

OTL10-1

TL10-2

B

P

B

ELECTROCHROMIC MIRROR:REVERSE LAMPS ACTIVATED

PARKING AID:REVERSE LAMPS ACTIVATED

(CIRCUITS CONTINUED)

REVERSE GEAR (AUTO)

LIGHTING MESSAGES

NOTE: Refer to Fig. 07.1 for Instrument Clusterpower supplies and grounds.

LH TURN

RH TURN


TURN SIGNAL SWITCH

HAZARD SWITCH



REAR FOG STATUS(CIRCUIT CONTINUED)

REAR FOG LAMPS

SIDE LAMPS

MASTER LIGHTING SWITCH

BRAKE ON / OFFSWITCH

INSTRUMENT CLUSTER

LIGHTING

LIGHTINGCONTROL



REVERSE LAMPSWITCH

REVERSE LAMPSRELAY


STOP

TAIL

FOG

TURN

REVERSE

LH TAIL LAMPUNIT

NOTE: CAS92 – Side Marker only.

LH REAR SIDEMARKER LAMP

LH LICENSE PLATELAMP

RH LICENSE PLATELAMP

STOP

TAIL

FOG

TURN

REVERSE

RH TAIL LAMPUNIT

NOTE: CAS91 – Side Marker only.

RH REAR SIDEMARKER LAMP

HIGH-MOUNTSTOP LAMP

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Exterior Lighting: Rear – European Trailer Towing Exterior Lighting: Rear – European Trailer Towing Fig. 08.4

OG

IP17-8

R

B

19

IP17-16

IP17-5

RIP17-4

R

IP17-9

GWIP17-10

WU

U

Y20.2

20.2

IP5-19

IP5-18

S

S

23 OJB172-5

IP53-2

BGIP53-1

BGIP53-3

BIP53-5

OYIP53-4

I

I

O

CA86-2

OYO

CA87-4

IP6-17

OO

IP6-19

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

GB

WU

07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4

IP4-4 IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

O

O

OG

07.1

CA86-5

B

G4AL

44II

SCP

GWCA1-21

CAS26

B

G

BW

BG

PY

PY

CAS80

O

O

TMS1

O

O

OW

O

57II


GWGWJB2-1 (2.5, 3.0 L)JB196-1 (2.0 L)

CA170-15

CA76-2

GR

CA76-3

O

CA76-4

OG OG

BTM4-1 TM4-2

BTM5-1 TM5-2

TT4-3

TT4-7

TT4-1

TT4-2

TT4-6

TT4-5

TT5-5

TT5-1

TT5-7

TT5-6

TT5-2

TT5-3

BCA304-2 CA304-1

CA45-1

CA45-2TMS2

B

N

CAS9

B

G1AR

G

P

G

G38AS

T5011-09

T5011-10

T5011-1

T5011-2

T5011-4

T5011-5

T5011-6

T5011-7

T5011-8

T5011-3

T5011-11

T5011-13

Y

R

URYUROPOWPONWNWNW

B B

TT2-2

TT2-1

TT1-1

TT1-4

TT1-5

TT1-2

TT2-5

TT2-4

TT2-3

TT2-6

TT2-7

TT1-3

TT1-6

TT3-8

TT3-10

TT3-3

TT3-4

TT3-5

TT3-9

TT3-2

TT3-7

TT3-6

TT3-1

NW

PYBWNPYBGBOPOWRWWWPO

S18.1 WCA129-11

W SCA302-1 TT6-1

CA175-2

CA176-6

CA176-7

CA175-1

CA175-5

CA175-3

CA175-7

CA176-1

CA176-3

CA176-5

GW

GW

GBGB

OY

GR

I I I I I OOI IOOI

O

O

O

CA176-2

CA175-6

G2BL G2BR

F100 20AT5020-1 T5020-2

T5001-1

T5001-2

T5001-3

NG

RBY

R

R

R

R

T5S1N

CA146-2

CA146-3

YT5S2

2I

30

BCA146-1

G1AR

BCAS9

TT2-8

IPS65

G36AL(G5AR)

B

G37BL(G36BL)

G5AS(G5AR)


B

B

GB08.3

TL10-1

O

BTL10-2

T5S3

T5S4

B

P

NW NW

B B

PARKING AID:TRAILER CONNECTED(CIRCUIT CONTINUED)

LIGHTING MESSAGES

LH TURN

RH TURN


TURN SIGNAL SWITCH

HAZARD SWITCH




REAR FOG LAMPS

SIDE LAMPS



LIGHTING

LIGHTINGCONTROL

RH TURN

LH TURN



REVERSE LAMPSACTIVATION

IN-LINE FUSE

TRAILER TOWINGREAR ACCESSORY

CONNECTOR

TRAILER TOWINGCONTROL MODULE

B+ (ACCESSORY)

B+ (BATTERY)

LH TURN

FOG LAMPS

RH TURN

RH TAIL LAMP

STOP LAMPS

LH TAIL LAMP

REVERSE LAMPS

TRAILERCONNECTOR

FOG

TURN

TAIL

STOP

REVERSE

FOG

LH TAIL LAMPUNIT

TURN

TAIL

STOP

REVERSE

RH TAIL LAMPUNIT



HIGH-MOUNTSTOP LAMP

EUR Trailer Towing Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Exterior Lighting: Rear – U.K. Trailer Towing Exterior Lighting: Rear – U.K. Trailer Towing Fig. 08.5

OG

IP17-8

R

B

19

IP17-16

IP17-5

RIP17-4

R

IP17-9

GWIP17-10

WU

U

Y20.2

20.2

IP5-19

IP5-18

S

S

23 OJB172-5

IP53-2

BGIP53-1

BGIP53-3

BIP53-5

OYIP53-4

I

I

O

CA86-2

OYO

CA87-4

IP6-17

OO

IP6-19

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

GB

WU

07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4

IP4-4 IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

O

O

OG

07.1

CA86-5

B

G4AL

44II

SCP

GWCA1-21

CAS26GB

B

G

BW

BG

PY

PY

CAS80

O

OW

O

57II


GWGWJB2-1 (2.5, 3.0 L)JB196-1 (2.0 L)

CA170-15

CA76-2

GR

CA76-3

O

CA76-4

OG OG

TT4-3

TT4-7

TT4-1

TT4-2

TT4-6

TT4-5

TT5-5

TT5-1

TT5-7

TT5-6

TT5-2

TT5-3

BCA304-2 CA304-1

N

G

P

G

G38AS

T312N-1

T312N-2

T312N-4

T312N-5

T312N-6

T312N-7

T312N-3

URYUROPOW

PO

NW

TT2-2

TT2-1

TT1-1

TT1-4

TT1-5

TT1-2

TT2-5

TT2-4

TT2-3

TT2-6

TT2-7

TT1-3

TT1-6

TT3-8

TT3-10

TT3-3

TT3-4

TT3-5

TT3-9

TT3-2

TT3-7

TT3-6

TT3-1

NW


CA175-2

CA176-6

CA176-7

CA175-1

CA175-5

CA175-3

CA175-7

CA176-1

CA176-3

CA176-5

GW

GW

GBGB

OY

GR

II I I I OOI IOOI

O

O

O

CA176-2

CA175-6

G2BL

F100 20AT4020-2 T4020-1

T4001-1

T4001-2

T4001-3

NG

R

B

Y

R

RT3S1

NCA146-2

CA146-3

YT4S1

2I

30

BCA146-1

G1AR

BCAS9

RR

R

Y

BT3001-3

T3001-2

T3001-1 T4S2

R

Y

R

T412S-1

T412S-6

T412S-4

T412S-3

T412S-7 NWNW

G2BR

18.1 WCA129-11

W SCA302-1 TT6-1

TT2-8

O

O

TMS1

O BTM4-1 TM4-2

BTM5-1 TM5-2

CA45-1

CA45-2TMS2

B

CAS9

B

G1AR

B B

B

IPS65

G36AL(G5AR)

B

G37BL(G36BL)

G5AS(G5AR)


B

S

TT7-1

PO

TL10-1

O

TL10-2

B

08.3

B

P

T3S2

NW

B B

REVERSE LAMPS

B+ (ACCESSORY)

B+ (BATTERY


CARAVANCONNECTOR

IN-LINE FUSE

LIGHTING MESSAGES

LH TURN

RH TURN


TURN SIGNAL SWITCH

HAZARD SWITCH




REAR FOG LAMPS

SIDE LAMPS



LIGHTING

LIGHTINGCONTROL

RH TURN

LH TURN





CONNECTOR


LH TURN

FOG LAMPS

RH TURN

RH TAIL LAMP

STOP LAMPS

LH TAIL LAMP

TRAILERCONNECTOR

FOG

TURN

TAIL

STOP

REVERSE

LH TAIL LAMPUNIT

FOG

TURN

TAIL

STOP

REVERSE

RH TAIL LAMPUNIT



HIGH-MOUNTSTOP LAMP

U.K. Trailer Towing Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

OG

IP17-8

R

B

19

IP17-16

IP17-5

RIP17-4

R

IP17-9

GWIP17-10

WU

U

Y20.2

20.2

IP5-19

IP5-18

S

S

23 OJB172-5

IP53-2

BGIP53-1

BGIP53-3

BIP53-5

OYIP53-4

I

I

O

CA86-2

OYO

CA87-4

IP6-17

OO

IP6-19

IP6-1

IP5-22

B

BOIP51-4

IIP6-23

BIP51-5

GB

WU

07.1

IP2-10

F63 7.5A

F64 7.5A

F97 7.5A

JB51-6

CA78-4

IP4-4 IP2-9

CA78-16

JB51-7

CA76-7

IP1-3

OY

O

O

OG

07.1

CA86-5

B

G4AL

44II

SCP

GWCA1-21

CAS26

B

G

BW

BG

PY

PY

CAS80

O

O

TMS1

O

O

OW

O

57II


GWGWJB2-1 (2,5, 3.0 L)JB196-1 (2.0 L)

CA170-15

CA76-2

GR

CA76-3

O

CA76-4

OG OG

BTM4-1 TM4-2

BTM5-1 TM5-2

TT4-3

TT4-7

TT4-1

TT4-2

TT4-6

TT4-5

TT5-5

TT5-1

TT5-7

TT5-6

TT5-2

TT5-3

BCA304-2 CA304-1

CA45-1

CA45-2TMS2

B

N

CAS9

B

G1AR

G

P

G

G38AS

T6US1-3

T6US1-4

T6US1-2

T6US1-1

Y

G

NW** BW

W

B B

TT2-2

TT2-1

TT1-1

TT1-4

TT1-5

TT1-2

TT2-5

TT2-4

TT2-3

TT2-6

TT2-7

TT1-3

TT1-6

TT3-8

TT3-10

TT3-3

TT3-5

TT3-9

TT3-7

TT3-1

W


S18.1 WCA129-11

W SCA302-1 TT6-1

CA175-2

CA176-6

CA176-7

CA175-1

CA175-5

CA175-3

CA175-7

CA176-1

CA176-3

CA176-5

GW

GW

GBGB

OY

GR

I I I I I OOI IOOI

O

O

O

CA176-2

CA175-6

G2BL

T3001-1

T3001-2

T3001-3NG

R

B

Y

R

R

R

T3S1N

CA146-2

CA146-3

Y2I

30

BCA146-1

G1AR

BCAS9

TT2-8

IPS65

G36AL

B

G37BL

G5AS

IPS67

B

B

GB08.3

TL10-1

O

BTL10-2

OY

O

CAS94

CAS95

W

NW

T6S2*

T6S1

BRB5-1 RB5-2

OYCA129-6

BRB6-1 RB6-2

O

RBS10

B

G2AL

B

CA129-7

CA129-10

B

P

B B

NW**BW

Exterior Lighting: Rear – NAS Trailer Towing Exterior Lighting: Rear – NAS Trailer Towing Fig. 08.6

NAS Trailer Towing Vehicles


LIGHTING MESSAGES

LH TURN

RH TURN


TURN SIGNAL SWITCH

HAZARD SWITCH



REAR FOG LAMPS

SIDE LAMPS



LIGHTING

LIGHTINGCONTROL

RH TURN

LH TURN





CONNECTOR


LH TURN AND STOP

RH TURN AND STOP

TAIL LAMPS

GROUND

TRAILERCONNECTOR

FOG

TURN

TAIL

STOP

REVERSE

LH TAIL LAMPUNIT

FOG

TURN

TAIL

STOP

REVERSE

RH TAIL LAMPUNIT

LH REAR SIDEMARKER LAMP

RH REAR SIDEMARKER LAMP



HIGH-MOUNTSTOP LAMP

* NOTE: T6S2 and circuit to TT3-9 – early production vehicles only.

** NOTE: NW – early production vehicles.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Headlamp Leveling Headlamp Leveling Fig. 08.7

GU

GB

IP17-13

GB

IPS56


IP17-6

BB

G37BL(G36BL)

IP17-14

G

IP17-7

OY

14

22II

GU

GUJBS36F16 20A

F17 20A

OY

GWW

GO

GB

G

OY

OY

JBS37JB129-17IPS47

OYIP17-3

JB84-5 JB84-10

JB85-5 JB85-10

G11AL

B

G10AR

BGW

OY

OY07.1

08.1

08.1

UIP17-2

0123

UJB84-2

UJB85-2

JBS8CA1-1

UCA10-22

U

IP130-17

G

Y20.1

20.1

IP130-2

IP130-3

OWR

Y

IP130-23

IP130-6

B

G37BL

BIPS68IP130-24

31II

I

C

C

DWIP130-5

20.2

WIP130-25

UIP130-11

UYIP130-7

I

WGIP130-10

RIP130-12

JB140-6

JB140-5

JB140-1

HI1-6

HI1-5

HI1-1

UY

WG

R

Y

W

U

UY

WG

R

JB130-17

JB130-1

JB130-22

CA241-3

CA241-2

CA241-1

CA303-3

CA303-2

CA303-1

IP130-19

O

IP130-16

O

IP130-18

O

IP130-15

O

IP130-21

O

IP130-22

O

IP130-20

O

JB84-3

JB84-2

JB84-6

JB84-4

JB85-3

JB85-2

JB85-6

JB85-4

JB130-12

BW BW

JB130-13

BG* WU BG* WU

JB130-14

B B

JB130-15

BG BG

JB130-8

RW RW

JB130-9

RU RU

JB130-10

R R

JB130-11

RG RG

3

1

5

2

R9 4

GBJB129-15

B

O

O

P


HEADLAMP LEVELING

DIP BEAM


AUTOLAMPS

NOTE: IPS56 – Autolamps only.

DIP BEAMRELAY


SERVOAMPLIFIER

LH HEADLAMP UNIT

DIP

DIP

SERVOAMPLIFIER

RH HEADLAMP UNIT

DRIVER-CONTROLLED HEADLAMP LEVELING

FRONT AXLESENSOR

REAR AXLESENSOR


HEADLAMPLEVELING

STEPPER MOTOR

LH HEADLAMP UNIT

HEADLAMPLEVELING

STEPPER MOTOR

RH HEADLAMP UNIT

AUTOMATIC HEADLAMP LEVELING

Headlamp Leveling Vehicles

* NOTE: BG – early production vehicles.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

OY

CA1-2

B

BK BK

CAS8

CA45-3

B

G4AR

CA86-3U

Y20.2

20.2

IP5-19

IP5-18

S

S

O

23 OJB172-5

IP6-1

B

G5AS(G5AR)

OY

CA16-3

OY

CA132-1 CA132-2

RC9-2 RC9-1

OG

OY

FL7-2 FL7-1

OGCAS85

IIP6-22 (LHD)IP6-21 (RHD)

BFL9-1FL9-2

B R RCA15-20 CA1-7


BFR9-1FR9-2

B R RCA20-20 CA1-5

ICA87-15BL6-1BL6-2

B YCA25-14

ICA86-18

BBR6-1BR6-2

B YCA30-14BRS4

B BCA30-3

CAS10B

G15ALG15AR**

BBLS3

B BCA25-3

G4AL

FRS1B B

CA20-2

CAS10B

G15ALG15AR**

FLS1B B

CA15-2

CA86-1

O

IP25-2 IP25-1G5AS

(G37BL)

BIPS66 (LHD)IPS68 (RHD)

B OY

BK

CA36-1

OY

IP27-1 IP27-2

BK

OY

IP26-1 IP26-2

BKCA1-6

OYOGFR6-2 FR6-1

OG

CA21-3

OG

B73

B72

B74

TM6-4TM6-3TMS2

G1AR

CA45-2CAS9B B B

IPS13

B65

B66

RC22-3RC30-3*

RC22-9RC30-1*

RC22-1RC30-2*

RC11-1

RC20-1

RC11-2

BK

BK

BK

OY

OY

B71

B70

RC8-2 RC8-1

B

B

B

B

OY

OY

B68

B69B

RCS1CA36-13CAS10G15AL

G15AR**

BB

08.1

TL10-2

BTL10-3

OY

CAS10B

G15ALG15AR**

FLS1B B

CA15-2 FL3-6

FL3-5

FL3-7

BBB

CA86-16CA16-5

G

BCA86-14CA16-6

U

I

I

G4AL

FRS1B B

CA20-2

BBFR3-6

FR3-5

FR3-7

B

BCA21-5

CA21-6

I

I

CA86-16

G

CA86-14

U

CA86-5

B

G4AL

P

B

IP5-3

B I

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Interior Lighting Interior Lighting Fig. 09.1

NOTE: BLS3 – PoweredRear Windows only.

NOTE: BRS4 – PoweredRear Windows only.

DOOR AJARSWITCH


DOOR AJARSWITCH


DOOR AJARSWITCH

LH REAR DOORLATCH ASSEMBLY

DOOR AJARSWITCH

RH REAR DOORLATCH ASSEMBLY

TRUNKSWITCH

TRUNKLOCK MOTOR

LIGHTING

INTERIORLIGHTINGCONTROL


LH FOOTWELLLAMP

RH FOOTWELLLAMP

MAP LAMP 1

FRONTINTERIOR LAMP

MAP LAMP 2

ROOF CONSOLE

* NOTE: Roof Console withoutPrinted Circuit Board.

REAR INTERIOR LAMP

LH VANITY MIRRORLAMP

RH VANITY MIRRORLAMP

LH DOOR COURTESY LAMP

RH DOOR COURTESY LAMP

TRUNK LAMP

GLOVE BOX LAMP

FRONT EXTERIOR LIGHTING

All Vehicles

REMOTELOCK / UNLOCK

REMOTELOCK / UNLOCK

KEY BARREL(LHD ONLY)

KEY BARREL(RHD ONLY)

SET (LHD)

RESET (LHD)


SET (RHD)

RESET (RHD)


EXTERNAL ANTENNA(JAPAN, S. KOREA)** NOTE: G15AR – early production vehicles.


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Dimmer-Controlled Lighting Dimmer-Controlled Lighting Fig. 09.2

RC22-1RC22-10

BR1-8BR1-4 CAS59

IP17-8

R


19

IP17-6

BB

G37BL(G36BL)

IP17-1

O

YGSW4-4

YGSW4-3

SW3-4

SW5-1

O

B

SWS1

BJB129-14 JB1-24IP34-5 IP34-6SWS2

O

O

B YGO

PWM O

IPS4

O

O

O

O

FL1-14 (LHD)FR1-14 (RHD)


IP29-5IP29-6

IP14-2IP14-3

IP65-1IP65-17

IP70-12IP70-9

IP101-20

IP11-8IP11-21

IP51-5IP51-6

IP42-1IP110-1

O

O

O

O

O

IPS21

O

O

O

BL1-8BL1-4

FR10-8 (LHD)FL10-8 (RHD)

FR10-4 (LHD)FL10-4 (RHD)

O

CAS11

CA1-9

O

O

O

O

O

O

O

O

O

OCA36-4

CA30-11

CA15-16 (LHD)CA20-16 (RHD)

CA25-11

CA20-16 (LHD)CA15-16 (RHD)

BW

BW

FRS1 (LHD)FLS1 (RHD)

B

G4AL(G15AR)

BBCA20-2 (LHD)CA15-2 (RHD)

FLS1 (LHD)FRS1 (RHD)

B

G15AR(G4AL)

BBCA15-2 (LHD)CA20-2 (RHD)

CAS10B

G15ALG15AR*

BBBCA36-13RCS1

G36ALG5AL)

B

G5AR

B

B

G37AL(G36BL)

IP101-15

CAS10B

CAS10B

IPS68B

G37BL

B

G37AR

B

G37BR

B

G37BR

B

IPS68B

G37BL

B

O


BW BWCA15-7 (LHD)CA20-7 (RHD)

CA30-7

CA25-7

BW

BW

O

SW3-3

SW5-2

BIPS65

B

(2.5, 3.0 L)

(2.0 L) BJBS55

G14AL

03.2

SIDE LAMPS


RH REAR DOORSWITCH PACK

LH REAR DOORSWITCH PACK

CASSETTE

IN-CAR ENTERTAINMENTSWITCH ILLUMINATION

CRUISE CONTROLSWITCH ILLUMINATION

STEERING WHEEL

CASSETTE

INSTRUMENT CLUSTER

HAZARD, SEAT HEATERSWITCHES

CIGAR LIGHTER


ROOF CONSOLE

PASSENGER DOORSWITCH PACK

REAR WINDOWISOLATE CIRCUIT

DRIVER DOOR SWITCH PACK

NOTE: CAS10 – RHD only.

NOTE: CAS10 – LHD only.

ECM: GROUND

AIR CONDITIONINGCONTROL MODULE (PANEL)

TELEMATICS DISPLAY

AUDIO UNIT

J GATE

DYNAMIC STABILITY CONTROLSWITCH

All Vehicles


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Variable Assist Steering; Electrochromic Rear View Mirror Variable Assist Steering; Electrochromic Rear View Mirror Fig. 10.1

JB130-3

JB130-2

R

U

IP11-24

GR

G37AL(G36BL)

BIP11-8

42II

G

Y20.1

20.1

IP10-17

IP10-18

C

C

IP11-25

O

IP11-23

IJB145-2

JB145-3

R

U

R

UEM91-1

EM91-2

R

U

CAN

RC5-3

WU* BR

B

GB

RC5-1

RC5-2

ICA36-7

GB08.3

RCS1CA36-13CAS10BBB

G15ALG15AR*

54II

B

P

P

B

VEHICLE SPEED

INSTRUMENT CLUSTER

VARIABLE ASSISTSERVO

REVERSE LAMPS:REVERSE LAMPS ON

(CIRCUIT CONTINUED)

ELECTROCHROMICREAR VIEW

MIRROR

VARIABLE ASSIST STEERING

ELECTROCHROMIC REAR VIEW MIRROR

All Vehicles

* NOTE: G15AR, WU – early production vehicles.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

B

CA16-18 FL5-4

B

N

CA16-16

FL1-3FL1-14

CA270-3

CA270-4

CA16-12

FLS1B

G15ALG15AR*

G15ALG15AR*

FL5-2

YR

FL5-6

WR

FR4-4

N

FR4-2

YR

FR4-6

WR

LH

RH

CA15-2

B

O

O

O

O

N

WR

N

YR

WR

N

YR

WR

N

YR

WR

FLS2

FL1-18

FL1-4

FL1-16

FL1-17

CA16-19CA15-19

CA21-14CA16-14

CA21-13CA16-13

CA21-15CA16-15

GWFL1-15 CA16-14 FL5-4

B

N

FR1-3FR1-14

CA21-12

FRS1B

G4AL

FL5-2

YR

FL5-6

WR

FR4-4

N

FR4-2

YR

FR4-6

WR

LH

RH

CA20-2

B

O

O

O

O

N

WR

N

YR

WR

N

YR

WR

N

YR

WR

FRS7

FR1-18

FR1-4

FR1-16

FR1-17

CA16-15CA20-19

CA21-18CA21-14

CA16-13CA21-13

CA21-19CA21-15

GUFR1-15

48II

52II

CAS10B

BFL1-14FLS1

B

G15ALG15AR*

CA15-2

B RFL1-11CAS10

B R

64 N

CA270-2

CA270-5 CA270-1

UCAS46 CA21-17

U U

CAS64 CA21-11

W W

CA16-17

U U

CA16-11

W W

FL5-16

FL5-15

FR4-16

FR4-15

B

CA21-16

CA270-4

G15ALG15AR*

RFR1-11

R

64 N

CA270-2

CA270-5

BFR1-14FRS1

B

G4AL

CA20-2

BI

O

O

I

O

OW

CA270-3

CA270-1

UCAS46 CA21-17

U U

CAS64 CA21-11

W W

CA16-17

U U

CA16-11

W W

FL5-16

FL5-15

FR4-16

FR4-15

W

N

YR

WR

N

YR

WR

N

YR

WR

N

YR

WR

U

W

U

W

U

W

U

W

B

P P

B

BB

P PBCAS10

BCAS10

Door Mirrors: Movement, Fold-Back Door Mirrors: Movement, Fold-Back Fig. 10.2

COMMON


LH MIRROR

RH MIRROR

DOOR MIRROR MOVEMENT: LHD

DRIVER DOORSWITCH PACK

FOLD FLATMODULE

LH MIRROR

RH MIRROR

DOOR MIRROR FOLD: LHD

COMMON


LH MIRROR

RH MIRROR

DOOR MIRROR MOVEMENT: RHD

DRIVER DOORSWITCH PACK

FOLD FLATMODULE

LH MIRROR

RH MIRROR

DOOR MIRROR FOLD: RHD

All Vehicles




NOTE: Refer to Figures 06.1 and 06.2 for Mirror Heaters.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Powered Seats: 8-Way Movement Powered Seats: 8-Way Movement Fig. 11.1

B

YBLS1-4

LS5-2

LS5-1

WBYB

LS4-2

LS4-1

WGYG

LS2-2

LS2-1

WRYU

LS6-2

LS6-1

WRYR

WB

YG

WG

YU

WR

YR

WR

LS1-5

LS1-3

LS1-11

LS1-9

LS1-8

LS1-7

LS1-12

LS1-6

OG40

WG

YG

LS16-7

LS16-1

LS16-2

OG43

LS19-3

LS19-1

LS19-2

WBRS1-4

RS5-2

RS5-1

YBWB

RS4-2

RS4-1

YGWG

RS2-2

RS2-1

YUWR

RS6-2

RS6-1

YRWR

YB

WG

YG

WR

YU

WR

YR

RS1-5

RS1-3

RS1-11

RS1-9

RS1-8

RS1-7

RS1-12

RS1-6

OY45

YG

WG

RS16-7

RS16-1

RS16-2

OY48

RS19-3

RS19-1

42 47

BLS1-1

CA65-16

B

B

B

LSS1

B

G15AL(G4AR)

LS16-6

CAS8

BLS16-3

BRS19-2

BRS1-1

CA70-16

B

B

B

RSS1

B

G4AR(G15AL)

RS16-6

CAS8

BRS16-3

B B

P P

NOTE:

40 – Non Heated Seat.42 – Heated Seat.

LH SEAT SWITCH PACK

LH SEAT LUMBAR SWITCH PACKNOTE: LSS1 – Lumbar Vehicles only.


LH SEAT

NOTE:


RH SEAT SWITCH PACK

RH SEAT LUMBAR SWITCH PACK NOTE: RSS1 –Lumbar Vehicles only.


RH SEAT NOTE: Powered Lumbar Circuit and components – Powered Lumbar Seats only.

8-Way Powered Seat Vehicles

LH SEAT MOVEMENT MOTORS RH SEAT MOVEMENT MOTORS

LH SEAT LUMBAR PUMP RH SEAT LUMBAR PUMP

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Powered Seats: 2-Way Movement Powered Seats: 2-Way Movement Fig. 11.2

LS10-1

LS10-2

YGWG

WG

YG

LS16-7

LS16-1

LS16-2

OG42

CA65-16

BB BLSS1

B

G15AL(G4AR)

LS16-6 CAS8

BLS16-3

G4AR(G15AL)

40

RS10-1

RS10-2

WGYG

YG

WG

RS16-7

RS16-1

LS16-2

OY47

CA70-16

BB BRSS1

BRS16-6 CAS8

BRS16-3

45

NOTE:


LH SEAT SWITCH PACKNOTE: CAS8 – RHD only.

NOTE:


RH SEAT SWITCH PACK


RH SEATLH SEAT

2-Way Powered Seat Vehicles

LH SEAT MOVEMENT MOTOR RH SEAT MOVEMENT MOTOR

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Seat Heaters Seat Heaters Fig. 11.3

IP51-2 CA240-7

IP51-5

B

W W

IPS65

G36AL(G5AR)

LS13-6

O

OG

GBLS13-12

LS13-5

LS13-1

BLS7-4

N

CA65-10

W

IP51-3 CA240-1

R RCA65-17

R

IP51-1 CA240-6

U UCA65-10

U

41

27II

LS13-8

I

LS13-7

I

LS13-10

O

LS13-9

O

LS7-3

W

GB

B

LS13-3

I

LS13-4

O

IP56-2 CA240-4

IP51-5

B

W WRS13-6

O

OY

GBRS13-12

RS13-5

CA70-10

W

IP56-3 CA240-5

R RCA70-17

R

IP56-1 CA240-3

U UCA70-18

U

46

26II

RS13-8

I

RS13-7

I

RS13-10

O

RS13-9

O

RS13-3

I

RS13-4

O

B

40

LS7-1

LS7-2

LSS1 CA65-16 CAS8B B B

G15AL(G4AR)

RS13-1

BRSS1 CA70-16 CAS8

B B B

G4AR(G15AL)

RS7-4

W

RS7-3

N

GW

B

RS7-1

RS7-2

B

45

IPS65

G36AL(G5AR)

B

B

P

P

B

B

LH SEAT


STATE

SWITCH

LH SEATHEATER

NOTE:

40 – Heaters only Seat.41 – Powered Heated Seats.

LH SEAT HEATERMODULE

NOTE: LSS1 – 8-way; 2-way; Lumbar only.


TEMPERATURE SENSOR

LH CUSHION HEATER

LH SEAT BACK HEATER

RH SEAT


STATE

RH SEAT HEATERSWITCH

NOTE:

45 – Heaters only Seat.46 – Powered Heated Seats.

RH SEAT HEATERMODULE

NOTE: RSS1 – 8-way; 2-way; Lumbar only.


TEMPERATURE SENSOR

RH CUSHION HEATER

RH SEAT BACK HEATER

Heated Seat Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

U B

BCA1-4

CA45-2

IP5-5 (LHD)IP5-1 (RHD)

TM8-2TM8-1

TMS2

U

G1AR

U

Y20.2

20.2

IP5-19

IP5-18

S

S

22 OYJB172-1

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

IIP6-22 (LHD)

1P6-21 (RHD)

BFL9-1FL9-2

B R RCA15-20 CA1-7

ICA87-15 BL6-1 BL6-2

BYCA25-14 CAS10

B

G15ALG15AR*

BBLS3

BBCA25-3

CAS10B

G15ALG15AR*

B

FLS1B B

CA15-2

R

IP18-5

IP18-4

I

II

III

4

BIP6-8

I


R RCA20-20 CA1-5

G4AL

FRS1B B

CA20-2

ICA86-18 BR6-1 BR6-2

BYCA30-14 CAS8

B

G4AR

BBRS4

BBCA30-3

B BCAS9

B

CA45-6

BOTM6-3TM6-1

NTM6-5

NCA45-5

OCA45-4

UCA1-11

CA87-2

O

I

ICA86-22

IP5-16

O

BBR3-2

WB

CA30-8

CA87-5

BBL3-2CA25-8

CAS79

BBL3-1

BBL3-3

BBR3-1

BBR3-3

CA25-9

CA25-10

CA30-10

CA30-9

WB

WB

YB

YB

YB

YB

B

FL3-6

FL3-2

FL3-1

FL3-3

FL3-8

FL3-4

FL3-5

FL3-7

BB

OCA16-20

WG WG

BCA86-16CA16-5

G

BCA86-14CA16-6

U

I

I

I

I

CA86-19

O

CA87-16

WCAS74

CAS73BCA16-9

BCA16-8

O

W

BCA16-7

BCA16-10 CA87-3

OYB

CA86-4

OYBCAS2

CAS1

YB

YB

B

BFR9-1FR9-2

BB

FR3-6

FR3-8

FR3-4

FR3-5

FR3-7

BB B

B

B

B

B

B

FR3-3

FR3-1

FR3-2

CA21-7

CA21-5

CA21-6

CA21-9

CA21-8

CA21-20

CA21-10

CA1-8

YB

O

W

WB

YB

O

I

I


WB

CA86-16

G

CA86-14

U

IP5-3

B

TL10-6

U

TL10-5

TL10-4

WTM6-2TMS3

TL10-2

BO

N

GOIP18-1 IP132-1

IP132-3

GU

IP132-2

IPS45

GOGR

01.4

IP10-13

U

Y20.2

20.2

IP10-22

IP10-23

S

S

SCP

IP11-7

O

G37AL(G36BL)

B

61 IP11-8B

P

B

I

P

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Central Door Locking: Double Locking Central Door Locking: Double Locking Fig. 12.1

IGNITION SWITCHEDPOWER SUPPLY

KEY-IN

IGNITION SWITCH

INERTIA SWITCH

DOOR AJARSWITCH

ACTUATORSWITCHES

LOCK

UNLOCK

SET (LHD)

RESET (LHD)


ACTUATORSWITCHES

LOCK

UNLOCK

SET (RHD)

RESET (RHD)

DOOR AJARSWITCH


NOTE: Set / Reset Switch in Front Door Latch Assemblies –LHD: LH Front Latch only, RHD: RH Front Latch only.

NOTE: Drive-Away Door Locking occurs whenall doors are closed, the Ignition is switched toII or III and the vehicle speed exceeds 7 k/ph (4 mph).

VEHICLE SPEED;EMERGENCY UNLOCK

VEHICLEIMPACT

INSTRUMENT CLUSTER

LOCKING

LOCK /UNLOCK

REMOTELOCK / UNLOCK

UNLOCK

LOCK

DOUBLE LOCK

(KEY BARRELLHD ONLY)

UNLOCK

(KEY BARRELRHD ONLY)


NOT CONNECTED

TRUNK RELEASESWITCH

TRUNK AJARSWITCH

TRUNK LOCKMOTOR

DOOR AJARSWITCH

ACTUATORSWITCHES


ACTUATORSWITCHES

DOOR AJARSWITCH


NOTE: BLS3 – Powered Rear Windows only.

NOTE: BRS4 – Powered Rear Windows only.

Double Locking Vehicles

UNLOCK


LOCKINGCONTROL

REMOTELOCK / UNLOCK



VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

BCA1-4 IP5-5 (LHD)

IP5-1 (RHD)

U

Y20.2

20.2

IP5-19

IP5-18

S

S

22 OYJB172-1

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

IIP6-22 (LHD)

1P6-21 (RHD)

BFL9-1FL9-2

B R RCA15-20 CA1-7

ICA87-15 BL6-1 BL6-2

BYCA25-14 CAS10

BBBLS3

BBCA25-3

CAS10B

B

FLS1B B

CA15-2


R RCA20-20 CA1-5

G4AL

FRS1B B

CA20-2

ICA86-18 BR6-1 BR6-2

BYCA30-14 CAS8

B

G4AR

BBRS4

BBCA30-3

N

O

U

CA87-2

O

I

ICA86-22

IP5-16

O

BBR3-2

WB

CA30-8

CA87-5

BBL3-2CA25-8

CAS79

BBL3-1

BBR3-1

CA25-9

CA30-9

WB

WB

YB

YB

FL3-6

FL3-2

FL3-1

FL3-8

FL3-4

FL3-5

FL3-7

B

OCA16-20

WG WG

BCA86-16CA16-5

G

BCA86-14CA16-6

U

I

I

I

I

CA86-19

O

CA87-16

WCAS74

CAS73BCA16-9

BCA16-8

O

W

BCA16-10 CA87-3

OYBCAS1YB

BFR9-1FR9-2

BB

FR3-6

FR3-8

FR3-4

FR3-5

FR3-7

BB B

B

B

B

B

BFR3-1

FR3-2

CA21-5

CA21-6

CA21-9

CA21-8

CA21-20

CA21-10

CA1-8

O

W

WB

YB

O

I

I


WB

CA86-16G

CA86-14U

IP5-3

B

U B

CA45-2

TM8-2TM8-1

TMS2

U

G1AR

B BCAS9

B

CA45-6

BOTM6-3TM6-1

NTM6-5CA45-5

CA45-4

TL10-6

U

TL10-5

TL10-4

WTM6-2TMS3

TL10-2

B

CA1-11

O

N

R

IP18-5

IP18-4

I

II

III

4

BIP6-8

IB

GOIP18-1 IP132-1

IP132-3

GU

IP132-2

IPS45

GOGR

01.4

IP10-13

U

Y20.2

20.2

IP10-22

IP10-23

S

S

SCP

IP11-7O

G37AL(G36BL)

B

61IP11-8

B

P

B

I

P

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

G15ALG15AR*

G15ALG15AR*

Central Door Locking: Non Double Locking Central Door Locking: Non Double Locking Fig. 12.2

IGNITION SWITCHEDPOWER SUPPLY

KEY-IN

IGNITION SWITCH

INERTIA SWITCH

DOOR AJARSWITCH

LOCK

UNLOCK

SET (LHD)

RESET (LHD)


LOCK

UNLOCK

SET (LHD)

RESET (LHD)

DOOR AJARSWITCH


NOTE: Set / Reset Switch in Front Door Latch Assemblies –LHD: LH Front Latch only, RHD: RH Front Latch only.

NOTE: Drive-Away Door Locking occurs whenall doors are closed, the Ignition is switched toII or III and the vehicle speed exceeds 7 k/ph (4 mph).

VEHICLE SPEED;EMERGENCY UNLOCK

VEHICLEIMPACT

INSTRUMENT CLUSTER

LOCKING

LOCK /UNLOCK

REMOTELOCK / UNLOCK

UNLOCK

LOCK

(KEY BARRELLHD ONLY)

UNLOCK

(KEY BARRELRHD ONLY)


NOT CONNECTED

TRUNK RELEASESWITCH

TRUNK AJARSWITCH

TRUNK LOCKMOTOR

DOOR AJARSWITCH


DOOR AJARSWITCH


NOTE: BLS3 – Powered Rear Windows only.

NOTE: BRS4 – Powered Rear Windows only.

Non Double Locking Vehicles


UNLOCK

REMOTELOCK / UNLOCK

LOCKINGCONTROL



VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

B BJB81-1JB81-2

JBS56

JBS55B

G14AL

CA86-1723 OJB172-5

U

Y20.2

20.2

IP5-19

IP5-18

S

S

22 OYJB172-1

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

OTM6-1

NTM6-5

NCA45-5

OCA45-4 CA87-2

ICA86-22

CAS8B

G4AR


BFL9-1FL9-2

B R RCA15-20 CA1-7


BFR9-1FR9-2

B R RCA20-20 CA1-5

ICA87-15BL6-1BL6-2

B YCA25-14

ICA86-18

BBR6-1BR6-2

B YCA30-14BRS4

B BCA30-3

CAS10B

G15ALG15AR**

BBLS3

B BCA25-3

G4AL

FRS1B B

CA20-2

CAS10B

G15ALG15AR**

FLS1B B

CA15-2

BTM6-3TMS2

G1AR

CA45-2CAS9B B B

IJB172-21

IP11-7

O

OIP10-4IP15-4

S

SIP10-23

IP10-2220.2

20.2U

Y

WGIP10-3IP15-3

IP10-5IP15-2

IP15-1

G

IP11-8

G37AL(G36BL)

D

D

B

GIP10-6

IP11-11

GR

61

15II

B

G

Y20.1

20.1

IP10-17

IP10-18

C

C

WJB79-3

B

G11AR

O

UJB79-6

UJB79-4

JB79-5

UJB172-18

63

CA87-1

BSL2-1

24

OYJB87-2

JB87-1

B

G11AR

B

OY

OY

OY

SL1-1

JB79-1

JB79-5

B

B

B

G11AR

5

2

3

1

R34

B

JBS32OY

JB129-6

BOIP5-14

O

O

IP65-8

R

CA190-4

G

CA190-6

Y

RC22-6RC33-1*

Y

RC22-7RC33-4*

W

IP6-10

I

B

G1AR

CAS9

CA86-20

I

YCAS83

YCA36-11

CA36-10CA86-23

I W

CA190-5

B

RC22-1RC33-2*

BRCS1

BCAS10

BBCA36-13

G15ALG15AR**

JBS56B

BCA170-12

20II

JBS56B

D

JB172-4

OYO

JB172-3

OO

08.208.1

08.208.1

WDRC22-8RC33-3*

20.2

IP5-3

B

IP29-1IP10-2

OYOIP29-5

B

G37BL

BIPS68

WTM6-2TMS3

BTL10-2

TL10-5

N

OTL10-4

B

B

P

EN16-123EN65-88 (2.0L)

EN16-124EN65-89 (2.0L)

Y

GC

C

20.1

20.1

BIP6-8

I

R

IP18-5

IP18-4

I

II

III

4

B

I

B

B

O

P

IP65-1

B

G37AR

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Security System Security System Fig. 12.3


PASSIVEANTI-THEFT

SYSTEM

PATSPOWER

PATSGROUND

INSTRUMENT CLUSTER

SECURITY INDICATOR

DOOR AJARSWITCH


DOOR AJARSWITCH


NOTE: BLS3 – PoweredRear Windows only.

DOOR AJARSWITCH


NOTE: BRS4 – PoweredRear Windows only.

DOOR AJARSWITCH


TRUNK AJARSWITCH

NOT CONNECTED

TRUNK LOCKMOTOR

HOOD SECURITYSWITCH

POWER

SECURITYCONTROL

REMOTESECURITY


INCLINATION SENSOR

* NOTE: Roof Console withoutPrinted Circuit Board.

INTRUSIONSENSOR

ROOF CONSOLE

RADIOREMOVED

AUDIO UNIT

SERIAL COMMUNICATION

HORNS

TURN SIGNAL FLASH

HORN RELAY


PASSIVESECURITY SOUNDER

ACTIVESECURITY SOUNDER

NOTE: Check market specification and/or vehicle option specificationfor fitment of the following Security Components:

INCLINATION SENSORINTRUSION SENSORPASSIVE SECURITY SOUNDERACTIVE SECURITY SOUNDER

All Vehicles

NOTE: ECM power supplies andgrounds shown on Fig. 03.1or 03.3.


KEY-IN

IGNITION SWITCH

REMOTESECURITY




VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

IP16-4 IP5-21

WG WGJB129-8

WGJBS19

GW

JB172-23

O

22 OY

23 OJB172-1

JB172-5

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

IP6-5

GR I

IP5-4

GU I

IP6-4

W I

GU

JB172-2

WB


IP16-6

IP16-3

BB

62II

59II

61II

IP16-2

GRIPS22

IP16-8

WBJB3-3

WB

IP16-1

GU

IP16-10

W

IP16-7

WBJB3-13

WB

IP16-9

WGJB3-7

WG

O

I

OJB109-2JB109-1

JB63-5

JB63-2

G14AR

BJB65-2JB65-1

WB

JB63-1

JB63-3

JB63-4

B

GR

WG

WB

JBS26

GRJB129-7*JB3-11

GR 43II

GR

WG

WB

GR

5

2

R1

1

3

4

WB

61II

OYU

GU

27

GU

OY3

2

R5

1

5

4

E96

BJBS54

G10AL

JB130-19

WG

G37BL(G36BL)

B

B

U

Y20.2

20.2

IP5-19

IP5-18

S

SSCP

P

GW

F19 15AJB35-33 JB35-34

GW 63II

(1)

(2)

Wash / Wipe System Wash / Wipe System Fig. 13.1

FLICK WIPE

WASHER

FAST WIPE

INTERMITTENTWIPE

INTERMITTENT SELECT

WIPER PARK

SLOW WIPE

WIPER SWITCH ASSEMBLY

WASH / WIPECONTROL


POWER WASH PUMPRELAY


POWER WASHPUMP

RUN

PARK

HIGH SPEED

LOW SPEED

WIPER MOTOR ASSEMBLY

WINDSHIELDWIPER MOTOR

RELAY


WINDSHIELD WASHERPUMP

Non Rain Sensing Vehicles

SIDE LAMPS STATUS

NOTE: Headlamp Power Wash enabled when Side Lamps On.

* NOTE: JB129-7 – early production vehicles.NOTATION:

(1) Later production vehicles.(2) Early Production vehicles.

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

IP16-4 IP5-21

WG WGJB129-8

WGJBS19

GW

JB172-23

O

22 OY

23 OJB172-1

JB172-5

IP6-1

B

G5AS(G5AR)

CA86-5

B

G4AL

IP6-5

GR I

IP5-4

GU I

IP6-4

W I

GU

JB172-2

WB


IP16-6

IP16-3

BB

62II

59II

61II

IP16-2

GRIPS22

IP16-8

WBJB3-3

WB

IP16-1

GU

IP16-10

W

IP16-7

WBJB3-13

WB

IP16-9

WGCA230-15

WG

O

I

JB63-5

JB63-2

G14AR

BJB65-2JB65-1

WB

JB63-1

JB63-3

JB63-4

B

GR

WG

WB

JBS26

GR

WG

WB

GR

5

2

R1

1

3

4

WB

60II

OYU

GU

27

GU

OY3

2

R5

1

5

4

E96

BJBS54

G10AL

JB130-19

WG

CA6-1

O

O

U

CA6-6

CA6-8

CA6-12

B

G15ARG15AL**

IWCA6-10

GCA6-9

RC15-3

O

RC15-2

RC15-1

CA35-3

CA35-2

CA35-1

U

W

G

ICA6-7

ICA6-4

ICA6-11

ICA6-5

CA6-3

O

CA6-2

O

WG** WR

WB

GU

WB

GR

CA10-10

IPS23

CA241-5

GU

CA10-21

WB

WG

CA10-1

WG

JBS40

CA10-9

WB

CA241-6

GR

G37BL(G36BL)

U

Y20.2

20.2

IP5-19

IP5-18

S

SSCP

B

B

P

P

B

OJB109-2JB109-1

GRJB129-7*JB3-11

GR 43II

GW

F19 15AJB35-33 JB35-34

GW 63II

O

(1)

(2)JBS48

OCA10-3

Wash / Wipe System with Rain Sensing Wash / Wipe System with Rain Sensing Fig. 13.2

FLICK WIPE

WASHER

FAST WIPE

INTERMITTENTWIPE

INTERMITTENT SELECT

WIPER PARK

SLOW WIPE

WIPER SWITCH ASSEMBLY

RAIN SENSOR

POWER

GROUND

WASH / WIPECONTROL

RAIN SENSINGCONTROL MODULE


POWER WASH PUMPRELAY


POWER WASHPUMP

RUN

PARK

HIGH SPEED

LOW SPEED

WIPER MOTOR ASSEMBLY

WINDSHIELDWIPER MOTOR

RELAY


NOTATION:

(1) Later production vehicles.(2) Early Production vehicles.

Rain Sensing Vehicles

SIDE LAMPS STATUS

NOTE: Headlamp Power Wash enabled when Side Lamps On.

** NOTE: WG, G15AL – early production vehicles.

* NOTE: JB129-7 – early production vehicles.WINDSHIELD WASHER

PUMP

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

UCA15-3

FL2-8

FL2-7

B

OY

BLS1

BLS2

BRS1

CA87-17O

22 OYJB172-1

IP6-1

B

G5AS(G5AR)

FL1-5

BW

FL1-14

B

G15ALG15AR**

CAS10 CA15-2 FLS1

BBBFL1-2

YFL1-1

RFL1-10

YBFL1-9

RWFL1-20

OFL1-19

WFL1-13

GFL1-12

U

FL1-15

GW52II

GCA15-4

WCA15-5

OCA15-6

RWCA15-13

YBCA15-14

RCA15-11

YCA15-12

BWCA15-7

WG

FR10-8

B

G4AL

CA20-2 FRS1

BB

FR10-7

OFR10-3

W

BL1-7

YBL1-3

R

BL1-8

BW BWCA25-7

BR1-7

YBR1-3

R

BR1-8

BW BWCA30-7

FL2-2

GW

FL2-6

WG

FL2-4

U

FL2-3

G

FR2-8

FR2-7

B

OY

FR2-2

GU

FR2-6

WG

FR2-4

W

FR2-3

O

BL2-8

BL2-7

B

OY

BL2-2

GW

BL2-6

WG

BL2-4

R

BL2-3

Y

BR2-8

BR2-7

B

OY

BR2-2

GU

BR2-6

WG

BR2-4

R

BR2-3

Y

CAS59

WG

WG

36

45II

49II

38

CA30-6

CA25-6

CA20-10

WG

39

46II

CA15-10CAS22

WG

37

51II

B B BFLS1 CA15-2 CAS10

G15ALG15AR**

CA30-2

BRS2

FRS2

FRS3

CA30-1

CA25-2

CA25-1

CA20-6

CA20-5

CA15-15

CA15-1

U

G

W

O

R

Y

R

Y

B BFRS1 CA20-2

G4AL

B B BBLS3 CA25-3 CAS10

G15ALG15AR**

B B BBRS4 CA30-3 CAS8

G4AR

O

WG 14.3

CAS10B

G15ALG15AR**

FLS1B B

CA15-2 FL3-6

FL3-5

FL3-7

BB

CA86-16CA16-5

G I

IP5-3

B I

B

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Powered Windows: LHD Powered Windows: LHD Fig. 14.1

KEY BARRELSWITCH

LH FRONT DOORLATCH

REARWINDOWSISOLATE

CONTROL

ASSEMBLY

REAR WINDOWISOLATE

LH FRONTWINDOW

RH FRONTWINDOW

LH REARWINDOW

RH REARWINDOW





* NOTE: Remote Global Close –ROW vehicles only.

GLOBALCLOSE

GLOBALCLOSE


SLIDING ROOF

MOTORCONTROL

RELAY

POSITIONSENSORS

LH FRONT WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

RH FRONT WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

LH REAR WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

RH REAR WINDOW MOTOR ASSEMBLY

LHD Vehicles

NOTE: Vehicles with Manual Rear Windows –Rear Window Switches, Motors and associated wiring deleted.

REMOTEGLOBAL CLOSE*

REMOTEGLOBAL CLOSE*



SET



VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

WCA20-5

FL2-8

FL2-7

B

OY

BLS1

BLS2

BRS1

FR1-5

BW

FL10-8

B

G15ALG15AR*

CAS10 CA15-2 FLS1

BBB

FR1-2

YFR1-1

RFR1-10

YBFR1-9

RWFR1-13

GFR1-12

UFR1-20

OFR1-19

W

FR1-15

GU47II

OCA20-6

UCA20-3

GCA20-4

RWCA20-13

YBCA20-14

RCA20-11

YCA20-12

BWCA20-7

FR1-14

B

G4AL

CA20-2 FRS1

BB

FL10-7

OFL10-3

W

BL1-7

YBL1-3

R

BL1-8

BW BWCA25-7

BR1-7

YBR1-3

R

BR1-8

BW BWCA30-7

FL2-2

GU

FL2-6

WG

FR2-4

U

FR2-3

GFR2-8

FR2-7

B

OY

FR2-2

GW

FR2-6

WG

FL2-4

W

FL2-3

O

BL2-8

BL2-7

B

OY

BL2-2

GW

BL2-6

WG

BL2-4

R

BL2-3

Y

BR2-8

BR2-7

B

OY

BR2-2

GU

BR2-6

WG

BR2-4

R

BR2-3

Y

CAS59

WG

WG

36

45II

49II

38

CA30-6

CA25-6

CA20-10

WGCA15-10

CAS22WG

37

50II

B B BFLS1 CA15-2 CAS10

G15ALG15AR*

CA30-2

BRS2

FLS11

FLS10

CA30-1

CA25-2

CA25-1

CA15-6

CA15-5

CA20-15

CA20-1

U

G

W

O

R

Y

R

Y

B BFRS1 CA20-2

G4AL

B B BBLS3 CA25-3 CAS10

G15ALG15AR*

B B BBRS4 CA30-3 CAS8

G4AR

O

48II

39

WG 14.3

CA87-17O

22 OYJB172-1

IP6-1

B

WG

G4AL

FRS1B B

CA20-2 FR3-6

FR3-5

FR3-7

BB

CA86-16CA21-5

G I

G5AS(G5AR)

IP5-3

B I

B

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Powered Windows: RHD Powered Windows: RHD Fig. 14.2

KEY BARRELSWITCH


REARWINDOWSISOLATE

CONTROL

REAR WINDOWISOLATE

RH FRONTWINDOW

LH FRONTWINDOW

LH REARWINDOW

RH REARWINDOW

DRIVERDOOR

SWITCH PACK




REMOTEGLOBAL CLOSE

GLOBALCLOSE

GLOBALCLOSE


SLIDING ROOF

MOTORCONTROL

RELAY

POSITIONSENSORS

RH FRONT WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

LH FRONT WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

LH REAR WINDOW MOTOR ASSEMBLY

MOTORCONTROL

RELAY

POSITIONSENSORS

RH REAR WINDOW MOTOR ASSEMBLY

NOTE: Vehicles with Manual Rear Windows –Rear Window Switches, Motors and associated wiring deleted.

RHD Vehicles


REMOTEGLOBAL CLOSE


SET



VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

CA87-20

O

RC14-2

I

RC14-9

O WU

CA87-17

O

22 OYJB172-1

IP6-1

B

G5AS(G5AR)

WGCAS22

WGWGWG

U

Y20.2

20.2

IP5-19

IP5-18

S

S

U

WG

WGCA36-6

WG

UCA36-2

14.2 14.1

RC14-6

RC14-7

WURC14-1

O

I

59

53II

G15ALG15AR***

BRC14-10

B B BRCS1 CAS10CA36-13

RC22-5RC34-2*

RC22-4RC34-5*

RC22-1RC34-6*

B

RC14-8

O Y

CAS10B

G15ALG15AR***

FLS1B B

CA15-2 FL3-6

FL3-5

FL3-7

BB

CA86-16CA16-5

G I

G4AL

FRS1B B

CA20-2 FR3-6

FR3-5

FR3-7

BB

CA86-16CA21-5

G I

SCP

IP5-3

B I

B

P

B

B

CA416-1

W

CA416-2

BRD

W

BRDCA417-1

CA417-2

I

Sliding Roof Sliding Roof Fig. 14.3

WINDOW CLOSE

VEHICLESPEED

SET / LOCK (LHD)

KEY BARRELSWITCH


SET / LOCK (RHD)

KEY BARRELSWITCH


GLOBALCLOSE

VEHICLESPEED

REMOTEGLOBAL CLOSE **

GLOBALCLOSE (LHD)

GLOBALCLOSE (RHD)


OPEN / DOWN

TILT / CLOSE

SLIDING ROOFCONTROL MODULE

* NOTE: Roof Console without Printed Circuit Board.

SLIDING ROOFMOTOR ASSEMBLY

ROOF CONSOLE

Sliding Roof Vehicles


**NOTE: Remote Global Close –ROW vehicles only.

REMOTEGLOBAL CLOSE **

*** NOTE: G15AR – early production vehicles.


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

In-Car Entertainment: Standard Fig. 15.1In-Car Entertainment: Standard

YG

W

Y

W

Y

ID1-1

BOF

ID1-2

BOF

IP65-1

B

AM

U

Y20.2

20.2

IP65-9

IP65-10

S

S

YG

NW58IP65-11

IP65-2

OIP65-17

I

SW4-2

SW4-3

03.2 YG

UY

YG

JB1-24

IIP65-18

FL6-2

FL6-1

BL4-2

BL4-1

FR5-1

FR5-2

BR4-1

BR4-2

IP106-J1 CA117-1CA189-1

IP65-8

R O

+–

SW3-2

SW3-3

B

UY

BSWS1

IP106-J2 CA117-2CA189-2

YGJB129-14

IP34-6

IP34-7

5I

12.3

CD2-1

BOF

CD2-2

BOF

D2

D2

20.3

20.3

09.2

G37AR

CA115-2

6I

CA183-2

FMCA183-1

YIP65-7

I16.1

IP65-19

O O20.3

BCA301-1

G1AL

OYCA301-2

55D2

D2

20.3

20.3

IP65-14

W

IP65-13

Y

IP65-3

WU

IP65-4

YU

IP65-5

WG

IP65-6

YR

IP65-16

WR

IP65-15

YR

CA16-2

CA16-1

CA230-6

CA230-5

WU

YU

WU

YUCA25-13

CA25-12

CA230-8

CA230-7

WG

YR

WG

YRCA30-13

CA30-12

CA230-10

CA230-9

WR

YR

WR

YRCA21-2

CA21-1

CA230-12

CA230-11D2B

57

CA301-3

O I20.3

16.216.316.4

B

B

P

P

P

B

B

P

I

O

O

O

O

O

O

O

O

B

(2.5, 3.0 L)

(2.0 L)BJBS55

G14AL

RADIO ILLUMINATION

SECURITY SYSTEM:RADIO REMOVED SENSING

TELEPHONE:MUTE

D2B NETWORK:“WAKE-UP”

PHONE;VOICE

VOLUME SEEK MODE

CASSETTE

AUDIO CONTROL SWITCHES

STEERING WHEEL

CASSETTE

ECM: GROUND

NOTE:

55 – Navigation vehicles.57 – Non Navigation vehicles.

D2B NETWORK“WAKE-UP”

CD AUTOCHANGER AUDIO UNIT

COAXIAL CABLE

ANTENNAMODULE

COAXIAL CABLES

HEATED REAR WINDOW

LH FRONTSPEAKER

LH REARSPEAKER

RH FRONTSPEAKER

RH REARSPEAKER

Standard ICE Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

In-Car Entertainment: Premium In-Car Entertainment: Premium Fig. 15.2

YG

W

Y

W

Y

ID1-1

BOF

ID1-2

BOF

IP65-1

B

AM

U

Y20.2

20.2

IP65-9

IP65-10

S

S

YG

NW58IP65-11

IP65-2

OIP65-17

I

SW4-2

SW4-3

UY

YG

IIP65-18

FL6-2

FL6-1

BL5-2

BL5-1

FR5-1

FR5-2

BR8-1

BR8-2

IP106-J1 CA117-1CA189-1

IP65-8

R O

+–

SW3-2

SW3-3

B

UY

BSWS1

IP106-J2 CA117-2CA189-2

IP34-6

IP34-7

5I

12.3

CD2-1

BOF

CD2-2

BOF

D2

D2

20.3

20.3

09.2

G37AR

CA115-2

6I

CA183-2

FMCA183-1

YIP65-7

I16.1

IP65-19

O O20.3

BCA301-1

G1AL

OYCA301-2

57D2

D2

20.3

20.3

IP65-14

W

IP65-13

Y

IP65-3

WU

IP65-4

YU

IP65-5

WG

IP65-6

YR

IP65-16

WR

IP65-15

YR

CA16-2

CA16-1

CA230-6

CA230-5

WU

YU

WU

YUCA25-13

CA25-12

CA230-8

CA230-7

WG

YR

WG

YRCA30-13

CA30-12

CA230-10

CA230-9

WR

YR

WR

YRCA21-2

CA21-1

CA230-12

CA230-11

D2B

W

Y

FL8-2

FL8-1

BL4-2

BL4-1

WU

YU

FR8-1

FR8-2

WR

YR

BR4-1

BR4-2

WG

YR

FRS6

FRS5

BRS6

BRS5

BLS6

BLS5

FLS9

FLS8W

Y

WU

YU

WG

YR

WR

YRCAS78

CAS77

CAS56

CAS55

CAS52

CAS51

CAS76

CAS75

CA124-1

B

G2AS

CA124-2

W I

CA124-7

NRCA124-9

YR

CA124-10

WR

CA124-5

YR

CA124-8

WG

CA124-14

YU

CA124-11

WU

CA124-12

Y

CA124-13

W

IP65-12

WOCA230-2

60

+ ve

- ve

+ ve

- ve

+ ve

- ve

+ ve

- ve

55

CA301-3

O I20.3

16.216.316.4

WRYRWGYR

W Y WU YU

B

B

B

P

P P

B

B

P

I

O

O

O

O

O

O

O

O

03.2 YGJB1-24

YGJB129-14

B

(2.5, 3.0 L)

(2.0 L)BJBS55

G14AL

RADIO ILLUMINATION

SECURITY SYSTEM:RADIO REMOVED SENSING

TELEPHONE:MUTE

D2B NETWORK:NETWORK “WAKE-UP”

PHONE;VOICE

VOLUME SEEK MODE


STEERING WHEEL

CASSETTE

CASSETTE

ECM: GROUND

NOTE:

55 – Navigation vehicles.57 – Non Navigation vehicles.

D2B NETWORK“WAKE-UP”

CD AUTOCHANGER

AUDIO UNIT

COAXIAL CABLE

ANTENNAMODULE

COAXIAL CABLES

HEATED REAR WINDOW LH FRONTMID BASSSPEAKER

LH FRONTTWEETER

LH REARMID BASSSPEAKER

LH REARTWEETER

RH FRONTMID BASSSPEAKER

RH FRONTTWEETER

RH REARMID BASSSPEAKER

RH REARTWEETER

SUB WOOFER

Premium ICE Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Telephone System: ROW Telephone System: ROW Fig. 16.1

PP1-4

RU

PH1-31

YB YBCA407-2

PH1-32

O OCA407-3

PH1-16

OG OGCA407-4

PH1-15

YU YUCA407-5

PH11-4

CA35-10

CA35-7

CA35-9

CA35-8

RU

YB

O

OG

YU

PH1-1

BOF

BOF20.320.4CD3-1

CD3-2

NR

Y

PH1-12

PH1-29

PH1-25

B

G39AS

PH1-30

NR I

51

28II

D2

D220.320.4

PH1-23

O20.3 O

PH1-9

B

PHS3

NRPH1-13

52

YGPH1-14

11I

PH1-4

Y O

PH5-1 PH6-1

PH6-2PH5-2

PH3-1

PH3-2

PP1-7

BGPH11-7

BGPH1-26

PP1-8

YUPH11-8

YUPH1-3

PP1-5

YBPH11-5

YBPH1-20

PP1-6

YUPH11-6

YUPH1-22

PP1-2

YGPH11-2

YGPH1-8

PP1-3

YPPH11-3

YRPH1-24

PP1-9

YSPH11-9

YBPH1-7

B

17.1

RC22-15

RC22-16

RC22-18

RC22-17

RC22-1 CAS10B

G15ALG15AR***

BBBCA36-13RCS1

O

O

I

I

PH1-18

PH1-17

CA406-2

CA406-1

CA35-5

CA35-4

G

Y

G

Y

WPH1-11CA406-3CA35-6

BRD BRD

G

Y

RC22-12RC31-2*

RC22-11RC31-1*

BRD W W W W

I

I

I

YNA7-13

YIP65-7

YIP70-10

Y

Y

Y

Y

CA414-8

CAS49CA241-8

CA1-19

CA407-7

NRNRCA241-13 CA407-1

G

Y

RCS6*

RCS7*

PH13-1

PH13-2

PH3-1

PH3-2

B

B

B

B

P

P

I

I

D

D

O

O

I

I

NAVIGATION CONTROL MODULE

AUDIO UNIT

TELEMATICS DISPLAY

MICROPHONE

ROOF CONSOLE * NOTE: Roof Console without Printed Circuit Board.

SUPPLEMENTAL RESTRAINT SYSTEM:AIRBAG DEPLOYED (CIRCUIT CONTINUED)


NOTE: CAS49 – Navigation only.

TELEPHONE

MUTE

JaguarNet **

INFORMATION

ASSIST


COAXIAL CABLE

COAXIAL CABLE

TELEPHONEANTENNA(BUMPER)

TELEPHONEANTENNA

(WITH JaguarNet)

TELEPHONE

COMPUTER

HANDSETRECEIVER

JaguarNetGPS ANTENNA

INFORMATION

ASSIST

ROOF CONSOLE

** NOTE: JaguarNet components, wiring and circuitry – JaguarNet vehicles only.

ROW Vehicles


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Telephone System: NAS Telephone System: NAS Fig. 16.2

PH1-31

YB YBCA407-2

PH1-32

O OCA407-3

PH1-16

OG OGCA407-4

PH1-15

YU YUCA407-5

PH10-3

CA35-10

CA35-7

CA35-9

CA35-8

RU

YB

O

OG

YU

PH1-1

BOF

BOF20.320.4CD3-1

CD3-2

NR

Y

PH1-12

PH1-29

PH1-25

B

G39AS

51

28II

D2

D220.320.4

PH1-23

O20.3 O

PH1-9

B

PHS3

NRPH1-13

52

YGPH1-14

11I

PH5-1 PH6-1

PH6-2PH5-2

PH9-1

PH9-2

PH10-2

BGPH1-26

PH10-8

WGPH1-2

PH10-9

YUPH1-3

PH10-1

YPH1-6

PH10-10

YPH1-5

PH10-7

BOPH1-10

PH10-4

YGPH1-21

B

RC22-15

RC22-16

RC22-18

RC22-17

RC22-1 CAS10B

G15ALG15AR***

BBBCA36-13RCS1

O

O

I

I

PH1-18

PH1-17

CA406-2

CA406-1

CA35-5

CA35-4

G

Y

G

Y

WPH1-11CA406-3CA35-6

BRD BRD

G

Y

RC22-12RC31-2*

RC22-11RC31-1*

BRD W W W WPH10-5

YBPH1-20

PH10-6

YUPH1-22

PH4-1

PH4-2PH1-4

Y O

I

I

I

YNA7-13

YIP65-7

YIP70-10

Y

Y

Y

Y

CA414-8

CAS49CA241-8

CA1-19

CA407-7

PH1-30

NR I17.1 NRNRCA241-13 CA407-1

G

Y

RCS6*

RCS7*

PH9-1

PH9-2

PH12-1

PH12-2

B

B

B

B

P

P

D

D

D

I

I

O

O

O

I

I

I


AUDIO UNIT

TELEMATICS DISPLAY

MICROPHONE

ROOF CONSOLE* NOTE: Roof Console without Printed Circuit Board.



NOTE: CAS49 – Navigation only.

TELEPHONE

MUTE

JaguarNet **

INFORMATION

ASSIST


COAXIAL CABLE

HANDSETRECEIVER

COAXIAL CABLE

COAXIAL CABLE


TELEPHONEANTENNA

(WITH JaguarNet)


INFORMATION

ASSIST

ROOF CONSOLE


NAS Vehicles


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

PH2-1

PP1-4

RU

PH1-31

YB YBCA407-2

PH1-32

O OCA407-3

PH1-16

OG OGCA407-4

PH1-15

YU YUCA407-5

PH11-4

CA35-10

CA35-7

CA35-9

CA35-8

RU

YB

O

OG

YU

PH1-1

BOF

BOF20.320.4CD3-1

CD3-2

NR

Y

PH1-12

PH1-29

PH1-25

B

G39AS

51

28II

D2

D220.320.4

PH1-23

O20.3 O

PH1-9

B

PHS3

NRPH1-13

52

YGPH1-14

11I

PH5-1 PH6-1

PH6-2PH5-2

PH3-1

PH3-2

PP1-7

BGPH11-7

BGPH1-26

PP1-8

YUPH11-8

YUPH1-3

PP1-5

YBPH11-5

YBPH1-20

PP1-6

YUPH11-6

YUPH1-22

PP1-2

YGPH11-2

YGPH1-8

PP1-3

YPPH11-3

YRPH1-24

PP1-9

YSPH11-9

YBPH1-7

B

RC22-15

RC22-16

RC22-18

RC22-17

RC22-1 CAS10B

G15ALG15AR***

BBBCA36-13RCS1

O

O

I

I

PH1-18

PH1-17

CA406-2

CA406-1

CA35-5

CA35-4

G

Y

G

Y

WPH1-11CA406-3CA35-6

BRD BRD

G

Y

RC22-12RC31-2*

RC22-11RC31-1*

BRD W W W WBRD

G

Y

WPH2-2

PH2-12 PH2-13

PH2-3

BOF

BOF20.320.4CD4-1

CD4-2

WRPH2-6

25II

D2

D220.320.4

PH2-14

O20.3 O

NRPH2-22

50

YGPH2-8

10I

D2B

PH2-11

B

B

PH1-4

YO

I

I

I

YNA7-13

YIP65-7

YIP70-10

Y

Y

Y

Y

CA414-8

CAS49 CA241-8

CA1-19

CA407-7

PH1-30

NR I17.1 NRNRCA241-13 CA407-1

ID1-1

BOF

ID1-2

BOF

SW4-2

SW4-3

03.2 YG

UY

YG

JB1-24

IIP65-18

SW3-2

SW3-3

B

UY

BSWS1

YG

JB129-14IP34-6

IP34-7

D2

D2

20.3

20.3

20.4

20.4

G

Y

RCS6*

RCS7*

PH3-1

PH3-2

PH13-1

PH13-2

B

B

B

B

P

P

P

B

B

B

I

I

I

I

I

D

D

O

O

B(2.5, 3.0 L) (2.0 L) BJBS55

G14AL

Telephone System with Voice: ROW Telephone System with Voice: ROW Fig. 16.3

ECM: GROUND

PHONE;VOICE


STEERING WHEEL

AUDIO UNIT

CASSETTE

CASSETTE

MICROPHONE






MUTE

TELEPHONE

JaguarNet **

INFORMATION

ASSIST



COAXIAL CABLE

COAXIAL CABLE

NOTE: CAS49 – Navigation only.NAVIGATION CONTROL MODULE

AUDIO UNIT

TELEMATICS DISPLAY

TELEPHONE ANTENNA(BUMPER)

TELEPHONE ANTENNA(WITH JaguarNet)

TELEPHONE

COMPUTER

HANDSETRECEIVER


INFORMATION

ASSIST

ROOF CONSOLE

NOTE: Japan Vehicles with Voice Activation Control, refer to Fig. 16.7.

ROW Vehicles


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

PH2-1

PH1-31

YB YBCA407-2

PH1-32

O OCA407-3

PH1-16

OG OGCA407-4

PH1-15

YU YUCA407-5

CA35-10

CA35-7

CA35-9

CA35-8

YB

O

OG

YU

BOF

BOF20.320.4CD3-1

CD3-2

NR

Y

PH1-12

PH1-29

PH1-25

B

G39AS

51

28II

D2

D220.320.4

PH1-23

O20.3 O

PH1-9

B

PHS3

NRPH1-13

52

YGPH1-14

11I

PH5-1 PH6-1

PH6-2PH5-2

B

RC22-15

RC22-16

RC22-18

RC22-17

RC22-1 CAS10B

G15ALG15AR***

BBBCA36-13RCS1

O

O

I

I

PH1-18

PH1-17

CA406-2

CA406-1

CA35-5

CA35-4

G

Y

G

Y

WPH1-11CA406-3CA35-6

BRD BRD

G

Y

RC22-12RC31-2*

RC22-11RC31-1*

BRD W W W WBRD

G

Y

WPH2-2

PH2-12 PH2-13

PH2-3

BOF

BOF20.320.4CD4-1

CD4-2

WRPH2-6

25II

D2

D220.320.4

PH2-14

O20.3 O

NRPH2-22

50

YGPH2-8

10I

PH2-11

B

B

PH10-3

RUPH1-1

PH10-2

BGPH1-26

PH10-8

WGPH1-2

PH10-9

YUPH1-3

PH10-1

YPH1-6

PH10-10

YPH1-5

PH10-7

BOPH1-10

PH10-4

YGPH1-21

PH10-5

YBPH1-20

PH10-6

YUPH1-22

PH1-30

NR I17.1 NRNRCA241-13 CA407-1

PH1-4

YO

I

I

I

YNA7-13

YIP65-7

YIP70-10

Y

Y

Y

Y

CA414-8

CAS49 CA241-8

CA1-19

CA407-7

D2B

ID1-1

BOF

ID1-2

BOF

SW4-2

SW4-3

03.2 YG

UY

YG

JB1-24

IIP65-18

SW3-2

SW3-3

B

UY

BSWS1

YGJB129-14

IP34-6

IP34-7

D2

D2

20.3

20.3

20.4

20.4

G

Y

RCS6*

RCS7*

PH9-1

PH9-2

PH4-1

PH4-2

PH9-1

PH9-2

PH12-1

PH12-2

B

B

B

B

P

P

P

B

B

B

D

D

D

I

I

I

I

O

O

O

I

Telephone System with Voice: NAS Telephone System with Voice: NAS Fig. 16.4

ECM: GROUND

PHONE;VOICE


STEERING WHEEL

CASSETTE

CASSETTE

AUDIO UNIT

MICROPHONE






MUTE

TELEPHONE

JaguarNet **

INFORMATION

ASSIST


COAXIAL CABLE


NOTE: CAS49 – Navigation only.NAVIGATION CONTROL MODULE

AUDIO UNIT

TELEMATICS DISPLAY

HANDSETRECEIVER

COAXIAL CABLE

COAXIAL CABLE


TELEPHONEANTENNA

(WITH JaguarNet)


INFORMATION

ASSIST

ROOF CONSOLE

NAS Vehicles


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Voice Control System Voice Control System Fig. 16.5

PH2-1

G1BR

CA406-2

CA406-1

CA35-5

CA35-4

G

Y

WCA406-3CA35-6

BRD

G

Y

RC22-12RC31-2*

RC22-11RC31-1*

BRD W W W BRD

G

Y

WPH2-2

PH2-12

BOF

BOF20.320.4CD4-1

CD4-2

WRPH2-6

25II

D2

D220.320.4

PH2-14

O20.3 O

NRPH2-22

50

YGPH2-8

10I

PH2-11

B

D2B

ID1-1

BOF

ID1-2

BOF

SW4-2

SW4-3

03.2 YG

UY

JB1-24

IIP65-18

SW3-2

SW3-3

B

UY

BSWS1

YG

IP34-6

IP34-7

D2

D2

20.3

20.3

20.4

20.4

G

Y

RCS6*

RCS7*

B

B

B

P

I

I

YGJB129-14

B

(2.5, 3.0 L)

(2.0 L) BJBS55

G14AL

ECM: GROUND

PHONE;VOICE


STEERING WHEEL

CASSETTE

CASSETTE

AUDIO UNIT

MICROPHONE




NOTE: Japan Vehicles with Voice Activation Control, refer to Fig. 16.7.

Voice Only Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

U

Y20.2

20.2

NA7-4

NA7-14

S

S

UUNA1-20

BOF

BOF20.320.4CD5-1

CD5-2

OY

YGNA7-1

NA7-11

B

G40BS

54

D2

D220.320.4

NA7-3

O20.3 O

NA7-13

Y16.116.216.316.4 I

NA7-2

8I

NA6-1 NA12-1

NA12-2NA6-2

GB

YG

IP70-12

B

G37BR

OIP70-9

IP70-2

IP70-1

4I

18

09.2

NA24-2 IP70-15

YYNA1-7 NA24-1 IP70-4

UUNA1-15 NA24-4 IP70-17

GGNA1-2 NA24-3 IP70-7

YYNA1-3 NA24-6 IP70-5

RRNA1-14 NA24-5 IP70-6

BRDWNA1-16 NA24-8 IP70-8

BBNA1-1 NA24-7 IP70-18

W WBRD W

56 B

B

P

P

B

B

I

Navigation System (except Japan) Navigation System (except Japan) Fig. 16.6

NOTE:

54 – Vehicles with Navigation and CD Autochanger.56 – Vehicles with Navigation only.


TELEPHONE: MUTE


COAXIAL CABLE

NAVIGATIONGPS ANTENNA

NAVIGATION SCREENAND

TELEMATICS DISPLAY

DIMMER-CONTROLLEDLIGHTING

NAV Vehicles except Japan

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Navigation System: Japan Navigation System: Japan Fig. 16.7

U

Y20.2

20.2

NA7-4

NA7-14

S

S

U

CA222-1

NA9-6

CA222-2

NA25-1

NA25-2

NA25-7

NA25-8

NA25-3

NA25-4

NA25-5

NA25-6

U

IP136-1

R

NA1-20

BOF

BOF20.320.4CD5-1

CD5-2

OY

YGNA7-1

NA7-11

B

G40BS

NA2-5

54

D2

D220.320.4

NA7-3

O20.3 O

NA7-13

Y16.116.216.316.4 I

NA2-6

NA2-11

CA406-1

CA406-2

CA35-4

CA35-5

Y

G

Y

G

WNA2-12CA406-3CA35-6

BRD BRD

Y

GRC22-12

RC22-11

BRD W W W W

NA7-2NAS4

B

B

8I

NA6-1 NA12-1

NA12-2NA6-2

GB

YG

IP70-12

B

G37BR

OIP70-9

IP70-2

IP70-1

4I

18

09.2

NA24-2 IP70-15

YYNA1-7 NA24-1 IP70-4

UUNA1-15 NA24-4 IP70-17

GGNA1-2 NA24-3 IP70-7

YYNA1-3 NA24-6 IP70-5

RRNA1-14 NA24-5 IP70-6


BBNA1-1 NA24-7 IP70-18

W WBRD W

NR

YGNA9-3

NA9-4

49

7I

56

NA9-5

NA9-1 NA2-4

NA9-2 NA2-10

NA9-7

BRDNA2-9

K

W

RR

BRD

NA10-1

NA10-2

W W

NA11-1

NA11-2

NA8-1

NA8-2

GGNA2-1 NA24-12 IP70-19

RRNA2-2 NA24-14 IP70-21

UUNA2-7 NA24-13 IP70-20


YYNA2-8 NA24-15 IP70-22

W WBRD W

YI 16.1 16.2 16.3 16.4IP70-10

IP136-2

BRD

IP137-1

R

IP137-2

BRD

IP138-1

R

IP138-2

BRD

IP139-1

R

IP139-2

BRD

R

BRD

R

BRD

R

BRD

R

BRD

NA20-1

NA20-2

NA21-1

NA21-2

NA22-1

NA22-2

NA23-1

NA23-2

B

B

PP

B

B

I

I

I

I

B

B

I

I

I

I

P

NOTE:

54 – Vehicles with Navigation and CD Autochanger.56 – Vehicles with Navigation only.


TELEPHONE: MUTE

MICROPHONE

ROOF CONSOLE

VEHICLEINFORMATION

ANTENNAVICS

ANTENNAAMPLIFIER

VEHICLEINFORMATION

SENSOR

VEHICLE INFORMATIONCONTROL MODULE

NOTE: Vehicle Information components and wiring – VICS vehicles only.

NOTE: NAS4 – VICS vehicles only.


COAXIAL CABLE

NAVIGATIONGPS ANTENNA

NAVIGATION SCREEN,TELEVISION SCREEN,

ANDTELEMATICS DISPLAY

DIMMER-CONTROLLEDLIGHTING

TELEPHONE: MUTE

TVANTENNAAMPLIFIER

1

TELEVISIONANTENNA

1

TVANTENNAAMPLIFIER

2

TELEVISIONANTENNA

2

TVANTENNAAMPLIFIER

3

TELEVISIONANTENNA

3

TVANTENNAAMPLIFIER

4

TELEVISIONANTENNA

4

Japan NAV Vehicles

COAXIAL CABLE

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Advanced Restraint System Advanced Restraint System Fig. 17.1

OCA65-14

B

G15ALG15AR*(G4AR)

CA215-2

O

U

WS18-A

WS18-C

WS18-B

WS17-E

IP74-5GIP74-12

IP74-16

B

G37AR

CA165-23

W

18II

IP74-19

U O

U

W

RWS17-H

WS17-J

WS17-K

AL1-1

AL1-2

RW

BW

CA65-5

CA65-6

RW

BW

CA65-7

CA65-8

WR

NW

CA144-1

CA144-2

RW

BW

SW1-1

G

B

IP34-1

SW1-2IP34-2

SW2-1

G

B

IP34-9

SW2-2IP34-10

OGR

07.1

IP74-17

NR O16.116.216.316.4

IP74-22

O O07.2

IP74-11

W20.2 D

CA65-13 CA165-25

B RCA70-14CAS96 (LHD)

CAS97 (RHD)

B

G4AR(G15AL)

(G15AR*)

CA70-13 CA165-26

IP74-15 OIP140-3IP140-1

16II

CA215-1

CA165-27

W

CA165-28

N

CA216-2

CA216-1

CA165-29

W**

CA165-30

N

JB93-2

W

JB93-1

NCA165-19

W

CA165-20

NCA10-5

CA10-4

CA165-24

UCA65-2

CA65-1

OCA165-17

UCA165-18

C

CWS17-F CA70-2

CA70-1

C

C

GRWS17-G

17II

IP74-6

IP74-1

IP74-2

CA165-3

CA165-4

CA165-31

CA165-32

CA165-1

CA165-2

IP74-13

IP37-1

RW

BW

IP37-2

IP36-1

RW

BW

IP36-2

IP74-14

IP74-3

IP74-4

AD1-1

AD1-2

RW

BW

CA70-5

CA70-6

RW

BW

CA70-7

CA70-8

GO

BR

CA145-1

CA145-2

RW

BW

CA165-5

CA165-6

CA165-33

CA165-34

CA165-21

CA165-22

CA165-13

W

CA165-14

NCA140-2

CA140-1

CA165-15

W

CA165-16

NCA131-2

CA131-1

+

–

+

–

G4AR

B B BWS17-D CA70-4 CAS96 (LHD)

CAS97 (RHD)

B

P

B

H

H

H

U

FRONT IMPACTSENSOR

DRIVERSIDE IMPACT

SENSOR

PASSENGERSIDE IMPACT

SENSOR

DRIVERREAR SIDE IMPACT

SENSOR

PASSENGERREAR SIDE IMPACT

SENSOR

DRIVER SEATPOSITION SWITCH

DRIVERSEAT BELT SWITCH

PASSENGERSEAT BELT SWITCH

PASSENGER SEATWEIGHT

PRESSURE SENSORPASSENGER SEATWEIGHT SENSING

CONTROL MODULE

NOTE: The CAN Network connecting the SRS Control Modulesis a local CAN Network. It is not part of Powertrain CAN.

PASSENGER AIRBAGDEACTIVATED

INDICATOR LAMP

STAGEONE


TELEPHONE / VEMS: AIRBAG DEPLOYED(CIRCUIT CONTINUED)

INSTRUMENT CLUSTER: AIRBAG WARNING(CIRCUIT CONTINUED)

GECM: SEAT BELT AUDIBLE WARNING

STAGETWO

STAGETWO

STAGEONE


CASSETTE

CASSETTE

CASSETTE

CASSETTE

DRIVERDUAL AIRBAGIGNITERS

DRIVERCURTAIN AIRBAGIGNITER

DRIVERSIDE AIRBAGIGNITER

DRIVERSEAT BELTPRETENSIONERIGNITER

PASSENGERDUAL AIRBAGIGNITERS

PASSENGERCURTAIN AIRBAGIGNITER

PASSENGERSIDE AIRBAGIGNITER

PASSENGERSEAT BELTPRETENSIONERIGNITER

All Vehicles

** NOTE: W – early production vehicles.


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Parking Aid System Parking Aid System Fig. 18.1

CA129-4

CA129-5

YGRB7-1

G2AR

RB7-3

B

RB7-14

RU

RB7-17

Y

RB3-1

RW

RB3-2

WR

RB3-3

BG

RB7-15

CA136-1

CA136-2

RB4-1

RW

RB4-2

W

RB4-3

BG

RB2-1

RW

RB2-2

WU

RB2-3

BG

RB1-1

RW

RB1-2

WG

RB1-3

BG

RB7-24

RB7-16

RB7-23

RB7-10

RB7-11

GBRB7-9

08.3 I

9I

WRB7-8

I08.408.5

WRB7-5

20.2 D

RU

Y

WR

RW

W

BG

WU

WG

RBS1

RBS2

BCA129-8

08.6

B

P

O

O

+

–

D

D

D

D

REVERSE LAMPS: ACTIVATED(CIRCUIT CONTINUED)

REAR EXTERIOR LIGHTING:TRAILER CONNECTED(CIRCUIT CONTINUED)



PARKING AIDSOUNDER

RHSENSOR

RH CENTERSENSOR

LH CENTERSENSOR

LHSENSOR

Parking Aid Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Ancillaries Ancillaries Fig. 19.1

JBS56

B

24

OYJB87-2

JB87-1

B

G11AR

B

OY

OY

OY5

2

3

1

R34

B

JBS32

OY

JB129-6

B

SW4-6

SW4-5

BG BG

B

IP34-3

IP34-4

SW6-1

SW6-2 IPS67 (LHD)IPS69 (RHD)

B

G37BL(G36BL)

BIP42-2

OYIP42-1 IPS65

B

G36AL(G5AL)

B

IP24-2

IP24-3

IP24-1

G5AS(G5AL)

N

NG1I

29

IPS66

B B

CA146-2

CA146-3

CA146-1

G1AR

N

NG2I

30

CAS9

B RC22-1 RC22-9

B OYB

71BRCS1CA36-13CAS10

G15ALG15AR*

BB

IP5-14

O

22 OYJB172-1

CA86-5

B

G4AL

IP6-20

I BG

OY

OY55II

44

B

P

HORNSWITCH

STEERING WHEEL

CASSETTE

CASSETTE


HORNS

HORN RELAY


HORN

CIGAR LIGHTER


CIGAR LIGHTER

CABINACCESSORYCONNECTOR


TRUNKACCESSORYCONNECTOR

ACCESSORY CONNECTORS GARAGE DOOR OPENER

GARAGE DOOROPENER

ROOF CONSOLE

All Vehicles

PRINTED CIRCUIT BOARD


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

IP22-4

B

IP22-5

B

53

35II

G37BL(G36BL)


G

YIP10-17

IP10-18

+

–

C

C

OY

WR

G

Y

IP22-16

IP22-9

IP22-6

IP22-14

C

C

+

–

B

EN16-124

EN16-123

+

–

C

C

IP101-9

IP101-10

C

C –

+

G

YIP101-22

IP101-23

C

C–

+

G

Y

IP130-2

IP130-3

+

–

C

C

G

YIP20-3

IP20-2

+

–

C

C

G

Y

IP14-9

IP14-10

C

C –

+

G

YIP14-11

IP14-12

C

C–

+

G37AL

JB1-21

JB1-22

Y

G

Y

G

JBS31

JBS30

G

YJB45-24

JB45-40

+

–

C

C

G

YJB184-24

JB185-40

+

–

C

C

(ABS)

(ABS)

(DSC)

(DSC)

G

YJB131-34

JB131-13

C

C –

+

G

YJB131-33

JB131-12

C

C–

+

G

YJB130-18

JB130-16 IPS8

IPS9

G

YIPS11

IPS10

G

YIPS52

IPS51

IPS39

IPS38

G

Y

G

Y

G

YIP19-3

IP19-4

+

–

C

C

G

YIP10-17

IP10-18

+

–

C

C

G

YIP22-6

IP22-14

C

C

+

–

EN16-124

EN16-123

+

–

C

C

IP101-9

IP101-10

C

C –

+

G

YIP101-22

IP101-23

C

C–

+

G

Y

IP130-2

IP130-3

+

–

C

C

G

YIP20-3

IP20-2

+

–

C

C

G

Y

IP14-9

IP14-10

C

C G

YIP14-11

IP14-12

C

C–

+

JB1-21

JB1-22

Y

G

Y

G

Y

G

Y

G

G

Y

G

YJB45-24

JB45-40

+

–

C

C

G

Y

G

YJB184-24

JB185-40

+

–

C

C

(ABS)

(ABS)

(DSC)

(DSC)

G

YJB131-34

JB131-13

C

C –

+

JB131-33

JB131-12

C

C–

+

G

Y

G

YJB130-18

JB130-16 IPS8

IPS9

G

YIPS11

IPS10

G

YIPS52

IPS51

IPS39

IPS38

G

Y

G

Y

G

YIP19-3

IP19-4

+

–

C

C

–

+

P

B

BG

YJB197-24

JB197-40

C

C –

+(ABS/TC)

(ABS/TC)

G

YJB197-24

JB197-40

C

C –

+(ABS/TC)

(ABS/TC)

EN65-89

EN65-88

+

–

C

CJB1-21

JB1-22

Y

G

Y

G

JBS31

JBS30

EN65-89

EN65-88

+

–

C

CJB1-21

JB1-22

Y

G

Y

G

Controller Area Network Controller Area Network Fig. 20.1

DYNAMIC STABILITY CONTROLCONTROL MODULE



(2.5L & 3.0L)


(AUTOMATIC TRANSMISSIONVEHICLES ONLY)

HEADLAMP LEVELINGCONTROL MODULE*

YAW RATE SENSOR**


NOTES:

* Headlamp Leveling Control Module and associated wiring –Automatic Headlamp Leveling vehicles only.

**Yaw Rate Sensor and Steering Angle Sensor and associated wiring –Dynamic Stability Control vehicles only.

STEERING ANGLESENSOR**

J GATE(AUTOMATIC TRANSMISSION

VEHICLES ONLY)

INSTRUMENT CLUSTER

CONTROLLER AREA NETWORK: LHD

DYNAMIC STABILITY CONTROLCONTROL MODULE



(2.5L & 3.0L)


(AUTOMATIC TRANSMISSIONVEHICLES ONLY)

HEADLAMP LEVELINGCONTROL MODULE*

YAW RATE SENSOR**


NOTES:

* Headlamp Leveling Control Module and associated wiring –Automatic Headlamp Leveling vehicles only.

**Yaw Rate Sensor and Steering Angle Sensor and associated wiring –Dynamic Stability Control vehicles only.

STEERING ANGLESENSOR**

J GATE(AUTOMATIC TRANSMISSION

VEHICLES ONLY)

INSTRUMENT CLUSTER

DATA LINKCONNECTOR

CONTROLLER AREA NETWORK: RHD

All Vehicles


(2.0L)



(2.0L)


VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

Standard Corporate Protocol Network; Serial Data Link Standard Corporate Protocol Network; Serial Data Link Fig. 20.2

53

35II

OY

WRIP22-16

IP22-9

WIP22-7

W

WRB7-5

WEN16-105 (2.5, 3.0 L)EN65-39 (2.0 L)

IP130-5

W DD

DRC22-8

RC33-3*

W D

CA129-9 CA230-3

JB1-20 CA230-4

W

W

W

DIP74-11

D

IPS25

IP22-10

UIP22-2

Y

S

S Y

UIP10-22

IP10-23

–

+

S

S Y

UNA7-4

NA7-14

–

+

S

S Y

UIP65-9

IP65-10

–

+

S

S Y

UIP5-19

IP5-18

–

+

U

Y

CA414-7

CA414-6

IPS31

IPS32

Y

UCA241-9

CA241-10

Y

U

S

S

–

+

W

JB130-4 CA36-9

W

W W

IP22-4

B

IP22-5

B

G37BL(G36BL)


B

G37AL

BOF

BOFID1-1

ID1-2

D2

D2

B

B

P

INSTRUMENT CLUSTER


AUDIO UNIT


STANDARD CORPORATE PROTOCOL NETWORK (SCP)

RESTRAINTS CONTROL MODULE

PARKING AID CONTROL MODULE


SERIAL DATA LINK

HEADLAMP LEVELING CONTROL MODULE

* NOTE: Roof Console without Printed Circuit Board. INTRUSION SENSOR

ROOF CONSOLE

DATA LINKCONNECTOR

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

D2B Network: Part 1 D2B Network: Part 1 Fig. 20.3

OIP65-19

PH1-23

O

NA7-3

O

CA241-11

CA407-12

O

CAS45

CA414-5

O

O

CA301-3

OO

PH2-14

O

OPHS5

BOF

BOFID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOFCD1-1

CD1-2

CD6-1

CD6-2

BOF

BOFID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOFCD1-1

CD1-2

CD6-1

CD6-2

BOF

BOFID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOFCD1-1

CD1-2

CD6-1

CD6-2

BOF

BOFID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOFCD1-1

CD1-2

CD6-1

CD6-2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1

CD2-2

D2

D2

CD3-1

CD3-2

D2

D2

CD4-1

CD4-2

D2

D2

CD5-1

CD5-2

D2

D2

CD2-1 CD2-2

BOFD2

D2

CD4-1 CD4-2

D2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1 CD2-2

BOFD2

D2

CD3-1 CD3-2

D2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD3-1 CD3-2

BOFD2

D2

CD4-1 CD4-2

D2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1 CD2-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD3-1 CD3-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD4-1 CD4-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

O

O

O

O

AUDIO UNIT

NOTE: PHS5 – Voice only.



CD AUTOCHANGER


AUDIO UNIT

D2B NETWORK “WAKE-UP”

AUDIO UNIT

AUDIO UNIT

AUDIO UNIT

CD AUTOCHANGER


VOICECONTROL MODULE


TWO-MODULE NETWORKS

AUDIO UNIT

AUDIO UNIT

AUDIO UNIT

CD AUTOCHANGER

CD AUTOCHANGER

CELLULAR PHONE CONTROL MODULE


VOICE CONTROL MODULE


AUDIO UNIT

AUDIO UNIT

AUDIO UNIT

CD AUTOCHANGER






NOTE: Figs. 20.3 and 20.4 show all possible combinations of D2B Networks.THREE-MODULE NETWORKS

All Vehicles

VARIANT:VIN RANGE:

DATE OF ISSUE:


Output



B+

1 13 14 64 12 63 64 74B BII III I


I

O

+

–

C

S

D2

DP1 11 75 96



Power Ground

D2B Network: Part 2 D2B Network: Part 2 Fig. 20.4

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD3-1 CD3-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

CD4-1 CD4-2

BOFD2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1 CD2-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

CD4-1 CD4-2

BOFD2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1 CD2-2

BOFD2

D2

CD5-1 CD5-2

D2

D2

CD3-1 CD3-2

BOFD2

D2

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

CD2-1 CD2-2

BOFD2

D2

D2

D2

BOFD2

D2

BOFD2

D2

CD3-2CD3-1 CD4-2CD4-1 CD5-2CD5-1

BOF

BOF

ID1-1

ID1-2

D2

D2

BOF

BOF

BOF

BOF

CD1-1

CD1-2

CD6-1

CD6-2

DC2-1 CD2-2

BOFD2

D2

CD4-1 CD4-2

D2

D2

CD3-1 CD3-2

BOFD2

D2

AUDIO UNIT

AUDIO UNIT

AUDIO UNIT

AUDIO UNIT

CD AUTOCHANGER

CD AUTOCHANGER


CD AUTOCHANGER









FOUR-MODULE NETWORKS

AUDIO UNIT

CD AUTOCHANGER CELLULAR PHONE CONTROL MODULE VOICE CONTROL MODULE NAVIGATION CONTROL MODULE

FIVE-MODULE NETWORKNOTES:

Figs. 20.3 and 20.4 show all possible combinations of D2B Networks.

Network “Wake-Up” Circuit – refer to Fig. 20.3.

D2B Network Diagnostics – refer to Fig. 20.2.

All Vehicles

Jaguar X-TYPE 2.0L/2.5L/3.0L Appendix

DATE OF ISSUE: December 2001 i

This Appendix contains a listing of CAN and SCP Network messages.

The following acronyms and abbreviations are used throughout this section:

A/C Air ConditioningABS Anti Lock Braking System

ABSCM Anti Lock Braking System Control ModuleABS/TCCM Anti Lock Braking / Traction Control Control Module

A/CCM Air Conditioning Control ModuleACK Acknowledge

AIRCON Climate ControlAT Cmd Commands for configuring and controlling telecommunication devicesAUDIO Audio Unit

BIT Smallest element of data code (1 or 0)BYTE Grouping of 8 bits (one alphanumeric character)

°C Degrees CentigradeCAL CalibrateCAN Controller Area NetworkCID CAN IdentifierCM Control Module

CONFIG ConfigureD2B OPC Instructions for translating and routing data for D2B use

D2B Fibre Optic NetworkDIAG Diagnostics

DSCCM Dynamic Stability Control Control ModuleDTC Diagnostic Trouble CodeECM Engine Control Module

°F Degrees FahrenheitFL Front LeftFR Front Right

Gateway Device that converts messages between different types of networksGECM General Electronic Control ModuleHLCM Headlight Levelling Control Module

IC Instrument ClusterIDB Identification ByteJGM J Gate Module

Lb. Ft. Pound Feet (Measure of Torque)LED Light Emitting Diode

m Meter (length)MIL Malfunction Indicator Lampml Millilitrems Millisecond

MSG MessageNCM Navigation Control Module

Nm Newton Meter (Measure of Torque)OBD On Board Diagnostics

OBD II On Board Diagnostics IIODO Odometer

Oz OuncePATS Passive Anti Theft System

PECUS Programmable Electronic Control Units SystemPOS Positive (+)PTT Push to TalkRCC Climate Control

RL Rear LeftRPM Revolutions Per Minute

RR Rear RightSCP Standard Corporate Protocol NetworkSMS Short Message Service for Mobile CommunicationsSTM Switch to Test ModeSWS Steering Wheel Angle SensorTCM Transmission Control Module

VEMS JaguarNetWDS World Diagnostic SystemYRS Yaw Rate Sensor

ii DATE OF ISSUE: December 2001

Jaguar X-TYPE 2.0L/2.5L/3.0LAppendix

SCP Message Matrix

No.

Mes

sage

Nam

eSo

urc

e

Rec

eive

rs

GEC

MIC

NC

MA

UD

IO

1A

ll he

adla

mp

stat

us: O

FFIC

XX

2A

ll he

adla

mp

stat

us: O

NIC

XX

3A

ll pa

rk la

mp

stat

us: O

FFIC

XX

X

4A

ll pa

rk la

mp

stat

us: O

NIC

XX

X

5A

ll tu

rn la

mp

Com

man

d: O

FFG

ECM

X

6A

ll tu

rn la

mp

Com

man

d: O

NG

ECM

X

7C

ellu

lar

phon

e in

use

: NO

(Fal

se)

AU

DIO

X

8C

ellu

lar

phon

e in

use

: YES

(Tru

e)A

UD

IOX

9Tr

unk

lid a

jar

switc

h: A

CTI

VE

GEC

MX

X

10Tr

unk

lid a

jar

switc

h: IN

AC

TIV

EG

ECM

XX

11D

ispl

ay a

cces

s co

nfir

mat

ion

stat

us: A

CC

EPT

ICX

X

12D

ispl

ay a

cces

s co

nfir

mat

ion

stat

us: R

EJEC

TIC

XX

13D

ispl

ay a

cces

s di

spla

y st

ring

: Cle

ar D

ispl

ayA

UD

IOX

14D

ispl

ay a

cces

s di

spla

y st

ring

: Cle

ar D

ispl

ayN

CM

X

15D

ispl

ay a

cces

s di

spla

y st

ring

: Ove

rwri

te D

ispl

ayA

UD

IOX

16D

ispl

ay a

cces

s di

spla

y st

ring

: Ove

rwri

te D

ispl

ayN

CM

X

17D

ispl

ay a

cces

s te

rmin

ate

com

man

dA

UD

IOX

18D

ispl

ay a

cces

s te

rmin

ate

com

man

dN

CM

X

19D

ownl

oad

bloc

k to

dis

play

com

man

dA

UD

IOX

20D

ownl

oad

bloc

k to

dis

play

com

man

dN

CM

X

21D

rive

r’s

fron

t doo

r aj

ar s

witc

h st

atus

: AC

TIV

EG

ECM

XX

22D

rive

r’s

fron

t doo

r aj

ar s

witc

h st

atus

: IN

AC

TIV

EG

ECM

XX

23D

rive

r’s

rear

doo

r aj

ar s

witc

h st

atus

: AC

TIV

EG

ECM

XX

24D

rive

r’s

rear

doo

r aj

ar s

witc

h st

atus

: IN

AC

TIV

EG

ECM

XX

25G

atew

ay A

/CC

M to

Dis

play

ICX

26G

atew

ay A

/CC

M to

Voi

ceIC

X

27G

atew

ay A

udio

to N

CM

AU

DIO

X

28G

atew

ay A

udio

to N

CM

(Mul

tifra

me)

AU

DIO

X

29G

atew

ay D

ispl

ay to

A/C

CM

com

man

dN

CM

X

30G

atew

ay N

CM

to A

udio

NC

MX

31G

atew

ay N

CM

to P

hone

: AT

Cm

d fr

ame

1N

CM

X


DATE OF ISSUE: December 2001 iii

SCP Message Matrix32

Gat

eway

NC

M to

Pho

ne: A

T C

md

fram

e2

NC

MX

33G

atew

ay N

CM

to P

hone

: D2B

OPC

fram

e1

NC

MX

34G

atew

ay N

CM

to P

hone

: D2B

OPC

fram

e2

NC

MX

35G

atew

ay N

CM

to S

MS:

SM

S D

ata

fram

e1

NC

MX

36G

atew

ay N

CM

to S

MS:

SM

S D

ata

fram

e2

NC

MX

37G

atew

ay N

CM

to V

EMS:

AT

Cm

d fr

ame

1N

CM

X

38G

atew

ay N

CM

to V

EMS:

AT

Cm

d fr

ame

2N

CM

X

39G

atew

ay N

CM

to V

EMS:

D2B

OPC

fram

e1

NC

MX

40G

atew

ay N

CM

to V

EMS:

D2B

OPC

fram

e2

NC

MX

41G

atew

ay N

CM

to V

oice

NC

MX

42G

atew

ay P

hone

to N

CM

: AT

Cm

d fr

ame

1A

UD

IOX

43G

atew

ay P

hone

to N

CM

: AT

Cm

d fr

ame

2A

UD

IOX

44G

atew

ay P

hone

to N

CM

: D2B

OPC

fram

e1

AU

DIO

X

45G

atew

ay P

hone

to N

CM

: D2B

OPC

fram

e2

AU

DIO

X

46G

atew

ay S

MS

to N

CM

: SM

S D

ata

fram

e1

AU

DIO

X

47G

atew

ay S

MS

to N

CM

: SM

S D

ata

fram

e2

AU

DIO

X

48G

atew

ay V

EMS

to N

CM

: AT

Cm

d fr

ame

1A

UD

IOX

49G

atew

ay V

EMS

to N

CM

: AT

Cm

d fr

ame

2A

UD

IOX

50G

atew

ay V

EMS

to N

CM

: D2B

OPC

fram

e1

AU

DIO

X

51G

atew

ay V

EMS

to N

CM

: D2B

OPC

fram

e2

AU

DIO

X

52G

atew

ay v

oice

to A

/CC

M c

omm

and

AU

DIO

X

53G

atew

ay v

oice

to N

CM

AU

DIO

X

54H

ood

ajar

sw

itch:

AC

TIV

EG

ECM

XX

55H

ood

ajar

sw

itch:

INA

CTI

VE

GEC

MX

X

56Ig

nitio

n sw

itch

posi

tion

w/ i

nitia

lize

stat

us: N

OIC

XX

X

57Ig

nitio

n sw

itch

posi

tion

w/ i

nitia

lize

stat

us: Y

ESIC

XX

X

58Le

ft si

de tu

rn s

igna

l Com

man

d: O

FFG

ECM

X

59Le

ft si

de tu

rn s

igna

l Com

man

d: O

NG

ECM

X

60Lo

w fu

el le

vel s

tatu

s: N

OIC

X

61Lo

w fu

el le

vel s

tatu

s: Y

ESIC

X

62Lo

w w

ashe

r flu

id w

arni

ng: O

FFIC

X

No.

Mes

sage

Nam

eSo

urc

e

Rec

eive

rs

GEC

MIC

NC

MA

UD

IO

iv DATE OF ISSUE: December 2001



Low

was

her

fluid

war

ning

: ON

ICX

64N

etw

ork

bus

wak

e up

Com

man

d: Y

ES (T

rue)

GEC

M

65N

etw

ork

bus

wak

e up

Com

man

d: Y

ES (T

rue)

IC

66O

dom

eter

rol

ling

coun

t sta

tus

ICX

67Pa

rkin

g br

ake

switc

h st

atus

: AC

TIV

EIC

X

68Pa

rkin

g br

ake

switc

h st

atus

: IN

AC

TIV

EIC

X

69Pa

ssen

ger’

s fr

ont d

oor

ajar

sw

itch

stat

us: A

CTI

VE

GEC

MX

X

70Pa

ssen

ger’

s fr

ont d

oor

ajar

sw

itch

stat

us: I

NA

CTI

VE

GEC

MX

X

71Pa

ssen

ger’

s re

ar d

oor

ajar

sw

itch

stat

us: A

CTI

VE

GEC

MX

X

72Pa

ssen

ger’

s re

ar d

oor

ajar

sw

itch

stat

us: I

NA

CTI

VE

GEC

MX

X

73Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n7

(PTT

) AC

TIV

EA

UD

IOX

74Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n6

(VO

L+) A

CTI

VE

AU

DIO

X

75Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n 5

(VO

L) A

CTI

VE

AU

DIO

X

76Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n4

(Sel

ect)

AC

TIV

EA

UD

IOX

77Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n3

(See

k U

P) A

CTI

VE

AU

DIO

X

78Re

mot

e co

ntro

l but

ton

stat

us: B

utto

n2

(See

k D

OW

N) A

CTI

VE

AU

DIO

X

79Re

mot

e co

ntro

l but

ton

stat

us: A

ll bu

tton

s IN

AC

TIV

EA

UD

IOX

80Re

ques

t all

head

lam

p st

atus

GEC

MX

81Re

ques

t all

head

lam

p st

atus

AU

DIO

X

82Re

ques

t all

park

lam

p st

atus

GEC

MX

83Re

ques

t all

park

lam

p st

atus

NC

MX

84Re

ques

t all

park

lam

p st

atus

AU

DIO

X

85Re

ques

t tru

nk a

jar

switc

h st

atus

ICX

86Re

ques

t tru

nk a

jar

switc

h st

atus

AU

DIO

X

87Re

ques

t dri

ver’

s fr

ont d

oor

ajar

sw

itch

stat

usIC

X

88Re

ques

t dri

ver’

s fr

ont d

oor

ajar

sw

itch

stat

usA

UD

IOX

89Re

ques

t dri

ver’

s re

ar d

oor

ajar

sw

itch

stat

usIC

X

90Re

ques

t dri

ver’

s re

ar d

oor

ajar

sw

itch

stat

usA

UD

IOX

91Re

ques

t hoo

d aj

ar s

witc

h st

atus

ICX

92Re

ques

t hoo

d aj

ar s

witc

h st

atus

AU

DIO

X

93Re

ques

t ign

ition

sw

itch

posi

tion

w/ I

nitia

lize

stat

usG

ECM

X

No.

Mes

sage

Nam

eSo

urc

e

Rec

eive

rs

GEC

MIC

NC

MA

UD

IO


DATE OF ISSUE: December 2001 v


Requ

est i

gniti

on s

witc

h po

sitio

n w

/ Ini

tializ

e st

atus

AU

DIO

X

95Re

ques

t ign

ition

sw

itch

posi

tion

w/ i

nitia

lize

stat

usN

CM

X

96Re

ques

t low

fuel

leve

l sta

tus

NC

MX

97Re

ques

t low

was

her

fluid

war

ning

com

man

dG

ECM

X

98Re

ques

t par

king

bra

ke s

witc

h st

atus

AU

DIO

X

99Re

ques

t pas

seng

er’s

fron

t doo

r aj

ar s

witc

h st

atus

ICX

100

Requ

est p

asse

nger

’s fr

ont d

oor

ajar

sw

itch

stat

usA

UD

IOX

101

Requ

est p

asse

nger

’s r

ear

door

aja

r sw

itch

stat

usIC

X

102

Requ

est p

asse

nger

’s r

ear

door

aja

r sw

itch

stat

usA

UD

IOX

103

Requ

est s

eat b

elt w

arni

ng s

tatu

sIC

X

104

Requ

est v

ehic

le S

ecur

ity S

yste

m s

tatu

sIC

X

105

Requ

est v

ehic

le c

onfig

urat

ion

mod

ule

prog

ram

med

sta

tus

ICX

106

Requ

est v

ehic

le In

ertia

Sw

itch

stat

usG

ECM

X

107

Requ

est v

ehic

le S

ecur

ity k

ey s

tatu

sG

ECM

X

108

Requ

est v

ehic

le S

ecur

ity k

ey s

tatu

sA

UD

IOX

109

Righ

t sid

e tu

rn s

igna

l tur

n la

mp

Com

man

d: O

FFG

ECM

X

110

Righ

t sid

e tu

rn s

igna

l tur

n la

mp

Com

man

d: O

NG

ECM

X

111

Seat

bel

t war

ning

Com

man

d: O

FFG

ECM

X

112

Seat

bel

t war

ning

Com

man

d: O

NG

ECM

X

113

Term

inat

e di

spla

y co

nfir

mat

ion

stat

us: A

CC

EPT

ICX

X

114

Term

inat

e di

spla

y co

nfir

mat

ion

stat

us: R

EJEC

TIC

XX

115

Term

inat

e di

spla

y de

finiti

on c

omm

and

AU

DIO

X

116

Term

inat

e di

spla

y de

finiti

on c

omm

and

NC

MX

117

Tim

e of

day

(w/ m

ode)

com

man

dN

CM

X

118

Tim

e of

day

(w/ m

ode)

sta

tus

AU

DIO

X

119

Tran

sit m

ode

Com

man

d: A

CTI

VE

EXTE

RNX

X

120

Tran

sit m

ode

Com

man

d: IN

AC

TIV

EIC

X

121

Tran

smis

sion

PRN

DL

rang

e se

lect

ed s

tatu

sIC

X

122

Veh

icle

Sec

urity

Sys

tem

sta

tus

GEC

MX

123

Veh

icle

con

figur

atio

n m

odul

e pr

ogra

mm

ed s

tatu

s: N

OG

ECM

X

124

Veh

icle

con

figur

atio

n m

odul

e pr

ogra

mm

ed s

tatu

s: N

OA

UD

IOX

No.

Mes

sage

Nam

eSo

urc

e

Rec

eive

rs

GEC

MIC

NC

MA

UD

IO

vi DATE OF ISSUE: December 2001



5V

ehic

le c

onfig

urat

ion

mod

ule

prog

ram

med

sta

tus:

YES

GEC

MX

126

Veh

icle

Iner

tia S

witc

h st

atus

: AC

TIV

E (C

rash

ed)

ICX

127

Veh

icle

Iner

tia S

witc

h st

atus

: IN

AC

TIV

E (O

K)

ICX

128

Veh

icle

Sec

urity

key

sta

tus

ICX

X

129

Veh

icle

spe

ed h

igh

reso

lutio

n st

atus

ICX

X

130

VA

CM

con

trol

mod

e st

atus

: OFF

AU

DIO

XX

131

VA

CM

con

trol

mod

e st

atus

: ON

AU

DIO

XX

132

VA

CM

con

trol

mod

e st

atus

: OFF

NC

MX

X

133

VA

CM

con

trol

mod

e st

atus

: ON

NC

MX

X

134

VA

CM

trai

ning

mod

e A

/B e

ntry

NC

MX

No.

Mes

sage

Nam

eSo

urc

e

Rec

eive

rs

GEC

MIC

NC

MA

UD

IO


DATE OF ISSUE: December 2001 vii

CAN Message Matrix

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG

020h

CA

N R

EFLA

SH W

DS

ECM

Flas

h re

prog

ram

min

g co

mm

and

DIA

GX

030h

CA

N R

EFLA

SH E

CM

WD

SC

onfir

ms

flash

rep

rogr

amm

ing

ECM

X

040h

CA

N P

ATS

SEQ

UEN

CE

ICD

efin

es s

ecur

ity c

lear

ance

sta

geIC

X

040h

CA

N IG

NIT

ION

OFF

TIM

ERRo

lling

tim

e ig

nitio

n ha

s be

en in

pos

ition

I or

0IC

X

040h

CA

N P

ATS

DA

TA IC

Secu

rity

sys

tem

IC d

ata

ICX

046h

CA

N P

ATS

SEQ

UEN

CE

ECM

Def

ines

sec

urity

cle

aran

ce s

tage

ECM

X

046h

CA

N P

ATS

DA

TA E

CM

Secu

rity

sys

tem

EC

M d

ata

ECM

X

065h

CA

N E

NG

INE

TORQ

UE

REQ

UES

TTo

rque

red

uctio

n re

ques

t: th

rott

le c

ontr

olA

BSC

MX

065h

CA

N E

NG

INE

TORQ

UE

REQ

UES

TTo

rque

red

uctio

n re

ques

t: th

rott

le c

ontr

olA

BS/T

CC

MX

065h

CA

N E

NG

INE

TORQ

UE

REQ

UES

TTo

rque

red

uctio

n re

ques

t: th

rott

le c

ontr

olD

SCC

MX

065h

CA

N T

EMPO

RARY

TO

RQU

E RE

QU

EST

Torq

ue r

educ

tion

requ

est:

igni

tion

timin

g, fu

el c

utof

fA

BSC

MX

065h

CA

N T

EMPO

RARY

TO

RQU

E RE

QU

EST

Torq

ue r

educ

tion

requ

est:

igni

tion

timin

g, fu

el c

utof

fA

BS/T

CC

MX

065h

CA

N T

EMPO

RARY

TO

RQU

E RE

QU

EST

Torq

ue r

educ

tion

requ

est:

igni

tion

timin

g, fu

el c

utof

fD

SCC

MX

070h

CA

N Y

RS T

EST

MO

DE

YRS

test

dat

aYR

SX

070h

CA

N Y

RS P

OS

TM B

ITYR

S te

st d

ata

YRS

X

070h

CA

N Y

RS E

RRO

R BI

TYR

S te

st d

ata

YRS

X

070h

CA

N Y

RS T

EMP

ERRO

R BI

TYR

S te

st d

ata

YRS

X

070h

CA

N Y

RS C

AL

RESP

ON

SEYR

S re

spon

se to

CA

N Y

RS C

AL

mes

sage

YRS

X

070h

CA

N Y

RS ID

B RE

SPO

NSE

YRS

resp

onse

to C

AN

YRS

IDB

mes

sage

YRS

X

070h

CA

N Y

AW

RA

TE S

IGN

AL

Yaw

rat

e va

lue

YRS

X

070h

CA

N L

ATE

RAL

AC

CEL

SIG

NA

LLa

tera

l acc

eler

atio

n va

lue

YRS

X

075h

CA

N Y

RS S

TMYR

S, s

witc

h to

test

mod

e co

mm

and

DSC

CM

X

075h

CA

N Y

RS C

AL

Cal

ibra

tion

info

rmat

ion

DSC

CM

X

075h

CA

N Y

RS ID

BYR

S id

entif

icat

ion

byte

DSC

CM

X

080h

CA

N S

TEER

ING

WH

EEL

AN

GLE

Stee

ring

whe

el a

ngle

val

ueSW

SX

080h

CA

N S

TEER

ING

WH

EEL

SPEE

DSt

eeri

ng w

heel

rot

atio

n sp

eed

SWS

X

080h

CA

N S

TEER

ING

WH

EEL

STA

TUS

Val

idat

es S

WS

SWS

X

080h

CA

N S

WS

MSG

CO

UN

TC

onfir

ms

SWS

mes

sage

s re

ceiv

edSW

SX

080h

CA

N S

WS

CH

ECK

SUM

Val

idat

es S

WS

mes

sage

sSW

SX

viii DATE OF ISSUE: December 2001


CAN Message Matrix

097h

CA

N IN

DIC

ATE

D E

NG

INE

TORQ

UE

Estim

ated

ava

ilabl

e to

rque

: cur

rent

eng

ine

spee

d, lo

ad, i

gniti

on ti

min

g an

d fu

ellin

g in

terv

entio

n no

t inc

lude

dEC

MX

XX

X

097h

CA

N E

NG

INE

FRIC

TIO

N T

ORQ

UE

Estim

ated

torq

ue lo

ss c

ause

d by

: eng

ine

fric

tion,

eng

ine

driv

en

acce

ssor

ies

ECM

XX

XX

097h

CA

N A

CTU

AL

ENG

INE

TORQ

UE

Estim

ated

ava

ilabl

e to

rque

: cur

rent

eng

ine

spee

d, lo

ad ig

nitio

n tim

ing

and

fuel

ling

ECM

XX

XX

097h

CA

N D

RIV

ER D

EMA

ND

TO

RQU

EEs

timat

ed a

vaila

ble

torq

ue: c

urre

nt th

rott

le p

edal

pos

ition

, no

inte

rven

tion

incl

uded

ECM

XX

XX

0C9h

CA

N T

ORQ

UE

RED

UC

TIO

N R

EQU

EST

Torq

ue re

duct

ion

requ

este

d fo

r shi

ft en

ergy

man

agem

ent (

uses

igni

tion

inte

rven

tion

only

)TC

MX

0C9h

CA

N T

RAN

SMIS

SIO

N T

ORQ

UE

LIM

ITEn

gine

torq

ue li

mit

with

cur

rent

tran

smis

sion

faul

tTC

MX

0C9h

CA

N T

ORQ

UE

CO

NV

ERTE

R SL

IPPe

rcen

tage

of t

orqu

e co

nver

ter

slip

TCM

XX

XX

0C9h

CA

N T

RAN

SMIS

SIO

N IN

PUT

SPEE

DTr

ansm

issi

on in

put s

haft

RPM

TCM

X

0C9h

CA

N T

RAN

SMIS

SIO

N O

UTP

UT

SPEE

DTr

ansm

issi

on o

utpu

t sha

ft RP

MTC

MX

0FBh

CA

N T

RAC

TIO

N S

HIF

T M

AP

Use

Tra

ctio

n Sh

ift M

apA

BSC

MX

0FBh

CA

N T

RAC

TIO

N S

HIF

T M

AP

Use

Tra

ctio

n Sh

ift M

apA

BS/T

CC

MX

0FBh

CA

N T

RAC

TIO

N S

HIF

T M

AP

Use

Tra

ctio

n Sh

ift M

apD

SCC

MX

0FBh

CA

N O

BD II

ABS

CLE

AR

AC

KC

onfir

ms

ABS

OBD

II D

TCs

clea

red

ABS

CM

X

0FBh

CA

N O

BD II

ABS

CLE

AR

AC

KC

onfir

ms

ABS

OBD

II D

TCs

clea

red

ABS

/TC

CM

X

0FBh

CA

N O

BD II

ABS

CLE

AR

AC

KC

onfir

ms

DSC

OBD

II D

TCs

clea

red

DSC

CM

X

0FBh

CA

N A

BS F

AU

LT C

OD

E M

IL S

TATU

SIn

dica

tes

flagg

ed D

TC r

equi

res

MIL

illu

min

atio

nA

BSC

MX

0FBh

CA

N A

BS F

AU

LT C

OD

E M

IL S

TATU

SIn

dica

tes

flagg

ed D

TC r

equi

res

MIL

illu

min

atio

nA

BS/T

CC

MX

0FBh

CA

N A

BS F

AU

LT C

OD

E M

IL S

TATU

SIn

dica

tes

flagg

ed D

TC r

equi

res

MIL

illu

min

atio

nD

SCC

MX

0FBh

CA

N A

BS S

TATU

SIn

dica

tes

whe

n A

BS s

yste

m is

func

tioni

ngA

BSC

M

0FBh

CA

N A

BS S

TATU

SIn

dica

tes

whe

n A

BS s

yste

m is

func

tioni

ngA

BS/T

CC

M

0FBh

CA

N A

BS S

TATU

SIn

dica

tes

whe

n A

BS s

yste

m is

func

tioni

ngD

SCC

M

0FBh

CA

N V

EHIC

LE R

EFER

ENC

E SP

EED

Veh

icle

spe

ed (r

efer

ence

whe

el c

ircu

mfe

renc

e X

whe

el r

otat

ion

spee

d)A

BSC

MX

XX

X

0FBh

CA

N V

EHIC

LE R

EFER

ENC

E SP

EED

Veh

icle

spe

ed (r

efer

ence

whe

el c

ircu

mfe

renc

e X

whe

el r

otat

ion

spee

d)A

BS/T

CC

MX

XX

X

0FBh

CA

N V

EHIC

LE R

EFER

ENC

E SP

EED

Veh

icle

spe

ed (r

efer

ence

whe

el c

ircu

mfe

renc

e X

whe

el r

otat

ion

spee

d)D

SCC

MX

XX

X

0FBh

CA

N A

BS F

AU

LT C

OD

ESIn

dica

tes

ABS

DTC

s to

sto

re in

the

ECM

ABS

CM

X

0FBh

CA

N A

BS F

AU

LT C

OD

ESIn

dica

tes

ABS

DTC

s to

sto

re in

the

ECM

ABS

/TC

CM

X

0FBh

CA

N A

BS F

AU

LT C

OD

ESIn

dica

tes

ABS

DTC

s to

sto

re in

the

ECM

DSC

CM

X

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG


DATE OF ISSUE: December 2001 ix

CAN Message Matrix

0FBh

CA

N O

DO

RO

LLIN

G C

OU

NT

Rolli

ng c

ount

of d

ista

nce

vehi

cle

has

trav

elle

dA

BSC

MX

0FBh

CA

N O

DO

RO

LLIN

G C

OU

NT

Rolli

ng c

ount

of d

ista

nce

vehi

cle

has

trav

elle

dA

BS/T

CC

MX

0FBh

CA

N O

DO

RO

LLIN

G C

OU

NT

Rolli

ng c

ount

of d

ista

nce

vehi

cle

has

trav

elle

dD

SCC

MX

0FBh

CA

N A

BS M

ALF

UN

CTI

ON

ABS

and

bra

kes

mal

func

tion

data

, als

o ac

tivat

es IC

war

ning

sA

BSC

MX

X

0FBh

CA

N A

BS M

ALF

UN

CTI

ON

ABS

/TC

and

bra

kes

mal

func

tion

data

, als

o ac

tivat

es IC

war

ning

sA

BS/T

CC

MX

X

0FBh

CA

N A

BS M

ALF

UN

CTI

ON

ABS

, DSC

and

bra

kes

mal

func

tion

data

, als

o ac

tivat

es IC

war

ning

sD

SCC

MX

X

0FBh

CA

N A

BS F

LAG

SA

BS a

nd b

rake

sys

tem

s st

atus

and

flag

info

rmat

ion

ABS

CM

XX

X

0FBh

CA

N A

BS F

LAG

SA

BS/T

C a

nd b

rake

sys

tem

s st

atus

and

flag

info

rmat

ion

ABS

/TC

CM

XX

X

0FBh

CA

N A

BS F

LAG

SA

BS, D

SC a

nd b

rake

sys

tem

s st

atus

and

flag

info

rmat

ion

DSC

CM

XX

X

120h

CA

N T

RAN

S IN

PUT

IND

ICA

TED

TO

RQU

EEn

gine

torq

ue in

put t

o tr

ansm

issi

on, i

nclu

des

inte

rven

tions

ECM

XX

XX

12D

hC

AN

EN

GIN

E A

CC

ELER

ATI

ON

Rate

of e

ngin

e sp

eed

incr

ease

ECM

XX

X

12D

hC

AN

TH

ROTT

LE P

OSI

TIO

NTa

rget

thro

ttle

valv

e po

sitio

nEC

MX

XX

X

12D

hC

AN

PED

AL

POSI

TIO

NA

ccel

erat

or p

edal

pos

ition

, dri

ver

thro

ttle

dem

and

ECM

XX

XX

12D

hC

AN

EN

GIN

E SP

EED

Engi

ne s

peed

in R

PMEC

MX

XX

XX

X

12D

hC

AN

ALT

ERN

ATO

R ST

ATU

SA

ltern

ator

sta

tus:

faul

t or

OK

ECM

X

12D

hC

AN

CRU

ISE

STA

TUS

Cru

ise

cont

rol s

tatu

s: O

verr

ide

switc

h ac

tive,

Cru

ise

ON

, ena

bled

, re

sum

ing

ECM

XX

12D

hC

AN

OBD

II C

LEA

R FA

ULT

CO

DES

Requ

est A

BS a

nd T

CM

to c

lear

OBD

DTC

sEC

MX

XX

X

12D

hC

AN

BRA

KE

PED

AL

PRES

SED

Brak

e sw

itch

stat

usEC

MX

XX

12D

hC

AN

CRA

NK

IN P

ROG

RESS

Engi

ne c

rank

ing

in p

rogr

ess

ECM

XX

XX

XX

12D

hC

AN

TRA

CTI

ON

AC

KN

OW

LED

GE

Con

firm

s to

rque

redu

ctio

n in

pro

gres

s, c

an/ c

anno

t ach

ieve

, una

ble

to

resp

ond

ECM

XX

X

12D

hC

AN

FU

EL C

AP

WA

RNIN

GD

ispl

ay C

heck

Fue

l Cap

war

ning

ECM

X

1F5h

CA

N B

RAK

E FL

UID

LO

WD

ispl

ay B

rake

Flu

id L

evel

Low

ICX

XX

1F5h

CA

N P

ARK

BRA

KE

STA

TUS

Park

ing

brak

e: O

FF/ O

NIC

XX

XX

1F5h

CA

N D

IPPE

D B

EAM

STA

TUS

Hea

dlig

ht d

ippe

d be

am: O

FF/ O

NIC

XX

X

1F5h

CA

N R

EV G

EAR

MA

N S

ELEC

TED

Man

ual t

rans

mis

sion

onl

y, r

ever

se g

ear

sele

cted

ICX

1F5h

CA

N O

IL P

RESS

URE

LO

WEn

gine

oil

pres

sure

bel

ow s

peci

ficat

ion

ICX

1F5h

CA

N R

ESTR

ICT

RCC

BLO

WER

SRe

stri

ct c

limat

e co

ntro

l blo

wer

spe

edIC

X

1F5h

CA

N F

UEL

LEV

EL D

AM

PED

Dam

ped

fuel

leve

l (fu

el g

auge

sig

nal)

ICX

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG

x DATE OF ISSUE: December 2001


CAN Message Matrix

1F5h

CA

N F

UEL

LEV

EL R

AW

1Fu

el le

vel s

ende

r1

sign

al (b

efor

e si

gnal

con

ditio

ning

)IC

X

1F5h

CA

N F

UEL

LEV

EL R

AW

2Fu

el le

vel s

ende

r2

sign

al (b

efor

e si

gnal

con

ditio

ning

)IC

X

3E9h

CA

N G

EAR

POSI

TIO

N A

CTU

AL

Tran

smis

sion

gea

r po

sitio

ns: N

, 1, 2

, 3, 4

, 5, R

, or

shift

in p

rogr

ess

TCM

XX

XX

X

3E9h

CA

N G

EAR

POSI

TIO

N S

ELEC

TED

Tran

smis

sion

rot

ary

switc

h po

sitio

ns: P

, R N

, D, 4

, 3, 2

, or

sele

ctor

be

twee

n po

sitio

ns s

igna

lsTC

MX

XX

3E9h

CA

N T

RAN

SMIS

SIO

N S

HIF

T M

AP

TCM

shi

ft m

ap in

use

sig

nal:

Nor

mal

, Spo

rt, H

ot, G

radi

ent,

Trac

tion,

M

anua

l, or

Cru

ise

TCM

XX

XX

3E9h

CA

N T

RAN

SMIS

SIO

N O

IL T

EMPE

RATU

RETr

ansm

issi

on fl

uid

tem

pera

ture

–40

°C to

214

°C. N

ote:

will

not

ex

ceed

150

°CTC

MX

X

3E9h

CA

N T

RAN

SMIS

SIO

N M

ALF

UN

CTI

ON

Tran

smis

sion

mal

func

tion

data

, als

o ac

tivat

e tr

ansm

issi

on w

arni

ng

sign

als

TCM

XX

XX

X

3E9h

CA

N T

CM

CO

NFI

G F

LAG

TCM

PEC

US

prog

ram

med

YES

/ NO

TCM

X

3E9h

CA

N T

ORQ

UE

CO

NV

ERTE

R ST

ATU

STo

rque

con

vert

er c

lutc

h di

seng

aged

, eng

aged

or

cons

tant

slip

TCM

XX

XX

3E9h

CA

N G

EAR

SELE

CTI

ON

FA

ULT

CA

N G

EAR

POSI

TIO

N S

ELEC

TED

sig

nal v

alid

ityTC

MX

XX

3E9h

CA

N ID

LE N

EUTR

AL

CO

NTR

OL

Idle

neu

tral

con

trol

in/ n

ot in

pro

gres

sTC

MX

3E9h

CA

N P

ERFO

RMA

NC

E M

OD

E IN

DIC

ATI

ON

Switc

h Pe

rfor

man

ce M

ode

LED

ON

/ OFF

TCM

X

3E9h

CA

N T

CM

FA

ULT

CO

DE

MIL

STA

TUS

Indi

cate

s fla

gged

DTC

req

uire

s M

IL il

lum

inat

ion

TCM

X

3E9h

CA

N O

BD II

TC

M C

LEA

R A

CK

Con

firm

s tr

ansm

issi

on O

BD D

TCs

clea

red

TCM

X

3E9h

CA

N T

RAN

SMIS

SIO

N F

AU

LT C

OD

ESIn

dica

tes

tran

smis

sion

faul

t cod

es to

sto

re E

CM

TCM

XX

XX

3E9h

CA

N G

EAR

POSI

TIO

N T

ARG

ETN

ext a

ctua

l tra

nsm

issi

on g

ear

posi

tion

(for

trac

tion

cont

rol)

TCM

XX

XX

41A

hC

AN

PRE

SSU

RE T

RAN

SDU

CER

A/C

ref

rige

rant

pre

ssur

e, fo

r fa

n co

ntro

l and

dia

gnos

tics

TCM

X

41A

hC

AN

EN

GIN

E IN

TAK

E TE

MPE

RATU

REEn

gine

inta

ke a

ir te

mpe

ratu

re:4

0°C

to80

°C (4

0°F

to17

6°F

)EC

MX

41A

hC

AN

A/C

CLU

TCH

INH

IBIT

STA

TUS

Con

firm

s A

/C c

ompr

esso

r cl

utch

ON

/ OFF

ECM

X

41A

hC

AN

ELE

CTR

ICA

L LO

AD

MA

NA

GEM

ENT

Inhi

bit:

hea

ted

rear

win

dow

, win

dshi

eld,

wip

er p

ark

area

, aut

omat

ic

heat

ed w

inds

hiel

d.EC

MX

41A

hC

AN

CO

OLI

NG

FA

N F

EED

BAC

KA

ctua

l coo

ling

fan

spee

d. R

espo

nse

to C

OO

LIN

G F

AN

REQ

UES

T m

essa

geEC

MX

441h

CA

N A

MBI

ENT

TEM

PERA

TURE

Out

side

air

tem

pera

ture

40°C

to80

°C (4

0°F

to17

6°F

)A

/CC

MX

X

441h

CA

N C

OM

PRES

SOR

TORQ

UE

Pred

icte

d A

/C c

ompr

esso

r to

rque

in 1

00m

sA

/CC

MX

441h

CA

N A

/C C

OM

MA

ND

SRe

ques

t A/C

com

pres

sor

ON

/ OFF

. Max

imum

hea

t req

uire

d: Y

ES/ N

OA

/CC

MX

441h

CA

N A

/C S

TATU

SIn

dica

tes:

win

dshi

eld,

rea

r do

or m

irro

rs, a

nd w

inds

hiel

d w

iper

par

k ar

ea h

eate

r O

N/ O

FF a

nd b

low

er s

peed

A/C

CM

X

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG


DATE OF ISSUE: December 2001 xi

CAN Message Matrix

441h

CA

N C

OO

LIN

G F

AN

REQ

UES

TRe

ques

t clim

ate

cont

rol f

an s

peed

and

offs

et, a

nd fa

n ru

n on

at i

gniti

on

OFF

A/C

CM

X

44D

hC

AN

FU

EL U

SED

Dat

a fo

r tr

ip c

ompu

ter

calc

ulat

ions

ECM

X

44D

hC

AN

EN

GIN

E O

BD II

MIL

Switc

h C

HEC

K E

NG

INE

MIL

ON

/ OFF

ECM

X

44D

hC

AN

TH

ROTT

LE M

ALF

UN

CTI

ON

RED

Switc

h re

d w

arni

ng li

ght O

FF (d

efau

lts to

ON

) — D

ispl

ay:

Rest

rict

edth

rott

le/ p

erfo

rman

ce, L

imp

hom

e/ i

dle

mod

e, E

ngin

e sh

ut

dow

n m

essa

ges

ECM

XX

XX

44D

hC

AN

TH

ROTT

LE M

ALF

UN

CTI

ON

AM

BER

Switc

h am

ber

war

ning

ligh

t OFF

(def

aults

to O

N) —

Dis

play

: C

ruis

ein

hibi

ted,

Red

unda

ncy

mod

e, O

BD e

ngin

e ov

ersp

eed

fuel

cut

off

mes

sage

sEC

MX

XX

X

44D

hC

AN

EC

M F

AU

LT C

OD

E M

IL S

TATU

SIn

dica

tes

flagg

ed D

TC r

equi

res

MIL

illu

min

atio

nEC

MX

XX

XX

44D

hC

AN

EC

M C

ON

FIG

FLA

GEC

M P

ECU

S pr

ogra

mm

ing

stat

us: p

rogr

amm

ed Y

ES/ N

OEC

MX

44D

hC

AN

EN

GIN

E FA

ULT

CO

DES

Indi

cate

s en

gine

faul

t cod

es to

sto

re E

CM

ECM

X

44D

hC

AN

EN

GIN

E C

OO

LAN

T TE

MPE

RATU

REEn

gine

coo

lant

tem

pera

ture

(°C).

Not

e: W

ill n

ot e

xcee

d14

0°C

(284

°F)

ECM

XX

X

44D

hC

AN

EN

GIN

E O

IL T

EMPE

RATU

REEn

gine

oil

tem

pera

ture

40 to

214

°C (4

0 to

417

°F)

ECM

X

44D

hC

AN

BA

ROM

ETRI

C P

RESS

URE

Baro

met

ric

pres

sure

as

%of

1 st

anda

rd a

tmos

pher

e(0

to12

5%)

ECM

X

4BO

hC

AN

FL

WH

EEL

SPEE

DFr

ont l

eft w

heel

spe

edA

BSC

MX

XX

4BO

hC

AN

FL

WH

EEL

SPEE

DFr

ont l

eft w

heel

spe

edA

BS/T

CC

MX

XX

4BO

hC

AN

FL

WH

EEL

SPEE

DFr

ont l

eft w

heel

spe

edD

SCC

MX

XX

4BO

hC

AN

FR

WH

EEL

SPEE

DFr

ont r

ight

whe

el s

peed

ABS

CM

XX

X

4BO

hC

AN

FR

WH

EEL

SPEE

DFr

ont r

ight

whe

el s

peed

ABS

/TC

CM

XX

X

4BO

hC

AN

FR

WH

EEL

SPEE

DFr

ont r

ight

whe

el s

peed

DSC

CM

XX

X

4BO

hC

AN

RL

WH

EEL

SPEE

DRe

ar le

ft w

heel

spe

edA

BSC

MX

XX

4BO

hC

AN

RL

WH

EEL

SPEE

DRe

ar le

ft w

heel

spe

edA

BS/T

CC

MX

XX

4BO

hC

AN

RL

WH

EEL

SPEE

DRe

ar le

ft w

heel

spe

edD

SCC

MX

XX

4BO

hC

AN

RR

WH

EEL

SPEE

DRe

ar r

ight

whe

el s

peed

ABS

CM

XX

X

4BO

hC

AN

RR

WH

EEL

SPEE

DRe

ar r

ight

whe

el s

peed

ABS

/TC

CM

XX

X

4BO

hC

AN

RR

WH

EEL

SPEE

DRe

ar r

ight

whe

el s

peed

DSC

CM

XX

X

4CO

hC

AN

OD

OM

ETER

REA

DIN

GO

dom

eter

dis

tanc

e tr

avel

led

for

DTC

s an

d di

agno

stic

sIC

XX

694h

CA

N V

OIC

E A

IRC

ON

CO

MM

AN

DSC

P to

CA

N g

atew

ay m

essa

geIC

X

695h

CA

N A

IRC

ON

VO

ICE

STA

TUS

CA

N to

SC

P ga

tew

ay m

essa

geA

/CC

MX

696h

CA

N D

ISPL

AY

AIR

CO

N C

OM

MA

ND

SCP

to C

AN

gat

eway

com

man

d m

essa

geIC

X

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG

xii DATE OF ISSUE: December 2001


CAN Message Matrix

697h

CA

N A

IRC

ON

DIS

PLA

Y ST

ATU

SC

AN

to S

CP

gate

way

mes

sage

A/C

CM

X

6AO

hC

AN

PO

WER

TRA

IN C

ON

FIG

URA

TIO

NN

etw

ork

man

agem

ent

ECM

XX

XX

6F1h

CA

N S

WS

CO

MM

AN

D C

OD

E W

ORD

Stee

ring

Ang

le S

enso

r ca

libra

tion

inst

ruct

ions

DSC

CM

X

6F1h

CA

N S

WS

CID

CA

N id

entif

ier

for

mes

sage

tran

smis

sion

DSC

CM

X

7C4h

CA

N D

IAG

NO

STIC

DA

TA IN

RC

CA

/CC

M d

iagn

ostic

s m

essa

geD

IAG

X

7C5h

CA

N D

IAG

NO

STIC

DA

TA O

UT

RCC

A/C

CM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7C

4hA

/CC

MX

7E8h

CA

N D

IAG

NO

STIC

DA

TA IN

EC

MEC

M d

iagn

ostic

s m

essa

geD

IAG

X

7E9h

CA

N D

IAG

NO

STIC

DA

TA IN

TC

MTC

M d

iagn

ostic

s m

essa

geD

IAG

X

7Eah

CA

N D

IAG

NO

STIC

DA

TA IN

ICIC

dia

gnos

tics

mes

sage

DIA

GX

7Ebh

CA

N D

IAG

NO

STIC

DA

TA IN

ABS

ABS

CM

dia

gnos

tics

mes

sage

DIA

GX

XX

7Ech

CA

N D

IAG

NO

STIC

DA

TA O

UT

ECM

ECM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

8hEC

MX

7Edh

CA

N D

IAG

NO

STIC

DA

TA O

UT

TCM

TCM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

9hTC

MX

7Eeh

CA

N D

IAG

NO

STIC

DA

TA O

UT

ICIC

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

Ah

ICX

7Efh

CA

N D

IAG

NO

STIC

DA

TA O

UT

ABS

ABS

CM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

BhA

BSC

MX

7Efh

CA

N D

IAG

NO

STIC

DA

TA O

UT

ABS

ABS

CM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

BhA

BS/T

CC

MX

7Efh

CA

N D

IAG

NO

STIC

DA

TA O

UT

ABS

DSC

CM

dia

gnos

tics

data

out

. Onl

y in

res

pons

e to

mes

sage

#7E

BhD

SCC

MX

No.

Mes

sage

Nam

eU

sage

Sourc

e

Rec

eive

rs

ABSCM

ABS/TCCM

DSCCM

ECM

TCM

IC

A/CCM

HLCM

JGM

SWS

YRS

DIAG

2.0L/2.5L/3.0L Electrical Guide - Jagrepair.com · ECT SENSOR Engine Coolant ... The “Battery...

Documents

Transcript of 2.0L/2.5L/3.0L Electrical Guide - Jagrepair.com · ECT SENSOR Engine Coolant ... The “Battery...