2018 FORD FIESTA ST - fordservicecontent.com · purchase or lease the latest from Ford Performance...

October 2017 First Printing Supplement Fiesta ST Litho in USA

JE8J 19A285 HA

2 0 1 8 F O R D F I E S T A S TS U P P L E M E N T

owner.ford.com (U.S.) ford.ca (Canada)

This Supplement is not intended to replace your vehicle Owner’s Manual which contains more detailed information concerning the features of your vehicle, as well as important safety warnings designed to help reduce the risk of injury to you and your passengers. Please read your entire Owner’s Manual carefully as you begin learning about your new vehicle and refer to the appropriate sections when questions arise.

All information contained in this supplement was accurate at the time of duplication. We reserve the right to change features, operation and/or functionality of any vehicle specification at any time. Your Ford dealer is the best source for the most current information. For detailed operating and safety information, please consult your Owner’s Manual.

The information contained in this publication was correct at the time of going to print. In the interest ofcontinuous development, we reserve the right to change specifications, design or equipment at any timewithout notice or obligation. No part of this publication may be reproduced, transmitted, stored in aretrieval system or translated into any language in any form by any means without our written permission.Errors and omissions excepted.© Ford Motor Company 2017

All rights reserved.Part Number: JE8J 19A285 HA 201706 20170824122121

IntroductionAbout This Supplement.................................3SVT.........................................................................4Team RS...............................................................4Ford Performance............................................4

At a GlanceAt a Glance..........................................................6

TransmissionManual Transmission....................................10

Stability ControlUsing Stability Control..................................12

Driving HintsBreaking-In........................................................14General Driving Points...................................14Engine Overspeed...........................................14Engine Overboost...........................................14

Roadside EmergenciesRoadside Assistance.....................................16

MaintenanceUnder Hood Overview...................................17Engine Oil Dipstick..........................................18Drive Belt Routing...........................................18

Wheels and TiresWheels................................................................19Tires......................................................................19Using Winter Tires..........................................20Tire Pressure Monitoring System..............21Changing a Road Wheel..............................22Technical Specifications.............................24

Capacities and Specific-ations

Engine Specifications...................................25Transmission Specifications......................25Motorcraft Parts.............................................26Capacities and Specifications...................27

Warranty Terms andConditions

Base Warranty.................................................30

1

2018 Fiesta ST (CCT) ST, Canada/Mexico/United States of America, JE8J 19A285 HA enUSA, Edition date: 201706, First Printing

Table of Contents

2


ABOUT THIS SUPPLEMENTCongratulations on your decision topurchase or lease the latest from FordPerformance — the Fiesta ST. If you haveowned or leased an SVT or ST product inthe past, we are glad you are back. If this

is your first Ford Performance vehicle,welcome to the family! We are confidentthat our dedication to performance,quality, craftsmanship and customerservice will provide many miles ofexhilarating, safe and comfortable drivingin your new ST vehicle.

E163959

Your choice of a Ford Performance productis an intelligent and informed one. Westrive to build engaging vehicles thatinvolve the driver in every aspect of thedriving experience. Although performanceis at the heart of every FordPerformance-developed vehicle, we gomuch further. Our goal is to deliver acomprehensive, complete vehicle,sweating the details such as the sound ofthe exhaust, the quality of the interiormaterials, and the functionality and thecomfort of the seats, to make sure that thedriver enjoys not only exceptionalperformance but an outstanding drivingenvironment as well. In the Fiesta ST, thatphilosophy is expressed by a sophisticatedpowertrain, outstanding chassis dynamicsand significant interior and exteriorenhancements.

This supplement complements your FiestaOwner’s Manual and provides informationspecific to the Fiesta ST. By referring to thepages listed in this supplement, you canidentify those features, recommendationsand specifications unique to your STvehicle. If there are any discrepanciesbetween this supplement and the FiestaOwner’s Manual, this supplement shallsupersede the information found in theFiesta Owner’s Manual.If you have any questions or concernsregarding your vehicle, please call the FordPerformance Info Center at1-800-FORD-SVT (367-3788).

3


Introduction

SVTThe Special Vehicle Team (SVT) wasestablished in 1991 to polish the Ford Ovalby creating low-volume, factory-producedvehicles designed for people whose ideaof driving is a high-powered, passionateexperience - not just a means of gettingfrom A to B.To support such spirited enthusiasm, wecarefully integrated the wide array of talentin the company into a small,cross-functional group of engineers andproduct planners and located them underone roof with a common mission to createvehicles specifically designed to meet theunique needs and desires of the drivingenthusiast.We produced more than 250,000 SVTvehicles since 1993 model year includingthe SVT Mustang Cobra and the Cobra R,the SVT F-150 Lightning, the SVT Contour,the SVT Focus, Ford GT, Shelby GT500,GT500KR and the F-150 SVT Raptor.

TEAM RSTeam RS traces its roots back nearly 60years from the Lotus Cortina and TwinCam Escorts of the mid-1960s, throughthe first RS branded Escorts of the 1970sto the founding of Special VehicleEngineering (SVE) in 1980. Through the1980s and 90s, SVE delivered a breadthof vehicles from exciting XR and RSbranded road going performance carsthrough homologation specials includingthe iconic Sierra Cosworth RS500 andRS200. The first ST vehicle appeared in1996 as the ST24 Mondeo. The first

collaboration between our European andNorth American performance teamsappeared in 2002 as the ST170 in Europeand SVT Focus in North America. In 2003,Team RS replaced SVE in Europe when webrought performance car and motorsportpersonnel together as one team.

FORD PERFORMANCEWelcome to the Ford Performance family!Performance and racing are deeplyembedded in Ford’s DNA, dating back toOctober 10, 1901 when Henry Ford won hisfirst race against Alexander Winton,America’s greatest racer at the time. HenryFord founded Ford Motor Company 18months later with capital raised on theback of this remarkable upset victory.Today, that spirit of passion, innovationand performance lives on through FordPerformance. Established in 2015, thecompany’s performance teams -- FordSpecial Vehicle Team (United States),Team RS (Europe), Ford Performance(Australia) and Ford Racing (UnitedStates) – have unified under the missionto create the world’s leading performancevehicles, parts, accessories andexperiences for enthusiasts. This includesaccelerating the development of advancedaerodynamics, lightweighting, electronics,powertrain performance, fuel efficiencyand other technologies that can be appliedacross Ford’s product portfolio.We are proud and passionate about whatwe do and we look forward to a long andexciting relationship with you. Thank youfor choosing Ford Performance!

4


Introduction

E211570

5


Introduction

E163958

• 1.6L GTDI EcoBoost I4 engine• Overboost function for increased

torque• Electronic overspeed function with

6500 RPM redline• ST-tuned 55 millimeters (2.17 inches)

exhaust system with dual tips• Ford B6 6-speed manual transaxle• Sound symposer• ST-tuned electric power assisted

steering• Modified front suspension knuckle for

improved wheel end geometry• ST-tuned springs, dampers, stabilizer

bar and rear twist beam• Increased diameter front brake rotors

(278 millimeters x 23 millimeters) (10.9inches x 0.91 inches) with uniquecalipers and ST-tuned brake pads

• Rear brake rotors (253 millimeters x10.2 millimeters) (9.9 inches x 0.40inches) with unique calipers andST-tuned brake pads

• Enhanced torque vectoring withundersteer control

• AdvanceTrac stability enhancementsystem with three modes: Normal,Sport and Disabled

• 17 inch x 7.0 inch wheels with 47.5millimeter offset

• P205/40-R17 Bridgestone RE050Asummer-only tires

• Optional P205/40-R17 Michelin PilotSport A/S3 all-season performancetire

• ST-engineered front and rear fasciasand rear wing

• Optional Recaro front seats withincreased lateral support and matchingrear seat covers

• ST-unique instrument panel appliques,shift knob, steering wheel and rockerscuff panels

• ST high-speed instrument cluster

6


At a Glance

Vehicle Specifications

E163960

DescriptionItem

Ford B6 6-speed manual with 228 millimeter clutch and dualmass flywheel

Transmission

Final driveRatioGearGear ratios

3.823.7271st

3.822.0982nd

3.821.3573rd

3.821.0304th

3.820.8215th

3.820.6906th

3.823.818Reverse

7


At a Glance

Engine Specifications

DescriptionItem

Transversely mounted I4, cast aluminum cylinder block andcylinder heads

Configuration

3.1 in (79 mm) bore x 3.2 in (81.4 mm) strokeBore x stroke

97 in³ (1,597 cm³)Displacement

10.0:1Compression ratio

197 hp @ 6350 RPM on 93 octaneHorsepower

202 lb-ft @ 4200 RPM on 93 octaneTorque

6375 RPM continuousRedline6500 RPM three second overspeed

123 horsepower per literSpecific output

Twin independent variable cam timingValvetrain

Coil-on-plugIgnition

Pressurize, direct injection, electric returnless fuel systemFuel system

2.0 in (52 mm)Throttle body

Die cast aluminum alloyPistons

Cast ironCrankshaft

Sinter forged steelConnecting rods

Borg Warner KP39Turbo

2.17 in (55 mm) diameterExhaust system

8


At a Glance

Suspension Specifications

DescriptionItem

MacPherson strut with L-arm front suspension and revisedknuckle

Front suspension

Twist beam 0.3 in (8.5 mm) thickRear suspension

154 lb/in (27N/mm)Front spring rate

131 lb/in (23N/mm)Rear spring rate

0.83 in (21 mm)Front stabilizer bar

9


At a Glance

MANUAL TRANSMISSIONUsing the ClutchNote: Failure to fully depress the clutchpedal to the floor may cause increased shiftefforts, prematurely wear transmissioncomponents or damage the transmission.Note: Do not drive with your foot resting onthe clutch pedal or use the clutch pedal tohold your vehicle at a standstill whilewaiting on a hill. These actions will reducethe life of the clutch and could nullify aclutch warranty claim.

E144954

Manual transmission vehicles have astarter interlock that prevents cranking theengine unless the clutch pedal is fullydepressed.

Starting Your Vehicle

WARNINGMake sure the floor mat is positionedcorrectly so that it does not interferewith the full extension of the clutch

pedal.

1. Make sure the parking brake is fully setand shift the gearshift lever to theneutral position.

2. Fully depress the clutch pedal thenstart the engine.

3. Press the brake pedal and shift thegearshift lever to first or reverse gear.

4. Release the parking brake and slowlyrelease the clutch pedal while slowlypressing on the accelerator.

During each shift, make sure you fullydepress the clutch pedal.

Recommended Shift SpeedsNote: Do not shift the gearshift lever to firstgear when your vehicle is moving faster than15 mph (24 km/h). This will damage theclutch.We recommend you change gearaccording to the following guide to achievethe best fuel economy for your vehicle.

Recommendedspeed

Shift from

12 mph (19 km/h)1 - 2

23 mph (37 km/h)2 - 3

32 mph (51 km/h)3 - 4

41 mph (66 km/h)4 - 5

42 mph (67 km/h)5 - 6

ReverseNote: Do not shift the gearshift lever toreverse gear when your vehicle is moving.This can cause damage to the transmission.1. Fully depress the clutch pedal to

disengage the clutch.2. Shift the gearshift lever to the neutral

position and wait at least threeseconds before moving it to reverse.

3. Raise the collar below the gearshiftlever to shift to reverse gear.

Note: This is a lockout feature whichprotects the transmission from accidentallyengaging reverse gear when intending toselect first gear.

10


Transmission

E99067

If reverse gear is not fully engaged, pressthe clutch pedal down and shift thegearshift lever to the neutral position.Release the clutch pedal for a moment,then raise the collar and shift the gearshiftlever to reverse again.

Parking Your VehicleWARNING

Do not park your vehicle with thegearshift lever in the neutral position.Your vehicle may move unexpectedly

and injure someone. Shift the gearshiftlever to first gear and set the parking brakefully.

To park your vehicle:1. Press the brake pedal and shift the

gearshift lever to the neutral position.2. Fully apply the parking brake and

switch the ignition off.3. Hold the clutch pedal down, and shift

the gearshift lever to first gear.

11


Transmission

USING STABILITY CONTROLThe AdvanceTrac system includes tractioncontrol and electronic stability control. Seethe Traction Control and Stability Controlchapters of the Owner's Manual for moreinformation.AdvanceTrac provides three modes ofoperation specially calibrated for yourvehicle.

E156922

Press the AdvanceTrac button on thecenter console to select these modes.

AdvanceTrac Modes

DisplayButton operationDescriptionMode

NoneNoneDaily usage with alldriver aids engaged

Normal

-Message centerdisplays Sport Mode

Single pressSpirited driving.Thresholds alteredon traction control

and electronicstability control to

allow more tire spinand vehicle slip

Sport

-Amber light incluster illuminates

-Message centerdisplays Hold toswitch ESC OFF,

then

Press and hold forfive seconds

-Track Use Only-Traction control

and electronicstability control are

disabled

Off

-Electronic StabilityControl off

-Amber light incluster illuminates

12


Stability Control (If Equipped)

Enhanced Torque VectoringControlEnhanced torque vectoring control iscomprised of two elements:• Torque vectoring control which applies

brake torque on the inner wheel in acurve for better traction and lessundersteer.

• Cornering understeer control whichcontrols the yaw response of yourvehicle when you accelerate on highand low friction surfaces.

No action is required to activate torquevectoring control. It operates automaticallydue to vehicle operating conditions.Unlike electronic stability control,enhanced torque vectoring control doesnot slow the vehicle but does help controlexcessive wheel slip and gives the vehiclecornering agility. The system only increasesperformance. Because of this, enhancedtorque vectoring control is not disabledwhen the AdvanceTrac system is off.

13


Stability Control (If Equipped)

BREAKING-INYour vehicle does not need an extensivebreak–in. Try not to drive continuously atthe same speed for the first 1000 miles(1600 kilometers) of new vehicleoperation. Vary your speed frequently inorder to give the moving parts a chance tobreak in.Do not add friction modifier compoundsor special break–in oils since theseadditives may prevent piston ring seating.

GENERAL DRIVING POINTSOperating at High SpeedsYour ST vehicle is capable of high speedsand is equipped with tires rated for thevehicle’s maximum speed. Remember todrive safely, obey all traffic laws and onlyoperate your ST vehicle at high speeds atlocations equipped and designed to do sosafely. Before operating your vehicle athigh speeds:• Verify correct tire pressures. See Tires

(page 19).• Inspect wheels and tires for wear and

damage. Replace any damaged wheelsor tires.

• Do not operate your vehicle at highspeeds with more than two passengersor while carrying cargo.

Curbs, Parking Lot Obstacles andCommercial Car WashingAs part of its performance tuning package,your ST vehicle has a lower ride height thana standard Fiesta. Because of lower groundclearance, use caution when approachingcurbs, speed bumps or steep drivewayramps. It is recommended to cross speedbumps or driveway curbs slowly and at a45 degree angle to reduce the risk ofvehicle damage. Also, exercise extreme

care if using automated commercial carwashes. Do not drive through car washeswith the vehicle heavily loaded (multiplepassengers or luggage). Use onlycommercial car washes withoutmechanical tracks or hand wash to avoidpotential damage.

ENGINE OVERSPEEDNote: Always wait until the engine isproperly warmed up before running highengine speeds.Your ST vehicle is equipped with anoverspeed feature to increase itsperformance range. The standardmaximum engine speed of 6375 RPM isindicated by a narrow redline on thetachometer face. The redline becomesthicker at the overspeed engine speed of6500 RPM.This feature allows three seconds ofoverspeed above 6375 RPM. Once thethree second limit has been reached, theelectronically controlled rev limit rampsdown to 6375 RPM and holds there. Onceengine speed has dropped below 6175RPM, the overspeed timer is reset andthree seconds of overspeed up to amaximum of 6500 RPM is enabled.Do not operate the engine at high RPM andlow load for sustained periods of time, asdamage may occur.

ENGINE OVERBOOSTYour vehicle has an engine overboostfeature to allow additional torque delivery.The overboost feature controls a varietyof engine parameters to deliver additionaltorque. This feature widens the enginespeed range of the peak torque curve,giving maximum performance whilepassing another vehicle or launching froma standing start.

14


Driving Hints

The system allows a maximum of 20seconds of engine overboost. After thisthe system reduces turbo charger boostand maximizes it at a predetermined limit.Once the turbo charger boost drops belowthe predetermined limit the system resetsand a further 20 seconds of engineoverboost is permitted.Note: You do not need to take any actionas the system allows overboost when youdemand it.

15


Driving Hints

ROADSIDE ASSISTANCE

E143886

Contact your roadside assistance centeror a professional towing service if you needto have your vehicle towed.Ford recommends that your vehicle betowed with a wheel lift and dollies or withflatbed equipment. When towing with aflatbed, 4x4 blocks may help preventdamage when loading or unloading yourvehicle. Do not tow with a slingbelt. FordMotor Company has not approved aslingbelt towing procedure.Note: If the vehicle is towed by other meansor incorrectly, vehicle damage may occur.

16


Roadside Emergencies

UNDER HOOD OVERVIEW

E163014

A B C D E

FGH

Engine coolant reservoirAEngine oil filler capBEngine oil dipstickCBatteryDBrake and clutch fluid reservoirEEngine compartment fuse boxFWindshield and rear window washer fluid reservoirGAir cleanerH

17


Maintenance

ENGINE OIL DIPSTICK

E199415

A B

Minimum.AMaximum.B

DRIVE BELT ROUTING

E161372

18


Maintenance

WHEELSYour ST vehicle is equipped with uniquewheels matched to the tires. These wheelsare more susceptible to damage due totheir diameter, width and low profile tires.To avoid damage to your wheels:• Maintain proper tire pressure.• Exercise caution when using

automated, commercial car washes.Hand washing or using touchlesscommercial car washes withoutmechanical tracks is the best way toavoid potential damage.

• When installing wheels, always torquelug nuts to specification with a torquewrench.

• Inspect your wheels for damage on aregular basis. If a wheel is damaged,replace it immediately.

• If you encounter an abnormally harshimpact, inspect the outer diameter ofyour wheels, both inside and out, fordamage.

TIRES

OptionalMichelin Pilot Sport

A/S3

StandardBridgestone Potenza

RE050 ATires

205/40 R17205/40 R17Size

VWSpeed rating

8484Load rating

Performance all seasonSummer onlyUsage

17 in. x 7.0 in, 47.5 mm offset aluminum wheelsWheels

Your ST vehicle is equipped with lowprofile, high performance tires that aredesigned to optimize the driving dynamicsyou expect in an ST vehicle. These tires arenot optimized for off-road or winter (snowor cold weather) performance, and theirride, noise and wear characteristics aredifferent than non-performance tires. Also,because of their lower profile, the tires aremore susceptible to damage due topotholes and rough roads. To make surethat your tires perform as intended, it isimportant that you maintain your tiresproperly:

Note: Do not use tire chains on the originalwheels and tires of your vehicle. The use ofany type of tire chain on these tires maydamage your vehicle.• Do not overload your vehicle. Maximum

vehicle and axle weights are listed onthe tire information placard.

• Take extra caution when operating thevehicle near its maximum load,including assuring proper tire pressureand reducing speeds.

• Take extra caution when operating onrough roads to avoid impacts thatcould cause tire damage.

19


Wheels and Tires

• If you encounter an abnormally harshimpact, inspect your tires for damage.

• Inspect your tires for damage on aregular basis. If a tire is damaged,replace it immediately.

• Proper suspension alignment is criticalfor maximum performance andoptimal tire wear. If you notice uneventire wear, have your alignment checked.

• When replacing tires, the only way tomaintain original performance is to usethe original equipment tire. If a differentsummer tire is used, it should be thesame size, speed rating and load ratingas the originally equipped tire. Replacetires as a set of four. Never mix tirebrands or models.

Tire Pressure• For tire pressures, see the placard

located on the B-pillar inside the driverdoor.

• Always maintain your tire pressuresaccording to the tire informationplacard on the driver door jamb, usingan accurate gauge.

• Tire pressures are specified cold. Checkthem after the vehicle has been parkedfor at least three hours. Do not reducepressure of warm tires.

• Check your tire pressure often tomaintain it properly. Tire pressure candiminish over time and fluctuate withtemperature.

Tire Pressure for High Speed UsageIf you are operating your ST vehicle in areasthat allow high-speed driving over 100 mph(160 km/h), increase the tire pressure inall four tires by 3 psi above the pressureslisted on the Tire Pressure placard locatedon the driver side b-pillar.

Optional All-Season TiresYour ST vehicle may come equipped withan optional All-Season performance tire.This choice will provide the benefit of fourseason mobility without requiring theinstallation of winter tires. It is importantto realize that ultimate summerperformance will be reduced relative tothe standard equipment summer only tire.Additionally, ultimate winter traction andcontrol will be less than a dedicated wintertire would provide. If you drive during thewinter months in areas with heavy snowfallor hilly terrain, you may wish to install adedicated winter tire if ultimate tractionand control are desired.

USING WINTER TIRESIf so equipped, the original equipmentsummer-only tires on your ST vehicle aredesigned for maximum performance in dryand wet summer conditions. They are notdesigned for winter use on ice or snow andcannot be used with snow chains. Forddoes not recommend using the originalequipment tires when temperatures dropto approximately 40°F (5°C) or below(depending on tire wear and environmentalconditions) or in snow and ice conditions.You must use winter or all-season tires ifyou will be operating your vehicle in theseconditions.• Even with clear, dry driving conditions

do not operate your vehicle aboveposted speed limits or perform highspeed maneuvers with winter tires.

• Do not use tire chains on the originalwheels and tires of your vehicle. Theuse of any type of tire chain on thesetires may damage your vehicle.

20


Wheels and Tires

The following table lists acceptable tiresizes for winter tires. Tire speed and loadratings should match those of the originallyequipped tires as closely as possible. If itis required to fit winter tires with a speed

rating less than the original equipment tires(to fit snow chains, for example), be awareof the maximum speed rating for the tireand never exceed.

Compatible Snow Tire and Wheel Packages

Required wheelTire size

Original equipment ST wheel or equivalent205/40 R17

Owner supplied. See your Ford dealer forsuitable wheels from the Fiesta lineup.

195/45 R16*

* Required size to prevent vehicle damage if snow chain use is required

Please call the Ford Performance InfoCenter at 1-800-FORD-SVT (367-3788)for specific winter tire recommendations.

TIRE PRESSURE MONITORINGSYSTEMTire Pressure Monitoring SystemReset ProcedureYou must perform the tire pressuremonitoring system reset procedure aftereach tire rotation on vehicles with differentrecommended front and rear tire pressures.This procedure provides the tire pressuremonitoring system with the location ofeach tire so it can detect and properly warnof low tire pressures.

WARNINGTo determine the requiredpressure(s) for your vehicle, see theSafety Compliance Certification

Label (affixed to either the door hingepillar, door-latch post, or the door edgethat meets the door-latch post, next to thedriver's seating position), or Tire Labellocated on the B-Pillar or the edge of thedriver's door.

System reset tips:• To reduce the chances of interference

from another vehicle, perform thesystem reset procedure at least threefeet (one meter) away from anotherFord Motor Company vehicleundergoing the system reset procedureat the same time.

• Do not wait more than two minutesbetween resetting each tire sensor orthe system will time-out and you willneed to repeat the entire procedure onall four wheels.

• A double horn will sound indicating theneed to repeat the procedure.

Performing the System ResetProcedureRead the entire procedure beforeattempting.1. Drive the vehicle above 20 mph (32

km/h) for at least two minutes, thenpark in a safe location where you caneasily get to all four tires and haveaccess to an air pump.

2. Place the ignition in the off position andkeep the key in the ignition (vehicleswith keys only).

3. Turn the ignition on.

21


Wheels and Tires

4. Turn the hazard flashers on then offthree times. You must accomplish thiswithin 10 seconds. If you have enteredthe reset mode successfully, the hornwill sound once, the system indicatorwill flash and a message appears in theinformation display. If this does notoccur, please try again starting at Step2. If after repeated attempts to enterthe reset mode, the horn does notsound, the system indicator does notflash and no message is shown in theinformation display, seek service fromyour authorized dealer.

5. Train the tire pressure monitoringsystem sensors in the tires using thefollowing system reset sequence. Startwith the left front tire in the followingclockwise order: left front (driver's sidefront tire), right front (passenger's sidefront tire), right rear (passenger's siderear tire), and left rear (driver's side reartire).

6. Remove the valve cap from the valvestem on the left front tire. Decrease theair pressure until the horn sounds.Note: The horn will sound once whenthe module learns the sensoridentification code for this position. Ifyou hear the horn sound twice, thereset procedure was unsuccessful, andyou must repeat the entire procedure.

7. Remove the valve cap from the valvestem on the right front tire. Decreasethe air pressure until the horn sounds.

8. Remove the valve cap from the valvestem on the right rear tire. Decrease theair pressure until the horn sounds.

9. Remove the valve cap from the valvestem on the left rear tire. Decrease theair pressure until the horn sounds.Training is complete after the hornsounds for the last tire trained (driver'sside rear tire), the system indicatorstops flashing, and a message is shownin the information display.

10. Turn the ignition off. If you hear thehorn sound twice, the reset procedurewas unsuccessful and you mustrepeat it. If after repeating theprocedure and you hear the hornsound twice when you turn theignition off, seek assistance from yourauthorized dealer.

11. Set all four tires to the recommendedair pressure as indicated on theSafety Compliance CertificationLabel (affixed to either the door hingepillar, door-latch post, or the dooredge that meets the door-latch post,next to the driver's seating position)or Tire Label located on the B-Pillaror the edge of the driver's door.

CHANGING A ROAD WHEELSee the Wheels and Tires chapter of yourowner's manual for instructions onchanging a road wheel.

Full Size SpareYour ST vehicle is equipped with a full-size,spare tire assembly. Although the spare isa traditional, full size tire (as opposed to amini-spare), it is different in both size andhandling characteristics from the standardFiesta ST performance tire. If you need toinstall the spare tire, you must adhere tothe following precautions:• Because of the different performance

characteristics of the spare tire, avoidaggressive steering, braking,acceleration or high speeds when thespare tire is installed.

• Never enable electronic stabilitycontrol sport mode or fully disableelectronic stability control when thespare tire is installed.

• Replace the spare tire with the correctoriginal equipment specified tire assoon as possible.

22


Wheels and Tires

The following table lists the specificationsfor the full size spare tire and wheelassembly. Tire speed and load ratings

should match those of the originallyequipped tires as closely as possible.

-Spare tire

185/60 R15Size

HSpeed rating

84Load rating

All seasonUsage

15 in. x 6.0 in., 47.5 mm offset steel wheelsWheel

Removing the Spare Tire

E170423

To remove the wheel:1. Lift the front of the wheel by gripping

it firmly and pulling up. The wheel is atight fit in the spare wheel well.

2. Remove the spare tire.

1

2

E170424

To reinstall the wheel:1. Place the wheel in the spare wheel

well.2. Push down firmly on the front of the

tire to fit it in the spare wheel well. Thewheel is a tight fit in the spare wheelwell.

23


Wheels and Tires

Wheel Lug Nut TorqueSpecifications

WARNINGWhen a wheel is installed, alwaysremove any corrosion, dirt or foreignmaterials present on the mounting

surfaces of the wheel or the surface of thewheel hub, brake drum or brake disc thatcontacts the wheel. Make sure that anyfasteners that attach the rotor to the hubare secured so they do not interfere withthe mounting surfaces of the wheel.Installing wheels without correctmetal-to-metal contact at the wheelmounting surfaces can cause the wheelnuts to loosen and the wheel to come offwhile the vehicle is in motion, resulting inloss of control.

Retighten the lug nuts to the specifiedtorque at 500 miles (800 kilometers) afterany wheel disturbance (such as tirerotation, changing a flat tire, wheelremoval).

lb-ft (Nm)*Bolt size

100 (135)M12 x 1.5

Torque specifications are for nut and boltthreads free of dirt and rust. Use only Fordrecommended replacement fasteners.

TECHNICAL SPECIFICATIONS

Wheel specifications

17 in. x 7.0 in.Diameter and width

47.5 mmOffset

5.8 in. (149.5 mm)Backspacing

63.3 mmCenter bore

22.5 lb. (10.2 kg)Weight

24


Wheels and Tires

ENGINE SPECIFICATIONS

Specification

98Cubic inches.

10:1Compression ratio.

Specification

Spark plug gap. 0.028–0.031 in(0.7–0.8 mm)

Minimum 87 octaneRequired fuel.

TRANSMISSION SPECIFICATIONSGear Ratios

RatioItem

3.727:11st gear.

2.048:12nd gear.

1.357:13rd gear.

1.032:14th gear.

0.821:15th gear.

0.690:16th gear.

3.818:1Reverse gear.

3.824:1Final Drive.

25


Capacities and Specifications

MOTORCRAFT PARTSWe recommend that you demand the useof genuine Ford and Motorcraft partswhenever your vehicle requires scheduledmaintenance or repair.

Incorrect component use can causedamage not covered by the vehicleWarranty. The Ford Warranty may notcover damage caused to your vehicle as aresult of failed non-Ford parts.

Part NumberEngine Component

FA-1914Air filter.

BXT-96R-500Battery.

FL-910SOil filter.1

SP-532Spark plugs.2

FP-69Cabin air filter.

WW-2430Windshield wiper blade - driver side.

WW-1613Windshield wiper blade - passenger side.

WW-1204Rear window wiper blade.1 If a Motorcraft oil filter is not available, use an oil filter that meets industry performancespecification SAE/USCAR-36.2 Replace the spark plugs at the appropriate intervals. For spark plug replacement, werecommend that you contact an authorized dealer.

26



CAPACITIES ANDSPECIFICATIONS

WARNINGThe air conditioning refrigerantsystem contains refrigerant underhigh pressure. Only qualified

personnel should service the airconditioning refrigerant system. Openingthe air conditioning refrigerant system cancause personal injury.

Capacities

QuantityItem

1.1 gal (4.1 L)Engine oil fill capacity including the oil filter.

1.0 gal (3.75 L)Engine oil fill capacity excluding the oil filter.

2.1 gal (8 L)Engine coolant fill capacity.

0.4 gal (1.67 L)Manual transmission fluid fill capacity.

23.8 oz (0.675 kg)Air conditioning refrigerant fill capacity.

5.1 fl oz (150 ml)Air conditioning refrigerant compressor oil fill capacity.

12.4 gal (47 L)Fuel tank fill capacity.

0.8 gal (3.2 L)Washer system fill capacity.

Adding Engine Oil

Quantity

0.7 qt (0.7 L)

The quantity of engine oil required to raisethe indicated level on the dipstick fromminimum to maximum.

Specifications

MaterialsSpecificationName

WSS-M2C945-AMotorcraft® SAE 5W-20 Synthetic Blend Motor Oil (U.S.)Motorcraft® SAE 5W-20 Super Premium Motor Oil / Huile moteurde très haute qualité SAE 5W-20 Motorcraft® (Canada)XO-5W20-QSP (U.S.)CXO-5W20-LSP12 (Canada)

27



SpecificationNameWSS-M97B44-D2Motorcraft® Orange Prediluted Antifreeze/Coolant (U.S.)

Motorcraft® Orange Prediluted Antifreeze/Coolant / Antigel/liquidede refroidissement prédilué orange Motorcraft® (Canada)VC-3DIL-B (U.S.)CVC-3DIL-B (Canada)

WSS-M2C200-D2Motorcraft® Dual Clutch Transmission Fluid (U.S.)Motorcraft® Dual Clutch Transmission Fluid / Huile pour boîtesembrayage double Motorcraft® (Canada)XT-11-QDC (U.S. & Canada)

WSS-M6C65-A2Motorcraft® DOT 4 LV High Performance Motor Vehicle Brake Fluid(U.S.)Motorcraft® DOT 4 LV High Performance Motor Vehicle Brake Fluid/ Liquide de frein automobile haute performance DOT 4 LVMotorcraft® (Canada)PM-20 (U.S. & Canada)

WSH-M17B19-AMotorcraft® R-134a Refrigerant (U.S.)R-134a Refrigerant / Frigorigène R-134a (Canada)YN-19 (U.S.)CYN-19-R (Canada)

WSH-M1C231-BMotorcraft® PAG Refrigerant Compressor Oil (U.S.)Motorcraft® PAG Refrigerant Compressor Oil / Huile PAG pourcompresseur frigorifique Motorcraft® (Canada)YN-12-D (U.S. & Canada)

WSS-M14P19-AMotorcraft® Premium Windshield Wash Concentrate with Bitterant(U.S.)Motorcraft® Premium Quality Windshield Washer Fluid / Liquidelave-glace de haute qualité Motorcraft® (Canada)ZC-32-B2 (U.S.)CXC-37-A/B/D/F (Canada)

ESB-M1C93-BMotorcraft® Multi-Purpose Grease Spray (U.S.)Motorcraft® Multi-Purpose Grease Spray / Graisse tout usage enaérosol Motorcraft® (Canada)XL-5-A (U.S. & Canada)

-Motorcraft® Penetrating and Lock Lubricant (U.S.)Motorcraft® Penetrating Fluid / Liquide dégrippant Motorcraft®(Canada)XL-1 (U.S.)CXC-51-A (Canada)Motor oils of the recommended viscositygrade that display the API CertificationMark for gasoline engines are alsoacceptable. Do not use oil labeled withAPI SN service category unless the labelalso displays the API certification mark.

28



E142732

An oil that displays this symbol conformsto current engine, emission system andfuel economy performance standards ofthe International Lubricants SpecificationAdvisory Committee (ILSAC).Note: Do not use more than 1.1 qt (1 L) ofthe alternative engine oil betweenscheduled service intervals.Using oil and fluids that do not meet thedefined specification and viscosity grademay lead to:• Component damage which may not be

covered by the vehicle Warranty.• Longer engine cranking periods.• Increased emission levels.• Reduced engine performance.• Reduced fuel economy.• Reduced brake performance.Do not use supplemental engine oiladditives because they are unnecessaryand could lead to engine damage that maynot be covered by the vehicle Warranty.

29



BASE WARRANTYYour ST vehicle carries the same warrantyas other Ford Fiesta models. Thisinformation is covered in its entirety in thewarranty information.You can obtain warranty service for yourST vehicle or any ST vehicle at any Forddealer nationwide.Ford Global Performance does notrecommend modifying or racing ST, SVTor RS vehicles, as they are designed andbuilt to be driven as delivered from thefactory. The warranty informationdiscusses vehicle usage and theinstallation of aftermarket parts and theireffect on warranty coverage.In the event the vehicle is intended for trackuse, and the loss of warranty coverage isnot of concern, the following vehicledurability actions are required:• Perform multi-point inspection and the

maintenance outlined in the 150000mile (240000 kilometer) normalmaintenance schedule of thescheduled maintenance before andafter track use. See the vehicle servicemanual for removal and installationprocedures.

• Replace with Genuine Ford andMotorcraft service parts as needed.

These actions may not necessarily protectyour vehicle from damage in competitionconditions. Subjecting your vehicle tocompetition conditions even with thisrecommended action may render repairsnon-reimbursable under the warranty.

30


Warranty Terms and Conditions

AAbout This Supplement.................................3At a Glance..........................................................6

Engine Specifications...........................................8Suspension Specifications.................................9Vehicle Specifications...........................................7

BBase Warranty.................................................30Breaking-In........................................................14

CCapacities and Specifications...................27

Capacities................................................................27Specifications.........................................................27

Changing a Road Wheel..............................22Full Size Spare.......................................................22Wheel Lug Nut Torque Specifications..........24

DDrive Belt Routing...........................................18Driving Hints......................................................14

EEngine Oil Dipstick..........................................18Engine Overboost...........................................14Engine Overspeed...........................................14Engine Specifications...................................25

FFord Performance............................................4

GGearbox

See: Transmission.................................................10General Driving Points...................................14

Curbs, Parking Lot Obstacles andCommercial Car Washing.............................14

Operating at High Speeds..................................14

IIntroduction........................................................3

LLug Nuts

See: Changing a Road Wheel..........................22

MMaintenance......................................................17Manual Transmission....................................10

Parking Your Vehicle..............................................11Recommended Shift Speeds...........................10Reverse.....................................................................10Using the Clutch....................................................10

Motorcraft Parts.............................................26

RRoadside Assistance.....................................16Roadside Emergencies.................................16Running-In

See: Breaking-In.....................................................14

SSpare Wheel

See: Changing a Road Wheel..........................22Stability Control...............................................12SVT.........................................................................4

TTeam RS...............................................................4Technical Specifications

See: Capacities and Specifications...............25Tire Pressure Monitoring System..............21

Tire Pressure Monitoring System ResetProcedure............................................................21

Tires......................................................................19Tire Pressure..........................................................20

TiresSee: Wheels and Tires.........................................19

Transmission Specifications......................25Transmission....................................................10

31


Index

UUnder Hood Overview....................................17Using Stability Control..................................12

Enhanced Torque Vectoring Control..............13Using Winter Tires..........................................20

WWarranty Terms and Conditions..............30Wheel Nuts

See: Changing a Road Wheel..........................22Wheels and Tires............................................19

Technical Specifications....................................24Wheels................................................................19Winter Tires

See: Using Winter Tires......................................20

32


Index

2018 FORD FIESTA ST - fordservicecontent.com · purchase or lease the latest from Ford Performance...

Documents

Transcript of 2018 FORD FIESTA ST - fordservicecontent.com · purchase or lease the latest from Ford Performance...