1202 D Labstamp User Guide Finalmicell.weblike.jp/.../labstamp/labstamp_user_manual.pdfuser must us...
Transcript of 1202 D Labstamp User Guide Finalmicell.weblike.jp/.../labstamp/labstamp_user_manual.pdfuser must us...
USER GUIDELabstamp 1.0
SOMARK Innovations, Inc.San Diego, CA
USA
www.labstamp.com1-800-430-1243
L A B S T A M P TM
By Somark
C
©
A
SAf
2
Copyrig
© 2012 Copy
All rights res
Safety Always follofire or electr
1. PleasLabst
2. Obse
3. The sspecifDeterGauglargerdamaICR(C
4. AnestComm
5. The Ldesig
6. This pand/o
7. Use oprovid
8. Use owheth
9. Befor
10. Do no
11. HandunliketreatmCartri
ght Info
yright SOM
erved. Soma
Informaow basic saric shock.
se read and utamp™ Syste
rve all warnin
suitability of tafically tail girthrmining the coe, enables tar than the Taiage to the NeeCD-1) mice.
thesia is not rmittee (IACUC
Labstamp Sysned for nor te
product does or emissions r
only the poweded by SOMA
only a groundher the outlet
e cleaning thi
ot install or us
le Needle Caely event that ment and/or redges are safe
ormatio
MARKTM Inno
ark, Labstam
ation
afety precau
nderstand all m.
ngs and follow
attooing any ph. The rangeorrect Restraittooing mice fl Gauge indicedle Cartridge
required for taC) for any ani
stem was desested on rats.
not have a Crequirements
er supply provARK Innovatio
ed electrical ois grounded,
is product, un
se this produc
rtridges with cyou accident
eporting the ine and designe
on
ovations, In
mp and TriC
utions when
the instructio
w all instructio
particular moue of acceptablnt Cartridge afrom weanling
cates may rese. The tail gir
attooing mice.mal welfare c
signed and tes
E or UL markhave not yet
vided or approons could dam
outlet when ccheck with a
nplug it from w
ct near water,
care and disctally stick youncident to youed to last for u
Over
nc.
ell are trade
n using this
ons included i
ons provided w
use using the e tail girths is
and Needle Cg to adult. Us
sult in poor tatrths were test
. Defer to youconcerns.
sted for use o
king applied abeen verified
oved by SOMmage the App
onnecting thisqualified tech
wall outlets.
when you ar
card used Neerself with a neur employer. up to 50 tattoo
rview | Labsta
emarks of So
s product to
n the docume
with the produ
Labstamp Sys determined
Cartridge comsing the Labsttoo quality, cted using C57
ur Institutiona
on mice. The
at this time, bed.
ARK Innovatplicator Machi
s product to ahnician.
re wet, or if th
edle Cartridgeeedle, be famIf used and hos.
amp User Gu
omark Innov
o reduce ris
entation that c
uct.
ystem is baseby the Labstabination as p
stamp Systemcause harm to7BL/6, BALB/
al Animal Car
Labstamp Sy
ecause comp
ions. Using aine and void t
a power sourc
e product is w
es into a sharmiliar with youhandled prope
uide | PN: 12
ations Inc.
k of injury f
comes with th
ed upon tail samp Tail Gaurescribed by t
m on mice smao the animal, a/c, C3H/He, a
e and Use
ystem was ne
pliance with sa
a power suppthe warranty.
ce. If you do n
wet.
rps containerr site policy foerly, Needle
02.D
from
he
ize, uge. the Tail aller or and/or
and
either
afety
ply not
not know
r. In the or any
T
S
S
S
S
S
S
S
3
Tableof
Section 1 O
Section 2 L
Section 3 P
3.1. PRE
3.2. RES
3.3. DET
3.4. INS
3.5. CHA
3.6. APP
3.7. INS
3.8. PLA
3.9. LOA
3.10. SEL
3.11. APP
Section 4 C
4.1. AS
4.2. AFT
4.3. AFT
4.4. AT
Section 5 S
Section 6 T
Section 7 A
fConten
Overview ...
Labstamp C
Procedure..
EPARING W
STRAINING
TERMINING
STALL THE N
ANGING TH
PLYING TAIL
SERTING TH
ACING THE T
ADING THE
LECTING TH
PLY THE TA
Cleaning &
NEEDED .....
TER EACH T
TER EVERY
THE COMPL
System Mes
Troubleshoo
Applicator M
nts
..................
Component
..................
WORKSPACE
THE MOUSE
THE CORR
NEEDLE CAR
E NEEDLE C
L OIL ...........
E INK SLIDE
TAIL COVER
RESTRAINT
HE ID METHO
ATTOO .........
Maintenanc
....................
TATTOO ......
50 TATTOO
LETION OF T
ssages .......
oting .........
Machine Sp
...................
s ................
...................
..................
E .................
ECT RESTR
RTRIDGE ....
CARTRIDGE
...................
E ..................
R .................
T CARTRIDG
OD / ENTER
...................
ce ..............
...................
...................
OS ................
THE SESSIO
...................
...................
pecification
Over
..................
..................
..................
....................
....................
RAINT AND N
....................
...................
....................
....................
....................
GE INTO THE
ING THE ID
....................
..................
....................
....................
....................
ON ................
..................
..................
ns ...............
rview | Labsta
..................
..................
..................
...................
...................
NEEDLE CAR
...................
...................
...................
...................
...................
E APPLICATO
...................
...................
..................
...................
...................
...................
...................
..................
..................
..................
amp User Gu
..................
..................
..................
....................
....................
RTRIDGE CO
....................
....................
....................
....................
....................
OR MACHIN
....................
....................
..................
....................
....................
....................
....................
..................
..................
..................
uide | PN: 12
..................
..................
..................
....................
....................
OMBINATION
....................
....................
....................
....................
....................
E .................
....................
....................
..................
....................
....................
....................
....................
..................
..................
..................
02.D
............ 4
............ 5
............ 7
........... 7
........... 7
N ......... 8
........... 9
........... 9
......... 10
......... 10
......... 11
......... 11
......... 12
......... 13
.......... 14
......... 14
......... 14
......... 14
......... 14
.......... 15
.......... 16
.......... 17
S
T
m
e
a
o
m
r
I T
r
fo
c
(c
G
c
N
C
U
u
T
A
C
c
4
Section
This documen
mouse identifi
ensuring accu
automatically
overcomes iss
mice from wea
research with
MPORTANT
The Labstamp
rats. The Sys
found in mice
combination o
longer) Needcombination th
Gauge must
combination.
Note: Tail siz
Cartridge and
Using the Lab
undersized an
The complete
Anesthesia is
Care and Use
concerns.
n1 O
nt describes th
ication. The L
uracy of anima
applies the m
sues associat
anling to adul
many advant
T
p System was
stem was des
from weanlin
of red (labelle
dle Cartridge. hat will produ
be used for
.
e, and not an
Needle Cartr
bstamp System
nimals, and it
tail size rang
not required
e Committee (
Overview
he procedure
Labstamp Sy
al research. T
most consisten
ted with tradit
lt, the Labstam
tages to the f
s designed an
igned to acco
ng to adult. A
d SMALL) or
For each anuce an optima
guidance in
nimal age or w
ridge that the
m on mice ou
may cause h
ge was tested
for using the
(IACUC), atte
w
e for using the
ystem is a sign
The Labstamp
nt, readable a
tional visual id
mp System is
facility, operat
nd validated f
ommodate a s
Accommodatin
blue (labelled
imal, there is al tattoo (i.e. o
selecting the
weight, dictate
user must us
utside of the ta
harm to the an
d and validate
Labstamp Sy
ending veterin
Figure 1-1
Over
e Labstamp S
nificant break
p System feat
and durable ID
dentification m
s setting a new
tor and the an
for mice. The
specific range
ng such a wid
d LARGE) Re
only one Resone that is leg
e correct Res
es the correct
se.
ail size range
nimal or dama
d using C57B
ystem. Howe
narian and/or v
Labstamp Sy
rview | Labsta
System to crea
kthrough for re
tures unsurpa
D to research
methods. By a
w standard to
nimal.
e System was
e of mouse ta
de range of ta
estraint Cartrid
straint Cartridgible and perm
straint Cartr
t and singular
e will result in
age to the Ne
BL/6, BALB/c,
ever, please d
veterinary se
ystem
amp User Gu
ate automated
esearchers an
assed techno
h mice. Its adv
applying auto
o protect the i
s neither desig
ail diameters (
il girth is achi
dge, and yello
dge and Needmanent). The
ridge and Ne
r combination
light or incom
eedle Cartridg
, C3H/He, an
defer to your I
rvices for any
uide | PN: 12
d tail tattoos f
nd scientists
ology that
vanced desig
omated tattoo
ntegrity of cri
gned nor valid
(girth) as is ge
ieved by usin
ow (shorter) o
dle Cartridge
e Labstamp T
edle Cartridg
n of Restraint
mplete tattoos
ge on oversize
d ICR(CD-1)
nstitutional A
y animal welfa
02.D
for
for
n
s to
tical
dated for
enerally
g a
or green
Tail
ge
s on
ed mice.
mice.
Animal
are
S
5
Section
LABSTAMP
1 Applicato
2 Restraint
3 Tail Gaug
4 Needle C
5 UV Thum
6 Ink Slidepouches
7 Tail Oil
RESTRAINT
1 TriCell In
2 Tail Cove
3 Red Dom
4 Tail Grip
5 Tail Grip
6 V-Groove
7 Tail Bed
8 Tail Cove
9 Restraint
(labelled
10 Handle
n2 L
P SYSTEM:
or Machine
t Cartridges (S
ge
Cartridges (Ye
mb Light
s (Black or UV)
T CARTRIDG
nk slide
er
me
per buttons
pers
e Tail Guide
er Alignment
t Cartridge Pl
SMALL or LA
abstam
SMALL and L
ellow and Gre
V Green, in fo
GE COMPON
Posts
atform
ARGE)
Labsta
mpCom
LARGE)
een)
oil
ENTS
Fig
amp Compon
ponent
gure 2-2 Restr
nents | Labsta
ts
Figure 2-1
raint Cartridg
amp User Gu
Labstamp Sy
ge Componen
uide | PN: 12
ystem
nts
02.D
6
CONTR
APPLIC
1 Gun-H
2 Contro
3 Power
4 Power
5 USB P
1 Rest
Red insertatto
Red Do ntattoretur
Greeinsertatto
Lighdete
2 Auto
TurnAutowhile
3 Cha
Opengun-the AretraNeed
Fig
ROL PANEL
CATOR MACH
Head Door/Gu
ol Panel (see
r Switch
r Plug
Port (optional)
traint Cartrid
solid light -Trted but not fuoing.
flashing lighnot remove Reoing is complrned to green
en light - Therted correctlyo or remove t
ht off - No Rected.
o increment b
ns the Auto Ino Increment be the machine
nge Needle b
ns the gun-he-head and insApplicator Maact the gun-hedle Cartridge.
gure 2-4 Cont
HINE
un-Head
Control Pane
)
dge Status lig
The Restraintully seated in
ht -Tattooing estraint Cartrilete and the s.
e Restraint Ca. You are reathe Restraint
estraint Cartrid
button
crement modbutton light wie is in this mo
button
ead door and stalled Needleachine. May aead after insta.
trol Panel
Labsta
el, below)
ght
t Cartridge is place for
is in progressridge until status light ha
artridge has bdy to start a Cartridge.
dge has been
de ON. The ill remain on ode.
extends the e Cartridge oualso be used alling a new
amp Compon
s.
as
been
n
ut of to
4
5
6
7
8
F
nents | Labsta
4 Start button
Begins the tahead and NeMachine.
5 LCD display
Provides useMessages o
6 Stop buttonAborts Appli
7 Alpha key
Changes kemode for sinlock-in the a
8 Backspace
“Backspace.entered.
Figure 2-3 Ap
amp User Gu
n
attooing proceedle Cartridg
y screen
er instructionon page 15.
n icator Machin
ypad to A-Z. ngle characteralpha mode.
button
.” Erases the
plicator Mach
uide | PN: 12
cess. Retractsge into the Ap
. See System
ne operations.
Press once tor. Press and h
last characte
hine
02.D
s the gun-pplicator
m
.
o turn on hold to
er
S
3
3
7
Section
3.1. PREPAR
3.1.1 SM(kCS
3.1.2 O
3.1.3 PMthth
3.1.4 WS
Noteor re
3.1.5 P
3.2. RESTRA
3.2.1 M(So
3.2.2 Rlifit
3.2.3 Whasp
3.2.4 Lotaoa
3.2.5 WmRm
n3 P
RING WORKS
et-up the tattMachine, Reskeep in foil po
Cartridge(s), aystem
Obtain a smal
lug the SOMMachine, and he power swihe Applicator
When ready tolides.
e: Once opene-sealed with
our a small a
INING THE M
Make an initiaSMALL or LAr adult. See
Remove the Rfting it straighon the Restr
With one handand to pick upread open t
ower the Redail gripper bun the Restraire engaged.
With the tail gmouse gently Release the tamay now relea
Procedu
SPACE
tooing area wtraint Cartridouch until reaand Tail Oil.
ll dish, cotton
MARK provideplug the powtch located o
r Machine. Se
o tattoo, open
ned, Ink Slidhin twenty-fo
amount of Ta
MOUSE
al selection ofARGE) based
Figure 3-3 R
Red Dome anht-up off of thraint Cartridg
d still holdingup the Red Dhe tail grippe
d Dome overttons pressedint Cartridge
ripper buttonagainst the b
ail gripper buase the mous
ure
with the suppge(s), Tail Gady to tattoo)See Figure 3
n tipped appl
ed power supwer supply inon the rear ofee Figure 3-2
n the foil pou
des must be uour (24) hours
ail Oil into the
f the Restraind upon whethRestraint Cart
nd Tail Coverhe Restraint Cge platform w
g the mouse bome. Depresers. See Figu
r the mouse kd open. Set tplatform unt
ns still presseback wall of tuttons to secuse tail.
Proce
plied Applicatauge, Ink Sli), Needle 3-1 Labstam
icators, and
pply into the Ato a power of the machine2 Power Swit
uch containin
used rs.
e dish.
nt Cartridge er mice are ytridges
r from the ReCartridge pla
with the head
by the tail, usss the tail gripure 3-4 Restr
keeping the the Red Domil the magnet
ed open, pull the Red Domure the mous
edure | Labsta
tor ides
p
gauze.
Applicator utlet. Using e, turn on tch.
ng the Ink
young
estraint Cartriatform.) Pick-
facing towar
se your forefipper buttons raining a mou
me in place t guides
the me. se. You
Fi
Fi
amp User Gu
Figure 3-4 Re
idge. (Remo-up a mouse rd the handle
inger and thu on either sid
use.
igure 3-1 Lab
Figure 3-2 Po
igure 3-3 Res
uide | PN: 12
estraining a m
ove the Tail Cby the tail an
e.
umb on your de of the dom
stamp System
ower Switch
straint Cartrid
02.D
mouse
Cover by nd place
other me to
m
dges
3
8
3.3. DETERM
IMPOCartuse RelyNeed
TTc
AdM
TI
3.3.1 Tv-ta
3.3.2 Hi.e
NOTresp
3.3.3 Mo
3.3.4. TisG
3.3.5. Osi
Inyo
NOTEon a dcomb
IMPO
MINING THE C
ORTANT: Ttridge and Nof this tool
ying on the adle Cartridg
The Tail GauTwo of the 5 colored zone
Above each odots correspoMachine.
The 5th slot ot identifies m
o measure th-groove of thail in place. S
Hold the Tail Ge. where the
TE: Ensure tect to the tai
Measure fromn the right, u
he approprias permissible Gauge.
Once the slot ize and Need
n some casesou first selec
E: Any time different Res
bination of Re
ORTANT: If th
CORRECT R
The LabstamNeedle Cartri
will ensure age or weigh
ge will not re
ge is comprisslots fall withs correspond
of the 4 slotsond to the ye
on the far leftmice that are t
he tail, positioe rubber tail See Figure 3
Gauge as clotail exits the
he Tail Gaugl.
the smallestntil you find t
ate slot on thebut do not fo
that best fitsdle Cartridge
s, you may ncted to measu
that a mousestraint Cartridestraint Cartr
he tail is too
Figure 3-5 T
RESTRAINT
p Tail Gaugidge combinthat the besht of a mousesult in a qua
sed of 5 slotshin a red colod to the SMA
on the Tail Gllow and gre
t of the Tail Gtoo small to b
on the mousebed. If nece-6 Positionin
ose as practic red dome,
ge is held ver
t slot on the lthe appropria
e Tail Gaugeorce the gaug
the mouse tcolor that co
eed to changure the tail.
e is placed ordge, it is impoidge and Nee
large for an
Tail Gauge
Proce
AND NEEDL
e is used to nation that isst quality andse to determality tattoo.
s of increasinored zone, anLL and LARG
Gauge is a yeen colored N
Gauge has thbe used in th
e tail across essary, gentlyg the Tail Ga
cal to the tail
rtically and sq
left, to the larate fit.
should dropge over the t
tail is determorresponds to
ge the mouse
r repositionedortant to use edle Cartridg
y of the slots
edure | Labsta
LE CARTRID
determine ts to be usedd most dura
mine the appr
ng widths. Snd two fall wiGE Restraint
ellow or greeNeedle Cartrid
he internationhe Labstamp
the y hold the auge.
grippers,
quare with
rgest slot
p under its owail. See Figu
ined, identifyo that slot.
e to the other
d, either on tthe Tail Gau
ge is being us
s, the anima
amp User Gu
DGE COMBIN
the approprid for each mable tattoo isropriate Res
See Figure 3-ithin a blue ct Cartridges,
en colored dodges used in
nal circle-slasSystem at th
wn weight oveure 3-6 Positi
y the correct
r Restraint C
the same Resuge to confirmsed.
l is too large
Figure 3-6 P
uide | PN: 12
NATION
riate Restrainouse. The ps produced. straint Cartr
5 Tail Gaugecolored zone.respectively.
ot. These con the Applicat
sh symbol abhis time.
er the tail. Aoning the Ta
Restraint Ca
artridge than
straint Cartridm the approp
e to be tattoo
Positioning th
02.D
nt proper
ridge or
e. These .
lored tor
bove it.
A snug fit ail
artridge
n what
dge or priate
oed.
he Tail Gaugee
3
IfC
3
9
3.4. INSTALL
IMPOneedpleasAppli
f you are chCARTRIDGE
3.4.1 PAgS
NOTE: If
th
po
M
3.4.2 WCwa
3.4.3 PpaE
3.4.4 O
3.5. CHANGIN
IMPOthe nPleasAppli
3.5.1 PATin
3.5.2 Usedeg
L THE NEEDL
ORTANT: Nedle tips becose always haicator Machi
hanging the E
ress the CHAApplicator Ma
un-head will See Figure 3-
this is the firs
he gun-head
osition with th
Machine.
With the needCartridge by liwith the slots
rms snap into
ress the CHAanel of the Ansure the sm
Once the Nee
NG THE NEE
ORTANT: Neneedle tips bse always haicator Machi
ress the CHAApplicator Ma
he gun-headnside the App
Using the forkection of the epress the clun-head. See
LE CARTRID
eedle Cartridme blunt an
andle Needleine.
Needle Cart
ANGE NEEDchine. The gemerge from7 Change Ne
st time the Ap
will already
he gun-head
le pointing dining up the cin the gun-heo place. See
ANGE NEEDApplicator Mamall gun-head
dle Cartridge
EDLE CARTR
eedle Cartridbecome blunandle Needleine.
ANGE NEEDchine. See F
d and used Nplicator Mach
ked-end of theNeedle Cartlip arms to ree Figure 3-9
DGE
dges can be nd are not ase Cartridges
ridge, proce
DLE button ongun-head doo
m inside the Aeedle Button
pplicator Mach
y be in the
protruding ou
ownward, insclip arms of tead. Gently Figure 3-8 In
DLE or STARchine to retrad door closes
e is installed,
RIDGE
dges can be nt and are noe Cartridges
DLE button onFigure 3-7 Cheedle Cartrid
hine.
e Tail Gaugeridge. The ta
elease the NeTail Gauge F
Proce
used for a ms effective ats with care.
eed to Sectio
n the front paor will open, Applicator Ma
hine is being
e Change N
ut of the Appl
stall the Needthe Needle Cpush in until nstall Needle
T button on tact the gun-hs.
proceed to s
used for a mot as effectivs with care.
n the front pahange Needledge will emer
e, push it ontoangs of the foeedle CartridFork-End.
edure | Labsta
maximum oft producing Never put y
on 3.5 CHAN
anel of the and the
achine.
used,
Needle
licator
dle Cartridge
the clip e Cartridge.
the front head.
section 3.6 -
maximum ofve at producNever put y
anel of the e Button. rge from
o the mid-ork will ge from the
amp User Gu
f 50 IDs. Afta quality ta
your fingers
NGING THE
APPLYING T
f 50 IDs. Aftcing a qualityour fingers
Figure 3-9 T
Figure 3-7 C
Figure 3-8 In
uide | PN: 12
ter 50 IDs, thttoo. Also, inside the
NEEDLE
TAIL OIL
ter 50 IDs, ty tattoo. inside the
Tail Gauge Fo
Change Needl
nstall Needle
02.D
he
rk-End
e Button
Cartridge
3
3
10
3.5.3 W
3.5.4 InuinN
3.5.5 Precl
3.5.6 D
3.5.7 InC
3.6. APPLYIN
IMPOcoatethe sink to
3.6.1 S
3.6.2 Wo3-
3.7. INSERTIN
NOTEeach four (light o
3.7.1 PPcous
3.7.2 InTthwa
Withdraw the
nstall the repp the clip arm
n on the bodyNeedle Cartrid
ress the CHAetract the gunloses.
Discard used
nstall the repCARTRIDGE.
NG TAIL OIL
ORTANT: Pred with a laykin, enhanc
o be remove
aturate a cot
While gently hn the top and-10 Apply Ta
NG THE INK
E: The Ink SlID. Once op24) hours or or incomplete
ull out one Inouch. Verify ompartmentsse a differen
nsert the Ink ail Cover. E
he holes in thwhen it will no
ligned. See F
Tail Gauge.
lacement Nems of the Neey of the Needdge.
ANGE NEEDn-head. See
Needle Cartr
lacement Ne
rior to tattooyer of Tail Oie needle pen
ed more read
tton-tipped a
holding the tad sides of theail Oil.
K SLIDE
ides are singpened, the pa
re-sealed ote tattoos whe
nk Slide fromthat ink is pr
s. If any of tht ink slide.
Slide into thensure that th
he Tail Coverot push-in anyFigure 3-12 I
The used Ne
edle Cartridgedle Cartridgdle Cartridge
DLE or STARFigure 3-7 C
ridges into an
edle Cartridg
oing, the mouil. The Tail netration, andily after the
pplicator with
ail, liberally ae tail that lies
gle-use only aackage of slidherwise the
en used.
m the foil poucresent in eace ink compar
e slotted opee holes of th
r. The Ink Sly further andnk Slide Inse
Proce
eedle Cartrid
ge by holdinge with the slountil the clip
T button on tChange Need
n approved s
ge as describ
use tail shoOil serves tond enable exe tattoo proc
h Tail Oil.
pply a layer os across the v
and will needdes must be Ink Slides wi
ch. See Figuh of the threertments are d
ning on the se Ink Slide liide is proper the alignme
ertion.
edure | Labsta
dge will be re
g it between yots in the gun arms snap i
the front panle Button. En
sharps contai
bed in Sectio
uld be o condition xcess tattoocess.
of Tail Oil v-groove of th
d to be replacused within tll dry-out and
re 3-11 Ink Se (3) ink dried or dama
side of the ne up with
rly installed nt holes are
amp User Gu
Figur
etained betwe
your thumb an head, and nto place. S
el of the Appnsure the sm
iner.
n 3.4- INSTA
o
he rubber tai
ced after twenty-d result in
Slide
aged,
Figure 3-
Figure 3-
uide | PN: 12
re 3-11 Ink Sli
een the fork t
and forefingethen gently p
See Figure 3-
plicator Machmall gun-head
ALL THE NEE
il bed. See F
-12 Ink Slide I
-10 Apply Tai
02.D
ide Pouch
tangs.
er, lining-pushing-8 Install
hine to d door
EDLE
igure
Insertion
l Oil
3
3
11
3.8. PLACING
3.8.1 Athth
3.8.2 ARw
3.8.3 Covhap
NOTE: Tt
3.9. LOADING
3.9.1 W
3.9.2 GoLo
3.9.3 InR
3.9.3.1 TRre
3.9.4 Y
G THE TAIL C
Align the tail whe tail gently he tail nor ho
Align the Tail Restraint Cartwith red. See
Carefully lowever the tail. ave applied tlace.
The Tail Covehat the Tail C
G THE REST
With the mous
Gently insert tn the front ofoad Restrain
n the upper leRESTRAINT C
he Restraint RESTRAINT Ced to green.
You are ready
COVER
within the v-gto keep it in ld it taut. See
Cover with thtridge platformFigure 3-13 T
er the Tail CoBe sure to reto the tail wh
er has magneCover snaps
TRAINT CAR
se and Tail C
the Restraintf the Applicatnt Cartridge.
eft corner of tCARTRIDGE
Cartridge is CARTRIDGE
y to apply a ta
groove of the place, but doe Figure 3-14
he color-coorm - blue alignTail Cover
over, with theelease any teile attempting
ets and alignminto proper p
RTRIDGE INT
Cover in place
Cartridge intor Machine.
the Control PE STATUS lig
properly instE STATUS lig
attoo.
Proce
rubber tail bo not attempt4 Aligning the
rdinated postns with blue,
e Ink Slide insension that yog to hold the
ment posts toposition.
TO THE APP
e, lift the Res
to the dockinSee Figure 3
Panel, check ght:
talled when tght changes f
edure | Labsta
ed. Hold t to stretch e tail.
ts of the and red
serted, ou may tail in
o ensure
PLICATOR M
straint Cartrid
ng port 3-15
the
he from Fig
amp User Gu
Figure 3-14 A
Figure 3-13 T
MACHINE
dge by the ha
gure 3-15 Loa
uide | PN: 12
Aligning the t
Tail Cover
andle.
d Restraint C
02.D
tail
Cartridge
3
12
3.10. SELE
There are
3.10.1
3.10
3.10.2
3.10
3.10
Auto incr
Alphachara
ECTING THE
e two options
Manual en
Auto incre
1 Option 1:
0.1.1 UsingID co(-) are
2 Option 2:
0.2.1 Press
0.2.2 Enterenterbelow
rement sequ
a/Numeric seqacter.
If the firs
9 _
_ _
A 9
_ A
A 0
1 Z
_ 1
0 1
A 0
Z _
_ _
E ID METHOD
for selecting t
ntry
ment.
Manual En
g the Applicambination froe also availa
Auto Incre
s the AUTO I
r the first ID ied, the subse
w.
ence rules
quences will in
st ID is…
_ _
_ 9
9 _
A 9
0 9
Z _
1 Z
1 Z
0 Z
_ _
_ Z
D / ENTERIN
the ID to be a
try
tor Machine om 0-999 andble.
ment
NCREMENT
n your desireequent tattoo
ncrease by 1
Proce
NG THE ID
applied:
keypad, ented/or A-Z. A s
T button. The
ed sequenceos that are ap
from 0-999 o
the next
1
_
B
_
A
2
_
0
1
A
_
edure | Labsta
er the desiredspace and pl
e button light
. Beginningpplied will inc
or A-Z. You m
ID will be …
1 0 _
_ 1 0
B 0 _
_ B 0
A 1 0
2 A _
_ 2 A
0 2 A
B 0
A A _
_ A A
amp User Gu
Figure 3-16 E
d alpha/numeus/positive (+
t will illuminat
g with the numcrease accor
may start with
& t
uide | PN: 12
Entering the I
eric +) or minus/n
te.
mber that yourding to the ru
any alpha/nu
the final ID w
9 9 9
9 9 9
Z 9 _
_ Z 9
Z 9 9
0 Z _
_ 0 Z
9 9 Z
9 Z 9
Z Z Z
Z Z Z
02.D
D
negative
u ules
umeric
will be …
3
Ww
in
13
3.11. APPL
3.11.1 EC
3.11.2 PSa
NOTE: Wwill beginMachine
NOTE: W
prepare t
should no
mouse.
3.11.3 ASCM
3.11.4 R
3.11.5 We
3.11.6 Whao
When finishewith the next
nstruction on
LY THE TATT
nsure that thCARTRIDGE
ress the STAtart Button. Tnd the Applic
When the man to flash red.while the ligh
While one ani
the next anim
ot be left for m
After tattooingTATUS light
Cartridge by sMachine. See
Remove the T
While holding ither a cotton
With one handand to deprerder to releas
d, clean the mouse, See
n cleaning the
TOO
he ID has beeSTATUS ligh
ART button toThe button wcator Machin
chine begins Do not attem
ht is flashing r
imal is being
mal for identific
more than a c
g is completereturns to gr
sliding it straiFigure 3-18
Tail Cover by
the tail gentln-tipped appl
d holding theess the tail grse the mouse
Labstamp coCleaning & M
e System.
en selected aht is green.
o begin tattoowill beep when
e will begin t
to tattoo, thempt to removered.
tattooed, you
cation. Howe
couple of minu
and the RESreen, removeght-back and
lifting it strai
ly, remove exicator or a pi
mouse by thripper buttonse from the Re
omponents asMaintenance
Proce
and the REST
oing. See Fign it has beento tattoo.
RESTRAINTe the Restrain
can use a se
ever, for the co
utes with the
STRAINT CAe the Restraind out of the A
ight-up off of
xcess tattoo ece of gauze
he tail, use ths on the red destraint Cartr
s needed, ane below for de
edure | Labsta
TRAINT
gure 3-17 n pressed,
T CARTRIDGnt Cartridge fr
econd Restra
omfort of the
tail grippers r
ARTRIDGE nt
Applicator
f the Restrain
ink by wipinge saturated w
he other dome in ridge.
nd proceed etailed
amp User Gu
Figure 3-19 T
GE STATUS lirom the Appli
int Cartridge
mouse, anim
restraining the
nt Cartridge p
g the newly tawith Tail Oil.
Figure 3-17 S
Figure 3-18 R
uide | PN: 12
Tattoo Compl
ght icator
to
mals
e
platform.
attooed tail w
Start Button
Removing the
02.D
ete
with
e Restraint
S
Ff
4
4
4
4
N
C
A
A
R
I
N
14
Section
For best resulfollowing:
4.1. AS NEE
4.1.1 C
4.1.
4.1.2 InJ-
4.1.
4.1.
4.2. AFTER
4.2.1
4.3. AFTER
4.3.1
4.4. AT THE
4.4.1
Note: Do not
CLEANING M
Acceptable cle
Applicator m
Restraint car
nk slide (sin
Needle
n4 C
lts and to pres
DED
Clean the Nee
1.1 PressGentltail oibutton
nspect the Ne-Hooked Nee
2.1 Pressend oof theSee F
2.2 Inspe3-1 J-Hoo
EACH TATT
Replace th
EVERY 50 T
Replace th
COMPLETIO
Wipe dowcomponenneedle caagent.
t spray into th
METHODS
eaning metho
machine
rtridge
gle-use)
leaning
serve the life
edle Cartridg
s the “Changy wipe the nel, alcohol or n to retract th
eedle Cartridedle
s the “Changof the Tail Gae fork will depFigure 3-9 Ta
ect the Needl
oked Needle
TOO
he Ink Slide.
TATTOOS
he Needle Ca
ON OF THE
n the Applicants and Tail Grtridge with a
e Applicator M
ods for each L
ETO
•
•
•
Cleanin
g&Mai
of your Labst
e.
e Needle” bueedle tips witother cleaninhe gun head.
ge to check f
e Needle” buauge, push it press the clipail Gauge For
e Cartridge t
artridge at le
SESSION
ator MachineGauge thoroua cotton-tippe
Machine port
Labstamp com
Irradiate
•
•
•
g & Maintena
intenan
tamp System
utton. Wait fth a cotton-ting agent. Pr.
for damaged
utton. Wait foonto the mid
p arms to relerk-End
to check for d
ast after eve
, all Restrainughly accordied applicator
in the front n
mponent are l
Autoclave
ance | Labsta
nce
m, please ens
for the gun hepped applicaess the “Cha
d or J-Hooked
or the gun hed-section of thease the Nee
damaged or J
ery 50 tattoos
nt Cartridge ing to your lacoated in ta
or into the air
listed below:
VHP
•
•
•
•
amp User Gu
ure the
ead to emergator coated inange Needle”
d needles. Se
ead to emerghe Needle Cedle Cartridge
J-Hooked ne
s.
aboratory guiil oil, alcohol
r vents to the
Spray/wipe
•
•
•
•
uide | PN: 12
ge. n ”
ee Figure 3-1
ge. Using theartridge. Thee from the gu
eedles. See F
delines. Clea or other clea
rear of the S
Chlorinedioxide ga
•
•
•
•
Figure 3-J-Hooked
02.D
1
e forked-e tangs un-head.
Figure
an the aning
ystem.
e as
-1d Needle
T
E
V
T
S
15
Tail oil
ETO= Ethylene
VHP= Vaporize
The Applicator
W
TTDl
Section
Message
ENTER M
_ _ _
ENTER F
TATTOO
NEXT MO
PRESS S
REPLACE
REMOVE
PLEASE
AUTO INC
MODE ON
AUTO INC
MODE O
e oxide
ed hydrogen pe
Machine can fi
WARNINGS
The ApplicatoThe external sDo not spray ocated on the
n5 S
e
MOUSE ID
FIRST ID
ING IN PROG
OUSE ID _ _ _
START
E NEEDLE
E RESTRAINT
WAIT
CREMENT
N
CREMENT
FF
•
eroxide
it inside an isol
or Machine hasurfaces of thany liquid (ince back.
ystemM
GRESS
_
T CARTRIDG
S
•
lator with a 12”
as electrical che machine cacluding sterila
Messag
What it
Appears will need
Appears
The macRestraintRESTRA
In the Auautomati
50 tattooreplaced
GE Usually aThe ResNeedle C
The gun-machinechange t
The Auto
The Auto
ystem Messa
•
” diameter trans
components than be cleanedant or disinfec
ges
means
in the Manuad to be entere
in the Auto In
chine is tattoot Cartridge fro
AINT CARTRI
uto Incrementcally appears
oed IDs have . Will stay on
appears after traint Cartridg
Cartridge.
-head is eithe. Wait until ththe Needle Ca
o Increment o
o Increment o
ages | Labsta
•
sfer portal.
hat can be dad with any stectant) directly
al Entry optioned for each mo
ncrement opt
oing a mouse.om the dockinIDGE STATU
t option, the ns. Press STAR
been applied until the new
r pushing the ge must be re
er extending ohe gun-head sartridge.
option has bee
option has bee
amp User Gu
•
amaged by auerilant or disiny into the dock
n. In this optioouse.
tion. See rules
. Do not remong port until th
US light return
next number iRT to begin ta
d. The needle w needle has
CHANGE NEemoved befor
out of or retrastops before a
en turned on.
en turned off.
uide | PN: 12
•
utoclave procenfectant solutking port or ai
on, a new ID
s on page 12
ove the he ns to green.
n the sequenattooing.
must be been installed
EEDLE buttonre changing th
cting into the attempting to
.
.
02.D
esses. ion. ir vents,
.
ce
d.
n. he
S
16
Section
In addition
a SOMAR
ALERT M
If you eSystemTurn oApplicthat apperepresen
Check theaddition, crecomme.
Check theinspect th
Check to as prescri
Check to
Check for
If the neemay interthe Labst
n6 T
n to the troub
RK representa
MESSAGES
experiencm: off the Apcator Macears on the Ltative.
e Ink Slides bcheck the expnded.
e Needle Carte needles an
ensure that thibed by the Ta
ensure the ta
r any debris th
edle has not brfere with thetamp System
Trouble
leshooting tip
ative at 1-800
S
ce an ale
pplicator Mchine on. LCD screen a
efore use by piration date.
tridge for damd verify if the
he appropriatail Gauge.
ail was proper
hat may be pr
been properly operation of. Contact SO
eshootin
ps below, sup
-430-1243 or
ert messa
Machine. If this does
and the Appl
gently squee Slides are in
maged or J-honeedles are
e Restraint C
rly positioned
resent under
y installed, itf the ApplicatOMARK for f
Troubleshoo
ng
port for the La
r support@s
age or pro
Wait 5 s not resolve
icator’s seria
zing the ink pntended for sin
ooked needleshooked or da
Cartridge and
in the Restra
the Tail Cove
may fall off ttor. Do not infurther assist
oting | Labsta
abstamp Sys
omarkinnova
oblem wit
econds. the issue, n
al number an
portion to ensngle use only
s. Use an eyamaged.
Needle Cartr
aint Cartridge.
er. Clear the
the gun headnstall anotheance.
amp User Gu
stem can be o
ations.com.
th the La
Then turote the Labs
nd contact a
ure liquid is py. Re-using a
ye loupe or ste
ridge were se
.
debris and re
d. If this haper needle or a
uide | PN: 12
obtained by co
abstamp
n the stamp alert m
SOMARK
present insidean ink slide is
ereo microsco
lected for the
esume tattooin
ppens, the neattempt to op
02.D
ontacting
message
e. In not
ope to
mouse
ng.
eedle perate
S
17
Section
General
Model
Dimensio
Weight
DISPLAY
Type
Screen si
Resolutio
ELECTRI
Power so
Power co
Operating
ENVIRON
Storage te
Operating
n7 A
ns
Y
ze
n
ICAL
urce
nsumption
g temperature
NMENTAL
emperature
g relative hum
Appl
Applicat
Labsta
10.9”
9.5 lbs
LCD
2.5” x
80 x 1
120V,
1.5A (
e 32°F t
-4°C t
midity 90% m
icator Machi
torMac
amp 1.0
x 12.5” x 4” (
s (4.3 kg)
0.6” (6.35 x
6
60Hz
(max)
to 122°F (0°C
to 122°C (-20
max. (non-con
ne Specificat
chineSp
(27.7 x 31.8 x
1.52 cm)
C to 50°C)
0°C to 50°C)
ndensing)
tions | Labsta
pecifica
x 10.2 cm)
amp User Gu
ations
uide | PN: 1202.D