2-Port Solenoid Valves / Multilex Valves
of 1
/1
Embed Size (px)
Transcript of 2-Port Solenoid Valves / Multilex Valves
-15052 -15062
QMultilex Valves
QSolenoid Valves - 2-Port Solenoid ValvesPilot-Operated
Part Number - G (Rc) - Rated Voltage (V)
MMRBC3 - 2 - B
Part Number - G(Rc) - Rated Voltage (V)
MDPN1 - 4 - B
2-Port Solenoid Valves / Multilex ValvesDirect Operation / Pilot-Operated
QFeatures: Universal Multilex Valves for various fluids such as air, water and oil, etc.
MMRBC3 MMRBC4
28
3420 27 Lead Wire Length (300)
11
36
7563
OUTIN
G (Rc)
18
2-M5 Depth 8
Lead Wire Length (300)
G (Rc)2-M5 Depth 8
OUTIN
A
18
B
3823.5 30.5
FE
D
MDPNG2, 3 G4, 6
Lead Wire Length (300)
IN OUT
38
46
2350
23.5 34.5
68.5
92.5
11.5 G (Rc)
Lead Wire Length (300)
G (Rc)
3823.5 34.5
E F
D
A
B
OUTIN
W
QSolenoid Valves - 2-Port Solenoid ValvesDirect Operation QBasic Specifications of Solenoid Valves
Direction 2 PortsNumber of Positions 2Applicable Fluid
Air, Water, Kerosene, Oil (50mm2/S)
Operating Pressure Range 0~1.5MPaOperating Temp. Range 5 ~ 40°CAllowable Voltage Range ±10%
Valve Type Direct Poppet Design Normally Closed (Exciting Open Type)
No. G (Rc) A B D E F
42 36 28 11 68 80.53 40 28 12 71 83.5
Part Number G(Rc)
Rated Voltage
(V)
Orifice Dia.(mm)
Max. Operating Pressure Differential (Mpa) Max. Operating Pressure
(MPa)
Flow Rate Characteristics ConsumptionCurrent (W) Apparent Power
Mass (kg) Unit PriceAir
Water, Warm Water,
Kerosene
Oil (50mm2/S) C* b Cv AC
50/60HzHolding Starting
Type No. 50Hz 60Hz 50Hz 60Hz
MMRBC3
1 (Rc1/8) B(100VAC)
C(200VAC)
3.0 1.0 0.7 0.5 5
1.1 0.52 0.31 5.2/3.8 12 10 17 14 0.352 (Rc1/4)
4 2 (Rc1/4)4.0 1.0 0.7 0.5 2.10 0.48 0.54 6.7/5.7 18 15 29 24
0.433 (Rc3/8) 0.45
E*C=[dm3/(s • bar)]ENormally closed.
G (Rc) A B D E F WRc1/2 71 27 14.5 75.5 102 50Rc3/4 80 32 17.5 79 108.5 60
Part NumberG
(Rc)Rated Voltage
(V)Orifice Dia.
(mm)
Min. Operating Pressure
Differential (Mpa)
Max. Operating Pressure Differential (Mpa) Flow Rate Characteristics ConsumptionCurrent (W) Apparent Power
Mass (kg)
Unit Price
Type No. Air Water, Kerosene
Oil (50mm2/S) C* b Cv S
(mm3)AC
50/60HzHolding Starting Rated Voltage (V)50Hz 60Hz 50Hz 60Hz B C
MDPN 1
2 (Rc1/4) B(100VAC)
C(200VAC)
12
0 1 1 0.7
9.2 0.36 2.0 -10/8 24 19 61 54
0.65 3 (Rc3/8) 12 11 0.46 2.4 - 0.65 4 (Rc1/2) 16
0.6 20 0.31 4.5 -
10/8.5 25 21 84 750.90
6 (Rc3/4) 23 - - 8.6 162 1.00 E*C=[dm3/(s • bar)]ENormally closed.
Part Number
Rated Voltage(V)
Rated Voltage(mA) 50/60Hz
Pipe Connection Bore Dia.
Orifice Dia. (mm)
Effective Sectional Area(mm2) Cv Mass
(kg) Unit Price
MDSNB(100VAC) 88/73
Rc1/8 Ø1.6 1.54 0.09 0.31C(200VAC) 43/37
Flow Rate Properties (Air)
Flow Rate L/min(AIR)
Seco
ndar
y Pre
ssur
e MP
a
0 20 40 60 80 100 120 140 160
0.80.70.60.50.40.30.20.1
0
Flow Rate Properties (Water)
Flow Rate L/min(AIR)
Seco
ndar
y Pre
ssur
e MP
a
0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0
0.80.70.60.50.40.30.20.1
0
0.2MPa0.3MPa0.4MPa0.5MPa0.6MPa0.7MPa
0.2MPa0.3MPa0.4MPa0.5MPa0.6MPa0.7MPa
Flow Rate Properties (Air)
Flow Rate l/min (AIR)Se
cond
ary P
ress
ure
MPa
0 20 40 60 80 100 120 140 160
0.80.70.60.50.40.30.20.1
0
Flow Rate Properties (Water)
Flow Rate l/min (AIR)
Seco
ndar
y Pre
ssur
e MP
a
0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0
0.80.70.60.50.40.30.20.1
0
QFeatures• Compact 2-port solenoid valves for air, water and oil.• Direct operation enables use under low pressure as well.• Easy mount bracket are included.
QPrecautions for UseG Operating Environment
• Use the solenoid valves at temperatures between 5 and 40 °C. Avoid any use and storage in a corrosive atmosphere.
• Keep the solenoid valves away from strong impacts and vibrations. They may be closed from being open, and vice versa.
G Fluid Quality• When compressed air is used as a fluid, removes drainage and dust through an air filter.• When the fluid is water, remove grit and rust inside a pipe through a filter. Do not run poor quality water.
G Installation• Install the solenoid valves horizontally with the coil part upward.• The body might be damaged if the M4 screws are excessively tightened up.
G Plumbing• Before plumbing, cleanse and flush thoroughly the valves to remove cutting chips, dust and cutting oil.
• Note that plumbing will not cause a strong turbulence on the IN side.G Maintenance
• Do not disassemble the solenoid valves.
Part Number - Rated Voltage (V)
MDSN - B
MDSN
JIS Symbol20
Ø34
20
IN OUT
OUT
IN2-M4x0.7 Depth 8
8
65
2-RC1/8
Lead Wire Length 500
20
20
2-M4x0.7 Depth 8
JIS Symbol
OUT
IN
2
3
1
4
QComponentsQComponent ListPart Number Name MMaterial SSurface Treatment1 Main Body C3604B -2 Fixed Core Magnetic Stainless Steel -3 Coil Case SPC Black Resin Paint4 Nut S15C Nickel Plating
QSpecificationsPart Number MMRBC MDPN
Applicable Fluid Air / Vacuum [(1.33x103Pa(abs)], Water, Kerosene, Oil (50mm2, S or Less)Operating Pressure Difference Range (MPa) 0 ~ 5 (Size Dependent) 0 ~ 1.0 (Size Dependent)Max. Operating Pressure (MPa) - 2Pressure Resistance (MPa) 25 (w/Water) 4 (w/Water)Fluid Temp. (°C) -10 ~ 60 (Non-Freezing)Ambient Temperature (°C) -20~60 -10~60Heat Resistant Class BAtmosphere No Corrosive or Explosive Gases in SurroundingsValve Structure Direct Poppet Design Pilot Poppet Design Diaphragm DriveValve Seat Leak (cm3/min) (ANR) 0.2 or Less (w/Air) 1 or Less (w/Air)Mounting Orientation FlexibleMaterial (Body, Seal) Brass, Nitrile Rubber
QComponent ListPart Number Name MMaterial Part
Number Name MMaterial1 Coil - 5 Plunger Spring SUS3042 Core Assembly SUS405 Equivalent 6 O-Ring NBR3 Shading Coil Cu 7 Seal NBR4 Plunger SUS405 Equivalent 8 Main Body C3771
QComponent ListPart Number Name MMaterial Part
Number Name MMaterial1 Core Assembly SUS405 Equivalent / SUS316L / SUS403 7 Stuffing C37712 Shading Coil Cu 8 Seal NBR3 Coil - 9 Diaphragm Assembly SUS303, 304, NBR4 Plunger Assembly SUS405 Equivalent / SUS304 * / NBR 0 Main Body CAC4075 Plunger Spring SUS304 q O-Ring NBR6 Kick Spring SUS304 * For Connection Diameter Rc 1/2, 3/4, SUS304 is not available.
MMRBC
1
345
67
8
2
IN OUT
MDPN(G2, 3)
IN OUT
1
8
9
q
0
2
3
4
5
6
7
MDPN(G4, 6)
IN OUT
1
8
9
q
0
2
3
4
56
7
MDSN
Air Blow NozzleABTA (P.1469)
Workpiece
TubePUT (P.1385)
