Post on 09-Aug-2020
INSTALLATION GUIDE
tivoliframeless shower screen
JohnsonSuisse
Introduction..................04
Care..................10
Warranty..................11
CONTENTS
tivoliframeless shower screen
3
Please inspect the product immediately upon receipt for damage, missing components or manufacturing
faults. Damage reported later will not be accepted.
Please handle the product with care avoiding knocks and shock loading to all sides and edges of glass.
Glass edge must not contact any hard surface.
Claims for defects/damage cannot be made after installation is completed.
NOTE: SAFETY GLASS CANNOT BE REWORKED. DO NOT TRY TO ALTER PARTS IN ANY WAY.
Please read these instructions carefully before you start installation. Special care should be taken when
drilling walls to avoid hidden pipes or electrical cables.
This product is heavy and may require two people to install.
GENERAL INFORMATION
Tools required
tivoliframeless shower screen
COMPONENTS
4
INSTA
LLATI
ON
Ins
truct
ions
[2] 1 x Fixed Panel.
2 x .Setting blocks
[ ] .
2 x Regulator rings.
1 2 x Clips
[ ] 2
2 x Round Screws M4x35 .
2 x Screw Cover Caps.
3 x Wall Plugs.
[3] 2 x Wall Plugs.
2 x Round Screws M4x35 .
2 x Screw Cover Caps.
[4]
4 x Regulator Rings.
4 x Cushions.
4 x .Wall Patch Fittings
[5] .2 x Hinges
[7] 2 x .Drip Seals
[8] 2 x Fixed Panels.
[9] 1 x Door Panel.
2 x .
Setting blocks
[1] 1 x Brackets.
1
2 x Bar Fasteners.
1 x Wall Connect Clips
1 x Wall Fixings.
x Wall Plug.
1 x Screw M4x35 .
[2] 1 x Handle Set.
[6] 1 x Aluminum Seal.
4 x Clips.
Before commencing installation, please check you have received the correct parts required; outlined below
tivoliframeless shower screen
ASSEMBLY DRAWING
5
INSTA
LLATIO
N Instructio
ns
[1] 5 x Wall Plugs
[2] 4 x Round Screws M4x35
[3] 2 x Fixed Panels
[4] 4 x
[5] 4 x Screw Cover Caps
[6] 4 x Regulator rings
[7] 1 x Aluminum Seal
[8] 1 x
[9] 1 x Door Panel
Wall Patch Fittings
Horizontal drip seal
[10] 1 x Handle Set
[11] 1 x
[12] 1 x Bracket
[13] 2 x Glass Fixings
[14] 1 x Wall Connector
[15] 1 x Wall Clip Fixing
[16] 1 x Screw M4x35
[17] 2 x
[18] 2 x Clips
[19] 2 x
Vertical drip seal
Hinges
Setting blocks
[12]
[2]
[15]
[13]
[14]
[5]
[7]
[18]
[10]
[9]
[1]
[4]
[6][8]
[11]
[17]
[3]
[16]
[19]
tivoliframeless shower screen
Before starting:
Ensure floor area for installation is completely level.
Walls must be plumb to within 5mm over the height of the screen.
Check/measure that the screen size shown on the packaging
suits the intended installation area.
INSTALLATION
M4x35
6
INSTA
LLATI
ON
Ins
truct
ions
Step 1
Step 2
1a
1b
1c
1
2a
2b
2c
tivoliframeless shower screen
* Ensure the panels
are positioned within
the dimensions
shown on page 9.
INSTALLATION
7
INSTA
LLATIO
N Instructio
ns
Step 3
Step 4View from inside
Fixed PanelDoor Panel
1a 2a
1b
1c
2b
2c
tivoliframeless shower screen
INSTALLATION
8
INSTA
LLATI
ON
Ins
truct
ions
Step 5
Step 6
2a
3a
1a
2
1
3
1
2 3
1b
2b
3b
4a 4b 4c
tivoliframeless shower screen
Allow 24 hours for silicone
to dry before using shower.
INSTALLATION
9
INSTA
LLATIO
N Instructio
ns
Step 7
From w
all corne
r to
1180 - 1210
960 - 990
860 - 890
From wall corner to 960860
tivoliframeless shower screen
outer f
ace of
wall bra
cket outer face of wall bracket
2000
CARE INSTRUCTIONS
CA
RE Ins
truct
ions
10
This screen has been treated with easy-to-clean glass surface treatment.
Please follow the care instructions to ensure your treatment is long lasting.
After use, your shower should be cleaned with a mild detergent and water.
This is particularly imprortant in hard water districts where insoluble lime
salts may be deposited and allowed to build up.
Do not use abrasive based cleaners.
Care should be taken to avoid contact with strong chemicals such as
organic solvents and strippers.
If in doubt please contact JohnsonSuisse or visit the website for details.
Please retain these instructions for aftercare and customer service details.
tivoliframeless shower screen
11
WA
RRAN
TY Info
rmatio
n
This product is covered by a 7 year product replacement and a 1 year parts and labour warranty.
Refer to www.johnsonsuisse.com.au for full warranty terms and conditions.
Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You
are entitled to a replacement or refund for the major failure and for compensation for any other reasonably
foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail
This warranty is provided by:
Bathroom Products Australia Pty Ltd
ABN 87 079297 617
PO Box 728
Botany NSW 2019
T 1300 717 717
F 1300 746 480
E bpa.warranty@johnsonsuisse.com.au
to be of acceptable quality and the failure does not amount to a major failure
WARRANTY INFORMATION
tivoliframeless shower screen
12
tivoliframeless shower screen
FOR FURTHER INFORMATION PLEASE CONTACT YOUR NEAREST JOHNSON SUISSE OFFICE:
HEAD OFFICE (SYDNEY)
2/97 Banksia St, Botany, NSW 2019
T 1300 717 717 F 1300 746 480
MELBOURNE
31 Koornang Rd, Scoresby, VIC 3179
T 1300 717 717 F 1800 225 315
BRISBANE
1/477 Newman Rd, Geebung, QLD 4034
T 1300 717 717 F 1300 746 480
PERTH
27 Harris Rd, Malaga, WA 6090
T 1300 717 717 F 1800 746 480
ADELAIDE
Rep: Terry Hayes
T 0499 221 201 F 1800 225 315
HOBART
Rep: Bob Moore
T 0428 223 116 F 1800 225 315
DUBBO
Rogers Agencies
6 Richard Ryan Pl, Dubbo NSW 2830
T 02 6882 2733 F 02 6882 2169
www.johnsonsuisse.com.au
R1.1